2015 Mazda MAZDA6

Premature sub-frame corrosion front and rear due to road salt and poor part finishing affecting most underbody components. All exposed stamped structural sub-frame components rusting at weld locations. Critical parts with severe rust and imminent failure: Lower Rear Control Arms (Left & Right), Rear Stabilizer Links (Left & Right). Potentially hazardous corrosion on Front Lower Control Arms. Rear Cross-member rusting at all weld locations. Cat. Sensor Protector Shield has disintegrated. Available for inspection upon request. Failure has not happened yet, but when it does vehicle control will be compromised. Dealer identified problems 12/18/21 and recommended/quoted repair. Vehicle inspected by dealer only. No indicator warnings exist for structural corrosion.

Mazda recalled the problem with the emergency brake(recall1217F) .The dealership did some cosmetic fix that did not prevent it from happening. The emergency brake when applied activated a lever when the brake is released the lever returns to it's original position.The recall was supposed to address the corrosion on the lever shaft that causes it to stick and not release the brake.

WHILE DRIVING MY 2015 MAZDA 6 GT, WITH 40,0000 MILES ON IT, ON A MAIN LOCAL ROAD, WITH A MAX SPEED LIMIT REQUIREMENT OF 45 MPH, I ATTEMPTED TO TURN INTO THE RIGHT TURN LANE AT A SPEED OF APPROX 35 MPH, WHILE LIGHTLY DEPRESSING THE BRAKE. AS I BEGAN TO TURN, THE STEERING JUST LOCKED UP, AND THE POWER STEERING STOPPED WORKING. A FEW DASHBOARD LIGHTS ALSO CAME ON AT THE SAME TIME.. ONE SAID POWER STEERING MALFUNCTION, THE OTHER WAS A RED HAZARD SYMBOL, AND I DON'T SPECIFICALLY RECALL THE OTHER. I FINALLY SHUT THE CAR OFF AFTER A FEW MINUTES. WHEN I RESTARTED THE CAR, AFTER SEVERAL SECONDS THE WHEEL REGAINED MOBILITY AND THE DASHBOARD LIGHTS WENT OFF. I CAREFULLY AND SLOWLY DROVE MY CAR HOME, APRROX 2 MILES FROM WHERE IT HAPPENED. I HAVEN'T DRIVEN THE CAR SINCE, DUE TO FEAR OF IT HAPPENING AGAIN. I WAS ALMOST REAR ENDED TWICE WHEN IT HAPPENED.

MY VEHICLE HAS HAD STRANGE GRUNTING, SQUEAKING, POPPING NOISES COMING FROM THE FRONTEND, PARTICULARLY THE DRIVERS SIDE. IT HAS HAD THIS ISSUE SINCE I BOUGHT THE CAR IN JUNE 2017. THE NOISE SEEMS TO BE WORSE WHEN DRIVING OVER SMALL BUMPS. IT'S VERY NOTICEABLE WHEN I BACK OUT OF MY DRIVEWAY. I HAVE ADDRESSED THIS ISSUE WITH THE DEALERSHIP I PURCHASED MY CAR FROM. THEY CAN'T DUPLICATE. I HAVE RESEARCHED THIS EXACT ISSUE AND FOUND THERE IS A TSB FOR THE SUSPENSION ISSUE I'M DESCRIBING. I'M JUST GETTING WORRIED ABOUT MY SAFETY. I'M AFRAID SOMETHING WILL FAIL AND I FEEL IT'S THE MANUFACTURERS RESPONSIBILITY TO CORRECT THIS UNSAFE ISSUE WITH THE SUSPENSION THAT AFFECTING MANY OTHER MAZDA 6 VEHICLES.

TL* THE CONTACT OWNS A 2015 MAZDA 6. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR FLASHED ON AND OFF AND THE FRONT PASSENGER AIR BAG OFF INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 60,000.

AFTER STOPPING, THE CAR DOES NOT POWER OFF ALL THE WAY, DASHBOARD AND RADIO ARE STILL ON. IT HAPPENS VERY FREQUENTLY AND IN SOME CASES I WASTE A LOT OF TIME TO TRY THIS 10-20 TIME BEFORE IT ACTUALLY TURNS OFF. ON SOME OCCASIONS, I DID NOT HAVE MUCH TIME AND I LEFT IT THAT WAY AND I COULD NOT CLOSE THE CAR AND AFTER FEW HOURS THE BATTERY DRAINED AND I COULD NOT START THE CAR.

TL* THE CONTACT OWNS A 2015 MAZDA 6. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER AN UNKNOWN RECALL REGARDING THE BRAKES IN MARCH OF 2018. AFTER THE REPAIR, THE CONTACT HEARD A GRINDING SOUND COMING FROM THE BRAKES. THE INITIAL REPAIRS WERE PERFORMED BY BRADSHAW MAZDA SERVICE (2512 LAURENS RD, GREENVILLE, SC 29607, (864) 458-3500). THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO WANTED TO CHARGE THE CONTACT A DIAGNOSTIC FEE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 42,172.

I AM THE ORIGINAL OWNER OF A 2015 MAZDA 6. WHILE TRAVELING ON A STRAIGHT 60 MPH HIGHWAY, MY SUNROOF WINDOW SUDDENLY EXPLODED, WITH A LOUD "BANG!". THE WINDOW WAS CLOSED AT THE TIME AND HAD NOT BEEN OPENED IN APPROXIMATELY 3 DAYS. FORTUNATELY, THE INTERIOR DEFLECTOR (SLIDING COVER) WAS CLOSED AT THE TIME, OR GLASS SHARDS WOULD HAVE RAINED DOWN ON MY FACE AND HAIR. NO OBJECTS OR SUDDEN MOTIONS PROVOKED THE EXPLOSION. POLICE WOULD NOT WRITE A REPORT BECAUSE THERE WERE "NO SUSPECTS OF VANDALISM" AND "NO COLLISION WITH OTHER VEHICLES OR PROPERTY". $725 LATER, I HAVE A NEW REPLACEMENT WINDOW FROM THE MANUFACTURER AND HOPE FOR NO SIMILAR FUTURE INCIDENTS OR POSSIBLE MOLD/MILDEW ISSUES. THE CAUSE OF THE SAFETY RISK IS UNKNOWN BUT IS CERTAINLY UNACCEPTABLE, GIVEN THAT I MAINTAIN MY VEHICLE TO THE HIGHEST STANDARDS AND AM THE ORIGINAL OWNER OF ONLY 3 YEARS. I HAVE REPAIR INVOICES, SHOULD THEY BE NECESSARY TO SUBSTANTIATE THIS COMPLAINT.

VEHICLE HAS HAD 3 WINDSHIELD REPLACEMENTS IN JUST THREE YEARS OF USE AND OWNERSHIP. THE WINDSHIELD DESIGN SEEMS TO BE EXTREMELY FRAGILE AND INDUCES SAFETY RELATED SENSOR FUNCTION ANOMALIES. MY GRAND TOURING MODEL IS ALSO EQUIPPED WITH A BOSE SPEAKER SYSTEM WHICH CAUSES POPPING FROM A FAULTY SPEAKER. THIS SEEMS TO BE A COMMON PROBLEM WITH THESE VEHICLES.