TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED WHILE DRIVING 30 MPH, HE HEARD AN ABNORMAL NOISE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT DRIVABLE. THE CONTACT STATED PARKED ON THE SIDE OF THE ROADWAY. THE CONTACT STATED HE AND 3 OTHER BYSTANDERS PUSHED THE VEHICLE TO A NEARBY INDEPE…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED WHILE DRIVING 30 MPH, HE HEARD AN ABNORMAL NOISE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT DRIVABLE. THE CONTACT STATED PARKED ON THE SIDE OF THE ROADWAY. THE CONTACT STATED HE AND 3 OTHER BYSTANDERS PUSHED THE VEHICLE TO A NEARBY INDEPENDENT MECHANIC. THE INDEPENDENT MECHANIC INFORMED HIM THAT THE REAR WHEEL WHEEL-BEARINGS NEEDED TO BE REPLACED. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT YET DIAGNOSED NOR REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 126,500.
NHTSA ODI #11365221
92,000 miles · Oct 4, 2016
Service BrakesSuspension
REAR AXLE SEAL LEAKS IN THIS MODEL IT IS A KNOWN PROBLEM YET NISSAN STILL CHOOSES TO DO NOTHING ABOUT IT ,IT IS A HUGE SAFETY ISSUE IT LEAKS FLUID CONTINUOUSLY ON TO THE BACK BREAKING SYSTEM SO NOT ONLY COULD IT COMPRISE YOUR WHOLE BACK END BUT ALSO YOUR ABILITY TO STOP YOUR VEHICLE SAFELY,THIS HAS BEEN REPORTED THOUSANDS OF TIM…
Read full complaint
REAR AXLE SEAL LEAKS IN THIS MODEL IT IS A KNOWN PROBLEM YET NISSAN STILL CHOOSES TO DO NOTHING ABOUT IT ,IT IS A HUGE SAFETY ISSUE IT LEAKS FLUID CONTINUOUSLY ON TO THE BACK BREAKING SYSTEM SO NOT ONLY COULD IT COMPRISE YOUR WHOLE BACK END BUT ALSO YOUR ABILITY TO STOP YOUR VEHICLE SAFELY,THIS HAS BEEN REPORTED THOUSANDS OF TIMES TO YOUR AGENCY IN THE MEANTIME THE CONSUMERS CONTINUE TO REPLACE THESE EVERY 30-40,000 MILES JUST TO MAINTAIN THEIR SAFETY AND OTHERS ON THE ROAD WHEN I FEEL IT IS TIME NISSAN ADDRESS THIS AND TAKE THE NECESSARY STEPS TO ENSURE THE BRAKING SYSTEM IN THESE VEHICLES IS NOT CREATING A POTENTIAL HAZARD TOP THE DRIVER OR OTHERS ON THE ROAD . I TOOK MY VEHICLE IN FOR AN OIL CHANGE YESTERDAY ONLY TO FIND OUT MY SEAL IS LEAKING AGAIN AND NOW MY BACK BRAKES NEED TO BE REPLACED AGAIN BECAUSE THEY ARE NO LONGER SAFE DUE TO THE OIL LEAKING ON THEM AGAIN FROM THIS SEAL I DRIVE MY CHILDREN IN THIS VEHICLE DAILY TO SCHOOL TO GAMES AND IM THANKFUL THAT I HAPPENED TO NEED AN OIL CHANGE OR I WOULD HAVE HAD NO IDEA IT WAS LEAKING AGAIN OR JUST HOW UNSAFE MY DRIVING THIS VEHICLE COULD POTENTIALLY BE FOR MY CHILDREN AND MYSELF OR ANYBODY THAT IS DRIVING NEAR ME WHEN IT REQUIRES BRAKING TO STOP .
NHTSA ODI #10913738
60 miles · Jul 2, 2016
Suspension
FRONT CONTROL ARM LOWER.
NHTSA ODI #10882322
Mileage unknown · May 10, 2015
EngineFuel/propulsion SystemSuspension
HI, I HAVE A 2005 NISSAN TITAN AND THE EXHAUST MANIFOLD HAS CRACKED IN THE SAME SPOT TWICE NOW AND IT IS BEFORE THE CAT SO THAT MEANS ITS NOW A GROSS POLLUTER. THE PROBLEM IS YOU GET IT FIXED AND THEY PUT THE SAME PART BACK ON THAT CRACKS AGAIN BECAUSE THEY HAVEN'T CHANGED THE DESIGN. THERE ARE 3 OTHER TITANS IN MY TOWN AND A…
Read full complaint
HI, I HAVE A 2005 NISSAN TITAN AND THE EXHAUST MANIFOLD HAS CRACKED IN THE SAME SPOT TWICE NOW AND IT IS BEFORE THE CAT SO THAT MEANS ITS NOW A GROSS POLLUTER. THE PROBLEM IS YOU GET IT FIXED AND THEY PUT THE SAME PART BACK ON THAT CRACKS AGAIN BECAUSE THEY HAVEN'T CHANGED THE DESIGN. THERE ARE 3 OTHER TITANS IN MY TOWN AND ALL OF US HAVE THE SAME STORY. ALSO THE SWAY BAR MOUNT ON ALL OF OURS ARE BROKE WITCH RESULTS IN VERY POOR HANDLING. I HOPE IT CAN BE RECALLED BEFORE SOMETHING SERIOUS HAPPENS. THANK YOU.
