NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
15 reportsClear category filter130,000 miles · Jan 20, 2021
Air Bags
I WAS DRIVING MY 2003 SAAB 9-3 SE CONVERTIBLE TO THE NEARBY PUBLIX SUPERMARKET. THE CAR HAS NEVER BEEN IN AN ACCIDENT OR HIT. I PARKED IT IN THE LOT WITH THE TOP DOWN AND WENT INTO THE STORE FOR APPROXIMATELY 10 MINUTES. IT WAS A WARM DRY DAY IN FLORIDA ABOUT 85 DEGREES. I CAME OUT AND PUT THE KEY IN THE IGNITION AND TURNED I…
Read full complaint
I WAS DRIVING MY 2003 SAAB 9-3 SE CONVERTIBLE TO THE NEARBY PUBLIX SUPERMARKET. THE CAR HAS NEVER BEEN IN AN ACCIDENT OR HIT. I PARKED IT IN THE LOT WITH THE TOP DOWN AND WENT INTO THE STORE FOR APPROXIMATELY 10 MINUTES. IT WAS A WARM DRY DAY IN FLORIDA ABOUT 85 DEGREES. I CAME OUT AND PUT THE KEY IN THE IGNITION AND TURNED IT TO START THE CAR, AND THE PASSENGER SIDE AIRBAG EXPLODED FOR NO KNOWN REASON. I CALLED GM, THEY TOOK THE CAR TO A GM FACILITY AND INSPECTED IT, AND THEN CAME BACK A WEEK LATER AND SAID THE UNEXPLAINED DEPLOYMENT OF THE AIRBAG WAS NOT A MANUFACTURERS DEFECT AND THEY WOULD NOT REPAIR IT. I FIND THAT DIFFICULT TO BELIEVE. THE AIRBAG SHOULD NOT DEPLOY ARBITRARILY WHEN THE IGNITION KEY IS TURNED.
NHTSA ODI #11389024
168,000 miles · Jun 22, 2018
Air BagsInjury
TAKATA RECALL. DRIVER'S SEAT AIRBAG DEPLOYED WHILE WAITING AT A RED LIGHT THIS MORNING.
NHTSA ODI #11103343
Mileage unknown · Jan 3, 2018
Air Bags
2003 SAAB. CONSUMER WRITES IN REGARDS TO AIRBAG INFLATOR SAFETY RECALL. *LD THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAIR. *JS
NHTSA ODI #11054310
180,000 miles · Jun 17, 2017
Air BagsCrashInjury
I WAS DRIVING AT ABOUT 15 - 20 MPH TRYING TO ENTER HWY I-75. UPON ROUTINE BRAKING,THE AIRBAG DEPLOYED, CAUSING AN ACCIDENT.AFTER I HIT THE CAR IN FRONT OF ME,THE SECOND AIRBAG DEPLOYED. I AM HURT. THE VEHICLE WAS DEEMED TOTALLED BECAUSE THE AIRBAGS DEPLOYED, AND TAKEN AWAY.
NHTSA ODI #10995688
Mileage unknown · Aug 31, 2016
Air Bags
TAKATA RECALL I WAS NOTIFIED BY SAAB IN MARCH 2016 THAT I HAVE TAKATA AIRBAGS INSTALLED AND ARE SUBJECT TO RECALL. IT IS NOW SIX (6) MONTHS SINCE THE NOTIFICATION. I HAVE HAD NO FURTHER COMMUNICATION FROM SAAB. I FEEL THAT THE RECALL SHOULD TAKE PLACE IMMEDIATELY BEFORE I GET KILLED FROM THE AIRBAG INFLATING. SIX MONTHS SHO…
Read full complaint
TAKATA RECALL I WAS NOTIFIED BY SAAB IN MARCH 2016 THAT I HAVE TAKATA AIRBAGS INSTALLED AND ARE SUBJECT TO RECALL. IT IS NOW SIX (6) MONTHS SINCE THE NOTIFICATION. I HAVE HAD NO FURTHER COMMUNICATION FROM SAAB. I FEEL THAT THE RECALL SHOULD TAKE PLACE IMMEDIATELY BEFORE I GET KILLED FROM THE AIRBAG INFLATING. SIX MONTHS SHOULD BE MORE THAN ADEQUATE TO RESOLVE THE PROBLEM. I ASK THAT SAAB BE COMPELLED TO IMMEDIATELY MAKE THE NECESSARY REPAIRS!
