IllustrationTHE AIR CONDTIONING DOOR ACTUATORS COMMONLY GO OUT CAUSING THE SYSTEM TO NOT BE ABLE TO PERFORM THE DUTY OF DEFROSTING THE WINDSHIELD. EFFECTED ACTUATORS ARE BOTH THE TEMPERATURE CONTROL AND AIR FLOW CONTROL. THE PROBLEM HAS EFFECTED ALL NISSAN TITANS 2004-2015 HOWEVER A RECALL HAS ONLY BEEN ISSUED TO 2009 YEAR AND NEWER TITANS.
2005 Nissan Titan
Owner reports · Recalls · Investigations
More warning signs than most Titan years
Owner complaints for the 2005 Nissan Titan are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all Titan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1240–25K
13825–50K
21550–75K
16175–100K
105100–150K
57150K+
800 reports with mileage · 91 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 469 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
What owners actually said
891 reportsI NOTICED OIL IN MY DRIVEWAY. HOWEVER, I WAS UNABLE TO LOCATE THE SOURCE INITIALLY. THE LAST INCIDENT I RETURNED HOME FROM WORK. AS I WAS ABOUT TO LEAVE, I NOTICED MORE OIL ON THE GROUND. I STARTED LOOKING UNDER MY TRUCK AGAIN. THIS TIME I FOUND EXCESSIVE AMOUNTS OF OIL ON THE REAR DRIVER SIDE TIRE. I TOOK MY 2005 NISSAN TITAN T…
Read full complaint
I NOTICED OIL IN MY DRIVEWAY. HOWEVER, I WAS UNABLE TO LOCATE THE SOURCE INITIALLY. THE LAST INCIDENT I RETURNED HOME FROM WORK. AS I WAS ABOUT TO LEAVE, I NOTICED MORE OIL ON THE GROUND. I STARTED LOOKING UNDER MY TRUCK AGAIN. THIS TIME I FOUND EXCESSIVE AMOUNTS OF OIL ON THE REAR DRIVER SIDE TIRE. I TOOK MY 2005 NISSAN TITAN TO THE REPAIR SHOP. UPON COMPLETION OF THEIR INSPECTION, I WAS GIVEN A COPY OF NISSAN'S SERVICE BULLETIN REFERENCE #NTB10-032 2004 - 2008 TITAN, REAR AXLE SEAL LEAKS. THEIR LISTED REQUIRED ACTION IS TO "INSTALL THE NEW AXLE SHAFT ASSEMBLY---WHICH INCLUDES A NEW RETAINER, AXLE BEARING, OIL SEAL, BEARING CAGE, AND ABS ROTOR---LISTED IN THE PARTS INFORMATION TABLE". IMMEDIATELY BELOW ACTION IS A NOTE WHICH STATES "DO NOT REPLACE THE ENTIRE REAR AXLE ASSEMBLY FOR THIS INCIDENT, IF IT SHOULD OCCUR". I CONTACTED NHTSA WHO THEN REFERRED ME TO NISSAN @ 800-647-7261. ONCE IN CONTACT WITH NISSAN, THE REPRESENTATIVE ASKED FOR THE LAST SIX NUMBERS OF THE VIN, PLACED ME ON HOLD, AND AFTER A FEW MINUTES SHE CAME BACK AND REFERRED ME TO MY INITIAL POINT OF CONTACT. THIS SHOULD BE A RECALL, NOT JUST A SERVICE BULLETIN. IT WOULD BE VERY TRAGIC TO HEAR OF A FATALITY AS A RESULT OF A FAULTY PRODUCT. READING THE MANY REVIEWS FROM TITAN OWNERS IT IS EVIDENT THE PART IS A DEFECT AND SHOULD BE TREATED AS SUCH.
