IllustrationSTARTED NOTICING A WHINING FROM THE REAR END, SOON MY "SLIP AND ABS" LIGHTS WERE LIGHTING ON THE DASH. DEALER TOLD ME IT WAS ONLY A SENSOR AND REPLACED MY COMPLETE REAR END (FOR A SENSOR?). *NM
2005 Nissan Titan
Owner reports · Recalls · Investigations
More warning signs than most Titan years
Owner complaints for the 2005 Nissan Titan are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all Titan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1240–25K
13825–50K
21550–75K
16175–100K
105100–150K
57150K+
800 reports with mileage · 91 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 469 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
What owners actually said
891 reportsI WAS DRIVING MY VEHICLE OFF ROAD AND LIGHT TERRAIN WENT HE REAR DIFFERENTIAL STARTED MAKING NOISE I TOOK TRUCK TO DEALERSHIP AND IT IS BEING FIXED BUT THIS IS THE 3RD TIME THIS HAS HAPPENED. *JB
I HAVE A 2005 NISSAN TITAN 4X4 THAT SEEMS TO BE BUGGED BY PARTS FAILURES (GREMLINS AS THE DEALER LIKES TP CALL THEM). THE FIRST PROBLEM (BRAKES) HAPPENED AT ABOUT 2 WEEKS OLD OR 1000 MILES. THE DEALER IMMEDIATELY FIXED THE PROBLEM(SO THEY SAID). ABOUT 1 MONTH LATER THE SAME PROBLEM OCCURRED. AGAIN THE DEALER FIXED IT. AT ABOUT …
Read full complaint
I HAVE A 2005 NISSAN TITAN 4X4 THAT SEEMS TO BE BUGGED BY PARTS FAILURES (GREMLINS AS THE DEALER LIKES TP CALL THEM). THE FIRST PROBLEM (BRAKES) HAPPENED AT ABOUT 2 WEEKS OLD OR 1000 MILES. THE DEALER IMMEDIATELY FIXED THE PROBLEM(SO THEY SAID). ABOUT 1 MONTH LATER THE SAME PROBLEM OCCURRED. AGAIN THE DEALER FIXED IT. AT ABOUT 5 MONTHS OLD (8000 MILES) THE REAR END SEEMS TO FALL APART. WHEN I BROUGHT IT TO THE DEALER THEY SAID IT IS A COMMON PROBLEM. THAT WHEN THEY FIX IT, THEY WILL PUT THE UPGRADED REAR END IN, WHICH TOOK ABOUT 2 WEEKS TO HAVE DONE. AT ABOUT 7 MONTHS OLD (14000 MILES) WHILE ON VACATION IN FLORIDA, THE STEERING COLUMN DECIDED TO FALL APART, CAUSING ME TO LOOSE STEERING AND ALMOST CRASH. NOW I HAD TO BRING IT TO A NEW DEALER DOWN IN FLORIDA (WHO DID NOT WANT TO TAKE THE TRUCK IN FOR REPAIR, BUT AFTER A LONG CONVERSATION WITH NISSAN OF NORTH AMERICA TOOK IT IN, FOR 3 WEEKS TO FIX THE PROBLEM). NOW AFTER 10 MONTHS (16000 MILES) OF OWNING THE TRUCK, THE REAR END HAS BROKEN AGAIN. IT IS AT THE DEALER ONCE AGAIN, WHERE I WAS TOLD THE PARTS ARE (VOR ORDERED) BACK ORDERED WITH NO DATE OF ARRIVAL. I LOVE THIS TRUCK BUT JUST DON'T KNOW WHAT TO DO ANYMORE. *NM
REAR DIFFERENTIAL FAILURE (2005 NISSAN TITAN, 12,800 MILES) - THERE WERE VERY FEW SIGNS LEADING UP TO THE FAILURE OF THE READ DIFFERENTIAL. I NOTICED SOME LOUD THUDS COMING FROM THE DRIVETRAIN AS I ACCELERATED. THEN WITHIN ABOUT 0.5 MILES OF DRIVING, THE THUDS WERE LOUDER AND MUCH MORE FREQUENT, AND THE TRUCK WAS NOTICEABLY ST…
Read full complaint
