IllustrationTL* THE CONTACT OWNS A 2003 SAAB 9-3. WHEN THE VEHICLE DECELERATED, IT SHUT OFF WITHOUT WARNING AT WILL. THE CONTACT ALSO STATED THAT THE VEHICLE DECELERATED WHEN DRIVING UP A HILL. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 102,000.
2003 Saab 9-3
Owner reports · Recalls · Investigations
More warning signs than most 9-3 years
Owner complaints for the 2003 Saab 9-3 are substantially higher than the model-year median of 61.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all 9-3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
530–25K
3225–50K
4050–75K
2475–100K
12100–150K
6150K+
167 reports with mileage · 45 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports6 fire reports13 injury reports
Engine complaints
7 reportsTL* THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT STATED THAT THE VEHICLE JERKED WHEN THE BRAKE PEDAL WAS DEPRESSED AND STALLED. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED INTERMITTENTLY. IN ADDITION, IT TOOK MULTIPLE ATTEMPTS TO OPEN THE DRIVER SIDE DOOR. THE VEHICLE WAS TA…
Read full complaint
TL* THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT STATED THAT THE VEHICLE JERKED WHEN THE BRAKE PEDAL WAS DEPRESSED AND STALLED. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED INTERMITTENTLY. IN ADDITION, IT TOOK MULTIPLE ATTEMPTS TO OPEN THE DRIVER SIDE DOOR. THE VEHICLE WAS TAKEN TO AN INDEPENDENTLY MECHANIC WHERE IT WAS DIAGNOSED THAT THE SPARK PLUGS HAD FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 87,171.
TL* THE CONTACT OWNS A 2003 SAAB 9-3. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED WITHOUT WARNING AND WAS ABLE TO BE RESTARTED. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS NOT DIAGNOSED; HOWEVER, THE MECHANIC REPLACED THE DIC AND THE CRANKSHAFT SENSOR. THE VEHIC…
Read full complaint
TL* THE CONTACT OWNS A 2003 SAAB 9-3. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED WITHOUT WARNING AND WAS ABLE TO BE RESTARTED. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS NOT DIAGNOSED; HOWEVER, THE MECHANIC REPLACED THE DIC AND THE CRANKSHAFT SENSOR. THE VEHICLE WAS REPAIRED AND THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC AND THE DIC WAS REPLACED. THE FAILURE PERSISTED AND IT TOOK SEVERAL ATTEMPTS TO START THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE FAILURE MIRRORED NHTSA ACTION NUMBER: EA04008 (ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING). THE APPROXIMATE FAILURE MILEAGE WAS 45,000. UPDATED 02/23/16*LJ *CN
TL* THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE FAILED TO ACCELERATE AND DECELERATED INDEPENDENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, THE CONTACT STATED THAT WHILE DRIVING, THERE WAS AN ABNORMAL ODOR A…
Read full complaint
TL* THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE FAILED TO ACCELERATE AND DECELERATED INDEPENDENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, THE CONTACT STATED THAT WHILE DRIVING, THERE WAS AN ABNORMAL ODOR AND SMOKE COMING FROM THE FRONT OF THE VEHICLE. THE CONTACT PULLED OVER AND DISCOVERED THAT OIL WAS LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE VALVE COVER GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 184,000. ...UPDATED 01/07/16 *BF THE CONSUMER STATED THE VEHICLE FAILED TO ACCELERATE WHEN ENTERING TRAFFIC FROM THE DRIVEWAY, IT MOVES OUT OF GEAR, AND THE VEHICLE HAD AN ELECTRICAL GLITCH THAT CAUSED THE HEADLIGHTS TO GO OUT OFTEN NEEDING TO BE REPLACED. *JS