NHTSA ODI #10899863
Mileage unknown · Jun 10, 2016
Air Bags
TAKATA RECALL I DO NOT HAVE A DATE FOR OR MY SAAB AIR BAG RECALL. THIS CLEARLY SENDS A MESSAGE ABOUT GM. "DON'T BUY GM, AND FROM THOSE COMPANIES WHICH PLACE PEOPLE AT RISK OF AIR BAG FAILURE"
NHTSA ODI #10873695
Mileage unknown · Jun 9, 2016
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PART FOR THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF TH…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PART FOR THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10873508
Mileage unknown · Apr 21, 2016
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISS…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10860736
Mileage unknown · Apr 5, 2016
Air Bags
TAKATA RECALL...I AM ADVISED THAT THERE IS RISK OF INJURY/DEATH DUE TO DEPLOYMENT OF AIR BAGS. ASKING FOR REPAIR ADVISED TODAY 4/4/2016 BY (GENERAL MOTORS) THEY ARE NOT NOW DOING/CANNOT DO SAME. UNACCEPTABLE SAFETY.
NHTSA ODI #10853523
70,000 miles · Sep 4, 2009
Air BagsInjury
AIRBAG MALFUNCTION LIGHT HAD COME ON 4 DAYS PRIOR. I WAS PACKED THE KEY WAS OFF BUT STILL IN THE IGNITION. I WENT TO START THE CAR AND THE SIDE AIR BAGS WENT OFF. *TR
NHTSA ODI #10282827
Official recalls
4Mar 7, 2007
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
Consequence & remedy
Consequence: OVER TIME, THIS COULD CAUSE THE FUEL LINES TO LOOSEN FROM THE PUMP RESULTING IN FUEL LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, THE FUEL MAY IGNITE RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL DEVELOP A SECURING BRACKET THAT WILL SECURE THE FUEL LINES TO THE FUEL PUMP EVEN IF THE PLASTIC RETAINING TABS SHOULD BREAK. THE RECALL BEGAN ON JUNE 13, 2007. THIS IS AN EXPANSION OF PREVIOUS RECALL CAMPAIGNS - SEE 04V557 AND 06V126. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
May 19, 2005
CERTAIN SPORT SEDAN AND CONVERTIBLE PASSENGER VEHICLES WERE PRODUCED WITH A VACUUM PIPE CHECK VALVE FOR THE BRAKE BOOSTER THAT MAY FAIL FROM EXPOSURE TO ELEVATED TEMPERATURES. THIS COULD RESULT IN SUDDEN LOSS OF POWER BRAKE ASSIST, USUALLY WITH LITTLE OR NO WARNING.
Consequence & remedy
Consequence: IF THIS CONDITION WERE TO OCCUR WHEN MINIMUM STOPPING DISTANCE IS REQUIRED, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW REDESIGNED CHECK VALVE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
Oct 20, 2004
ON CERTAIN PASSENGER VEHICLES, THE ENGINE MANAGEMENT SYSTEM SOFTWARE MAY CAUSE ENGINE HESITATION OR STALLING.
Consequence & remedy
Consequence: IF THE VEHICLE STALLS AS A RESULT OF THIS CONDITION, IT CAN BE RESTARTED IMMEDIATELY.
Remedy: DEALERS WILL UPDATE THE ENGINE MANAGEMENT SYSTEM. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
May 11, 2004
SOME SPORT SEDANS WERE BUILT WITH SEAT BELT RETRACTORS THAT WERE DAMAGED DURING THE MANUFACTURING PROCESS. IF DAMAGED, OVER TIME, THE AUTOMATIC TENSIONING SYSTEM (ATS) CABLE IN THE SEAT BELT RETRACTOR COULD BREAK CAUSING THE BELT WEBBING TO NOT RETRACT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR ASSEMBLIES. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA08026 · Front Suspension Coil Spring Fracture
Opened Dec 22, 2008 · Closed Jun 4, 2010
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
To date, ODI is aware of 142 non-duplicative complaints related to the alleged defect.In addition, ODI is aware of 2,626 subject vehicles with one or more warranty claims related to the alleged defect.In total, ODI is aware of 2,714 unique subject vehicles that have experienced one or more front suspension coil spring fractures.ODI is not aware of any crashes or injuries related to the alleged defect.The engineering design and testing data supplied by GM, along with the frequency of consumer complaints and warranty claims related to the alleged defect, tends to support the position that, in general, the coil springs that fractured on many subject vehicles did not achieve the expected service life.However, in regard to the subject vehicles, a front suspension coil spring fracture itself has little safety consequence, as evidenced by the minimal impact on vehicle ride and handling and by the number of drivers who were unaware of the failure condition for some time until alerted by service personnel.The ratio of tire punctures to coil spring fractures appears low and there are no reports of crashes, deaths or injuries related to the alleged defect. A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor this issue and will take further action if warranted by the circumstances.See the EA08-026 Engineering Analysis Closing Report for more details.