REAR DIFFERENTIAL FAILURE (2005 NISSAN TITAN, 12,800 MILES) - THERE WERE VERY FEW SIGNS LEADING UP TO THE FAILURE OF THE READ DIFFERENTIAL. I NOTICED SOME LOUD THUDS COMING FROM THE DRIVETRAIN AS I ACCELERATED. THEN WITHIN ABOUT 0.5 MILES OF DRIVING, THE THUDS WERE LOUDER AND MUCH MORE FREQUENT, AND THE TRUCK WAS NOTICEABLY STRUGGLING TO MOVE. I IMMEDIATELY PARKED IT AND HAD IT TOWED TO THE DEALERSHIP. THEY ARE REPLACING THE REAR AXLE ASSEMBLY (THE DAMAGE IS IN THE REAR DIFFERENTIAL, BUT APPARENTLY NISSAN JUST REPLACES THE ENTIRE REAR AXLE ASSEMBLY). THE AXLE ASSEMBLY IS BACK ORDERED FOR 2 WEEKS. *JB
PULLED UP TO STOP SIGN WITH NO PREVIOUS INDICATION OF PROBLEM. WHEN I PROCEEDED TO TURN LEFT, THE REAR DIFFERENTIAL STARTED MAKING LOUD CLUNKING NOISES AND SLIPPED IN AND OUT OF ENGAGEMENT. I WAS ABLE TO PUT TRUCK IN 4 WHEEL DRIVE TO GET IT TO DEALERSHIP. *JB THE PROBLEM HAS NOT YET BEEN CORRECTED AS NISSAN STATES I NEED A NE…
Read full complaint
PULLED UP TO STOP SIGN WITH NO PREVIOUS INDICATION OF PROBLEM. WHEN I PROCEEDED TO TURN LEFT, THE REAR DIFFERENTIAL STARTED MAKING LOUD CLUNKING NOISES AND SLIPPED IN AND OUT OF ENGAGEMENT. I WAS ABLE TO PUT TRUCK IN 4 WHEEL DRIVE TO GET IT TO DEALERSHIP. *JB THE PROBLEM HAS NOT YET BEEN CORRECTED AS NISSAN STATES I NEED A NEW REAR DIFFERENTIAL AND THEY ARE ON NATIONAL BACK ORDER. THEY CAN GIVE ME NO ESTIMATE AS TO WHEN I WILL GET MY VEHICLE BACK.
1. NO SIGNS OF ANY TROUBLE, WENT TO ACCELERATE AROUND A CORNER AND AXLE EXPLODED. 2. FAILURE CAUSED COMPLETE REAR AXLE TO BE REPLACED, LOSS OF VEHICLE USE AND TIME. 3. NISSAN TOWED TO DEALERSHIP REPLACED COMPLETE AXLE AFTER WAITING 2 WEEKS FOR A AXLE. MY DEALERSHIP WAS GREAT! KEN GARFF OREM, UTAH. *NM
ON 03/27/2006 DRIVING TO WORK IN MY 2005 NISSAN TITAN [XXX] PICKUP ACCELERATED ON ITS ON. I WAS STOPPED AT A STOP LIGHT MERGING IN TO TRAFFIC WHEN IT ACCELERATED FORWARD BY IT SELF AND WITH MY FOOT ON THE BRAKE. WHEN THIS ACCRUED I TRIED TO PUT IT IN TO NEUTRAL, STILL NOTHING HAPPEN, EVEN WITH BOTH OF MY FEET BARRING DOWN ON THE…
Read full complaint
ON 03/27/2006 DRIVING TO WORK IN MY 2005 NISSAN TITAN [XXX] PICKUP ACCELERATED ON ITS ON. I WAS STOPPED AT A STOP LIGHT MERGING IN TO TRAFFIC WHEN IT ACCELERATED FORWARD BY IT SELF AND WITH MY FOOT ON THE BRAKE. WHEN THIS ACCRUED I TRIED TO PUT IT IN TO NEUTRAL, STILL NOTHING HAPPEN, EVEN WITH BOTH OF MY FEET BARRING DOWN ON THE BRAKE THE TIRES WHERE BURNING RUBBER AND I WAS STILL MOVING SLOWLY FORWARD. FINALLY I TURNED THE IGNITION OFF AND IT SHUT DOWN, I WAITED A FEW MOMENTS AND TRIED TO START THE ENGINE AGAIN. AT THIS TIME IT DID IT AGAIN AND TURN THE ENGINE OFF AGAIN, WAITED A FEW MORE MINUTES AND TRIED AGAIN, AT THIS TIME IT STARTED CORRECTLY AND I DROVE IT DIRECTLY TO KRAFT NISSAN DEALERSHIP FOR THERE SERVICE DEPARTMENT. KRAFT NISSAN TOOK THE AFTERNOON TO LOOK OVER THE TRUCK, AT AROUND 3:01 PM THE SERVICE WRITER CALLED AND SAID THAT THEY COULD NOT DUPLICATE THE PROBLEM AND MY TRUCK IS READY TO BE PICKED UP. I SAID THAT THE PROBLEM IS REAL AND THAT THEY NEED TO FIND IT, THEY SAID IF PROBLEM CAN'T BE SEEN THEY CAN'T FIX IT. I TALK WITH THE