IllustrationDIFFERENTIAL REAR BROKE AFTER ONLY 7100 MILES. NO TOWING EVER INVOLVED WITH THIS VEHICLE. *NM
2005 Nissan Titan
Owner reports · Recalls · Investigations
More warning signs than most Titan years
Owner complaints for the 2005 Nissan Titan are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all Titan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1240–25K
13825–50K
21550–75K
16175–100K
105100–150K
57150K+
800 reports with mileage · 91 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 469 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
What owners actually said
891 reportsI PURCHASED MY 2005 NISSAN TITAN ON SEPTEMBER 28, 2005. I NOTICED A VIBRATION BEGINNING IN LATE FEBRUARY 2006 WHEN BRAKING. ON MARCH 11, 2006, THE BRAKES WERE REPORTED WITHIN NORMAL LIMITS DURING REGULAR SCHEDULED MAINTENANCE AT 17344 MILES. THE SERVICE TECHNICIAN REPORTED THAT THE ROTORS WERE WARPED AND RECOMMENDED AN UPDATE…
Read full complaint
I PURCHASED MY 2005 NISSAN TITAN ON SEPTEMBER 28, 2005. I NOTICED A VIBRATION BEGINNING IN LATE FEBRUARY 2006 WHEN BRAKING. ON MARCH 11, 2006, THE BRAKES WERE REPORTED WITHIN NORMAL LIMITS DURING REGULAR SCHEDULED MAINTENANCE AT 17344 MILES. THE SERVICE TECHNICIAN REPORTED THAT THE ROTORS WERE WARPED AND RECOMMENDED AN UPDATED BRAKE KIT IF THE VEHICLE HAD NOT ALREADY HAD IT. THE SERVICE ADVISOR STATED THAT THERE WAS NO NEED TO DO THIS WORK UNTIL THE BRAKES NEEDED TO BE REPLACED AND THAT THE VEHICLE WAS STILL SAFE TO DRIVE. THE VIBRATION HAS CONSISTENTLY WORSENED SINCE THAT TIME AND THE ENTIRE TRUCK VIBRATES WHEN BRAKING. I FEEL THAT THIS IS A MANUFACTURER'S DEFECT. I HAVE OWNED MANY OTHER TRUCKS AND NEVER REQUIRED BRAKES OR ROTOR REPAIR WITHIN 6 MONTHS OF PURCHASE. I HAVE RESEARCHED DIFFERENT WEBSITES TO DISCOVER THERE HAVE BEEN NO RECALLS IN THIS AREA. *NM
LOUD CLUNK WHEN ACCELERATING, SLACK IN DRIVE LINE WHEN SHIFTING. DEALER REPLACED ENTIRE REAR END. *NM
UPON PULLING OUT INTO TRAFFIC FROM A GAS STATION THE REAR DIFFERENTIAL OR MY 05 NISSAN TITAN FAILED. I WAS ABLE TO DRIVE DIRECTLY TO THE DEALERSHIP BEING CAREFUL NOT TO ACCELERATE TO FAST. THE SPIDER GEAR FAILED AND THE ENTIRE REAR AXLE WAS REPLACED IN WEEK. *NM
I WAS DRIVING DOWN THE ROAD, WHEN THE REAR-END, LOCKED UP, AND THERE WAS A LOUD BANG FOLLOWED BY A VIOLENT JERKING MOTION. ALL I COULD HEAR WAS METAL ON METAL GRINDING AND MY TRANSMISSION GRINDING TO A HALT. SINCE THE REAR END HAS FAILED, THE TRANSMISSION HAS A SHUDDERING TO IT BETWEEN 30-35 MPH AND THE STEERING HAS BEEN OFF IN…
Read full complaint
I WAS DRIVING DOWN THE ROAD, WHEN THE REAR-END, LOCKED UP, AND THERE WAS A LOUD BANG FOLLOWED BY A VIOLENT JERKING MOTION. ALL I COULD HEAR WAS METAL ON METAL GRINDING AND MY TRANSMISSION GRINDING TO A HALT. SINCE THE REAR END HAS FAILED, THE TRANSMISSION HAS A SHUDDERING TO IT BETWEEN 30-35 MPH AND THE STEERING HAS BEEN OFF IN THE TRUCK AS WELL. IT IS HARD TO MAINTAIN CONTROL SOMETIMES, AND THE DEALER DOES NOT WANT TO HELP FIX THE PROBLEM. THE DEALER HAS REPLACED THE REAR-END, BUT THE SHUDDERING AND STEERING PROBLEMS ARE STILL PREVALENT, AND THE ANSWERS I SEEM TO BE GETTING FROM THE DEALER IS THAT IT IS MY FAULT, MY PROBLEM, AND THAT I AM LOOKING FOR THINGS FOR THEM TO FIX!!!!*JB
