NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
32 reports157,290 miles · Oct 27, 2025
Fuel System, Gasoline
The contact owns a 2005 Porsche Cayenne. The contact stated that fuel was leaking from the vehicle. There was an abnormal fuel odor. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 17V576000 (Fuel System, Gasoline). The contact replaced the fuel filter and repai…
Read full complaint
The contact owns a 2005 Porsche Cayenne. The contact stated that fuel was leaking from the vehicle. There was an abnormal fuel odor. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 17V576000 (Fuel System, Gasoline). The contact replaced the fuel filter and repaired the vehicle. The contact called the local dealer and was informed that parts were on back order. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 157,290.
NHTSA ODI #11695787
Mileage unknown · Jul 21, 2024
Unknown Or Other
headlamp wiring and turn signal failures. Big hazard!! Why is in the headlight assembly including the headlight wire harness is corroding due to the heat this is a common issue that I see that’s online. Everyone is having the same issue with the same type of vehicle this needs attention immediately and recalled before the media…
Read full complaint
headlamp wiring and turn signal failures. Big hazard!! Why is in the headlight assembly including the headlight wire harness is corroding due to the heat this is a common issue that I see that’s online. Everyone is having the same issue with the same type of vehicle this needs attention immediately and recalled before the media gets wind of this. The group chats that I am in is starting to do a petition because this was reported to you guys numerous amount of times as I can see in our group chats so please call this recall because it is a safety hazard to the roads. Headlights are going off as we’re driving due to that Issue please give me a email at [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11603601
Mileage unknown · Jul 13, 2024
Forward Collision AvoidancePower TrainSuspension
The transmission has quite a bit of slop or play when placing it in park. I do not believe it could be parked safely in a residential driveway. Tranny knocks a little in low gears.
NHTSA ODI #11601645
Mileage unknown · Dec 16, 2022
Fuel/propulsion System
We purchased the 2005 Porsche Cayenne from my brother-in-law in August of 2022. He had owned the vehicle for at least a year before I purchased it from him. Shortly after the purchase, I noticed the engine light came on. On 09/12/22 a strong smell of fuel was emitting from the vehicle in a Walmart parking lot in Denton, Texas…
Read full complaint
We purchased the 2005 Porsche Cayenne from my brother-in-law in August of 2022. He had owned the vehicle for at least a year before I purchased it from him. Shortly after the purchase, I noticed the engine light came on. On 09/12/22 a strong smell of fuel was emitting from the vehicle in a Walmart parking lot in Denton, Texas at approximately 1030pm. I noticed a large puddle of gasoline on the ground under the vehicle and it was steady stream of fuel while the vehicle was running. The vehicle was completely unsafe to drive for fear of ignition and fire. Due to the time and location, I had the vehicle towed to my mechanic approximately 3 miles away for diagnosis and/or repair. The closest Porsche dealership was approximately 25 miles away and the tow bill would have been excessive. Mechanic identified the problem as a cracked fuel filter flange/housing that sat on top of the fuel pump. The cracked fuel housing was replaced and the total for parts and labor was $462.48. No leaking fuel since repair. A few weeks later my brother-in -law contacted me and advised he had just received a recall (OCTOBER 2022) in the mail from Porsche for the exact part I had repaired (17V-576 / AH10). He mailed me the recall and I contacted Porsche for a reimbursement. They stated they only refund for repairs done at a Porsche dealership. I believe Porsche should cover the repair cost for their faulty equipment even after the recall was received. A Porsche Service Center would charge Porsche Corporate much more for this repair than what I paid. Please assist me in getting a refund for my expense of ($462.48) for the repair of Porsche's recall. Thanks [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #11497792
Mileage unknown · Nov 2, 2022
Fuel System, Gasoline
The contact owns a 2005 Porsche Cayenne. The contact stated that while refueling the vehicle with the engine running, the vehicle shut off. The vehicle hesitated while restarting. The contact detected fuel leaking from the vehicle. The check engine and oil light warning lights were illuminated. The local dealer was not contacte…
Read full complaint
The contact owns a 2005 Porsche Cayenne. The contact stated that while refueling the vehicle with the engine running, the vehicle shut off. The vehicle hesitated while restarting. The contact detected fuel leaking from the vehicle. The check engine and oil light warning lights were illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was unknown.
NHTSA ODI #11491876
150,000 miles · Oct 6, 2022
Fuel System, Gasoline
The contact owns a 2005 Porsche Cayenne. The contact received notification of the NHTSA Campaign Number: 17V576000 (Fuel System, Gasoline) however, the contact stated that while driving, he smelled a fuel odor throughout the vehicle. The contact stated that he started to feel dizzy and pulled the vehicle off the roadway. The con…
Read full complaint
The contact owns a 2005 Porsche Cayenne. The contact received notification of the NHTSA Campaign Number: 17V576000 (Fuel System, Gasoline) however, the contact stated that while driving, he smelled a fuel odor throughout the vehicle. The contact stated that he started to feel dizzy and pulled the vehicle off the roadway. The contact then stated that upon inspecting the vehicle, he noticed that fuel had leaked under the hood of the vehicle onto the ground. The vehicle was driven to the destination. No warning lights were illuminated. The vehicle was not diagnosed or repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and the contact was informed to have the vehicle towed to the dealer. The failure mileage was approximately 150,000.
