Illustration1996 SATURN SL2, A VEHICLE DEFECT CAUSED THE DRIVER TO LOSE CONTROL AND STRIKE THE CONCRETE BARRIER. *BF THE LEFT FRONT STRUT BROKE WHICH CAUSED THE CONSUMER TO LOSE CONTROL OF THE VEHICLE. THE DRIVER SUFFERED MINOR INJURIES. (OHIO TRAFFIC CRASH REPORT # 10-0304-91)*JB UPDATED 08/05/10 *BF
1996 Saturn Sl
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1996 Saturn Sl do not stand out strongly from the model-year median of 171.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sl years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 49 of 287 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
50 crash reports2 fire reports34 injury reports
Suspension complaints
8 reports1. HIGH REVVING ON IDLE MANUAL TRANS 2. FRONT END NOISE MANUAL TRANS P/S SIMILAR TO OTHER RECALL WORN OUT ? *NM
FEDERAL-MOGUL BEARING MANUFACTURE #512000 WAS REPLACED IN AUGUST OF 2000, BROKE WHILE DRIVING , THE WHEEL CAME OFF . I WAS LUCKY I WAS GOING SLOW AROUND A SHARP CURVE, AND THE CAR BEHIND ME WAS ABLE TO AVOID THE ROLLING WHEEL. *AK
THIS VEHICLE HAS HAD THREE FRONT WHEEL BEARING FAILURES SINCE PURCHASED NEW
WHEN DRIVING AT ANY SPEED AND APPLYING THE BRAKES, THE BRAKES FAILED AND WEREN'T STOPPING THE VEHICLE PROPERLY. ALSO, THERE IS VIRBRATION WITHIN THE STEERING AND A SHORT WITHIN THE ELECTRICAL SYSTEM. *AK
ENGINE STALLS DUE TO VALVES STICKING.
THE CAR WOULD SHAKE WHEN COMING TO A STOP, WITHIN 13800 MILES THE BRAKE PADS, ROTORS, STRUTS HAD TO BE REPLACED. PLEASE EXPLAIN MORE. *AK
THE CAR SHIMMIES AND CAUSES LOSS OF CONTROL OF THE STEERING WHEEL. PLEASE DESCRIBE. TT
Official recalls
197V138000 · Steering:gear Box (other Than Rack And Pinion)
Aug 29, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL STEERING. THE PINION BEARING CAGE IN THE STEERING GEAR CAN SEPARATE UNDER HIGH STEERING SYSTEM LOAD CONDITIONS, SUCH AS PARKING LOT OR SIMILAR LOW SPEED MANEUVERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN THE PINION GEAR DISENGAGING FROM THE RACK CAUSING A LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL REPLACE THE MANUAL STEERING GEAR ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.