IllustrationWHILE DRIVING AT 10 MPH ,MY DAUGHTER AND I HEARD A CLUNK IN THE REAR OF OUR 2004 KIA SEDONA LX. I WAS HEADING FOR A REPAIR SHOP AS A RESULT AND HEARD A SECOND CLUNK AND PULLED OFF ON A SIDE STREET AND DROVE 200 FEET WHEN THE WHEEL BEARING ASSEMBLY CAME APART AND THE WHOLE WHEEL FLEW OFF THE VAN. *TR
2004 Kia Sedona
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Kia Sedona do not stand out strongly from the model-year median of 120.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sedona years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
1625–50K
1850–75K
2175–100K
16100–150K
7150K+
129 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Wheels. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports13 fire reports8 injury reports
Suspension complaints
17 reportsUNSURE WHY THE FRONT RIGHT STRUT WENT OUT ON MY 2004 KIA SEDONA MINIVAN. STRUT WILL NEED TO BE REPLACED. *TR
BAD MISFIRE IN MOTOR CAUSING THE CRUISE CONTROL TO TURN OFF AND TRANS TO SLAM OUT AND THEN BACK INTO OVER DRIVE,CAME CLOSE TO GETTING HIT IN THE REAR ON I-95. I HAVE HAD THIS VAN BACK TO KIA MINEY TIMES AND ITS STILL NOT FIX. ALL SO THE LAST TIME I HAD THE VAN FOR SERVICE I COMPLAINED ABUT A BEARING NOISE THEY DID NOT FIX IT T…
Read full complaint
BAD MISFIRE IN MOTOR CAUSING THE CRUISE CONTROL TO TURN OFF AND TRANS TO SLAM OUT AND THEN BACK INTO OVER DRIVE,CAME CLOSE TO GETTING HIT IN THE REAR ON I-95. I HAVE HAD THIS VAN BACK TO KIA MINEY TIMES AND ITS STILL NOT FIX. ALL SO THE LAST TIME I HAD THE VAN FOR SERVICE I COMPLAINED ABUT A BEARING NOISE THEY DID NOT FIX IT THE NOISE IS GETTING WORSE. *TR
TL*THE CONTACT OWNS A 2004 KIA SEDONA. THE VEHICLE WAS INVOLVED IN RECALL # 05V232000 REGARDING THE WHEEL BEARINGS. THE CONTACT' S VEHICLE DEVELOPED BRAKE FAILURE SHORTLY AFTER THE RECALL REPAIR WAS PERFORMED. THE CONTACT HEARD A LOUD GRINDING NOISE WHEN STOPPING THE VEHICLE, AND THE STOPPING DISTANCE WAS REDUCED. THE FAIL…
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. THE VEHICLE WAS INVOLVED IN RECALL # 05V232000 REGARDING THE WHEEL BEARINGS. THE CONTACT' S VEHICLE DEVELOPED BRAKE FAILURE SHORTLY AFTER THE RECALL REPAIR WAS PERFORMED. THE CONTACT HEARD A LOUD GRINDING NOISE WHEN STOPPING THE VEHICLE, AND THE STOPPING DISTANCE WAS REDUCED. THE FAILURE OCCURRED INTERMITTENTLY. THE DEALER REPLACED AND REPAIRED THE BRAKE PADS, DRUMS, AND ROTORS, BUT THE NOISE CONTINUED. THE CURRENT MILEAGE IS 61,000, AND FAILURE MILEAGE WAS 13,000.*AK
DT*: THE CONTACT STATED THE REAR PASSENGER SIDE TIRE FELL OFF WHILE THE CONTACT WAS JACKING UP THE VEHICLE. THE NON SERVICE DEALER DETERMINED THIS OCCURRED DUE TO THE WHEEL BEARING DISINTEGRATING. THE FRONT DRIVER SIDE WHEEL BEARING ALSO DISINTEGRATED. THE MANUFACTURER HAD A RECALL #05V232000; REGARDING THE WHEELS, BUT THE VE…
Read full complaint
