NHTSA owner reports · September 18, 2026 snapshot.
Seats complaints
4 reportsClear category filter131,000 miles · Feb 5, 2011
Electrical SystemSeats
PASSENGER AND I WERE DRIVING AND ACTIVATED BOTH FRONT HEATED SEATS ON THE HIGHEST SETTING. SOON AFTER, BOTH OF US DETECTED A BURNING SMELL AND IMMEDIATELY SHUT OFF BOTH HEATED SEATS. UPON ARRIVAL, WE EXITED AND VISUALLY OBSERVED A SMALL BURN MARK WHERE THE PASSENGER'S LEFT SHOULDER WOULD BE. IT BURNED THROUGH THE LEATHER AND SIN…
Read full complaint
PASSENGER AND I WERE DRIVING AND ACTIVATED BOTH FRONT HEATED SEATS ON THE HIGHEST SETTING. SOON AFTER, BOTH OF US DETECTED A BURNING SMELL AND IMMEDIATELY SHUT OFF BOTH HEATED SEATS. UPON ARRIVAL, WE EXITED AND VISUALLY OBSERVED A SMALL BURN MARK WHERE THE PASSENGER'S LEFT SHOULDER WOULD BE. IT BURNED THROUGH THE LEATHER AND SINGED THE HAIR OF THE PASSENGER. THE BURN MARK IS ABOUT THE SIZE OF A NICKEL AND WE CAN NO LONGER USE THE HEATED SEAT FUNCTION. *TR
NHTSA ODI #10380857
Mileage unknown · Aug 14, 2007
Seats
I HAVE OWNED 4 DIFFERENT SAAB MODELS AND I HAVE ALLAYS HAD HEATED SEATS. THIS LAST WINTER WHILE WEARING A SUIT AND WOOL OVERCOAT I FELT A BURNING SENSATION ON MY BACK. I IMMEDIATELY TURNED MY SEAT OFF, WHEN I GOT OUT OF THE CAR THERE WHERE COIL BURN MARKS IN MY LEATHER SEAT. THERE HAS TO BE A SAFETY ISSUE IF A HEATED SEAT COI…
Read full complaint
I HAVE OWNED 4 DIFFERENT SAAB MODELS AND I HAVE ALLAYS HAD HEATED SEATS. THIS LAST WINTER WHILE WEARING A SUIT AND WOOL OVERCOAT I FELT A BURNING SENSATION ON MY BACK. I IMMEDIATELY TURNED MY SEAT OFF, WHEN I GOT OUT OF THE CAR THERE WHERE COIL BURN MARKS IN MY LEATHER SEAT. THERE HAS TO BE A SAFETY ISSUE IF A HEATED SEAT COIL CAN BURN THROUGH LEATHER, AND CAN BE FELT THROUGH AN INCH OF WOOL... *TR
NHTSA ODI #10199518
72,000 miles · Mar 21, 2007
Seats
MY 2003 SAAB 9-3 VECTOR STARTED TO HAVE A BURNING SENSATION ON THE DRIVER'S SEAT UNDER MY LEFT THIGH. IT WAS SO HOT THAT I HAD TO PUT A TOWEL UNDER MY LEG WHEN THE HEATED SEAT WAS ON. EVENTUALLY, AFTER 2 MONTHS OF THIS, THE HEATED SEAT QUIT WORKING ALL TOGETHER. I DID TAKE IT IN FOR MAINTENANCE AND THEY TOLD ME I WOULD HAVE T…
Read full complaint
MY 2003 SAAB 9-3 VECTOR STARTED TO HAVE A BURNING SENSATION ON THE DRIVER'S SEAT UNDER MY LEFT THIGH. IT WAS SO HOT THAT I HAD TO PUT A TOWEL UNDER MY LEG WHEN THE HEATED SEAT WAS ON. EVENTUALLY, AFTER 2 MONTHS OF THIS, THE HEATED SEAT QUIT WORKING ALL TOGETHER. I DID TAKE IT IN FOR MAINTENANCE AND THEY TOLD ME I WOULD HAVE TO BRING IT BACK AGAIN TO HAVE THEM DISASSEMBLE THE SEAT. I HAVE READ ON SAAB CHATLINES THAT IT'S A COMMON PROBLEM AND PEOPLE HAVE BEEN GETTING THEIR SEAT LEATHER REPLACED BECAUSE OF BURN MARKS. I THINK THIS IS A VERY REAL SAFETY ISSUE THAT SHOULD CALLED TO LIGHT. I HAVE BEEN TOLD IT'S A BAD HEATING ELEMENT.*AK
NHTSA ODI #10185754
Mileage unknown · Nov 24, 2003
EquipmentExterior LightingSeats
DEALER - SAAB EXCHANGE WON'T/CAN'T FIX VEHICLE. STEERING PROBLEM, RATTLE PROBLEM, FAN BLOWER PROBLEM, SEAT PROBLEM, BRAKE LIGHT PROBLEM, ETC... *LA
NHTSA ODI #10047502
Official recalls
4Mar 7, 2007
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
Consequence & remedy