I WAS LOOKING ON THIS WEBSITE AND SEEN 6 RECALLS FOR THE 2005 NISSAN TITAN WHICH I HAVE AND AND NOTICED THERE WAS A RECALL FOR THE WIRE HARNESS ON THE DRIVERSIDE REAR DOOR. WELL ALL THOSE WIRES ARE BROKEN OFF NO MUSIC FROM THE REAR SPEAKERS ON EITHER SIDE. I'M HAVING PROBLEMS WERE I TRY TO ACCELERATE AND THE TRUCK BARELY WANTS T…
Read full complaint
I WAS LOOKING ON THIS WEBSITE AND SEEN 6 RECALLS FOR THE 2005 NISSAN TITAN WHICH I HAVE AND AND NOTICED THERE WAS A RECALL FOR THE WIRE HARNESS ON THE DRIVERSIDE REAR DOOR. WELL ALL THOSE WIRES ARE BROKEN OFF NO MUSIC FROM THE REAR SPEAKERS ON EITHER SIDE. I'M HAVING PROBLEMS WERE I TRY TO ACCELERATE AND THE TRUCK BARELY WANTS TO MOVE AND SOMETIMES TAKES LONG TO FINALLY START. WHEN YOUR IDLING IT SOUNDS AS IF IT'S GOING TO BREAK DOWN. WHEN THE A.C. IS ON IT MAKES A VERY LOUD ANNOYING SOUND. I'VE ADDED PICS OF WHAT I FOUND ON YOUR WEBSITE AS I'VE INCLUDED A PIC OF THE FRAYED WIRES FROM THE HARNESS AND NISSAN OF MELBOURNE ISN'T TRYING TO FIX THIS BEING A RECALLED PART.
I TOOK MY TRUCK TO YOUNGBLOOD NISSAN IN SPRINGFIELD AND THEY SAID THAT THEY CANT FIXED MY RECALL BECAUSE OF THE LINES WERE RUSTED SOMETHING LIKE THAT AND IS GOING TO CHARGE ME 1200.00 BUT THE RECALL SHOULD COVERIT
WHILE DRIVING ONE THE HIGHWAY I NOTICED MY VEHICLE START TO SHUTTER AND SHUT DOWN AS IF IT RAN OUT OF GAS. MY FUEL GAUGE SAID HALF A TANK SO I DIDN'T THINK IT WAS THE PROBLEM UNTIL I WALKED TO THE GAS STATION TO FILL UP A GAS CAN. I PUT 2 GALLONS OF GAS INTO MY FUEL TANK THAT SAID I HAD A HALF A TANK. I STARTED MY TRUCK AND IT S…
Read full complaint
WHILE DRIVING ONE THE HIGHWAY I NOTICED MY VEHICLE START TO SHUTTER AND SHUT DOWN AS IF IT RAN OUT OF GAS. MY FUEL GAUGE SAID HALF A TANK SO I DIDN'T THINK IT WAS THE PROBLEM UNTIL I WALKED TO THE GAS STATION TO FILL UP A GAS CAN. I PUT 2 GALLONS OF GAS INTO MY FUEL TANK THAT SAID I HAD A HALF A TANK. I STARTED MY TRUCK AND IT STARTED. SINCE THAT INCIDENT IT HAS HAPPENED 3 TIMES, THE MOST RECENT BEING YESTERDAY 07/02/18. I REPLACED THE FUEL PUMP TODAY IN HOPES THAT IT FIXES THE PROBLEM.
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 80 MPH, THE VEHICLE STALLED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE FUEL GAUGE REFLECTED A QUARTER OF A TANK AVAILABLE. THE CONTACT COASTED THE VEHICLE TO THE SHOULDER OF THE ROAD. THE CONTACT CALLED A FAMILY MEMBER TO BRING SOME FUEL. AS SOON AS TH…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 80 MPH, THE VEHICLE STALLED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE FUEL GAUGE REFLECTED A QUARTER OF A TANK AVAILABLE. THE CONTACT COASTED THE VEHICLE TO THE SHOULDER OF THE ROAD. THE CONTACT CALLED A FAMILY MEMBER TO BRING SOME FUEL. AS SOON AS THE FUEL WAS ADDED, THE VEHICLE STARTED NORMALLY. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED THREE OTHER TIMES, BUT THE VEHICLE WOULD START WHEN FUEL WAS ADDED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 210,000.
