NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
175 reports67,780 miles · Apr 22, 2009
Steering
I HAVE A 2004 KIA SEDONA. I AM THE ONLY OWNER. I STARTED HAVING STEERING PROBLEMS ABOUT 5 DAYS AGO. I ALMOST RAN INTO ANOTHER CAR TURNING THE CORNER. I TOOK IT INTO MY KIA DEALER TO BE TOLD MY STEERING BINDING HAS FAILED. SO NOW I HAVE TO PAY OVER $500 TO HAVE IT REPAIRED, SINCE THIS IS A SAFETY HAZARD. I BELIEVE THIS TO BE A D…
Read full complaint
I HAVE A 2004 KIA SEDONA. I AM THE ONLY OWNER. I STARTED HAVING STEERING PROBLEMS ABOUT 5 DAYS AGO. I ALMOST RAN INTO ANOTHER CAR TURNING THE CORNER. I TOOK IT INTO MY KIA DEALER TO BE TOLD MY STEERING BINDING HAS FAILED. SO NOW I HAVE TO PAY OVER $500 TO HAVE IT REPAIRED, SINCE THIS IS A SAFETY HAZARD. I BELIEVE THIS TO BE A DEFECT ON MY KIA. I WOULD LIKE FOR THEM TO TAKE CARE OF IT AND REIMBURSE ME FOR MY COSTS. *TR
NHTSA ODI #10266385
62,000 miles · Feb 8, 2009
Steering
WHILE DRIVING, I NOTICED THE STEERING STARTED TO GET MORE AND MORE HARD TO CORRECT WHILE TURNING. AS YOU ARE TURNING THE WHEEL STICKS, THEN GIVES AND STICKS AGAIN. WHILE IN THE STUCK POSITION, IF YOU DO NOT TURN THE WHEEL HARDER, THE VAN WILL CONTINUE TO LEAD IN THE DIRECTION. WE TOOK THE VAN IN FOR INSPECTION, AND WERE TOLD …
Read full complaint
WHILE DRIVING, I NOTICED THE STEERING STARTED TO GET MORE AND MORE HARD TO CORRECT WHILE TURNING. AS YOU ARE TURNING THE WHEEL STICKS, THEN GIVES AND STICKS AGAIN. WHILE IN THE STUCK POSITION, IF YOU DO NOT TURN THE WHEEL HARDER, THE VAN WILL CONTINUE TO LEAD IN THE DIRECTION. WE TOOK THE VAN IN FOR INSPECTION, AND WERE TOLD IT WAS THE POWER STEERING PUMP. THEY REPLACED IT, BUT WE OUT OF THE 60,000 MILE WARRANTY. THANKFULLY WE BOUGHT THE EXTENDED WARRANTY, SO IT ONLY COST US THE $100 DEDUCTIBLE. THEY THEN TOLD US THE POWER STEERING BELT NEEDED REPLACED, BUT WAS NOT COVERED UNDER THE EXTENDED WARRANTY. AFTER WE RECEIVED THE VAN BACK, IT CONTINUED TO DO THE SAME. WE ARE TAKING THE VAN BACK IN FOR SERVICE AND COMPLAINT TOMORROW. HOPEFULLY THEY GET IT RIGHT THIS TIME. THIS IS NOT SOMETHING TO THINK YOU GOT IT RIGHT THE FIRST TIME, HAS TO BE ABSOLUTELY RIGHT THE FIRST TIME. ESPECIALLY WHEN YOU HAVE 2 SMALL KIDS. *TR
NHTSA ODI #10257989
100 miles · Sep 29, 2008
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2004 KIA SEDONA. EVER SINCE PURCHASING THE VEHICLE, THE CONTACT HAS HEARD A HUMMING NOISE COMING FROM THE REAR BRAKES WHILE DRIVING 10 MPH. SHE HAS TAKEN THE VEHICLE TO THE DEALER NUMEROUS TIMES, BUT THEY COULD NOT FIND ANY FAILURES. THE CONTACT STATED THAT IT SOUNDS AS IF SOMETHING IS WRONG WITH THE REA…
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. EVER SINCE PURCHASING THE VEHICLE, THE CONTACT HAS HEARD A HUMMING NOISE COMING FROM THE REAR BRAKES WHILE DRIVING 10 MPH. SHE HAS TAKEN THE VEHICLE TO THE DEALER NUMEROUS TIMES, BUT THEY COULD NOT FIND ANY FAILURES. THE CONTACT STATED THAT IT SOUNDS AS IF SOMETHING IS WRONG WITH THE REAR BRAKING SYSTEM AND IS CONCERNED OF THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 100 AND CURRENT MILEAGE WAS 45,000.