Consequence: OVER TIME, THIS COULD CAUSE THE FUEL LINES TO LOOSEN FROM THE PUMP RESULTING IN FUEL LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, THE FUEL MAY IGNITE RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL DEVELOP A SECURING BRACKET THAT WILL SECURE THE FUEL LINES TO THE FUEL PUMP EVEN IF THE PLASTIC RETAINING TABS SHOULD BREAK. THE RECALL BEGAN ON JUNE 13, 2007. THIS IS AN EXPANSION OF PREVIOUS RECALL CAMPAIGNS - SEE 04V557 AND 06V126. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
May 19, 2005
CERTAIN SPORT SEDAN AND CONVERTIBLE PASSENGER VEHICLES WERE PRODUCED WITH A VACUUM PIPE CHECK VALVE FOR THE BRAKE BOOSTER THAT MAY FAIL FROM EXPOSURE TO ELEVATED TEMPERATURES. THIS COULD RESULT IN SUDDEN LOSS OF POWER BRAKE ASSIST, USUALLY WITH LITTLE OR NO WARNING.
Consequence & remedy
Consequence: IF THIS CONDITION WERE TO OCCUR WHEN MINIMUM STOPPING DISTANCE IS REQUIRED, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW REDESIGNED CHECK VALVE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
Oct 20, 2004
ON CERTAIN PASSENGER VEHICLES, THE ENGINE MANAGEMENT SYSTEM SOFTWARE MAY CAUSE ENGINE HESITATION OR STALLING.
Consequence & remedy
Consequence: IF THE VEHICLE STALLS AS A RESULT OF THIS CONDITION, IT CAN BE RESTARTED IMMEDIATELY.
Remedy: DEALERS WILL UPDATE THE ENGINE MANAGEMENT SYSTEM. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
May 11, 2004
SOME SPORT SEDANS WERE BUILT WITH SEAT BELT RETRACTORS THAT WERE DAMAGED DURING THE MANUFACTURING PROCESS. IF DAMAGED, OVER TIME, THE AUTOMATIC TENSIONING SYSTEM (ATS) CABLE IN THE SEAT BELT RETRACTOR COULD BREAK CAUSING THE BELT WEBBING TO NOT RETRACT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR ASSEMBLIES. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA08026 · Front Suspension Coil Spring Fracture
Opened Dec 22, 2008 · Closed Jun 4, 2010
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
To date, ODI is aware of 142 non-duplicative complaints related to the alleged defect.In addition, ODI is aware of 2,626 subject vehicles with one or more warranty claims related to the alleged defect.In total, ODI is aware of 2,714 unique subject vehicles that have experienced one or more front suspension coil spring fractures.ODI is not aware of any crashes or injuries related to the alleged defect.The engineering design and testing data supplied by GM, along with the frequency of consumer complaints and warranty claims related to the alleged defect, tends to support the position that, in general, the coil springs that fractured on many subject vehicles did not achieve the expected service life.However, in regard to the subject vehicles, a front suspension coil spring fracture itself has little safety consequence, as evidenced by the minimal impact on vehicle ride and handling and by the number of drivers who were unaware of the failure condition for some time until alerted by service personnel.The ratio of tire punctures to coil spring fractures appears low and there are no reports of crashes, deaths or injuries related to the alleged defect. A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor this issue and will take further action if warranted by the circumstances.See the EA08-026 Engineering Analysis Closing Report for more details.