AS I WAS DRIVING IN THE MIDDLE LANE OF THE 3 NORTHBOUND LANES OF U.S. 23, THE ENGINE SUDDENLY STALLED. I WAS GOING ABOUT 62 MPH. I ACTIVATED MY EMERGENCY FLASHERS, SHIFTED THE AUTOMATIC TRANSMISSION TO NEUTRAL, AND SHUT OFF THE IGNITION KEY. I THEN TURNED THE IGNITION KEY TO RESTART THE ENGINE AND IT RESTARTED. THIS IS ABOUT THE…
Read full complaint
AS I WAS DRIVING IN THE MIDDLE LANE OF THE 3 NORTHBOUND LANES OF U.S. 23, THE ENGINE SUDDENLY STALLED. I WAS GOING ABOUT 62 MPH. I ACTIVATED MY EMERGENCY FLASHERS, SHIFTED THE AUTOMATIC TRANSMISSION TO NEUTRAL, AND SHUT OFF THE IGNITION KEY. I THEN TURNED THE IGNITION KEY TO RESTART THE ENGINE AND IT RESTARTED. THIS IS ABOUT THE 5TH TIME THIS HAS HAPPENED IN THE PAST 5 MONTHS. THIS VEHICLE SHOULD BE INCLUDED IN GMS IGNITION RECALL!!! *TR
WHILE DRIVING AT HIGHWAY SPEED, THE ENGINE SUDDENLY STALLED. SLOWED AND STOPPED VEHICLE OFF SIDE OF ROAD. TURNED KEY TO OFF POSITION, THEN RE-STARTED VEHICLE WHEN TURNED KEY TO ON. CAR RAN FINE AFTER RE-STARTED. THIS HAS HAPPENED MULTIPLE TIMES. SUSPECT DEFECTIVE IGNITION SWITCH, BUT THIS VEHICLE IS NOT ON THE RECALL LIST. *TR
THE VEHICLE WILL BECOME ALMOST IMMOBILE IN FIRST AND SECOND GEAR (MANUAL TRANSMISSION). ONCE IN THIRD GEAR, PERFORMANCE IS BACK TO NORMAL. IF DRIVER IS NOT AWARE OF SITUATION (CRUISE LIGHT OFF IS ONLY INDICATION IF CRUISE CONTROL SYSTEM IS TURNED ON), DRIVER CAN EASILY GET INTO BAD SITUATION AS CAR WILL NOT PERFORM AS USUAL (VER…
Read full complaint
THE VEHICLE WILL BECOME ALMOST IMMOBILE IN FIRST AND SECOND GEAR (MANUAL TRANSMISSION). ONCE IN THIRD GEAR, PERFORMANCE IS BACK TO NORMAL. IF DRIVER IS NOT AWARE OF SITUATION (CRUISE LIGHT OFF IS ONLY INDICATION IF CRUISE CONTROL SYSTEM IS TURNED ON), DRIVER CAN EASILY GET INTO BAD SITUATION AS CAR WILL NOT PERFORM AS USUAL (VERY SIGNIFICANT DEGRADATION OF PERFORMANCE). ALL THAT IS NEEDED TO RESET PROBLEM IS TO TURN THE KEY OFF AND RESTART THE ENGINE AND THE CONDITION WILL GO AWAY FOR AS LITTLE AS 10 MINUTES OR UP TO AS MUCH AS 2 HOURS OF DRIVING. IT IS SUSPECTED THAT THIS PROBLEM COULD BE ASSOCIATED WITH THE AIR MASS SENSOR AS REPLACING AIR MASS SENSOR WITH USED PART, PROBLEM DISAPPEARED FOR SEVERAL MONTHS. THIS CONDITION COULD CAUSE A SERIOUS SAFETY ISSUE IF DRIVER IS NOT AWARE AND TRIES TO MAKE A QUICK MANEUVER INVOLVING TIGHT TRAFFIC (LEFT TURN WHEN PERFORMANCE IS PARAMOUNT). WHATEVER THIS CONDITION IS THAT THE ELECTRONICS/ENGINE CONTROLS IS/ARE ENTERING IS UNACCEPTABLE AND THIS PROBLEM NEEDS TO BE CORRECTED BY THE MANUFACTURER IN A RECALL. *TR
Official recalls
407V087000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Mar 7, 2007
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
Consequence & remedy
Consequence: OVER TIME, THIS COULD CAUSE THE FUEL LINES TO LOOSEN FROM THE PUMP RESULTING IN FUEL LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, THE FUEL MAY IGNITE RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL DEVELOP A SECURING BRACKET THAT WILL SECURE THE FUEL LINES TO THE FUEL PUMP EVEN IF THE PLASTIC RETAINING TABS SHOULD BREAK. THE RECALL BEGAN ON JUNE 13, 2007. THIS IS AN EXPANSION OF PREVIOUS RECALL CAMPAIGNS - SEE 04V557 AND 06V126. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
05V236000 · Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
May 19, 2005
CERTAIN SPORT SEDAN AND CONVERTIBLE PASSENGER VEHICLES WERE PRODUCED WITH A VACUUM PIPE CHECK VALVE FOR THE BRAKE BOOSTER THAT MAY FAIL FROM EXPOSURE TO ELEVATED TEMPERATURES. THIS COULD RESULT IN SUDDEN LOSS OF POWER BRAKE ASSIST, USUALLY WITH LITTLE OR NO WARNING.
