Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Gasoline. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reports
Mileage unknown · Jul 11, 2018
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2003 PORSCHE CAYENNE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V576000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (PORSCHE ROCHESTER, 3955…
Read full complaint
TL* THE CONTACT OWNS A 2003 PORSCHE CAYENNE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V576000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (PORSCHE ROCHESTER, 3955 W HENRIETTA RD, ROCHESTER, NY 14623, (585) 334-1600) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WOULD BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #11110701
49,350 miles · Jan 25, 2012
Power TrainStructure
TL* THE CONTACT OWNS A 2003 PORSCHE CAYENNE. THE CONTACT STATED THE DRIVE SHAFT WOULD VIBRATE EXCESSIVELY WHEN DRIVING AT ANY SPEED. THE CONTACT STATED THE VIBRATION WENT FROM A PART TIME OCCURRENCE TO BEING A CONSISTENT OCCURRENCE. THE CONTACT BELIEVED THAT THE SUPPORT BEARING FAILED. THE CONTACT DISCOVERED THE SUPPORT BEARING…
Read full complaint
TL* THE CONTACT OWNS A 2003 PORSCHE CAYENNE. THE CONTACT STATED THE DRIVE SHAFT WOULD VIBRATE EXCESSIVELY WHEN DRIVING AT ANY SPEED. THE CONTACT STATED THE VIBRATION WENT FROM A PART TIME OCCURRENCE TO BEING A CONSISTENT OCCURRENCE. THE CONTACT BELIEVED THAT THE SUPPORT BEARING FAILED. THE CONTACT DISCOVERED THE SUPPORT BEARING WAS BEING HELD TOGETHER BY A PIECE OF RUBBER. THE FAILURE MILEAGE WAS 49,350 AND THE CURRENT MILEAGE IS 52,000. UPDATED 03/05/12*LJ THE CONSUMER STATED THE DRIVESHAFT FAILED PREMATURELY. UPDATED EVOQ 03/08/12 UPDATED EVOQ 04/12/12
Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2020 Porsche Macan, Cayenne, Panamera, and Cayman S, 2001-2004 Boxster, Boxster S, 2004 Boxster 50 JAHRE SPYDER 550 vehicles. Please see the recall report for a complete list of all affected models and model years. The caps that cover the low-beam headlight horizontal adjustment screws are missing, which can allow the headlights to be improperly adjusted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Improperly adjusted headlights may not illuminate the road properly, or cause a glare to oncoming drivers, which can increase the risk of a crash.
Remedy: Dealers will inspect the headlights for sealing caps and install missing caps as necessary, free of charge. Owner notification letters were mailed October 28, 2022. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is ANB4.
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.
Consequence & remedy
Consequence: WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED INCREASING THE RISK OF INJURY OR DEATH TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL PERMANENTLY INSTALL A CLIP IN EITHER OF THE AFFECTED REAR OUTBOARD SEAT BELTS AND PROVIDE AN OWNER'S MANUAL INSERT. THE CLIPS WILL PREVENT UNWARRANTED CONVERSION FROM ALR TO ELR MODE WITH CHILD SEAT INSTALLATION. THE RECALL BEGAN MAY 17, 2005. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA06005 · Srs Warning Light Illumination
Opened Mar 15, 2006 · Closed Mar 12, 2007
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Air Bags:frontal:sensor/control MODULE-INACTIVE
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags:side/window
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE05060 · Srs Warning Light Illumination
Opened Nov 10, 2005 · Closed Mar 15, 2006
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Additional source detail variants (3)
Air Bags:frontal:sensor/control MODULE-INACTIVE
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Air Bags
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Air Bags:side/window
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
2003 Porsche Cayenne Problems, Complaints & Recalls | Skip That Year
Illustration