2003 Kia Rio

THE SWITCH ASSEMBLY BLOWER (PART # 97251 FD000) CONSTANTLY GOES OUT ON MY 2003 KIA RIO. THE FIRST TIME IT HAPPENED MY CAR CAUGHT ON FIRE. I REPLACED IT. 6 MONTHS LATER IT WENT OUT AGAIN. I REPLACED IT ALONG WITH THE RESISTOR ASSEMBLY (PART# 1K552 61C08). 8 MONTHS LATER, IT WENT OUT AGAIN. THERE IS NOTHING WRONG WITH THE FUSE. THERE IS NOT A SHORT IN THE SYSTEM THAT CAN BE FOUND. I HAVE YET TO REPLACE THE SWITCH ASSEMBLY ANTICIPATING THE COMPANY RECTIFYING THIS. *TR

BACK IN 2006 I PURCHASED A 2003 KIA RIO AND IN AUG 2009 I WAS SENT A LETTER TELLING ME MY REAR SEATBELTS HAD BEEN RECALLED DUE TO MALFUNCTION WHEN CHILDRESTRANT SEATS WERE USED. THE COMPANY KNEW ABOUT THE RECALL IN 2006 ACCORDING TO THE LETTER BUT DIDN'T NOTIFY ME UNTIL 2009, AND I HAVE A 7 YR OLD SON WHO HAS BEEN RIDING IN MY CAR WITH RECALLED SEATBELTS, THIS MADE ME UPSET SINCE THAT'S THE SAFETY OF MY CHILD. THE COMPANY DID REPLACE THE SEATBELTS BUT IT TOOK THEM ANOTHER 3 WEEKS TO GET THE PARTS AFTER ME NOTIFYING THEM ABOUT THE RECALL LETTER. *TR

2003 KIA RIO DOOR OPENING MECHANISM HAS FAILED TWICE. IT WAS REPAIRED IN 2007. THE MECHANIC WHO REPAIRED THE DOOR SAID THE DESIGN OF THE DOOR OPENING SYSTEM INSIDE THE DOOR WAS NOT GOOD QUALITY AND POORLY ENGINEERED ANTICIPATING IT MIGHT FAIL AGAIN. THE DRIVER'S DOOR OPENING DEVISE IS TOTALLY DISENGAGED AND THE PASSENGER DOOR HAS TO BE USED TO ENTER AND EXIT THE VEHICLE. WHEN TAKEN TO KIA THE DEALER ACKNOWLEDGED IT WAS A PROBLEM WITH THIS MODEL BUT WOULD COST $250 TO $500 TO FIX THIS PROBLEM EVENTHOUGH IT WAS NOT THE FAULT OF THE OWNER AND HAD BEEN A PROBLEM WITH SEVERAL OTHERS. *TR

WHILE DRIVING DOWN THE ROAD WITH MY TWO YEAR OLD IN THE CAR, THE ENGINE SEIZED UP AND STALLED. THE CAR CURRENTLY WONT START AND HAD TO BE TOWED TO THE REPAIR SHOP. HOWEVER, WE JUST HAD ALL OF THE ROUTINE MAINTENANCE TO THE CAR LESS THEN 300 MILES PRIOR TO THE ENGINE SEIZING. THE CHECK ENGINE LIGHT NEVER CAME ON. AS OF TODAY, THEY DON'T KNOW WHAT THE PROBLEM IS EXCEPT THAT THE ENGINE SEIZED. THERE WAS NO PRIOR INCIDENTS WITH THE CAR AND IT WAS ALWAYS SERVICED ON TIME. *TR