Consequence & remedy
Consequence: IF THIS CONDITION WERE TO OCCUR WHEN MINIMUM STOPPING DISTANCE IS REQUIRED, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW REDESIGNED CHECK VALVE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
04V540000 · Engine And Engine Cooling
Oct 20, 2004
ON CERTAIN PASSENGER VEHICLES, THE ENGINE MANAGEMENT SYSTEM SOFTWARE MAY CAUSE ENGINE HESITATION OR STALLING.
Consequence & remedy
Consequence: IF THE VEHICLE STALLS AS A RESULT OF THIS CONDITION, IT CAN BE RESTARTED IMMEDIATELY.
Remedy: DEALERS WILL UPDATE THE ENGINE MANAGEMENT SYSTEM. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
04V226000 · Seat Belts:front:retractor
May 11, 2004
SOME SPORT SEDANS WERE BUILT WITH SEAT BELT RETRACTORS THAT WERE DAMAGED DURING THE MANUFACTURING PROCESS. IF DAMAGED, OVER TIME, THE AUTOMATIC TENSIONING SYSTEM (ATS) CABLE IN THE SEAT BELT RETRACTOR COULD BREAK CAUSING THE BELT WEBBING TO NOT RETRACT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR ASSEMBLIES. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA08026 · Front Suspension Coil Spring Fracture
Opened Dec 22, 2008 · Closed Jun 4, 2010
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
To date, ODI is aware of 142 non-duplicative complaints related to the alleged defect.In addition, ODI is aware of 2,626 subject vehicles with one or more warranty claims related to the alleged defect.In total, ODI is aware of 2,714 unique subject vehicles that have experienced one or more front suspension coil spring fractures.ODI is not aware of any crashes or injuries related to the alleged defect.The engineering design and testing data supplied by GM, along with the frequency of consumer complaints and warranty claims related to the alleged defect, tends to support the position that, in general, the coil springs that fractured on many subject vehicles did not achieve the expected service life.However, in regard to the subject vehicles, a front suspension coil spring fracture itself has little safety consequence, as evidenced by the minimal impact on vehicle ride and handling and by the number of drivers who were unaware of the failure condition for some time until alerted by service personnel.The ratio of tire punctures to coil spring fractures appears low and there are no reports of crashes, deaths or injuries related to the alleged defect. A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor this issue and will take further action if warranted by the circumstances.See the EA08-026 Engineering Analysis Closing Report for more details.