PE08051 · Front Suspension Coil Spring Fracture
Opened Aug 28, 2008 · Closed Dec 23, 2008
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
ON AUGUST 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE08-051) TO INVESTIGATE ALLEGED FRONT SUSPENSION COIL SPRING FRACTURES IN CERTAIN MODEL YEAR (MY) 2003-2004 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES.(NOTE: FOR PURPOSES OF THIS INVESTIGATION, THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).SUBSEQUENT ANALYSIS OF DATA PROVIDED BY GENERAL MOTORS CORP. (GM) HAS LED THE AGENCY TO EXPAND THE SCOPE OF THIS INVESTIGATION TO INCLUDE ALL MY 2003-2006 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES. TO DATE, ODI IS AWARE OF 53 NON-DUPLICATIVE COMPLAINTS AND/OR FIELD REPORTS THAT ALLEGE COIL SPRING FRACTURE IN THE SUBJECT VEHICLES, INCLUDING 23 ALLEGING THE FRACTURED SPRING DAMAGED A TIRE, WITH 16 OF THOSE INVOLVING A TIRE PUNCTURE.ANALYSIS OF WARRANTY DATA PROVIDED BY GM IDENTIFIED 1,218 CLAIMS PAID TO REPAIR SUBJECT VEHICLES THAT EXPERIENCED THE ALLEGED DEFECT, OF WHICH 138 VEHICLES ALSO SUFFERED DAMAGE TO THE ADJACENT TIRE AND OF THOSE, 79 VEHICLES EXPERIENCED A TIRE PUNCTURE.ODI IS NOT AWARE OF ANY CRASHES OR INJURIES RELATED TO THE ALLEGED DEFECT. GM MADE SEVERAL DESIGN CHANGES TO THE COIL SPRINGS AND/OR MCPHERSON STRUT ASSEMBLIES USED IN THE SUBJECT VEHICLES IN AN APPARENT EFFORT TO ADDRESS THE ALLEGED DEFECT CONDITION.HOWEVER, GM MAINTAINS THAT THE SUBJECT VEHICLES REMAIN WELL CONTROLLED IN THE EVENT OF TIRE PUNCTURE, THAT THE RATE OF TIRE PUNCTURE INCIDENTS RELATED TO COIL SPRING FRACTURES IS LOW, AND THAT THE ALLEGED DEFECT DOES NOT POSE AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-026) TO FURTHER STUDY THE SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
EA04008 · Engine Stall
Opened Mar 19, 2004 · Closed Oct 27, 2004
Status: closed (inferred from source dates) · Electrical System:ignition:module; Engine And Engine Cooling
ON DECEMBER 30, 2003, ODI OPENED A PRELIMINARY EVALUATION (PE03-059) TO INVESTIGATE 16 COMPLAINTS ALLEGING ENGINE STALL WHILE DRIVING IN MODEL YEAR 2003 SAAB 9-3 SPORT SEDANS WITH 2.0L TURBOCHARGED ENGINES.ON JANUARY 15, 2004, GENERAL MOTORS (GM) ADVISED ODI THAT GM AND SAAB HAD DECIDED TO CONDUCT A GLOBAL CUSTOMER SATISFACTION CAMPAIGN TO CORRECT TWO DISTINCT ENGINE MANAGEMENT SOFTWARE CONDITIONS THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 12 THOUSAND SAAB 9-3 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS.THE REMEDIES FOR BOTH CONDITIONS INVOLVED REPROGRAMMING THE ENGINE MANAGEMENT SOFTWARE. GM HAS STATED THAT