I HAVE RUN OUT OF GAS TWICE WHILE I WAS DRIVING. THE GAS GAUGE STILL SHOWED OVER A QUARTER OF A TANK. BOTH TIMES I WAS ON A RESIDENTIAL STREET. I LOST POWER STEERING AND BRAKES.
THE FUEL GAUGE SEEMS TO WORK INTERMITTENTLY AND AFTER RESEARCHING THE PROBLEM ONLINE IT APPEARS THERE IS A RECALL AFFECTING MY TRUCK, CAMPAIGN ID # R1010 NHTSA 10V-074.
DRIVING DOWN A BUSY ROAD ON MY WAY HOME FROM WORK AND VEHICLE SPUTTERS AS IF OUT OF FUEL UNTIL IT DIED. COULD NOT GET TRUCK TO CRANK AND WAS CLEARLY A LACK OF FUEL. FUEL GAUGE READ 1/4 TANK FULL EXACTLY AS DESCRIBED IN CAMPAIGN 10V074000. FORTUNATRLY A POLICE OFFICER ASSISTED IN PUSHING MY TRUCK INTO A PARKING LOT. I CALLED A FA…
Read full complaint
DRIVING DOWN A BUSY ROAD ON MY WAY HOME FROM WORK AND VEHICLE SPUTTERS AS IF OUT OF FUEL UNTIL IT DIED. COULD NOT GET TRUCK TO CRANK AND WAS CLEARLY A LACK OF FUEL. FUEL GAUGE READ 1/4 TANK FULL EXACTLY AS DESCRIBED IN CAMPAIGN 10V074000. FORTUNATRLY A POLICE OFFICER ASSISTED IN PUSHING MY TRUCK INTO A PARKING LOT. I CALLED A FAMILY MEMBER TO DRIVE UP WITH A GAS CONTAINER TO PUT A FEW GALLONS IN. SURE ENOUGH, CRANKED RIGHT UP. THE FOLLOWING DAY, I CONTACTED NISSAN OF USA, MY VEHICLE WAS NOT INCLUDED IN THE CAMPAIGN AND BECAUSE OF THE AGE AND MILEAGE OF MY TRUCK I WOULD NOT RECEIVE ASSISTANCE IN THE REPAIR OF THIS MANUFACTURER DEFECT.
2005 NISSAN TITAN 121K MILES. CRACKED EXHAUST MANIFOLD CAUSING A EXHAUST LEAK. THERE IS A STRONG EXHAUST SMELL IN THE CAB WHEN TRAVELING AT SLOWER SPEEDS (UNDER 35MPH). IT HAS BEEN SO BAD AT TIMES IT MAKES YOU LIGHT HEADED AND SICK TO YOUR STOMACH. THIS COULD CAUSE SOMEONE TO PASS OUT WHILE DRIVING CAUSING THEM TO LOOSE CONTROL …
Read full complaint
2005 NISSAN TITAN 121K MILES. CRACKED EXHAUST MANIFOLD CAUSING A EXHAUST LEAK. THERE IS A STRONG EXHAUST SMELL IN THE CAB WHEN TRAVELING AT SLOWER SPEEDS (UNDER 35MPH). IT HAS BEEN SO BAD AT TIMES IT MAKES YOU LIGHT HEADED AND SICK TO YOUR STOMACH. THIS COULD CAUSE SOMEONE TO PASS OUT WHILE DRIVING CAUSING THEM TO LOOSE CONTROL OF THEIR VEHICLE. DEFIANTLY A SAFETY HAZARD! ALSO CAUSING A DECREASE IN GAS MILEAGE AS WELL AS A LOUD KNOCKING/PUFFING NOISE UPON ACCELERATION. I HAVE SEARCHED THE INTERNET FINDING 100'S IF NOT 1000'S OF COMPLAINTS ABOUT THIS! WHY HAS THIS NEVER BEEN RECALLED? THE SAFETY ISSUE ALONE SHOULD WARRANT A RECALL, ITS OBVIOUSLY A FAULTY COMPONENT!
Official recalls
410V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V459000 · Electrical System
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.