NHTSA ODI #10243859
77,000 miles · Aug 18, 2008
Wheels
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING BETWEEN 45-55 MPH, THE CONTACT NOTICED A LOUD ROARING NOISE AND VIBRATION IN THE VEHICLE. SHE PULLED THE VEHICLE OVER AND CALLED THE MECHANIC. THE MECHANIC ADVISED HER TO CHECK THE LUGS TO SEE IF THE WHEELS WERE ON TIGHT. SHE DROVE TO THE NEXT TOWN AND STOPPED AT A REPAIR …
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING BETWEEN 45-55 MPH, THE CONTACT NOTICED A LOUD ROARING NOISE AND VIBRATION IN THE VEHICLE. SHE PULLED THE VEHICLE OVER AND CALLED THE MECHANIC. THE MECHANIC ADVISED HER TO CHECK THE LUGS TO SEE IF THE WHEELS WERE ON TIGHT. SHE DROVE TO THE NEXT TOWN AND STOPPED AT A REPAIR SHOP. THE MECHANIC DROVE AROUND THE BLOCK AND STATED THAT THE WHEEL BEARING APPEARED TO BE DEFECTIVE. THE DEALER STATED THAT HER VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V232000 (WHEELS). THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 77,000.
NHTSA ODI #10238760
61,000 miles · Aug 12, 2008
Electrical SystemStructure
VEHICLE FLOORBOARD GOT HOT AND MELTED THE WIRING HARNESS UNDER CARPET. KIA DEALER FOUND NO CAUSE FOR THE EXCESSIVE HEAT BUT REPLACED THE WIRING AT MY EXPENSE. *TR
NHTSA ODI #10237828
Mileage unknown · Jul 22, 2008
Suspension
UNSURE WHY THE FRONT RIGHT STRUT WENT OUT ON MY 2004 KIA SEDONA MINIVAN. STRUT WILL NEED TO BE REPLACED. *TR
NHTSA ODI #10235378
62,508 miles · Jun 10, 2008
Service Brakes, Air
IN MARCH OF THIS YEAR WE HAD THE SIXTH VISIT TO THE KIA DEALER IN REFERENCE TO BRAKES PULSATING WHILE COMMING TO A STOP AT ABOUT40 MPH IN THE PAST THE RESURFACE THE ROTORS AND ADJUST HE BREAKES AT ONE TIME THEY REPLACE THE ROTORS STILL HAVE THE SAME PROBLEM IF FEELS LIKE THE CALIPER ARE STUCK AND MAKE A RUBBING SOUND AND T…
Read full complaint
IN MARCH OF THIS YEAR WE HAD THE SIXTH VISIT TO THE KIA DEALER IN REFERENCE TO BRAKES PULSATING WHILE COMMING TO A STOP AT ABOUT40 MPH IN THE PAST THE RESURFACE THE ROTORS AND ADJUST HE BREAKES AT ONE TIME THEY REPLACE THE ROTORS STILL HAVE THE SAME PROBLEM IF FEELS LIKE THE CALIPER ARE STUCK AND MAKE A RUBBING SOUND AND THE CALIPERS START TO WORP AND TO VIBRATE MORE AND MORE , THE DEALER ACCUSE MY WIFE OF HEAVY FOOT SHE TRAVELS 15 MILES TO WORK EVERY DAY WITH NOT MUCH STOPPING , WE ARE JUST ABOUT TO GO BACK TO THE DEALER TO HAVE THEM LOOK AT THE PROBLEM THE LAST TIME WE WENT THEY REPLACE THE BRAKE SHOES . WE DONT KNOW WHAT TO DO.