DT*: THE CONTACT STATED THE REAR PASSENGER SIDE TIRE FELL OFF WHILE THE CONTACT WAS JACKING UP THE VEHICLE. THE NON SERVICE DEALER DETERMINED THIS OCCURRED DUE TO THE WHEEL BEARING DISINTEGRATING. THE FRONT DRIVER SIDE WHEEL BEARING ALSO DISINTEGRATED. THE MANUFACTURER HAD A RECALL #05V232000; REGARDING THE WHEELS, BUT THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.*AK
THEY WERE MINOR AT FIRST, SPEAKER COVER, WEATHER STRIPPING, AND NOISE WHEN BACKING UP. THEN THE OTHER PROBLEMS CAME: FAULTY PILOT BEARING, CLUTCH, AND PRESSURE PLATE, 4WD LIGHT, E BRAKE, POWER WINDOWS, PAINT COMING OF VEHICLE IN VARIOUS PLACES, DOME LAMP,DOOR LOCK SENSOR, GEAR SHIFTER, WINDSHIELD MOLDING, AIR BAG LIGHT,GAS PEDAL…
Read full complaint
THEY WERE MINOR AT FIRST, SPEAKER COVER, WEATHER STRIPPING, AND NOISE WHEN BACKING UP. THEN THE OTHER PROBLEMS CAME: FAULTY PILOT BEARING, CLUTCH, AND PRESSURE PLATE, 4WD LIGHT, E BRAKE, POWER WINDOWS, PAINT COMING OF VEHICLE IN VARIOUS PLACES, DOME LAMP,DOOR LOCK SENSOR, GEAR SHIFTER, WINDSHIELD MOLDING, AIR BAG LIGHT,GAS PEDAL STICKING, CUP HOLDER. THE ONES THAT CONCERN ME THE MOST IS THE VIBRATION THAT I HAVE AT SPEEDS OF 65-75 MPH. THE WHOLE STEERING WHEEL SHAKES AND THE VIBRATION CAN BE FELT BELOW. I HAVE SEEN WHERE THERE ARE OTHER COMPLAINTS ON THIS MODEL FOR THIS. I AM CONCERNED BECAUSE I HAVE TAKEN IT TO THE DEALER AND THEY CANNOT LOCATE THE PROBLEM. I ALSO HAVE PROBLEMS SHIFTING INTO LOWER GEARS ESPECIALLY IN THE MORNINGS. I ALSO HAVE PROBLEMS SHIFTING INTO 1ST GEAR FROM NEUTRAL. I WAS SITTING AT A STOP LIGHT AND WHEN THE LIGHT TURNED GREEN WENT TO PUT MY CAR INTO FIRST, IT WOULD NOT GO, I SHIFTED INTO 2ND AND TRIED TO GO INTO 1ST BUT IT WOULD NOT GO. I FINALLY CUT THE VEHICLE OFF AND GOT IT INTO 1ST. THE OTHER MAIN CONCERN IS THERE IS A DELAY ON ACCELERATION. I EXPERIENCE IT AFTER MY VEHICLE HAS SAT FOR 5 OR MORE HOURS. WHEN THE GAS PEDAL IS PUSHED THE VEHICLE WILL NOT GO OR WILL MOVE SEVERAL FEET AND THEN STOP. I HAVE MADE THE DEALERSHIP AWARE OF THESE PROBLEMS AND SOME HAVE BEEN FIXED BUT THE MAJOR ONES, VIBRATION, HESITATION, AND SHIFTING INTO 1ST CANNOT BE FIXED BECAUSE THE CAUSE IS UNKNOWN. I HAVE ALREADY HAD TWO CLOSE CALLS IN THIS VEHICLE ONE BECAUSE I COULD NOT GET MY CAR INTO GEAR AND I WAS ABOUT HIT FROM BEHIND. THE OTHER WAS THE HESITATION WHERE THE CAR STALLED JUST AS I WAS PULLING ONTO THE ROAD AND WOULD NOT GO. THE VIBRATION CONCERNS ME TOO BECAUSE THIS COULD BE THE TRANSMISSION OR STEERING, AND I KNOW THAT MUCH OF A VIBRATION HAS TO AFFECT OTHER THINGS AS WELL. I AM GOING TO CONTACT SOMEONE ABOUT TRYING TO DECLARE THIS VEHICLE AS A LEMON. I AM CONCERNED FOR MY DAUGHTER'S SAFETY AND THIS IS MY ONLY SOURCE OF TRANSPORTATION. PLEASE HELP ME. *JB
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE RIDES ROUGH. THE VEHICLE WAS TAKEN TO THE DEALER ON 5 OCCASIONS FOR THIS PROBLEM. THE FRONT STRUTS AND STRUT BOOTS WERE REPLACED, HOWEVER THE PROBLEM PERSISTED.