PE08051 · Front Suspension Coil Spring Fracture
Opened Aug 28, 2008 · Closed Dec 23, 2008
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
ON AUGUST 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE08-051) TO INVESTIGATE ALLEGED FRONT SUSPENSION COIL SPRING FRACTURES IN CERTAIN MODEL YEAR (MY) 2003-2004 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES.(NOTE: FOR PURPOSES OF THIS INVESTIGATION, THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).SUBSEQUENT ANALYSIS OF DATA PROVIDED BY GENERAL MOTORS CORP. (GM) HAS LED THE AGENCY TO EXPAND THE SCOPE OF THIS INVESTIGATION TO INCLUDE ALL MY 2003-2006 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES. TO DATE, ODI IS AWARE OF 53 NON-DUPLICATIVE COMPLAINTS AND/OR FIELD REPORTS THAT ALLEGE COIL SPRING FRACTURE IN THE SUBJECT VEHICLES, INCLUDING 23 ALLEGING THE FRACTURED SPRING DAMAGED A TIRE, WITH 16 OF THOSE INVOLVING A TIRE PUNCTURE.ANALYSIS OF WARRANTY DATA PROVIDED BY GM IDENTIFIED 1,218 CLAIMS PAID TO REPAIR SUBJECT VEHICLES THAT EXPERIENCED THE ALLEGED DEFECT, OF WHICH 138 VEHICLES ALSO SUFFERED DAMAGE TO THE ADJACENT TIRE AND OF THOSE, 79 VEHICLES EXPERIENCED A TIRE PUNCTURE.ODI IS NOT AWARE OF ANY CRASHES OR INJURIES RELATED TO THE ALLEGED DEFECT. GM MADE SEVERAL DESIGN CHANGES TO THE COIL SPRINGS AND/OR MCPHERSON STRUT ASSEMBLIES USED IN THE SUBJECT VEHICLES IN AN APPARENT EFFORT TO ADDRESS THE ALLEGED DEFECT CONDITION.HOWEVER, GM MAINTAINS THAT THE SUBJECT VEHICLES REMAIN WELL CONTROLLED IN THE EVENT OF TIRE PUNCTURE, THAT THE RATE OF TIRE PUNCTURE INCIDENTS RELATED TO COIL SPRING FRACTURES IS LOW, AND THAT THE ALLEGED DEFECT DOES NOT POSE AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-026) TO FURTHER STUDY THE SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
EA04008 · Engine Stall
Opened Mar 19, 2004 · Closed Oct 27, 2004
Status: closed (inferred from source dates) · Electrical System:ignition:module; Engine And Engine Cooling
ON DECEMBER 30, 2003, ODI OPENED A PRELIMINARY EVALUATION (PE03-059) TO INVESTIGATE 16 COMPLAINTS ALLEGING ENGINE STALL WHILE DRIVING IN MODEL YEAR 2003 SAAB 9-3 SPORT SEDANS WITH 2.0L TURBOCHARGED ENGINES.ON JANUARY 15, 2004, GENERAL MOTORS (GM) ADVISED ODI THAT GM AND SAAB HAD DECIDED TO CONDUCT A GLOBAL CUSTOMER SATISFACTION CAMPAIGN TO CORRECT TWO DISTINCT ENGINE MANAGEMENT SOFTWARE CONDITIONS THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 12 THOUSAND SAAB 9-3 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS.THE REMEDIES FOR BOTH CONDITIONS INVOLVED REPROGRAMMING THE ENGINE MANAGEMENT SOFTWARE. GM HAS STATED THAT NEITHER CONDITION CAN OCCUR DURING VEHICLE ACCELERATION AND IN BOTH CASES THE VEHICLE CAN BE SAFELY CONTROLLED AND IMMEDIATELY RESTARTED AFTER ENGINE STALL. FOR THESE REASONS, AMONG OTHERS, GM BELIEVES THAT THE SUBJECT VEHICLES DO NOT CONTAIN A SAFETY-RELATED DEFECT. TO DATE, ODI HAS NOT RECEIVED ANY REPORTS OF CRASHES ALLEGEDLY DUE TO STALLING OF THE SUBJECT VEHICLES.NEVERTHELESS, ODI BELIEVES THAT THE CIRCUMSTANCES ASSOCIATED WITH THESE STALLING CONDITIONS CAN HAVE A SIGNIFICANT ADVERSE EFFECT ON SAFETY.ODI BELIEVES THAT THE CONDITIONS ADDRESSED BY GM?S CUSTOMER SATISFACTION CAMPAIGN WOULD HAVE BEEN MORE APPROPRIATELY TREATED AS A SAFETY RECALL.HOWEVER, BASED ON THE VERY HIGH COMPLETION RATES FOR THAT CAMPAIGN (83.3 PERCENT OVERALL) AND GM?S LETTER DESCRIBING ITS FUTURE APPROACH TO THE CONSIDERATION OF STALLING ISSUES, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED.THEREFORE, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Electrical System:ignition:module