THE CLUTCH IN MY 2003 KIA RIO HAS FAILED/BROKEN FOUR TIMES NOW. MY FATHER AND I BOUGHT THE VEHICLE BRAND NEW IN MARCH 2003 THE FIRST CLUTCH FAILED AROUND 8000 MILES I BELIEVE, THE SECOND AROUND 24000 MILES, THE THIRD AROUND 40000 MILES, AND NOW IS SITTING IN MY GARAGE UNABLE TO GO INTO ANY GEAR; THE CAR HAS LESS THAN 65000 MILES ON IT. I HAVE BEEN DRIVING STICK SHIFTS FOR 14+ YRS. AND I KNOW HOW TO PROPERLY OPERATE THEM, YET WHENEVER I TAKE THE VEHICLE INTO THE DEALERSHIP I AM TOLD IT IS DRIVER ERROR AND CHARGED AT LEAST $1000 IN REPAIRS. I HAVE HAD AT LEAST THREE OTHER MECHANICS LOOK AT IT AND HAVE BEEN TOLD IT IS A DESIGN/BAD PARTS PROBLEM NOT DRIVING ERROR, HOWEVER I DON'T WANT TO JEOPARDIZE THE WARRANTY BY HAVING IT REPAIRED ANYWHERE BUT THE DEALERSHIP. WITH THE LAST REPAIR (CLUTCH #3) MY FATHER WAS ALLOWED TO SPEAK TO THE DEALERSHIPS MECHANIC AFTER THE CAR WAS PULLED APART AND CAUGHT THE DEALERSHIP IN A LOT OF LIES BASED ON THE TOTAL DAMAGE DONE TO THE CLUTCH AND SURROUNDING PARTS. THERE WAS NO WAY THAT MUCH DAMAGE COULD HAVE BEEN DONE SIMPLY BY DRIVING THE VEHICLE. THEY GAVE HIM SOME FREE PARTS AND LABOR BUT THE BILL WAS STILL OVER $600 AND THE PROBLEM IS STILL THERE AS EVIDENCED BY THE VEHICLE NOT GOING INTO ANY GEAR NOW. I HAVE READ OVER 100 SIMILAR REPORTS FROM OTHER PEOPLE WHO OWN THE SAME MAKE, MODEL, AND YEAR AS MINE. KIA NEEDS TO BE HELD RESPONSIBLE FOR THIS, NOT THE CUSTOMER. I HAVE BEEN LUCKY SO FAR AS TO NOT HAVE ANYONE INJURED, I DRIVE MY FIVE YEAR OLD DAUGHTER IN THAT CAR, BUT I HAVE BEEN LEFT STRANDED IN SEVERAL NOT NICE NEIGHBORHOODS BECAUSE OF THE CLUTCH FAILURE AND HAVE HAD THE CLUTCH GO OUT WHILE IN THE MIDDLE OF A BUSY INTERSECTION. THE PROBLEM COMES ON SUDDENLY WITH LITTLE TO NO WARNING OF THE CLUTCH HAVING PROBLEMS AND IS A SEVERE SAFETY HAZARD, NOT ONLY TO THE PEOPLE INSIDE THE VEHICLE BUT FOR THE OTHER PEOPLE ON THE ROAD. IF THIS CONTINUES, SOMEONE WILL BE SEVERELY INJURED OR KILLED IF IT HAS NOT HAPPENED ALREADY. PLEASE HELP. *TR

TL*THE CONTACT OWNS A 2003 KIA RIO. WHILE DRIVING AT AN UNKNOWN SPEED AND APPROACHING A STOP, THE VEHICLE STALLED BUT DID NOT SHUT OFF WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO A DEALER AND DIAGNOSED WITH FUEL PUMP FAILURE. THE FUEL PUMP WAS REPLACED. APPROXIMATELY FOUR MONTHS LATER, THE FAILURE RECURRED. THE DEALER COULD NOT DUPLICATE THE FAILURE. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 75,000 AND FAILURE MILEAGE WAS 69,500.

BOUGHT 2003 KIA RIO NEW. IN JAN 2005 AT ABOUT 53,000 MILES I HEARD A RATTLE AT ABOUT 50 MILES PER HOUR. IN A FEW SECONDS THE ENGINE JUST SHUTDOWN (TIMING BELT BROKE WHICH DESTROYED THE ENGINE) KIA REPLACED UNDER WARRANTY. MAY 21 2008 WHILE DRIVING ABOUT 45 MILES PER HOUR WE HEARD A SQUEAL AND AGAIN THE ENGINE SHUTDOWN. COASTED TO A STOP, ONCE AGAIN THE TIMING BELT WHICH MEANS ANOTHER ENGINE (58,000 SINCE THE LAST ENGINE) NO LONGER UNDER WARRANTY (AN ENGINE COST ALMOST AS MUCH AS THE CAR ITSELF). *TR

TL*THE CONTACT OWNS A 2003 KIA RIO. AFTER PARKING THE VEHICLE, THE PASSENGER SIDE DOOR FAILED TO OPEN AND THE CONTACT WAS TRAPPED INSIDE. THE DOOR WAS ABLE TO BE OPENED FROM THE OUTSIDE. THE DEALER STATED THAT THE FAILURE WAS UNRECOGNIZABLE. A FEW DAYS LATER, THE DRIVER SIDE DOOR FAILED AS WELL. NO REPAIRS WERE MADE ON THE DOORS. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 74,800.