NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
891 reports50,000 miles · Aug 6, 2010
Power Train
I AM COMPLAINING ABOUT A PROBLEM THAT HAS DEVELOPED IN MY 2005 NISSAN TITAN. BOTH REAR AXLE SEALS ARE LEAKING, OIL IS GETTING ONTO THE REAR WHEELS BRAKING SYSTEM THEREBY POSING A POTENTIALLY DANGEROUS SITUATION FOR THE OCCUPANTS AND THE VEHICLE. THIS PROBLEM OCCURRED JUST AROUND 50,000 MILES ON MY 2005 NISSAN TITAN, WHICH IS VE…
Read full complaint
I AM COMPLAINING ABOUT A PROBLEM THAT HAS DEVELOPED IN MY 2005 NISSAN TITAN. BOTH REAR AXLE SEALS ARE LEAKING, OIL IS GETTING ONTO THE REAR WHEELS BRAKING SYSTEM THEREBY POSING A POTENTIALLY DANGEROUS SITUATION FOR THE OCCUPANTS AND THE VEHICLE. THIS PROBLEM OCCURRED JUST AROUND 50,000 MILES ON MY 2005 NISSAN TITAN, WHICH IS VERY SURPRISING FOR ANY VEHICLE WITH THIS SMALL AMOUNT OF MILEAGE. I HAVE FOUND ON OTHER WEBSITES THAT HUNDREDS OF OTHER TITAN OWNERS HAVE HAD THE SAME PROBLEM WITH LEAKING REAR AXLE SEALS, WITH MILEAGE AS LOW AS 8,000 MILES, 25,000 MILES, 40,000 MILES; YET STILL, NISSAN CONTINUES TO IGNORE THIS PROBLEM, AS FAR AS A RECALL IS CONCERNED. THIS PROBLEM IS VERY COSTLY TO BE CORRECTED, RANGING FROM $1,000 TO AS HIGH AS $3,000, DEPENDING ON THE DEALER'S ESTIMATION. I WOULD STRONGLY RECOMMEND, FOR THE SAFETY OF PERSONS AND VEHICLES, THAT NISSAN BE COMPELLED TO COME UP WITH A RECALL OF THESE FAULTY AXLE SEALS ON NISSAN TITANS. THANK YOU. *TR
NHTSA ODI #10347874
200,000 miles · Aug 5, 2010
Power Train
REAR AXLE SEALS ON NISSAN TITAN PICKUP TRUCKS LEAKING AND REQUIRE REPLACEMENT OF ENTIRE AXLE SHAFTS. *TR
NHTSA ODI #10347532
52,830 miles · Aug 4, 2010
Power Train
2005 NISSAN TITAN, 52,830 MILES, PURCHASE DATE OF 7/23/2005. ONE WEEK OUT OF THE 5-YR WARRANTY, RIGHT REAR AXLE SEAL LEAKING DIFFERENTIAL FLUID. FLUID THROWN ON WHEEL AND BRAKE ROTOR FROM TIRE ROTATION. RIGHT REAR AXLE SEAL FAILED. BRAKING FELT OFF WHEN DRIVING, WHICH LED TO INITIAL WALK-AROUND OF THE TRUCK AND NOTICED FLUID ON …
Read full complaint
2005 NISSAN TITAN, 52,830 MILES, PURCHASE DATE OF 7/23/2005. ONE WEEK OUT OF THE 5-YR WARRANTY, RIGHT REAR AXLE SEAL LEAKING DIFFERENTIAL FLUID. FLUID THROWN ON WHEEL AND BRAKE ROTOR FROM TIRE ROTATION. RIGHT REAR AXLE SEAL FAILED. BRAKING FELT OFF WHEN DRIVING, WHICH LED TO INITIAL WALK-AROUND OF THE TRUCK AND NOTICED FLUID ON GROUND. CONTACT 3 NISSAN DEALERSHIPS. WOULD NOT TOUCH THE TRUCK SINCE TECHNICALLY OUT OF WARRANTY (1 WEEK). CONTACTED NISSAN CONSUMER AFFAIRS. NISSAN NOT INTERESTED IN HELPING. *TR
NHTSA ODI #10347265
60,000 miles · Aug 3, 2010
Electrical System
THE CAR WILL STOP IN THE MIDDLE OF THE ROAD AT ANY SPEED AND START KNOCKING. THE LIGHTS WILL GO ON AND OFF IN THE DASH FOR A FEW SECOND BEFORE IT COMPLETELY SHUTS OFF. IF YOU TRY TO IGNITION AGAIN YOU MAY NOT BE ABLE TO START. BUT YOU CAN TURN OFF THE CAR FOR A MINUTE AND START IT BACK UP. ONE TIME I WAS ABLE TO SHUT OFF MY TRU…