NHTSA ODI #10230518
15,000 miles · May 14, 2008
Service Brakes, Hydraulic
WE PURCHASED A 2004 KIA SEDONA IN JULY OF THAT YEAR, AND WHEN WE HAD 33,000 MILES ON IT , IT WAS ON ITS THIRD SET OF FRONT BRAKE PADS AND SECOND SET OF ROTORS, THE DEALER NEVER ONCE TOLD US THERE WAS A PROBLEM WITH THE KIA BRAKE SYSTEM, AND I CALLED KIA AND THEY TOLD ME THEY WERE NOT AWARE OF ANY BIG PROBLEM WITH THEM, AT THAT P…
Read full complaint
WE PURCHASED A 2004 KIA SEDONA IN JULY OF THAT YEAR, AND WHEN WE HAD 33,000 MILES ON IT , IT WAS ON ITS THIRD SET OF FRONT BRAKE PADS AND SECOND SET OF ROTORS, THE DEALER NEVER ONCE TOLD US THERE WAS A PROBLEM WITH THE KIA BRAKE SYSTEM, AND I CALLED KIA AND THEY TOLD ME THEY WERE NOT AWARE OF ANY BIG PROBLEM WITH THEM, AT THAT POINT I TOLD THE KIA REPRESENTATIVE THAT I WILL NEVER PURCHASE ANOTHER KIA, AND I WENT AND TRADED MY 2004 SEDONA FOR A CHEVROLET,AND NEVER WILL OWN A KIA AGAIN. *TR
NHTSA ODI #10227710
320 miles · Apr 28, 2008
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING 40 MPH, THE CONTACT HAD TO SLAM ON THE BRAKES AND THE ABS FAILED. THE ABS ENGAGED FOR 1 1/2 SECONDS, DISENGAGED FOR 5-6 SECONDS, AND THEN RE-ENGAGED, CAUSING THE VEHICLE TO SLIDE 12 FEET. THE CONTACT ALMOST DROVE OFF THE ROAD BEFORE THE BRAKES FINALLY STOPPED THE VEHICLE. …
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING 40 MPH, THE CONTACT HAD TO SLAM ON THE BRAKES AND THE ABS FAILED. THE ABS ENGAGED FOR 1 1/2 SECONDS, DISENGAGED FOR 5-6 SECONDS, AND THEN RE-ENGAGED, CAUSING THE VEHICLE TO SLIDE 12 FEET. THE CONTACT ALMOST DROVE OFF THE ROAD BEFORE THE BRAKES FINALLY STOPPED THE VEHICLE. THE ABS FAILURE OCCURRED NINE TIMES FROM THE DATE THE VEHICLE WAS PURCHASED. THE HARDER SHE DEPRESSES THE BRAKE PEDAL, THE LONGER IT TAKES TO STOP THE VEHICLE. AFTER AVOIDING A CRASH, THE CONTACT DROVE STRAIGHT TO THE DEALER. DUE TO THE RAIN, THE DEALER WOULD NOT ALLOW THE TECHNICIAN TO TEST DRIVE THE VEHICLE BECAUSE A CRASH COULD RESULT DUE TO THE BRAKE FAILURE. THE FAILURE MILEAGE WAS 320.
NHTSA ODI #10225867
70,000 miles · Apr 11, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2004 KIA SEDONA. IN JUNE OF 2007, WHILE BACKING OUT OF THE DRIVEWAY AT AN UNKNOWN SPEED, THE VEHICLE STALLED. THE FAILURE DATES WERE AUGUST 20, 2007 AT 74,200 MILES AND SEPTEMBER 9, 2007 AT 77,450 MILES. WHEN THE CONTACT APPROACHED A TRAFFIC LIGHT, THE BRAKES WERE DEPRESSED AND THE VEHICLE STALLED ON MAR…
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. IN JUNE OF 2007, WHILE BACKING OUT OF THE DRIVEWAY AT AN UNKNOWN SPEED, THE VEHICLE STALLED. THE FAILURE DATES WERE AUGUST 20, 2007 AT 74,200 MILES AND SEPTEMBER 9, 2007 AT 77,450 MILES. WHEN THE CONTACT APPROACHED A TRAFFIC LIGHT, THE BRAKES WERE DEPRESSED AND THE VEHICLE STALLED ON MARCH 28, 2008. WHILE DRIVING 50 MPH, THE VEHICLE STALLED AGAIN AT 83,000 MILES. THE CONTACT WAS NEAR A NAPA AUTO PARTS STORE AND PULLED INTO THE PARKING LOT. A MECHANIC INSPECTED THE VEHICLE TO IDENTIFY THE CAUSE OF THE FAILURE, BUT WAS UNSUCCESSFUL. THE CONTACT CALLED TWO DIFFERENT KIA DEALERS TO ATTEMPT TO DIAGNOSE THE FAILURE, BUT THEY WERE ALSO UNSUCCESSFUL. THE FAILURE MILEAGE WAS 70,000 AND CURRENT MILEAGE WAS 83,400. UPDATED 04/29/08 *BF
NHTSA ODI #10224179
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Illustration