SERVICE MANAGER AND THEN CALLED NISSAN AND WAS BASICALLY TOLD THE SAME THING. THE SERVICE MANAGER SAID TO DRIVE THE VEHICLE AND IF THE PROBLEM HAPPENS AGAIN THEY CAN TRY TO SOLVE AT THAT TIME. ALSO WAS TOLD THAT MY FOOT COULD HAVE BEEN ON THE BRAKE AND GAS PEDAL AT THE SAME TIME, TOLD HIM THAT WOULD HAVE BEEN IMPOSSIBLE BECAUSE BOTH OF MY FEET WHERE PRESSING THE BRAKE PEDAL TO THE FLOOR BOARD TO STOP THE TRUCK. *JB [XXX] UPDATED 07/16/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2005 NISSAN TITAN. PULLING ONTO A HIGHWAY ON RAMP FROM A STOP THE REAR DIFFERENTIAL BROKE. TRUCK WAS STILL DRIVABLE, BUT BY NO MEANS SAFE TO DRIVE. WAS ABLE TO DRIVE TO DEALERSHIP AND DROP OFF. *JB
1. WAS TURNING OUT OF PARKING LOT AND IN THE MIDDLE OF THE TURN I HEARD A CLANK, THEN LOSS OF POWER. I REGAINED POWER MOMENTARILY, BUT WAS NOT SURE WHAT EXACTLY HAD HAPPENED. I THEN DROVE HOME, ABOUT 1/2 A MILE, AND CALLED THE DEALERSHIP. THE DEALERSHIP THEN ASKED ME TO TAKE MY TRUCK TO THEM, ABOUT 4-5 MILES AWAY. THE DEALE…
Read full complaint
1. WAS TURNING OUT OF PARKING LOT AND IN THE MIDDLE OF THE TURN I HEARD A CLANK, THEN LOSS OF POWER. I REGAINED POWER MOMENTARILY, BUT WAS NOT SURE WHAT EXACTLY HAD HAPPENED. I THEN DROVE HOME, ABOUT 1/2 A MILE, AND CALLED THE DEALERSHIP. THE DEALERSHIP THEN ASKED ME TO TAKE MY TRUCK TO THEM, ABOUT 4-5 MILES AWAY. THE DEALERSHIP RECOGNIZED THAT SOMETHING WAS WRONG, BUT SOONEST AVAILABLE TIME TO LOOK AT IT WAS AFTER THE WEEKEND. I LEFT THE TRUCK AT THE DEALERSHIP BECAUSE I DID NOT FEEL COMFORTABLE DRIVING IT THE WAY IT WAS THEN. 2. THE FAILURE ENDED UP BEING THE REAR DIFFERENTIAL AND SINCE THERE HAS BEEN A NATIONAL BACK-ORDER IT HAS LEFT ME WITHOUT TRANSPORTATION UNTIL THE DEALERSHIP COULD RECEIVE THE PARTS AND INSTALL THEM. I WOULD NOT BE ABLE TO GET TO THE STORE TO BUY FOOD. 3. THE DEALERSHIP ORDERED REPLACEMENT PARTS FOR WHAT WAS BROKEN AND THEY PAID FOR MYSELF TO HAVE A RENTAL CAR WHILE I WAIT FOR THE PARTS TO COME IN AND GET PUT IN. *NM
DT*: THE CONTACT STATED WHILE DRIVING DOWNHILL 30MPH ON A WET ROAD, BRAKE PRESSURE WAS APPLIED AND THERE WAS A FRONT END VIBRATION AS THOUGH THE ABS ENGAGED. THIS WAS FOLLOWED BY THE VEHICLE'S REAR END SLING AROUND AND STRIKING SOME BRUSH AND TREES WITH MINOR DAMAGE. NO INJURIES WERE SUSTAINED AND THE POLICE WERE NOT CONTACTE…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING DOWNHILL 30MPH ON A WET ROAD, BRAKE PRESSURE WAS APPLIED AND THERE WAS A FRONT END VIBRATION AS THOUGH THE ABS ENGAGED. THIS WAS FOLLOWED BY THE VEHICLE'S REAR END SLING AROUND AND STRIKING SOME BRUSH AND TREES WITH MINOR DAMAGE. NO INJURIES WERE SUSTAINED AND THE POLICE WERE NOT CONTACTED. THE VEHICLE WAS SEEN BY A DEALER WHICH REPLACED THE ROTORS, BUT SUGGESTED THE ACCIDENT COULD BE ATTRIBUTED TO THE WET ROAD CONDITIONS.
Official recalls
410V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V459000 · Electrical System
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.