NHTSA ODI #10715537
80,000 miles · Oct 1, 2014
Power TrainSuspension
REAR END GAVE OUT AT 5 MPH. *TR
NHTSA ODI #10640682
137,460 miles · Sep 2, 2014
Power TrainSuspension
DRIVER SIDE AXLE SHAFT POP OUT OF FRONT DIFFERENTIAL AND THE FRONT DIFFERENTIAL NO LONGER WORKS. *TR
NHTSA ODI #10630267
28,000 miles · Apr 22, 2014
Suspension
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE REAR LEAF SPRING FRACTURED AND PUNCTURED THE BED OF THE TRUCK. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN DIAGNOSED THAT THE REAR LEAF SPRING NEEDED TO BE REPLACED. NO REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF FAILURE. TH…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE REAR LEAF SPRING FRACTURED AND PUNCTURED THE BED OF THE TRUCK. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN DIAGNOSED THAT THE REAR LEAF SPRING NEEDED TO BE REPLACED. NO REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 28,000.
NHTSA ODI #10584228
130,000 miles · Jan 8, 2014
Suspension
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE REAR OF THE VEHICLE EXHIBITED A LOUD POP. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE REAR DIFFERENTIAL FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE REAR OF THE VEHICLE EXHIBITED A LOUD POP. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE REAR DIFFERENTIAL FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.
NHTSA ODI #10559003
82,000 miles · Nov 6, 2013
Power TrainSuspension
WHEN I STEPPED ON THE BRAKES TO START STOPPING, IT DIDN'T FEEL LIKE IT WAS GRABBING AND I REALLY HAD TO STAND ON THE PEDAL TO STOP BEFORE I HIT THE CAR IN FRONT OF ME. WHEN I GOT HOME, I LOOKED AT ALL MY BRAKES AND FOUND THAT THE REAR AXLE SEAL ON THE DRIVER'S SIDE WAS LEAKING. GREASE/OIL WAS ALL OVER THE REAR BRAKES. I HAVE …
Read full complaint
WHEN I STEPPED ON THE BRAKES TO START STOPPING, IT DIDN'T FEEL LIKE IT WAS GRABBING AND I REALLY HAD TO STAND ON THE PEDAL TO STOP BEFORE I HIT THE CAR IN FRONT OF ME. WHEN I GOT HOME, I LOOKED AT ALL MY BRAKES AND FOUND THAT THE REAR AXLE SEAL ON THE DRIVER'S SIDE WAS LEAKING. GREASE/OIL WAS ALL OVER THE REAR BRAKES. I HAVE HAD THE SEAL REPLACED 3 TIMES NOW. THIS IS RIDICULOUS AND IS A SAFETY HAZARD. THE DEALER WANTS $1800 TO DO IT AGAIN!! WE NEED A RECALL. *TR
NHTSA ODI #10551106
48,000 miles · Aug 18, 2013
Power TrainSuspension
FRONT DIFFERENTIAL STARTED MAKING NOISE, WHEN MECHANICS OPENED IT, THEY SAID IT WAS IMPOSSIBLE TO REBUILD AND I NEED A BRAND NEW ASSEMBLY. (TOO MUCH INTERNAL DAMAGE.) FOR THE MILEAGE THIS TRUCK HAS, THIS PART FAILED WAY TO EARLY. MECHANIC SAID IT HAPPENED BECAUSE OF ITS POOR DESIGN. NOW TRUCK HAS 60,000 MILES AND REAR DIFFERENTI…
Read full complaint
FRONT DIFFERENTIAL STARTED MAKING NOISE, WHEN MECHANICS OPENED IT, THEY SAID IT WAS IMPOSSIBLE TO REBUILD AND I NEED A BRAND NEW ASSEMBLY. (TOO MUCH INTERNAL DAMAGE.) FOR THE MILEAGE THIS TRUCK HAS, THIS PART FAILED WAY TO EARLY. MECHANIC SAID IT HAPPENED BECAUSE OF ITS POOR DESIGN. NOW TRUCK HAS 60,000 MILES AND REAR DIFFERENTIAL STARTED TO LEAK. *TR
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
2005 Nissan Titan Problems, Complaints & Recalls | Skip That Year
Illustration