PE08051 · Front Suspension Coil Spring Fracture
Opened Aug 28, 2008 · Closed Dec 23, 2008
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
ON AUGUST 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE08-051) TO INVESTIGATE ALLEGED FRONT SUSPENSION COIL SPRING FRACTURES IN CERTAIN MODEL YEAR (MY) 2003-2004 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES.(NOTE: FOR PURPOSES OF THIS INVESTIGATION, THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).SUBSEQUENT ANALYSIS OF DATA PROVIDED BY GENERAL MOTORS CORP. (GM) HAS LED THE AGENCY TO EXPAND THE SCOPE OF THIS INVESTIGATION TO INCLUDE ALL MY 2003-2006 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES. TO DATE, ODI IS AWARE OF 53 NON-DUPLICATIVE COMPLAINTS AND/OR FIELD REPORTS THAT ALLEGE COIL SPRING FRACTURE IN THE SUBJECT VEHICLES, INCLUDING 23 ALLEGING THE FRACTURED SPRING DAMAGED A TIRE, WITH 16 OF THOSE INVOLVING A TIRE PUNCTURE.ANALYSIS OF WARRANTY DATA PROVIDED BY GM IDENTIFIED 1,218 CLAIMS PAID TO REPAIR SUBJECT VEHICLES THAT EXPERIENCED THE ALLEGED DEFECT, OF WHICH 138 VEHICLES ALSO SUFFERED DAMAGE TO THE ADJACENT TIRE AND OF THOSE, 79 VEHICLES EXPERIENCED A TIRE PUNCTURE.ODI IS NOT AWARE OF ANY CRASHES OR INJURIES RELATED TO THE ALLEGED DEFECT. GM MADE SEVERAL DESIGN CHANGES TO THE COIL SPRINGS AND/OR MCPHERSON STRUT ASSEMBLIES USED IN THE SUBJECT VEHICLES IN AN APPARENT EFFORT TO ADDRESS THE ALLEGED DEFECT CONDITION.HOWEVER, GM MAINTAINS THAT THE SUBJECT VEHICLES REMAIN WELL CONTROLLED IN THE EVENT OF TIRE PUNCTURE, THAT THE RATE OF TIRE PUNCTURE INCIDENTS RELATED TO COIL SPRING FRACTURES IS LOW, AND THAT THE ALLEGED DEFECT DOES NOT POSE AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-026) TO FURTHER STUDY THE SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
EA04008 · Engine Stall
Opened Mar 19, 2004 · Closed Oct 27, 2004
Status: closed (inferred from source dates) · Electrical System:ignition:module; Engine And Engine Cooling
ON DECEMBER 30, 2003, ODI OPENED A PRELIMINARY EVALUATION (PE03-059) TO INVESTIGATE 16 COMPLAINTS ALLEGING ENGINE STALL WHILE DRIVING IN MODEL YEAR 2003 SAAB 9-3 SPORT SEDANS WITH 2.0L TURBOCHARGED ENGINES.ON JANUARY 15, 2004, GENERAL MOTORS (GM) ADVISED ODI THAT GM AND SAAB HAD DECIDED TO CONDUCT A GLOBAL CUSTOMER SATISFACTION CAMPAIGN TO CORRECT TWO DISTINCT ENGINE MANAGEMENT SOFTWARE CONDITIONS THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 12 THOUSAND SAAB 9-3 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS.THE REMEDIES FOR BOTH CONDITIONS INVOLVED REPROGRAMMING THE ENGINE MANAGEMENT SOFTWARE. GM HAS STATED THAT