NEITHER CONDITION CAN OCCUR DURING VEHICLE ACCELERATION AND IN BOTH CASES THE VEHICLE CAN BE SAFELY CONTROLLED AND IMMEDIATELY RESTARTED AFTER ENGINE STALL. FOR THESE REASONS, AMONG OTHERS, GM BELIEVES THAT THE SUBJECT VEHICLES DO NOT CONTAIN A SAFETY-RELATED DEFECT. TO DATE, ODI HAS NOT RECEIVED ANY REPORTS OF CRASHES ALLEGEDLY DUE TO STALLING OF THE SUBJECT VEHICLES.NEVERTHELESS, ODI BELIEVES THAT THE CIRCUMSTANCES ASSOCIATED WITH THESE STALLING CONDITIONS CAN HAVE A SIGNIFICANT ADVERSE EFFECT ON SAFETY.ODI BELIEVES THAT THE CONDITIONS ADDRESSED BY GM?S CUSTOMER SATISFACTION CAMPAIGN WOULD HAVE BEEN MORE APPROPRIATELY TREATED AS A SAFETY RECALL.HOWEVER, BASED ON THE VERY HIGH COMPLETION RATES FOR THAT CAMPAIGN (83.3 PERCENT OVERALL) AND GM?S LETTER DESCRIBING ITS FUTURE APPROACH TO THE CONSIDERATION OF STALLING ISSUES, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED.THEREFORE, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Electrical System:ignition:module
ON DECEMBER 30, 2003, ODI OPENED A PRELIMINARY EVALUATION (PE03-059) TO INVESTIGATE 16 COMPLAINTS ALLEGING ENGINE STALL WHILE DRIVING IN MODEL YEAR 2003 SAAB 9-3 SPORT SEDANS WITH 2.0L TURBOCHARGED ENGINES.ON JANUARY 15, 2004, GENERAL MOTORS (GM) ADVISED ODI THAT GM AND SAAB HAD DECIDED TO CONDUCT A GLOBAL CUSTOMER SATISFACTION CAMPAIGN TO CORRECT TWO DISTINCT ENGINE MANAGEMENT SOFTWARE CONDITIONS THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 12 THOUSAND SAAB 9-3 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS.THE REMEDIES FOR BOTH CONDITIONS INVOLVED REPROGRAMMING THE ENGINE MANAGEMENT SOFTWARE. GM HAS STATED THAT NEITHER CONDITION CAN OCCUR DURING VEHICLE ACCELERATION AND IN BOTH CASES THE VEHICLE CAN BE SAFELY CONTROLLED AND IMMEDIATELY RESTARTED AFTER ENGINE STALL. FOR THESE REASONS, AMONG OTHERS, GM BELIEVES THAT THE SUBJECT VEHICLES DO NOT CONTAIN A SAFETY-RELATED DEFECT. TO DATE, ODI HAS NOT RECEIVED ANY REPORTS OF CRASHES ALLEGEDLY DUE TO STALLING OF THE SUBJECT VEHICLES.NEVERTHELESS, ODI BELIEVES THAT THE CIRCUMSTANCES ASSOCIATED WITH THESE STALLING CONDITIONS CAN HAVE A SIGNIFICANT ADVERSE EFFECT ON SAFETY.ODI BELIEVES THAT THE CONDITIONS ADDRESSED BY GM?S CUSTOMER SATISFACTION CAMPAIGN WOULD HAVE BEEN MORE APPROPRIATELY TREATED AS A SAFETY RECALL.HOWEVER, BASED ON THE VERY HIGH COMPLETION RATES FOR THAT CAMPAIGN (83.3 PERCENT OVERALL) AND GM?S LETTER DESCRIBING ITS FUTURE APPROACH TO THE CONSIDERATION OF STALLING ISSUES, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED.THEREFORE, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SEE THE ATTACHED REPORT.