DT: THE CONTACT STATED THAT WHILE DRIVING THE LEFT REAR PASSENGER WHEEL CAME LOOSE FROM THE VEHICLE WITH THE TIRE AS WELL AS THE LUGS NUTS STILL INTACT. THE CONTACT WAS ABLE TO COAST INTO A GAS STATION BEFORE THE WHEEL CAME COMPLETELY OFF. BEFORE THIS INCIDENT RECALL 05V232000 REPAIRS WERE PERFORMED ON REAR WHEEL BEARINGS FO…
Read full complaint
DT: THE CONTACT STATED THAT WHILE DRIVING THE LEFT REAR PASSENGER WHEEL CAME LOOSE FROM THE VEHICLE WITH THE TIRE AS WELL AS THE LUGS NUTS STILL INTACT. THE CONTACT WAS ABLE TO COAST INTO A GAS STATION BEFORE THE WHEEL CAME COMPLETELY OFF. BEFORE THIS INCIDENT RECALL 05V232000 REPAIRS WERE PERFORMED ON REAR WHEEL BEARINGS FOR WATER BY A LOCAL KIA DEALERSHIP. THE DEALERSHIP INSPECTED THE INSIDE WHEEL BEARINGS . THE VEHICLE WAS TOWED BACK TO THE KIA DEALERSHIP. THE DEALER COULD NOT DETERMINE WHY THIS OCCURRED, AND COULD NOT FIND ANY MOISTURE WITHIN THE BEARINGS. THE VEHICLE IS CURRENTLY AT THE DEALER FOR REPAIRS. *AK
DT: THE CONTACT OWNS A 2004 KIA SEDONA. WHEN APPLYING THE BRAKES THE WHOLE FRONT END VIBRATED. DID NOT HEAR NOISES WHEN APPLYING THE BRAKES. SHE NOTICED THIS AROUND TWO MONTHS AGO. THE CONSUMER MOTHER-IN -LAW ALSO HAD A 2005 KIA SEDONA AND SHE EXPERIENCED THE SAME PROBLEM. THE CONSUMER TOOK CAR TO A DEALER, AND THEY TOLD…
Read full complaint
DT: THE CONTACT OWNS A 2004 KIA SEDONA. WHEN APPLYING THE BRAKES THE WHOLE FRONT END VIBRATED. DID NOT HEAR NOISES WHEN APPLYING THE BRAKES. SHE NOTICED THIS AROUND TWO MONTHS AGO. THE CONSUMER MOTHER-IN -LAW ALSO HAD A 2005 KIA SEDONA AND SHE EXPERIENCED THE SAME PROBLEM. THE CONSUMER TOOK CAR TO A DEALER, AND THEY TOLD HER THAT IT WAS NOT THE BRAKES. THEY WERE NOT SURE WHAT IT WAS. THE CONSUMER SAID THIS HAPPENS AT ANY SPEED.*AK *JB
DT: THE CALLER RECEIVED RECALL LETTER CONCERNING OUTER REAR WHEEL BEARING IN JUNE AND HAS NOT BEEN ABLE TO GET WORK DONE. THE CALLER HAS NOT EXPERIENCED ANY PROBLEMS YET. DEALER SAID THE PARTS WERE ON BACK ORDER. MANUFACTURER SAID THEY WOULD CALL THE DEALER AND FIND OUT WHY THE CALLER COULD NOT GET PARTS. THEY WERE TOLD THE …
Read full complaint
DT: THE CALLER RECEIVED RECALL LETTER CONCERNING OUTER REAR WHEEL BEARING IN JUNE AND HAS NOT BEEN ABLE TO GET WORK DONE. THE CALLER HAS NOT EXPERIENCED ANY PROBLEMS YET. DEALER SAID THE PARTS WERE ON BACK ORDER. MANUFACTURER SAID THEY WOULD CALL THE DEALER AND FIND OUT WHY THE CALLER COULD NOT GET PARTS. THEY WERE TOLD THE CALLER WAS ON TOP OF LIST WHEN PARTS COME IN. CALLER WAS CONCERNED ABOUT THE SAFETY ISSUE OF THE WHEEL BEARING WENT OUT. THE CALLER SAID THE RECALL LETTER STATED THAT THE PROBLEM COULD LEAD TO A CRASH IF IT WAS NOT REPAIRED. *AK
Official recalls
205V329000 · Vehicle Speed Control:cables
Jul 20, 2005
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence & remedy
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
05V232000 · Wheels
May 19, 2005
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence & remedy
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.