Read full complaint
THE CAR WILL STOP IN THE MIDDLE OF THE ROAD AT ANY SPEED AND START KNOCKING. THE LIGHTS WILL GO ON AND OFF IN THE DASH FOR A FEW SECOND BEFORE IT COMPLETELY SHUTS OFF. IF YOU TRY TO IGNITION AGAIN YOU MAY NOT BE ABLE TO START. BUT YOU CAN TURN OFF THE CAR FOR A MINUTE AND START IT BACK UP. ONE TIME I WAS ABLE TO SHUT OFF MY TRUCK HITTING THE CRUISE BUTTON. THE BIG PROBLEM WITH THIS IS THAT WHEN YOU ARE ON THE ROAD CURSING AND YOU VEHICLE STALLS YOU JUST HOPE NO ONE IS BEHIND OR IN FRONT OF YOU. THE DEALER REPLACED THE PART BUT I HAD TO COVER HALF OF THE COST OF LABOR AND PART. *TR
NHTSA ODI #10346996
49,850 miles · Aug 2, 2010
Electrical System
REAR WIRING HARNESS MELTED DUE TO DEFECTIVE EXHAUST SYSTEM/HEAT SHIELDS. BRAKE LIGHTS, SAFETY HAZARDS, AND SIGNAL INDICATORS FAILED DURING HIGHWAY TRAVEL. *TR
NHTSA ODI #10346906
29,000 miles · Aug 2, 2010
Electrical SystemEngine And Engine Cooling
DESIGN FLAW ON NISSAN TITAN DUE TO EXHAUST LEAK WHICH WILL THEN BURN THE ELECTRICAL WIRING AND THE TRUCK WILL STOP ALL OF SUDDEN WITH LOST OF POWER AND BRAKES, WHICH MAY CAUSE ACCIDENTS. *TR WE WERE ON OUR WAY BACK FROM CAMPING TRIP WITH TRAVEL TRAILER IN TOW. ON INTERSTATE 81 NEAR WILKES BARRE, PA...WE WERE GOING 65 MPH AND…
Read full complaint
DESIGN FLAW ON NISSAN TITAN DUE TO EXHAUST LEAK WHICH WILL THEN BURN THE ELECTRICAL WIRING AND THE TRUCK WILL STOP ALL OF SUDDEN WITH LOST OF POWER AND BRAKES, WHICH MAY CAUSE ACCIDENTS. *TR WE WERE ON OUR WAY BACK FROM CAMPING TRIP WITH TRAVEL TRAILER IN TOW. ON INTERSTATE 81 NEAR WILKES BARRE, PA...WE WERE GOING 65 MPH AND ALL OF A SUDDEN THE VEHICLE ENGINE STOPPED, WE HAD A LOST OF POWER AND BRAKES AND HAD TO CRIPPLE TOWARDS THE SHOULDER AND COULDN'T START THE ENGINE AGAIN. WHAT CAUSED THIS FAILURE IS THE TAIL PIPE CAME LOOSE DUE TO RUST AND THE HEAT FROM THE EXHAUST BURNED THE ELECTRICAL WIRING THAT WAS PLACED ALONGISDE THE EXHAUST CAUSING THE ENGINE COMPUTER TO MALFUNCTION. WE HAD TO PAY $1,300.00 TO GET THE VEHICLE REPAIRED NOT INCLUDING ONE NIGHT HOTEL STAY AND RENTING A CAR BACK HOME BECAUSE THE PART WAS NOT AVAILABLE FOR A FEW DAYS AND HAVING TO DRIVE BACK UP TO PICK UP THE TRUCK WITH THE TRAVEL TRAILER AND BRING THEM ALL BACK HOME. THE DISTANCE IS 156 MILES FROM WHERE IT BROKE DOWN TO WHERE WE LIVE. I BELIEVE THERE'S A DESIGN FLAW THAT COULD BE DANGEROUS. THIS IS NOT THE FIRST TIME IT HAPPENED, SERVICE MANAGER IN WILKES BARRE ACKNOWLEDGED SEVERAL OTHER TITANS WITH THE SAME PROBLEM WHEN THERE IS AN EXHAUST LEAK AS WELL AS OUR LOCAL NISSAN SERVICE MANAGER ACKNOWLEDGED THE SAME. NISSAN SHOULD HAVE PROTECTED THE WIRING IN THE EXHAUST AREA WITH HEAT SHIELD OF SOME SORT. EXHAUST LEAKS OVER TIME, IT'S THE NATURE OF THE