NHTSA ODI #11488239
Mileage unknown · Jan 29, 2020
Fuel/propulsion System
PORSCHE RECALLED THIS FUEL PUMP (17V-576) AFTER I REPLACED FOR THE SAME REASON IT WAS RECALLED. I'VE CONTACTED PORSCHE SEVERAL TIMES AND THEY STILL HAVE NOT ADDRESSED REPLACING THE FUEL PUMP FILTER FLANGE. IT'S BEEN MORE THAN 2 YEARS NOW? WHAT CAN I DO?
NHTSA ODI #11302892
162,160 miles · Oct 9, 2019
Latches/locks/linkages
TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT STATED THAT ALL FOUR DOOR LATCHES FAILED TO OPEN FROM OUTSIDE AND INSIDE THE VEHICLE. THE CONTACT CALLED PORSCHE ORLANDO (9590 US-17, MAITLAND, FL 32751, (407) 680-0785) AND WAS INFORMED THAT THERE WOULD BE A FEE TO REPAIR EACH DOOR. THE VEHICLE WAS NOT TAKEN TO A DEALER …
Read full complaint
TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT STATED THAT ALL FOUR DOOR LATCHES FAILED TO OPEN FROM OUTSIDE AND INSIDE THE VEHICLE. THE CONTACT CALLED PORSCHE ORLANDO (9590 US-17, MAITLAND, FL 32751, (407) 680-0785) AND WAS INFORMED THAT THERE WOULD BE A FEE TO REPAIR EACH DOOR. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED CASE NUMBER: 5557958. THE APPROXIMATE FAILURE MILEAGE WAS 162,160.
NHTSA ODI #11267395
168,000 miles · May 28, 2019
Electrical SystemElectronic Stability Control (esc)Vehicle Speed Control
GOOGLE: CAYENNE WET FLOOR. ALL CAYENNE HAVE ISSUE WITH POOR WATER DRAINAGE SYSTEM ACCORDING TO THE WEBSITES. MY CAR WAS DRIVING FINE BEFORE I PARKED IT, THEN WHEN I TRY TO START IT, I GOT AN ERROR ON THE INFO DISPLAY IN RED: IGNITION LOCK FAULT, ABS BRAKE PROPORTIONING. NO CRANK FROM THE BATTERY, TRANSMISSION LOCKED IN PARK. SO …
Read full complaint
GOOGLE: CAYENNE WET FLOOR. ALL CAYENNE HAVE ISSUE WITH POOR WATER DRAINAGE SYSTEM ACCORDING TO THE WEBSITES. MY CAR WAS DRIVING FINE BEFORE I PARKED IT, THEN WHEN I TRY TO START IT, I GOT AN ERROR ON THE INFO DISPLAY IN RED: IGNITION LOCK FAULT, ABS BRAKE PROPORTIONING. NO CRANK FROM THE BATTERY, TRANSMISSION LOCKED IN PARK. SO I GOOGLED IT AND FOUND MANY OWNERS FROM AROUND THE WORLD REPORTING THIS ISSUE. THE DRAINAGE UNDER THE WINDSHIELD CAN GET BLOCKED EASILY WITH DEBRIS, AND CAUSE WATER TO OVERFLOW INSIDE THE CABIN AND OR ELECTRICAL MODULES LOCATED IN THE WINDSHIELD COWL AREA. ON THE DRIVER SIDE AS PER VIDEO, I REMOVED THE RUBBER CARPET AND FORCED LIFTED THE PERMANENT CARPET, AND FOUND POOL OF WATER UNDERNEATH, ON THE METAL FLOOR WAS A BUNCH OF WIRES CONNECTING TO THE CAR BATTERY UNDER THE DRIVER SEAT WERE ALL UNDER WATER. I STARTED EMPTYING BUT MORE WATER KEPT COMING, FOAMS, RUBBERS WERE ALL SOAKED. ACCORDING TO THE FORUMS AFTER REMOVING ALL WATER, I NEEDED TO LOCATE 3 SET OF WIRES AMONGST THE BUNCH, THESE 3 ARE JOINED BY TWISTING AND WRAPPED WITH ELECTRICAL TAPE/GAUGE FROM THE FACTORY. THESE WIRES SINCE EXPOSED ARE SUSCEPTIBLE TO CORROSION. 1 SET OF WIRE COMPLETELY SNAPPED, APPARENTLY 1 WIRE IS FOR ABS BRAKE, AND THE OTHER IS FOR IGNITION KEY LOCK THAT RENDERS THE CAR IMMOBILIZED. I FOLLOWED THE VIDEO DESCRIBING THE STEPS TO FIX THIS ISSUE MYSELF, AND BIG BOLD LETTERS ON VIDEOS TO DO NOT BRING THE CAR TO THE DEALER AS THEY WILL CHARGE THOUSANDS, IF MODULES NEED REPLACING, RUST AN OWNER RECORDED A VIDEO ONLINE OF HIS CAYENNE DASH STOP WORKING, ALL LIGHTS BLINKING WHILE THE CAR WAS IN MOTION. LUCKILY MINE MALFUNCTIONED WHILE PARKED AT HOME, NOT DRIVING WITH MY FAMILY. I HAVE 2 CAYENNE, A 2005 AND 2008 THAT MY WIFE DRIVES. I NEED TO FOLLOW FORUM INSTRUCTION IN CLEANING THE DRAINAGE AND REMOVING THE GROMMET THAT CAN BE BLOCKED AND CAUSE WATER NOT TO DRAIN.
NHTSA ODI #11210362
45,000 miles · Feb 4, 2019
Fuel/propulsion System
I CALLED 3 TIMES TO HAVE MY RECALL REMEDIED AND PORSCHE DENIED ME EACH TIME BUT YOUR WEBSITE SAYS I HAVE AN OPEN RECALL, THEY TOLD ME IT IS BECAUSE THE RECALL WASN'T THAT IMPORTANT
NHTSA ODI #11174386
Official recalls
4Aug 30, 2022
Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2020 Porsche Macan, Cayenne, Panamera, and Cayman S, 2001-2004 Boxster, Boxster S, 2004 Boxster 50 JAHRE SPYDER 550 vehicles. Please see the recall report for a complete list of all affected models and model years. The caps that cover the low-beam headlight horizontal adjustment screws are missing, which can allow the headlights to be improperly adjusted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Improperly adjusted headlights may not illuminate the road properly, or cause a glare to oncoming drivers, which can increase the risk of a crash.
Remedy: Dealers will inspect the headlights for sealing caps and install missing caps as necessary, free of charge. Owner notification letters were mailed October 28, 2022. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is ANB4.
Jun 12, 2019
Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2006 Cayenne S, Cayenne Turbo, 2004-2010 Cayenne, 2006 Cayenne Turbo S, 2010-2016 Panamera S, Panamera 4 S, Panamera Turbo, 2011-2016 Panamera, Panamera 4, 2012-2013 Panamera Turbo S, 2013-2016 Panamera 4 GTS, 2014-2016 Panamera 4 S Executive, Panamera Turbo Executive, Panamera Turbo S G1 II, Panamera Turbo S Executive, 2013 Panamera 4 Platinum Edition, Panamera Platinum Edition, 2016 Panamera 4 Edition, Panamera Edition, Panamera Turbo S Executive Luxury Sports vehicles. The bushing that attaches the gear selector lever to the gearbox may degrade over time, causing the bushing to detach. This condition could allow the driver to move the shift lever to Park and remove the ignition key, while the transmission may not be in Park, with no warning message or audible chime.
Consequence & remedy
Consequence: If the vehicle is exited without the transmission being in Park and without the parking brake being applied, the vehicle may unexpectedly move, increasing the risk of a crash.
Remedy: Porsche will notify owners, and dealers will replace the shifter cable bushing, free of charge. Owners are instructed to use the parking brake until their vehicle is repaired. The recall began August 9, 2019. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AKB1.
Sep 20, 2017
Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2006 Cayenne S and Cayenne Turbo vehicles, 2004-2006 Cayenne vehicles, and 2006 Cayenne S "Titanium" Edition vehicles. These gasoline-powered vehicles have a fuel pump flange that may crack, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Porsche will notify owners, and dealers will replace the fuel filter flanges with new filter flanges that have a protective film, free of charge. The recall began July 6, 2018. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AH10.
Dec 15, 2004
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.
Consequence & remedy
Consequence: WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED INCREASING THE RISK OF INJURY OR DEATH TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL PERMANENTLY INSTALL A CLIP IN EITHER OF THE AFFECTED REAR OUTBOARD SEAT BELTS AND PROVIDE AN OWNER'S MANUAL INSERT. THE CLIPS WILL PREVENT UNWARRANTED CONVERSION FROM ALR TO ELR MODE WITH CHILD SEAT INSTALLATION. THE RECALL BEGAN MAY 17, 2005. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA06005 · Srs Warning Light Illumination
Opened Mar 15, 2006 · Closed Mar 12, 2007
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Air Bags:frontal:sensor/control MODULE-INACTIVE
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags:side/window
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE05060 · Srs Warning Light Illumination
Opened Nov 10, 2005 · Closed Mar 15, 2006
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Additional source detail variants (3)
Air Bags:frontal:sensor/control MODULE-INACTIVE
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Air Bags
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Air Bags:side/window
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Illustration