ON DECEMBER 30, 2003, ODI OPENED A PRELIMINARY EVALUATION (PE03-059) TO INVESTIGATE 16 COMPLAINTS ALLEGING ENGINE STALL WHILE DRIVING IN MODEL YEAR 2003 SAAB 9-3 SPORT SEDANS WITH 2.0L TURBOCHARGED ENGINES.ON JANUARY 15, 2004, GENERAL MOTORS (GM) ADVISED ODI THAT GM AND SAAB HAD DECIDED TO CONDUCT A GLOBAL CUSTOMER SATISFACTION CAMPAIGN TO CORRECT TWO DISTINCT ENGINE MANAGEMENT SOFTWARE CONDITIONS THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 12 THOUSAND SAAB 9-3 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS.THE REMEDIES FOR BOTH CONDITIONS INVOLVED REPROGRAMMING THE ENGINE MANAGEMENT SOFTWARE. GM HAS STATED THAT NEITHER CONDITION CAN OCCUR DURING VEHICLE ACCELERATION AND IN BOTH CASES THE VEHICLE CAN BE SAFELY CONTROLLED AND IMMEDIATELY RESTARTED AFTER ENGINE STALL. FOR THESE REASONS, AMONG OTHERS, GM BELIEVES THAT THE SUBJECT VEHICLES DO NOT CONTAIN A SAFETY-RELATED DEFECT. TO DATE, ODI HAS NOT RECEIVED ANY REPORTS OF CRASHES ALLEGEDLY DUE TO STALLING OF THE SUBJECT VEHICLES.NEVERTHELESS, ODI BELIEVES THAT THE CIRCUMSTANCES ASSOCIATED WITH THESE STALLING CONDITIONS CAN HAVE A SIGNIFICANT ADVERSE EFFECT ON SAFETY.ODI BELIEVES THAT THE CONDITIONS ADDRESSED BY GM?S CUSTOMER SATISFACTION CAMPAIGN WOULD HAVE BEEN MORE APPROPRIATELY TREATED AS A SAFETY RECALL.HOWEVER, BASED ON THE VERY HIGH COMPLETION RATES FOR THAT CAMPAIGN (83.3 PERCENT OVERALL) AND GM?S LETTER DESCRIBING ITS FUTURE APPROACH TO THE CONSIDERATION OF STALLING ISSUES, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED.THEREFORE, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SEE THE ATTACHED REPORT.
Engine And Engine Cooling
ON DECEMBER 30, 2003, ODI OPENED A PRELIMINARY EVALUATION (PE03-059) TO INVESTIGATE 16 COMPLAINTS ALLEGING ENGINE STALL WHILE DRIVING IN MODEL YEAR 2003 SAAB 9-3 SPORT SEDANS WITH 2.0L TURBOCHARGED ENGINES.ON JANUARY 15, 2004, GENERAL MOTORS (GM) ADVISED ODI THAT GM AND SAAB HAD DECIDED TO CONDUCT A GLOBAL CUSTOMER SATISFACTION CAMPAIGN TO CORRECT TWO DISTINCT ENGINE MANAGEMENT SOFTWARE CONDITIONS THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 12 THOUSAND SAAB 9-3 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS.THE REMEDIES FOR BOTH CONDITIONS INVOLVED REPROGRAMMING THE ENGINE MANAGEMENT SOFTWARE. GM HAS STATED THAT NEITHER CONDITION CAN OCCUR DURING VEHICLE ACCELERATION AND IN BOTH CASES THE VEHICLE CAN BE SAFELY CONTROLLED AND IMMEDIATELY RESTARTED AFTER ENGINE STALL. FOR THESE REASONS, AMONG OTHERS, GM BELIEVES THAT THE SUBJECT VEHICLES DO NOT CONTAIN A SAFETY-RELATED DEFECT. TO DATE, ODI HAS NOT RECEIVED ANY REPORTS OF CRASHES ALLEGEDLY DUE TO STALLING OF THE SUBJECT VEHICLES.NEVERTHELESS, ODI BELIEVES THAT THE CIRCUMSTANCES ASSOCIATED WITH THESE STALLING CONDITIONS CAN HAVE A SIGNIFICANT ADVERSE EFFECT ON SAFETY.ODI BELIEVES THAT THE CONDITIONS ADDRESSED BY GM?S CUSTOMER SATISFACTION CAMPAIGN WOULD HAVE BEEN MORE APPROPRIATELY TREATED AS A SAFETY RECALL.HOWEVER, BASED ON THE VERY HIGH COMPLETION RATES FOR THAT CAMPAIGN (83.3 PERCENT OVERALL) AND GM?S LETTER DESCRIBING ITS FUTURE APPROACH TO THE CONSIDERATION OF STALLING ISSUES, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED.THEREFORE, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SEE THE ATTACHED REPORT.