NEITHER CONDITION CAN OCCUR DURING VEHICLE ACCELERATION AND IN BOTH CASES THE VEHICLE CAN BE SAFELY CONTROLLED AND IMMEDIATELY RESTARTED AFTER ENGINE STALL. FOR THESE REASONS, AMONG OTHERS, GM BELIEVES THAT THE SUBJECT VEHICLES DO NOT CONTAIN A SAFETY-RELATED DEFECT. TO DATE, ODI HAS NOT RECEIVED ANY REPORTS OF CRASHES ALLEGEDLY DUE TO STALLING OF THE SUBJECT VEHICLES.NEVERTHELESS, ODI BELIEVES THAT THE CIRCUMSTANCES ASSOCIATED WITH THESE STALLING CONDITIONS CAN HAVE A SIGNIFICANT ADVERSE EFFECT ON SAFETY.ODI BELIEVES THAT THE CONDITIONS ADDRESSED BY GM?S CUSTOMER SATISFACTION CAMPAIGN WOULD HAVE BEEN MORE APPROPRIATELY TREATED AS A SAFETY RECALL.HOWEVER, BASED ON THE VERY HIGH COMPLETION RATES FOR THAT CAMPAIGN (83.3 PERCENT OVERALL) AND GM?S LETTER DESCRIBING ITS FUTURE APPROACH TO THE CONSIDERATION OF STALLING ISSUES, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED.THEREFORE, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Electrical System:ignition:module
ON DECEMBER 30, 2003, ODI OPENED A PRELIMINARY EVALUATION (PE03-059) TO INVESTIGATE 16 COMPLAINTS ALLEGING ENGINE STALL WHILE DRIVING IN MODEL YEAR 2003 SAAB 9-3 SPORT SEDANS WITH 2.0L TURBOCHARGED ENGINES.ON JANUARY 15, 2004, GENERAL MOTORS (GM) ADVISED ODI THAT GM AND SAAB HAD DECIDED TO CONDUCT A GLOBAL CUSTOMER SATISFACTION CAMPAIGN TO CORRECT TWO DISTINCT ENGINE MANAGEMENT SOFTWARE CONDITIONS THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 12 THOUSAND SAAB 9-3 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS.THE REMEDIES FOR BOTH CONDITIONS INVOLVED REPROGRAMMING THE ENGINE MANAGEMENT SOFTWARE. GM HAS STATED THAT NEITHER CONDITION CAN OCCUR DURING VEHICLE ACCELERATION AND IN BOTH CASES THE VEHICLE CAN BE SAFELY CONTROLLED AND IMMEDIATELY RESTARTED AFTER ENGINE STALL. FOR THESE REASONS, AMONG OTHERS, GM BELIEVES THAT THE SUBJECT VEHICLES DO NOT CONTAIN A SAFETY-RELATED DEFECT. TO DATE, ODI HAS NOT RECEIVED ANY REPORTS OF CRASHES ALLEGEDLY DUE TO STALLING OF THE SUBJECT VEHICLES.NEVERTHELESS, ODI BELIEVES THAT THE CIRCUMSTANCES ASSOCIATED WITH THESE STALLING CONDITIONS CAN HAVE A SIGNIFICANT ADVERSE EFFECT ON SAFETY.ODI BELIEVES THAT THE CONDITIONS ADDRESSED BY GM?S CUSTOMER SATISFACTION CAMPAIGN WOULD HAVE BEEN MORE APPROPRIATELY TREATED AS A SAFETY RECALL.HOWEVER, BASED ON THE VERY HIGH COMPLETION RATES FOR THAT CAMPAIGN (83.3 PERCENT OVERALL) AND GM?S LETTER DESCRIBING ITS FUTURE APPROACH TO THE CONSIDERATION OF STALLING ISSUES, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED.THEREFORE, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SEE THE ATTACHED REPORT.