Engine And Engine Cooling
ON DECEMBER 30, 2003, ODI OPENED A PRELIMINARY EVALUATION (PE03-059) TO INVESTIGATE 16 COMPLAINTS ALLEGING ENGINE STALL WHILE DRIVING IN MODEL YEAR 2003 SAAB 9-3 SPORT SEDANS WITH 2.0L TURBOCHARGED ENGINES.ON JANUARY 15, 2004, GENERAL MOTORS (GM) ADVISED ODI THAT GM AND SAAB HAD DECIDED TO CONDUCT A GLOBAL CUSTOMER SATISFACTION CAMPAIGN TO CORRECT TWO DISTINCT ENGINE MANAGEMENT SOFTWARE CONDITIONS THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 12 THOUSAND SAAB 9-3 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS.THE REMEDIES FOR BOTH CONDITIONS INVOLVED REPROGRAMMING THE ENGINE MANAGEMENT SOFTWARE. GM HAS STATED THAT NEITHER CONDITION CAN OCCUR DURING VEHICLE ACCELERATION AND IN BOTH CASES THE VEHICLE CAN BE SAFELY CONTROLLED AND IMMEDIATELY RESTARTED AFTER ENGINE STALL. FOR THESE REASONS, AMONG OTHERS, GM BELIEVES THAT THE SUBJECT VEHICLES DO NOT CONTAIN A SAFETY-RELATED DEFECT. TO DATE, ODI HAS NOT RECEIVED ANY REPORTS OF CRASHES ALLEGEDLY DUE TO STALLING OF THE SUBJECT VEHICLES.NEVERTHELESS, ODI BELIEVES THAT THE CIRCUMSTANCES ASSOCIATED WITH THESE STALLING CONDITIONS CAN HAVE A SIGNIFICANT ADVERSE EFFECT ON SAFETY.ODI BELIEVES THAT THE CONDITIONS ADDRESSED BY GM?S CUSTOMER SATISFACTION CAMPAIGN WOULD HAVE BEEN MORE APPROPRIATELY TREATED AS A SAFETY RECALL.HOWEVER, BASED ON THE VERY HIGH COMPLETION RATES FOR THAT CAMPAIGN (83.3 PERCENT OVERALL) AND GM?S LETTER DESCRIBING ITS FUTURE APPROACH TO THE CONSIDERATION OF STALLING ISSUES, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED.THEREFORE, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SEE THE ATTACHED REPORT.
PE03059 · Engine Stall
Opened Dec 30, 2003 · Closed Mar 19, 2004
Status: closed (inferred from source dates) · Electrical System:ignition:module; Engine And Engine Cooling
THE SUBJECT VEHICLES ARE EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND TURBOCHARGED ENGINES WITH TWO DIFFERENT POWER OUTPUTS, 175 HP AND 210 HP.SAAB HAS MODIFIED THE ELECTONIC CONTROL MODULE (ECM) SOFTWARE IN THE SUBJECT VEHICLES TO CORRECT PROBLEMS THAT COULD RESULT IN ENGINE STALL IN BOTH ENGINES. IN JANUARY 2003, SAAB DISABLED THE DUAL MASS FLYWHEEL (DMF) PROTECTION (INTENDED ONLY FOR MANUAL TRANSMISSION VEHICLES) IN SUBJECT VEHICLES WITH 175 HP ENGINES.ACCORDING TO SAAB, DMF PROTECTION IN A VEHICLE WITH AUTOMATIC TRANMSSION MAY CAUSE THE ENGINE TO STALL WHEN RELEASING THE ACCELERATOR PEDAL WHEN COMING TO A STOP OR WHEN THE VEHICLE IS COASTING. IN AUGUST 2003, SAAB REVISED THE ECM SOFTWARE IN THE 210 HP ENGINES TO ADDRESS A CONCERN WITH ENGINE STALL DURING ABORTED TAKE-OFF MANUEVERS.ACCORDING TO SAAB, ABORTED TAKE-OFF STALLS OCCUR WHEN THE VEHICLE IS STATIONARY AND IN DRIVE GEAR, THE ENGINE IS IDLING, AND THE ACCELERATOR PEDAL IS PULSED (PRESSED QUICKLY AND RELEASED IN LESS THAN 1 SECOND). THERE HAVE BEEN 553 NON-DUPLICATIVE COMPLAINTS TO ODI AND SAAB ALLEGING ENGINE STALL IN THE SUBJECT VEHICLES.THERE IS ONE REPORTED CRASH AND NO INJURIES.SAAB INITIATED A CUSTOMER SATISFACTION PROGRAM IN EARLY FEBRUARY TO REPROGRAM THE ECM'S.SAAB REPORTED THAT 36% OF THE VEHICLES HAD BEEN SERVICED IN THE PROGRAM AS OF MARCH 9, 2004.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND SAAB'S ACTIONS TO ADDRESS THE PROBLEMS.
