Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
1625–50K
1850–75K
2175–100K
16100–150K
7150K+
129 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Wheels. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports13 fire reports8 injury reports
What owners actually said
175 reports
75,000 miles · Mar 10, 2010
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING AT SPEEDS OF 70 MPH THE VEHICLE WOULD CONTINUOUSLY MAKE A JERKING MOTION AND STALL WITHOUT WARNING; HOWEVER, THE PROBLEM WOULD OCCUR INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY COULD NOT DUPLICATE THE FAILURES AND RELEASED THE VEHICLE BACK TO THE OWNER. THE …
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING AT SPEEDS OF 70 MPH THE VEHICLE WOULD CONTINUOUSLY MAKE A JERKING MOTION AND STALL WITHOUT WARNING; HOWEVER, THE PROBLEM WOULD OCCUR INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY COULD NOT DUPLICATE THE FAILURES AND RELEASED THE VEHICLE BACK TO THE OWNER. THE VEHICLE CONTINUED TO STALL INTERMITTENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN BACK TO THE DEALER A SECOND TIME AND AGAIN THEY COULD NOT DUPLICATE THE FAILURE. HE THEN TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO ALSO COULD NOT DETERMINE THE CAUSE OF THE FAILURE. ON THE THIRD ATTEMPT, A SPECIALIST AT THE DEALERSHIP STATED THAT THE EMISSIONS SENSOR AND THE THROTTLE VALVE WERE REPLACED; HOWEVER, THE FAILURE PERSISTED. THERE WERE NO ADDITIONAL REPAIRS PERFORMED AND THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000 AND THE CURRENT MILEAGE WAS 98,000.
NHTSA ODI #10318527
47,000 miles · Mar 10, 2010
Steering
POWER STEERING SEEMS TO FADE IN AND OUT INTERMITTENTLY. *TR
NHTSA ODI #10318470
92,817 miles · Dec 24, 2009
StructureVisibility
THE FRONT WINDSHIELD FIRST STARTED MAKING CREAKING AND POPPING NOISES. THEN A LEAK BEGAN IN THE SAME AREA OF THE NOISES. WATER LEAKS ONTO THE FLOOR NEAR THE BRAKE PEDAL AND CAUSES A SLIPPERY SURFACE UNDER MY FEET. NOW I HAVE BEEN TOLD THAT THE ENTIRE WINDOW FRAME OF THE FRONT WINDSHIELD IS MOVING WHEN THE CAR MOVES AND COULD PO…
Read full complaint
THE FRONT WINDSHIELD FIRST STARTED MAKING CREAKING AND POPPING NOISES. THEN A LEAK BEGAN IN THE SAME AREA OF THE NOISES. WATER LEAKS ONTO THE FLOOR NEAR THE BRAKE PEDAL AND CAUSES A SLIPPERY SURFACE UNDER MY FEET. NOW I HAVE BEEN TOLD THAT THE ENTIRE WINDOW FRAME OF THE FRONT WINDSHIELD IS MOVING WHEN THE CAR MOVES AND COULD POP OUT OF PLACE OR SHATTER WHILE DRIVING. *TR
NHTSA ODI #10296916
50,000 miles · Dec 15, 2009
Steering
TL* THE CONTACT OWNS A 2004 KIA SEDONA. WHEN MAKING TURNS SHE CAN HEAR A CLINGING NOISE IN THE STEERING COLUMN. ALSO SHE EXPERIENCED DIFFICULTLY STEERING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. SHE WAS ADVISED THAT THE INTERMEDIATE SHAFT BINDING NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 50000.…
Read full complaint
TL* THE CONTACT OWNS A 2004 KIA SEDONA. WHEN MAKING TURNS SHE CAN HEAR A CLINGING NOISE IN THE STEERING COLUMN. ALSO SHE EXPERIENCED DIFFICULTLY STEERING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. SHE WAS ADVISED THAT THE INTERMEDIATE SHAFT BINDING NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 50000.