EXHAUST BUT IT SHOULD NOT REQUIRE CUSTOMERS TO PAY $1,300.00 TO GET THE ELECTRICAL SYSTEM REPAIRED. I HAVE REPORTED THIS TO NISSAN CONSUMER AFFAIRS ASKING FOR ASSISTING IN THE REPAIR COST DUE TO DESIGN FLAW, THEY DECLINED ASSISTANCE INDICATING THAT IT IS MY NEGLIGENCE THAT THE TAILPIPE SEPARATED FROM THE MUFFLER. NO OTHER CARS ON THE ROAD WITH A DANGLING TAILPIPE NEEDS TO HAVE ELECTRICAL WIRINGS REPLACED BECAUSE OF THAT, IT'S BECAUSE THEY DON'T RUN THE WIRINGS PARALLEL TO THE EXHAUST. *TR
NHTSA ODI #10346730
58,700 miles · Jul 30, 2010
Power Train
2005 NISSAN TITAN LE CREW CAB 4X4 WITH A FAILING REAR END DIFFERENTIAL. AT 58K MILES, THE TRUCK REAR END BEGAN TO SLIP BADLY. THE VEHICLE HAS NOT BEEN USED FOR ANYTHING OTHER THAN COMMUTING TO WORK. I DO NOT OFF ROAD OR HAVE OFF ROAD MODIFICATION THAT WOULD EXCEED MANUFACTURES SPECS AND PERFORMANCE. JUST NORMAL DRIVING. NIS…
Read full complaint
2005 NISSAN TITAN LE CREW CAB 4X4 WITH A FAILING REAR END DIFFERENTIAL. AT 58K MILES, THE TRUCK REAR END BEGAN TO SLIP BADLY. THE VEHICLE HAS NOT BEEN USED FOR ANYTHING OTHER THAN COMMUTING TO WORK. I DO NOT OFF ROAD OR HAVE OFF ROAD MODIFICATION THAT WOULD EXCEED MANUFACTURES SPECS AND PERFORMANCE. JUST NORMAL DRIVING. NISSAN INDICATES THAT I AM 30 DAYS PAST THE EXPIRATION OF MY WARRANTY, BUT UNDER THE MILEAGE REQUIREMENT. NISSAN NEEDS TO HELD ACCOUNTABLE FOR QUALITY CONTROLS ON THE MANUFACTURING OF THESE REAR END ASSEMBLIES. TYPICALLY $2500.00 REPAIR BILL....THAT SHOULD BE SHOULDERED BY NISSAN. *TR
NHTSA ODI #10346257
92,407 miles · Jul 29, 2010
Power Train
THE REAR AXLE SEALS ARE LEAKING ON MY 2005 NISSAN TITAN. THE OIL IS RUNNING FROM THE AXLE SEALS ON TO THE REAR BRAKE ROTORS AND REAR BRAKE PADS. THIS CAN RESULT IN REAR BRAKE FAILURE AND CAN CAUSE A CRASH. *TR
NHTSA ODI #10346022
95,403 miles · Jul 26, 2010
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED WHILE ATTEMPTING TO START THE VEHICLE, THE VEHICLE WAS HESITANT TO START. THE DEALER PERFORMED A DIAGNOSTIC ON THE VEHICLE AND FOUND THAT THE INTELLIGENT POWER DISTRIBUTION MODEL (IPDM) WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. TH…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED WHILE ATTEMPTING TO START THE VEHICLE, THE VEHICLE WAS HESITANT TO START. THE DEALER PERFORMED A DIAGNOSTIC ON THE VEHICLE AND FOUND THAT THE INTELLIGENT POWER DISTRIBUTION MODEL (IPDM) WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 95,403.
NHTSA ODI #10345305
Mileage unknown · Jul 26, 2010
Power Train
BROUGHT NISSAN TITAN TO MECHANIC TO HAVE BRAKES CHECKED. UPON REPLACEMENT OF BRAKES FOUND THAT THE REAR SEAL HAD FAILED AND GREASE HAD COVERED THE RIGHT WHEEL WELL AND TIRE RIM. SEALS AND BEARING HAD TO BE REPLACED. *TR
NHTSA ODI #10345256
Official recalls
4Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration