1997 Mazda 626

MY WIFE AND I OWN A 1997 MAZDA 626. IN 2006, SEEMINGLY OUT OF NOWHERE, THE TRANSMISSION STARTED SHIFTING ROUGH. I CHECKED FLUID LEVELS BUT THEY WERE FINE. THEN WHILE DRIVING ON THE INTERSTATE ONE MORNING, MY O/D KICKED OFF (WITH WARNING LIGHT) AND THE ENTIRE DRIVE HOME WAS EXTREMELY ROUGH. BROUGHT THE CAR TO A REPUTABLE LOCAL TRANSMISSION SHOP AND AS SOON AS I TOLD THEM WHAT KIND OF CAR I HAD, THEY KNEW RIGHT AWAY WHAT THE PROBLEM WAS. I ENDED UP PAYING $2000 TO HAVE A NEW TRANSMISSION INSTALLED DUE TO THE EXTENT OF DAMAGE IN THE ORIGINAL. SEEMS TO ME THAT IF ALL OF THE TRANSMISSION SHOPS AND (AS I FOUND OUT LATER) OWNER FORUMS KNOW ABOUT THE PROBLEMS WITH THESE TRANSMISSIONS, MAZDA/FORD PROBABLY KNOWS AS WELL. IT'S IRRESPONSIBLE TO KNOW THAT A $50 REPAIR COULD CORRECT THE PROBLEM BUT THEY DO NOTHING TO EVEN INFORM THEIR BUYERS OF THE PROBLEMS. $50 WOULD HAVE BEEN A LOT EASIER TO COME UP WITH THAN $2000. SUMMED UP: TRANSMISSION OVERHEATED DUE TO INSUFFICIENT COOLING CAUSING SEVERE TRANSMISSION FAILURE. TRANSMISSION HAD TO BE COMPLETELY REPLACED. *TR

TL* THE CONTACT OWNS A 1997 MAZDA 626. THE CONTACT STATED THAT THE VEHICLE WAS PURCHASED ON APRIL 16, 2007. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC ,WHO DETERMINED THAT THE TIMING BELT TENSIONER WAS CAUSING EXCESSIVE WEAR ON THE BELT. THE MECHANIC STATED THAT THERE WAS RECALL # 98V206001 CONCERNING ENGINE AND ENGINE COOLING ON, AND HE SHOULD CALL THE MAZDA MANUFACTURER. THE CONTACT CALLED THE MANUFACTURER, AND WAS INFORMED THAT THIS VEHICLEWAS INCLUDED IN THE RECALL. THE RECALL WAS NOT REMEDIED PREVIOUSLY. THE CONTACT ARRIVED AT A MAZDA DEALER FOR RECALL REPAIRS, WHERE HE WAS INFORMED THAT THIS VEHICLERWAS EXCLUDED FROM THE RECALL DUE TO THE VIN. HE SHOWED THE DEALER A COPY OF THE RECALL NOTICE, AND THEY STATED THAT THE VEHICLE WAS BRANDED WITH NO WARRANTY. THE DEALER REFUSED TO PERFORM RECALL REPAIRS. THE CURRENT MILEAGE IS 83,936, AND THE FAILURE MILEAGE WAS UNKNOWN.*AK

MY CAR IDLES BACK AND FORTH LIKE SOMEONE IS PRESSING THE GAS AND LETTING OFF. I HAD IT PUT ON A COMPUTER AT ADVANCED AUTOMOBILE AND I GOT A THROTLE POSITION SENSOR , AND HAD IT PUT ON. MY CAR STILL DID THE SAME EXACT THING. HAD IT PUT BACK ON THE COMPUTER, AND HAD A MASS FLOW SENSOR PUT ON IT. MY CAR STILL DID THE SAME THING .TOOK CAR TO DEALER, PUT IDLE AIR CONTROL VALVE AND REPLACED WIRING TO THIS SENSOR. I EVEN PUT AN EMC FROM A SALVAGE YARD IN MY CAR. STILL MY CAR DID THE SAME THING . WERE THERE ANY OTHER MAZDAS DOING THE SAME THING? I' SPENT ALOT OF MONEY TO TRY AND FIX MY CAR .*AK

AT 62,000 MILES OVERDRIVE LIGHT BEGAN FLASHING, TRANSMISSION BEGAN SHIFTING LIKE A WORN OUT 3 SPEED, DIAGNOSED BY SEVERAL SHOPS. I WAS TOLD TRANSMISSION HAS A DESIGN FLAW, SELL CAR BEFORE MAJOR PROBLEMS OCCUR. REPAIRED TRANSMISSION, VALVE BODY AND SOLENOID PACK, TORQUE CONVERTER REPLACED. 1,500 DOLLARS TOTAL. AT 100,000 MILES SAME PROBLEM EXCEPT I HAVE NO FORWARD OR REWARD MOTION. CAR IS SITTING UNDER MY CARPORT, COST TO REPAIR 2,500 DOLLARS REQUIRES A TRANSMISSION. *JB