PE03059 · Engine Stall
Opened Dec 30, 2003 · Closed Mar 19, 2004
Status: closed (inferred from source dates) · Electrical System:ignition:module; Engine And Engine Cooling
THE SUBJECT VEHICLES ARE EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND TURBOCHARGED ENGINES WITH TWO DIFFERENT POWER OUTPUTS, 175 HP AND 210 HP.SAAB HAS MODIFIED THE ELECTONIC CONTROL MODULE (ECM) SOFTWARE IN THE SUBJECT VEHICLES TO CORRECT PROBLEMS THAT COULD RESULT IN ENGINE STALL IN BOTH ENGINES. IN JANUARY 2003, SAAB DISABLED THE DUAL MASS FLYWHEEL (DMF) PROTECTION (INTENDED ONLY FOR MANUAL TRANSMISSION VEHICLES) IN SUBJECT VEHICLES WITH 175 HP ENGINES.ACCORDING TO SAAB, DMF PROTECTION IN A VEHICLE WITH AUTOMATIC TRANMSSION MAY CAUSE THE ENGINE TO STALL WHEN RELEASING THE ACCELERATOR PEDAL WHEN COMING TO A STOP OR WHEN THE VEHICLE IS COASTING. IN AUGUST 2003, SAAB REVISED THE ECM SOFTWARE IN THE 210 HP ENGINES TO ADDRESS A CONCERN WITH ENGINE STALL DURING ABORTED TAKE-OFF MANUEVERS.ACCORDING TO SAAB, ABORTED TAKE-OFF STALLS OCCUR WHEN THE VEHICLE IS STATIONARY AND IN DRIVE GEAR, THE ENGINE IS IDLING, AND THE ACCELERATOR PEDAL IS PULSED (PRESSED QUICKLY AND RELEASED IN LESS THAN 1 SECOND). THERE HAVE BEEN 553 NON-DUPLICATIVE COMPLAINTS TO ODI AND SAAB ALLEGING ENGINE STALL IN THE SUBJECT VEHICLES.THERE IS ONE REPORTED CRASH AND NO INJURIES.SAAB INITIATED A CUSTOMER SATISFACTION PROGRAM IN EARLY FEBRUARY TO REPROGRAM THE ECM'S.SAAB REPORTED THAT 36% OF THE VEHICLES HAD BEEN SERVICED IN THE PROGRAM AS OF MARCH 9, 2004.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND SAAB'S ACTIONS TO ADDRESS THE PROBLEMS.