NHTSA ODI #10295893
70,929 miles · Dec 13, 2009
SuspensionWheels
WHILE DRIVING AT 10 MPH ,MY DAUGHTER AND I HEARD A CLUNK IN THE REAR OF OUR 2004 KIA SEDONA LX. I WAS HEADING FOR A REPAIR SHOP AS A RESULT AND HEARD A SECOND CLUNK AND PULLED OFF ON A SIDE STREET AND DROVE 200 FEET WHEN THE WHEEL BEARING ASSEMBLY CAME APART AND THE WHOLE WHEEL FLEW OFF THE VAN. *TR
NHTSA ODI #10295523
45,000 miles · Oct 28, 2009
Electrical System
KIA SEDONA 2004-VEHICLE WILL NOT SHUT OFF EVEN WHEN THE KEYS ARE REMOVED FROM THE IGNITION. THE CAR WILL DRIVE HOWEVER NO FUNCTIONS ON THE DASHBOARD WILL WORK, LIGHTS, WIPERS, RADIO, HEADLIGHTS ETC. THIS HAPPENED FOR ABOUT 1 WEEK IN JUNE 2009 AND HERE AND THERE THROUGHOUT THE SUMMER. I DID HAVE IT TOWED BACK TO THE DEALERSHI…
Read full complaint
KIA SEDONA 2004-VEHICLE WILL NOT SHUT OFF EVEN WHEN THE KEYS ARE REMOVED FROM THE IGNITION. THE CAR WILL DRIVE HOWEVER NO FUNCTIONS ON THE DASHBOARD WILL WORK, LIGHTS, WIPERS, RADIO, HEADLIGHTS ETC. THIS HAPPENED FOR ABOUT 1 WEEK IN JUNE 2009 AND HERE AND THERE THROUGHOUT THE SUMMER. I DID HAVE IT TOWED BACK TO THE DEALERSHIP BUT AT THE TIME THEY WERE UNABLE TO IDENTIFY THE PROBLEM AS IT HAD CORRECTED ITSELF. IT HAPPENED AGAIN THE WEEK OF OCTOBER 21ST. THE BATTERY HAD TO BE DISCONNECTED TO TURN THE VEHICLE OFF. THEY ARE STILL UNSURE OF WHAT IS CAUSING THE CAR TO REMAIN ON WITHOUT THE KEY IN THE IGNITION. *TR
NHTSA ODI #10290164
Mileage unknown · Oct 5, 2009
Steering
ABOUT A YEAR AGO MY STEERING ON MY 04 KIA SEDONA WAS GETTING TIGHT AND HARD TO TURN, NOW THERE IS A CLICKING NOISE WHEN TURNING THE STEERING WHEEL MY FRIEND HAS AN 03 SEDONA AND HERS DID THE SAME THING IS THIS A RECALL? *TR
NHTSA ODI #10286332
88,000 miles · Aug 24, 2009
Vehicle Speed Control
COMPLAINT 10281505 PREVIOUSLY FILED. SEDONA HAD THROTTLE CABLE REPLACED IN OCTOBER 05 AS PART OF KIA SERVICE RECALL. PROBLEM SAME AS IN COMPLAINT 10139518 FROM SEPT 2005 REPORTED INCIDENT. THE 2005 AND THIS 2009 INCIDENT DID NOT OCCUR IN THE WINTER IN FREEZING CONDITIONS. *TR
NHTSA ODI #10281559
88,000 miles · Aug 24, 2009
Vehicle Speed Control
KIA SEDONA 2004 TRAVELING ABOUT 30 MPH WITH GENTLE ACCELERATION. CAR WITHOUT USING ACCELERATOR SPED UP TO 40+ MPH AND BRAKES COULD NOT STOP CAR. CAR STOPPED BY PULLING OVER AND TURNING OFF ENGINE. *TR
NHTSA ODI #10281505
79,460 miles · Jun 15, 2009
VisibilityInjury
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING 45 MPH, THE FRONT DRIVER'S SIDE WINDOW SHATTERED INTO PIECES. THE CONTACT'S ARM WAS INJURED FROM THE GLASS AND A POLICE REPORT WAS FILED. SHE STATED THAT THE WINDOW WAS PARTIALLY ROLLED DOWN PRIOR TO THE FAILURE AND NOTHING STRUCK THE GLASS. THE VEHICLE HAS NOT BEEN TAKEN …
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING 45 MPH, THE FRONT DRIVER'S SIDE WINDOW SHATTERED INTO PIECES. THE CONTACT'S ARM WAS INJURED FROM THE GLASS AND A POLICE REPORT WAS FILED. SHE STATED THAT THE WINDOW WAS PARTIALLY ROLLED DOWN PRIOR TO THE FAILURE AND NOTHING STRUCK THE GLASS. THE VEHICLE HAS NOT BEEN TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT NOTIFIED. THE CAUSE OF THE FAILURE HAS NOT BEEN DETERMINED. THE FAILURE MILEAGE WAS 79,460.
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence & remedy
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence & remedy
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
2004 Kia Sedona Problems, Complaints & Recalls | Skip That Year
Illustration