THE VEHICLE BEGAN SHIFTING VERY ROUGHLY, THEN THE OVERDRIVE STARTED BLINKING AND THE VEHICLE CEASED TO SHIFT, I WAS STUCK IN 3RD GEAR. THERE WAS A SMALL "BANG" IN THE ENGINE COMPARTMENT, THEN CHECK ENGINE LIGHT ILLUMINATED. I PULLED OVER TO A FUEL STATION AND OPENED THE HOOD. THERE WAS TRANSMISSION FLUID ALL OVER THE INTERIOR OF THE ENGINE COMPARTMENT, 1+ QUARTS. I COULD FIND NO OBVIOUS LEAKS, BUT PURCHASED SOME ADDITIONAL FLUID AND REFILLED WHAT WAS LOST. SINCE THEN WHENEVER IT IS WARM OUT OR THE CAR IS DRIVEN FOR OVER AN HOUR IN TEMPERATURES ABOVE ~50 F, IT SHIFTS VERY ROUGH AND THE OD LIGHT AND CHECK ENGINE LIGHT COME ON. I HAVE SINCE LEARNED THAT THIS IS A VERY COMMON PROBLEM AMONG 2.0L MAZDA 626'S WITH AN AUTOMATIC TRANSMISSION. THEY APPARENTLY OVERHEAT VERY EASILY. I HAVE BEEN TOLD I AM LUCKY THAT THE TRANSMISSION HAS NOT FAILED ON ME. I'VE TAKEN IT APART AND CLEANED IT OUT SEVERAL TIMES. I ALSO CHANGE THE TRANSMISSION FLUID FREQUENTLY. THESE ABOVE AVERAGE MAINTENANCE ROUTINES ARE LIKELY WHAT HAS KEPT THE TRANSMISSION FROM FAILING ALTOGETHER. THE VEHICLE IS BARELY TOLERABLE TO DRIVE WHEN IT IS HAVING THESE PROBLEMS AS IT WILL SLAM INTO THE NEXT GEAR HARD ENOUGH TO JERK THE OCCUPANTS FORWARD OR BACKWARD. *NM

ON SUNDAY AFTERNOON, OCTOBER 8, 2006, I WAS DRIVING LOCALLY TO VISIT A FRIEND IN A NEW HOME. I HAD JUST TURNED OFF A BUSY THOROUGHFARE ONTO A SIDE ROAD WHEN A HUGE EXPLOSION WENT OFF IN MY FACE. I WAS TRAUMATIZED AND BLINDED AT FIRST- ALL I KNEW WAS THAT I COULDN'T SEE, AND HAD BEEN HIT IN THE FACE WITH A TREMENDOUS FORCE--I IMMEDIATELY THOUGHT I HAD BEEN IN A COLLISION, BUT COULD NOT FIGURE OUT WHERE ANOTHER CAR COULD HAVE COME FROM--I WAS ABLE TO STOP THE CAR, UNDO MY SEAT BELT AND GET OUT OF THE SMOKEY INTERIOR--A WOMAN DRIVING BEHIND ME PULLED UP AND HELPED ME TO THE CURB, SAYING "GET AWAY FROM THE CAR!" SINCE IT LOOKED AS IF IT WAS GOING TO EXPLODE! SHE CALLED THE RESCUE SQUAD, AND THEY INSPECTED MY INJURIES, WHICH WERE MAINLY FACIAL BRUISING AND SCRAPES--ASKED ME IF I WANTED TO BE TAKEN TO THE HOSPITAL, AND I REFUSED, SIGNING A PAPER THAT SAID THAT I REFUSED--MY FRIEND CAME DOWN THE STREET AFTER I CALLED HER, AND BROUGHT ME A BAG OF ICE TO PUT ON MY FACE. I WAS GREATLY SHAKEN, AND STAYED AT HER HOME FOR THE AFTERNOON, AND THEN DROVE SLOWLY THE SHORT DISTANCE HOME WITH THE BAG TAPED UP -- I WAS TOLD TO NOT LET ANYONE SIT IN THE PASSENGERS SEAT SINCE THAT AIR BAG MIGHT DEPLOY ALSO AT ANY TIME! MY INSURANCE COMPANY SAID IT WOULD NOT COVER THE EXPENSES OF REPAIRING THE AIRBAG. *JB