Additional source detail variants (2)
Electrical System:ignition:module
THE SUBJECT VEHICLES ARE EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND TURBOCHARGED ENGINES WITH TWO DIFFERENT POWER OUTPUTS, 175 HP AND 210 HP.SAAB HAS MODIFIED THE ELECTONIC CONTROL MODULE (ECM) SOFTWARE IN THE SUBJECT VEHICLES TO CORRECT PROBLEMS THAT COULD RESULT IN ENGINE STALL IN BOTH ENGINES. IN JANUARY 2003, SAAB DISABLED THE DUAL MASS FLYWHEEL (DMF) PROTECTION (INTENDED ONLY FOR MANUAL TRANSMISSION VEHICLES) IN SUBJECT VEHICLES WITH 175 HP ENGINES.ACCORDING TO SAAB, DMF PROTECTION IN A VEHICLE WITH AUTOMATIC TRANMSSION MAY CAUSE THE ENGINE TO STALL WHEN RELEASING THE ACCELERATOR PEDAL WHEN COMING TO A STOP OR WHEN THE VEHICLE IS COASTING. IN AUGUST 2003, SAAB REVISED THE ECM SOFTWARE IN THE 210 HP ENGINES TO ADDRESS A CONCERN WITH ENGINE STALL DURING ABORTED TAKE-OFF MANUEVERS.ACCORDING TO SAAB, ABORTED TAKE-OFF STALLS OCCUR WHEN THE VEHICLE IS STATIONARY AND IN DRIVE GEAR, THE ENGINE IS IDLING, AND THE ACCELERATOR PEDAL IS PULSED (PRESSED QUICKLY AND RELEASED IN LESS THAN 1 SECOND). THERE HAVE BEEN 553 NON-DUPLICATIVE COMPLAINTS TO ODI AND SAAB ALLEGING ENGINE STALL IN THE SUBJECT VEHICLES.THERE IS ONE REPORTED CRASH AND NO INJURIES.SAAB INITIATED A CUSTOMER SATISFACTION PROGRAM IN EARLY FEBRUARY TO REPROGRAM THE ECM'S.SAAB REPORTED THAT 36% OF THE VEHICLES HAD BEEN SERVICED IN THE PROGRAM AS OF MARCH 9, 2004.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND SAAB'S ACTIONS TO ADDRESS THE PROBLEMS.
Engine And Engine Cooling
THE SUBJECT VEHICLES ARE EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND TURBOCHARGED ENGINES WITH TWO DIFFERENT POWER OUTPUTS, 175 HP AND 210 HP.SAAB HAS MODIFIED THE ELECTONIC CONTROL MODULE (ECM) SOFTWARE IN THE SUBJECT VEHICLES TO CORRECT PROBLEMS THAT COULD RESULT IN ENGINE STALL IN BOTH ENGINES. IN JANUARY 2003, SAAB DISABLED THE DUAL MASS FLYWHEEL (DMF) PROTECTION (INTENDED ONLY FOR MANUAL TRANSMISSION VEHICLES) IN SUBJECT VEHICLES WITH 175 HP ENGINES.ACCORDING TO SAAB, DMF PROTECTION IN A VEHICLE WITH AUTOMATIC TRANMSSION MAY CAUSE THE ENGINE TO STALL WHEN RELEASING THE ACCELERATOR PEDAL WHEN COMING TO A STOP OR WHEN THE VEHICLE IS COASTING. IN AUGUST 2003, SAAB REVISED THE ECM SOFTWARE IN THE 210 HP ENGINES TO ADDRESS A CONCERN WITH ENGINE STALL DURING ABORTED TAKE-OFF MANUEVERS.ACCORDING TO SAAB, ABORTED TAKE-OFF STALLS OCCUR WHEN THE VEHICLE IS STATIONARY AND IN DRIVE GEAR, THE ENGINE IS IDLING, AND THE ACCELERATOR PEDAL IS PULSED (PRESSED QUICKLY AND RELEASED IN LESS THAN 1 SECOND). THERE HAVE BEEN 553 NON-DUPLICATIVE COMPLAINTS TO ODI AND SAAB ALLEGING ENGINE STALL IN THE SUBJECT VEHICLES.THERE IS ONE REPORTED CRASH AND NO INJURIES.SAAB INITIATED A CUSTOMER SATISFACTION PROGRAM IN EARLY FEBRUARY TO REPROGRAM THE ECM'S.SAAB REPORTED THAT 36% OF THE VEHICLES HAD BEEN SERVICED IN THE PROGRAM AS OF MARCH 9, 2004.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND SAAB'S ACTIONS TO ADDRESS THE PROBLEMS.
Illustration