REAR END FAILED. NO TOWING WAS DONE WITH THIS TRUCK. NOTHING USER DID CONTRIBUTED TO FAILURE. REAR END REPLACED. REPLACEMENT TOOK 25 DAYS. *JB
DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT VARIOUS SPEEDS THE FRONT OF THE VEHICLE VIBRATES. THE VIBRATIONS CAN BE FELT IN THE STEERING WHEEL AND THE DRIVER'S SIDE FLOOR BOARD. THE PROBLEM OCCURS WITHOUT WARNING AND HAS PROGRESSIVELY BECOME WORSE. THE VEHICLE HAS NOT BEEN INSPECTED. *AK
WAS SITTING ON A SLIGHT UPHILL WAITING TO MAKE A LEFT TURN INTO A DRIVEWAY. HAD 2 MOTORCYCLES IN THE BACK. HIT THE GAS, HEARD A LOUD CLUNK THAT SHOOK THE WHOLE TRUCK. PULLED INTO PARKING LOT AND DISCOVERED IT WAS THE DIFF. AFTER THAT I DROVE IT TO THE DEALERSHIP. ANYTIME I TURNED OR ACCELERATED THE DIFF WOULD GO CLUNK CLUNK…
Read full complaint
WAS SITTING ON A SLIGHT UPHILL WAITING TO MAKE A LEFT TURN INTO A DRIVEWAY. HAD 2 MOTORCYCLES IN THE BACK. HIT THE GAS, HEARD A LOUD CLUNK THAT SHOOK THE WHOLE TRUCK. PULLED INTO PARKING LOT AND DISCOVERED IT WAS THE DIFF. AFTER THAT I DROVE IT TO THE DEALERSHIP. ANYTIME I TURNED OR ACCELERATED THE DIFF WOULD GO CLUNK CLUNK CLUNK. DEALER PAID UP TO $35 FOR A RENTAL CAR BUT BECAUSE I HAD THE DIRT BIKES I HAD TO PAY $10/DAY OUT OF POCKET TO RENT ANOTHER TRUCK. REPAIRS NOT COMPLETED YET. *NM
BRAKE PEDAL PUSHES BACK AGGRESSIVELY, SHIMMY IN STEERING WHEEL AT SPEEDS OF 35 MPH. STEERING WHEEL JERKS AT TIMES TO RIGHT AND LEFT AT SPEEDS OF UP TO 50 MPH ALONG WITH BRAKE PEDAL PUSH BACK. THIS HAPPENED IN A MATTER OF DAYS. THE PROBLEM IS GETTING WORSE. DEALERSHIP SAYS I HAVE TO PAY TO GET NEW ROTORS A BRAKES. I HAVE NOT DROV…
Read full complaint
BRAKE PEDAL PUSHES BACK AGGRESSIVELY, SHIMMY IN STEERING WHEEL AT SPEEDS OF 35 MPH. STEERING WHEEL JERKS AT TIMES TO RIGHT AND LEFT AT SPEEDS OF UP TO 50 MPH ALONG WITH BRAKE PEDAL PUSH BACK. THIS HAPPENED IN A MATTER OF DAYS. THE PROBLEM IS GETTING WORSE. DEALERSHIP SAYS I HAVE TO PAY TO GET NEW ROTORS A BRAKES. I HAVE NOT DROVE THAT AGGRESSIVE NOR SLAMMED ON MY BRAKES TO HAVE ROTORS REPLACED, NOR DO I RIDE THE BRAKES TO HAVE MY BRAKES REPLACED THIS EARLY IN THE GAME FOR A NEW TRUCK DO THIS! THIS IS OUTRAGEOUS THAT I WAS NEVER TOLD ABOUT A POSSIBLE BRAKE AND ROTOR PROBLEM. THIS IS A MAJOR SAFETY ISSUE. I WILL NOT PUT MY FAMILY IN THIS TRUCK. THE CORPORATE PERSON I TALKED TO SAYS THEY ARE AWARE OF THE PROBLEM AND ADDRESSED THE PROBLEM WITH THAT I WAS NOT THE ONLY PERSON HAVING THIS PROBLEM, BUT NO RECALL WAS ISSUED NOT EVEN A WARNING WAS POSTED. THIS IS NOT GENERAL MAINTENANCE THIS IS A MAJOR(SAFETY) DEFECT. CORPORATE TOLD ME THAT THE ROTORS ARE TO SMALL FOR THE TRUCK. IF THERE IS A MAJOR ACCIDENT WHO GETS STUCK WITH THE BILL MY INSURANCE COMPANY AND I COVER THE GAP. I HAVE ALREADY REPLACED TWO TIRES FOR ABNORMAL WEARING IN THE FRONT OF THE TRUCK AND THAT IS AFTER ROTATING SEVERAL TIMES. IS THIS A SAFETY ISSUE, LIKE THE ONE FORD HAD ON ITS EXPLORER? I WILL NOT RECOMMEND THIS CAR COMPANY TO ANYBODY. *JB
DT*: THE CONTACT STATED AT VARIOUS SPEEDS THE FRONT END VIBRATED. THE DEALERSHIP DETERMINED THE PROBLEM WAS WITH THE TIRES AND THE TIRES WERE ROTATED. THIS DID NOT RESOLVE THE PROBLEM.
Official recalls
410V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V459000 · Electrical System
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.