Engine And Engine Cooling
ON DECEMBER 30, 2003, ODI OPENED A PRELIMINARY EVALUATION (PE03-059) TO INVESTIGATE 16 COMPLAINTS ALLEGING ENGINE STALL WHILE DRIVING IN MODEL YEAR 2003 SAAB 9-3 SPORT SEDANS WITH 2.0L TURBOCHARGED ENGINES.ON JANUARY 15, 2004, GENERAL MOTORS (GM) ADVISED ODI THAT GM AND SAAB HAD DECIDED TO CONDUCT A GLOBAL CUSTOMER SATISFACTION CAMPAIGN TO CORRECT TWO DISTINCT ENGINE MANAGEMENT SOFTWARE CONDITIONS THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 12 THOUSAND SAAB 9-3 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS.THE REMEDIES FOR BOTH CONDITIONS INVOLVED REPROGRAMMING THE ENGINE MANAGEMENT SOFTWARE. GM HAS STATED THAT NEITHER CONDITION CAN OCCUR DURING VEHICLE ACCELERATION AND IN BOTH CASES THE VEHICLE CAN BE SAFELY CONTROLLED AND IMMEDIATELY RESTARTED AFTER ENGINE STALL. FOR THESE REASONS, AMONG OTHERS, GM BELIEVES THAT THE SUBJECT VEHICLES DO NOT CONTAIN A SAFETY-RELATED DEFECT. TO DATE, ODI HAS NOT RECEIVED ANY REPORTS OF CRASHES ALLEGEDLY DUE TO STALLING OF THE SUBJECT VEHICLES.NEVERTHELESS, ODI BELIEVES THAT THE CIRCUMSTANCES ASSOCIATED WITH THESE STALLING CONDITIONS CAN HAVE A SIGNIFICANT ADVERSE EFFECT ON SAFETY.ODI BELIEVES THAT THE CONDITIONS ADDRESSED BY GM?S CUSTOMER SATISFACTION CAMPAIGN WOULD HAVE BEEN MORE APPROPRIATELY TREATED AS A SAFETY RECALL.HOWEVER, BASED ON THE VERY HIGH COMPLETION RATES FOR THAT CAMPAIGN (83.3 PERCENT OVERALL) AND GM?S LETTER DESCRIBING ITS FUTURE APPROACH TO THE CONSIDERATION OF STALLING ISSUES, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED.THEREFORE, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SEE THE ATTACHED REPORT.
PE03059 · Engine Stall
Opened Dec 30, 2003 · Closed Mar 19, 2004
Status: closed (inferred from source dates) · Electrical System:ignition:module; Engine And Engine Cooling
THE SUBJECT VEHICLES ARE EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND TURBOCHARGED ENGINES WITH TWO DIFFERENT POWER OUTPUTS, 175 HP AND 210 HP.SAAB HAS MODIFIED THE ELECTONIC CONTROL MODULE (ECM) SOFTWARE IN THE SUBJECT VEHICLES TO CORRECT PROBLEMS THAT COULD RESULT IN ENGINE STALL IN BOTH ENGINES. IN JANUARY 2003, SAAB DISABLED THE DUAL MASS FLYWHEEL (DMF) PROTECTION (INTENDED ONLY FOR MANUAL TRANSMISSION VEHICLES) IN SUBJECT VEHICLES WITH 175 HP ENGINES.ACCORDING TO SAAB, DMF PROTECTION IN A VEHICLE WITH AUTOMATIC TRANMSSION MAY CAUSE THE ENGINE TO STALL WHEN RELEASING THE ACCELERATOR PEDAL WHEN COMING TO A STOP OR WHEN THE VEHICLE IS COASTING. IN AUGUST 2003, SAAB REVISED THE ECM SOFTWARE IN THE 210 HP ENGINES TO ADDRESS A CONCERN WITH ENGINE STALL DURING ABORTED TAKE-OFF MANUEVERS.ACCORDING TO SAAB, ABORTED TAKE-OFF STALLS OCCUR WHEN THE VEHICLE IS STATIONARY AND IN DRIVE GEAR, THE ENGINE IS IDLING, AND THE ACCELERATOR PEDAL IS PULSED (PRESSED QUICKLY AND RELEASED IN LESS THAN 1 SECOND). THERE HAVE BEEN 553 NON-DUPLICATIVE COMPLAINTS TO ODI AND SAAB ALLEGING ENGINE STALL IN THE SUBJECT VEHICLES.THERE IS ONE REPORTED CRASH AND NO INJURIES.SAAB INITIATED A CUSTOMER SATISFACTION PROGRAM IN EARLY FEBRUARY TO REPROGRAM THE ECM'S.SAAB REPORTED THAT 36% OF THE VEHICLES HAD BEEN SERVICED IN THE PROGRAM AS OF MARCH 9, 2004.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND SAAB'S ACTIONS TO ADDRESS THE PROBLEMS.
