2008 Nissan Titan

The exhaust manifolds on the driver and passenger side are cracked. Ticking sounds are made while car is cold and goes away after they have heated up enough, typically after 5 minutes. This results in letting in exhaust fumes inside the cabin, regardless of the air conditioner/heater is on, which leads to being lightheaded and nearly passing out and crashing. The fumes are stronger when stationary but happens no matter what, even after the ticking is gone and driving down the highway.

I am writing in regards to a recall that has previously been serviced on my vehicle. I bought my 2008 Nissan Titan through a private party on 4/16/23. The truck had no issues until 4/20/23. The fuel gauge read that I had a quarter tank of gas. However I was driving to work that morning and all of a sudden the truck acted as if it would when one runs out of fuel. I was not able to use the breaks and the steering was near impossible. I was frightened as I had my baby in the truck with me and I easily could have caused an accident not being able to use my breaks especially. Once I got to the side of the road and we stopped "coasting" I called for help. I did have an individual bring me some gas just incase that could have been the issue. Sure enough once I put fuel in it the truck started up and I got to the closet gas station to fuel up. Come to find out once my gas gauge reads a quarter tank it is in fact empty. The truck had a recall serviced on 4/16/2010 to replace the fuel gauge sending unit. I took the truck in to be serviced on 4/24/23 because of the issue I experienced. I was told that it was more than likely the sending unit and it would cost me $600-$800 to have it fixed. Why should I have to pay for a cost that has already been serviced once? Is there a warranty on a recall that has already been serviced? Can this possibly be a defect in the recall that was already serviced?

The contact owns a 2008 Nissan Titan. The contact stated upon starting the vehicle, the vehicle emitted abnormal ticking sounds. There was no warning light illuminated. The contact stated that the failure persisted. The vehicle was taken to an exhaust specialist where it was diagnosed that the weld joint between the tube and the common mounting plate of the manifold was cracked, allowing the exhaust gas to escape and expand underneath the hood of the vehicle. The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 95,000.

The contact owns a 2008 Nissan Titan. The contact stated that the fuel gauge inaccurately displayed the fuel level as empty. The contact had to constantly refuel the vehicle. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The contact related the failure to NHTSA Campaign Number: 10V074000 (Fuel System, Other) however, the VIN was not included in the recall. The failure mileage was approximately 186,000.