Additional source detail variants (2)
Electrical System:ignition:module
THE SUBJECT VEHICLES ARE EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND TURBOCHARGED ENGINES WITH TWO DIFFERENT POWER OUTPUTS, 175 HP AND 210 HP.SAAB HAS MODIFIED THE ELECTONIC CONTROL MODULE (ECM) SOFTWARE IN THE SUBJECT VEHICLES TO CORRECT PROBLEMS THAT COULD RESULT IN ENGINE STALL IN BOTH ENGINES. IN JANUARY 2003, SAAB DISABLED THE DUAL MASS FLYWHEEL (DMF) PROTECTION (INTENDED ONLY FOR MANUAL TRANSMISSION VEHICLES) IN SUBJECT VEHICLES WITH 175 HP ENGINES.ACCORDING TO SAAB, DMF PROTECTION IN A VEHICLE WITH AUTOMATIC TRANMSSION MAY CAUSE THE ENGINE TO STALL WHEN RELEASING THE ACCELERATOR PEDAL WHEN COMING TO A STOP OR WHEN THE VEHICLE IS COASTING. IN AUGUST 2003, SAAB REVISED THE ECM SOFTWARE IN THE 210 HP ENGINES TO ADDRESS A CONCERN WITH ENGINE STALL DURING ABORTED TAKE-OFF MANUEVERS.ACCORDING TO SAAB, ABORTED TAKE-OFF STALLS OCCUR WHEN THE VEHICLE IS STATIONARY AND IN DRIVE GEAR, THE ENGINE IS IDLING, AND THE ACCELERATOR PEDAL IS PULSED (PRESSED QUICKLY AND RELEASED IN LESS THAN 1 SECOND). THERE HAVE BEEN 553 NON-DUPLICATIVE COMPLAINTS TO ODI AND SAAB ALLEGING ENGINE STALL IN THE SUBJECT VEHICLES.THERE IS ONE REPORTED CRASH AND NO INJURIES.SAAB INITIATED A CUSTOMER SATISFACTION PROGRAM IN EARLY FEBRUARY TO REPROGRAM THE ECM'S.SAAB REPORTED THAT 36% OF THE VEHICLES HAD BEEN SERVICED IN THE PROGRAM AS OF MARCH 9, 2004.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND SAAB'S ACTIONS TO ADDRESS THE PROBLEMS.
Engine And Engine Cooling
THE SUBJECT VEHICLES ARE EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND TURBOCHARGED ENGINES WITH TWO DIFFERENT POWER OUTPUTS, 175 HP AND 210 HP.SAAB HAS MODIFIED THE ELECTONIC CONTROL MODULE (ECM) SOFTWARE IN THE SUBJECT VEHICLES TO CORRECT PROBLEMS THAT COULD RESULT IN ENGINE STALL IN BOTH ENGINES. IN JANUARY 2003, SAAB DISABLED THE DUAL MASS FLYWHEEL (DMF) PROTECTION (INTENDED ONLY FOR MANUAL TRANSMISSION VEHICLES) IN SUBJECT VEHICLES WITH 175 HP ENGINES.ACCORDING TO SAAB, DMF PROTECTION IN A VEHICLE WITH AUTOMATIC TRANMSSION MAY CAUSE THE ENGINE TO STALL WHEN RELEASING THE ACCELERATOR PEDAL WHEN COMING TO A STOP OR WHEN THE VEHICLE IS COASTING. IN AUGUST 2003, SAAB REVISED THE ECM SOFTWARE IN THE 210 HP ENGINES TO ADDRESS A CONCERN WITH ENGINE STALL DURING ABORTED TAKE-OFF MANUEVERS.ACCORDING TO SAAB, ABORTED TAKE-OFF STALLS OCCUR WHEN THE VEHICLE IS STATIONARY AND IN DRIVE GEAR, THE ENGINE IS IDLING, AND THE ACCELERATOR PEDAL IS PULSED (PRESSED QUICKLY AND RELEASED IN LESS THAN 1 SECOND). THERE HAVE BEEN 553 NON-DUPLICATIVE COMPLAINTS TO ODI AND SAAB ALLEGING ENGINE STALL IN THE SUBJECT VEHICLES.THERE IS ONE REPORTED CRASH AND NO INJURIES.SAAB INITIATED A CUSTOMER SATISFACTION PROGRAM IN EARLY FEBRUARY TO REPROGRAM THE ECM'S.SAAB REPORTED THAT 36% OF THE VEHICLES HAD BEEN SERVICED IN THE PROGRAM AS OF MARCH 9, 2004.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND SAAB'S ACTIONS TO ADDRESS THE PROBLEMS.