Additional source detail variants (2)
Electrical System:ignition:module
THE SUBJECT VEHICLES ARE EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND TURBOCHARGED ENGINES WITH TWO DIFFERENT POWER OUTPUTS, 175 HP AND 210 HP.SAAB HAS MODIFIED THE ELECTONIC CONTROL MODULE (ECM) SOFTWARE IN THE SUBJECT VEHICLES TO CORRECT PROBLEMS THAT COULD RESULT IN ENGINE STALL IN BOTH ENGINES. IN JANUARY 2003, SAAB DISABLED THE DUAL MASS FLYWHEEL (DMF) PROTECTION (INTENDED ONLY FOR MANUAL TRANSMISSION VEHICLES) IN SUBJECT VEHICLES WITH 175 HP ENGINES.ACCORDING TO SAAB, DMF PROTECTION IN A VEHICLE WITH AUTOMATIC TRANMSSION MAY CAUSE THE ENGINE TO STALL WHEN RELEASING THE ACCELERATOR PEDAL WHEN COMING TO A STOP OR WHEN THE VEHICLE IS COASTING. IN AUGUST 2003, SAAB REVISED THE ECM SOFTWARE IN THE 210 HP ENGINES TO ADDRESS A CONCERN WITH ENGINE STALL DURING ABORTED TAKE-OFF MANUEVERS.ACCORDING TO SAAB, ABORTED TAKE-OFF STALLS OCCUR WHEN THE VEHICLE IS STATIONARY AND IN DRIVE GEAR, THE ENGINE IS IDLING, AND THE ACCELERATOR PEDAL IS PULSED (PRESSED QUICKLY AND RELEASED IN LESS THAN 1 SECOND). THERE HAVE BEEN 553 NON-DUPLICATIVE COMPLAINTS TO ODI AND SAAB ALLEGING ENGINE STALL IN THE SUBJECT VEHICLES.THERE IS ONE REPORTED CRASH AND NO INJURIES.SAAB INITIATED A CUSTOMER SATISFACTION PROGRAM IN EARLY FEBRUARY TO REPROGRAM THE ECM'S.SAAB REPORTED THAT 36% OF THE VEHICLES HAD BEEN SERVICED IN THE PROGRAM AS OF MARCH 9, 2004.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND SAAB'S ACTIONS TO ADDRESS THE PROBLEMS.
Engine And Engine Cooling
THE SUBJECT VEHICLES ARE EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND TURBOCHARGED ENGINES WITH TWO DIFFERENT POWER OUTPUTS, 175 HP AND 210 HP.SAAB HAS MODIFIED THE ELECTONIC CONTROL MODULE (ECM) SOFTWARE IN THE SUBJECT VEHICLES TO CORRECT PROBLEMS THAT COULD RESULT IN ENGINE STALL IN BOTH ENGINES. IN JANUARY 2003, SAAB DISABLED THE DUAL MASS FLYWHEEL (DMF) PROTECTION (INTENDED ONLY FOR MANUAL TRANSMISSION VEHICLES) IN SUBJECT VEHICLES WITH 175 HP ENGINES.ACCORDING TO SAAB, DMF PROTECTION IN A VEHICLE WITH AUTOMATIC TRANMSSION MAY CAUSE THE ENGINE TO STALL WHEN RELEASING THE ACCELERATOR PEDAL WHEN COMING TO A STOP OR WHEN THE VEHICLE IS COASTING. IN AUGUST 2003, SAAB REVISED THE ECM SOFTWARE IN THE 210 HP ENGINES TO ADDRESS A CONCERN WITH ENGINE STALL DURING ABORTED TAKE-OFF MANUEVERS.ACCORDING TO SAAB, ABORTED TAKE-OFF STALLS OCCUR WHEN THE VEHICLE IS STATIONARY AND IN DRIVE GEAR, THE ENGINE IS IDLING, AND THE ACCELERATOR PEDAL IS PULSED (PRESSED QUICKLY AND RELEASED IN LESS THAN 1 SECOND). THERE HAVE BEEN 553 NON-DUPLICATIVE COMPLAINTS TO ODI AND SAAB ALLEGING ENGINE STALL IN THE SUBJECT VEHICLES.THERE IS ONE REPORTED CRASH AND NO INJURIES.SAAB INITIATED A CUSTOMER SATISFACTION PROGRAM IN EARLY FEBRUARY TO REPROGRAM THE ECM'S.SAAB REPORTED THAT 36% OF THE VEHICLES HAD BEEN SERVICED IN THE PROGRAM AS OF MARCH 9, 2004.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND SAAB'S ACTIONS TO ADDRESS THE PROBLEMS.
Illustration