NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
345 reportsMileage unknown · Jul 21, 2025
Electrical System
At approximately 36,600 miles, my 2023 Jeep Wrangler Sahara began experiencing a critical and recurring electrical malfunction. Upon attempting to start the vehicle: •All dashboard electronics power on, but the engine does not crank or start. •The brake pedal remains fully depressed and will not release. •The vehicle cannot be s…
Read full complaint
At approximately 36,600 miles, my 2023 Jeep Wrangler Sahara began experiencing a critical and recurring electrical malfunction. Upon attempting to start the vehicle: •All dashboard electronics power on, but the engine does not crank or start. •The brake pedal remains fully depressed and will not release. •The vehicle cannot be shut off by the ignition; the only way to power it down is by disconnecting the battery and fuse and waiting ~15 minutes. This issue renders the vehicle completely inoperable and has occurred multiple times. It began just 600 miles after the factory warranty expired (36,000 miles), and two dealership repair attempts have failed to resolve the issue. I’ve reviewed public NHTSA complaints and discovered that similar issues are being reported in 2023 Wranglers, including full power loss and no-start conditions. This issue is consistent with symptoms reported in the NHTSA’s July 2024 investigation into 2023–2024 Jeep Wrangler 4xe models for electrical system failures. I believe this is part of a systemic electrical defect and poses a serious safety risk due to its sudden onset and inability to shut the vehicle down normally.
NHTSA ODI #11674968
Mileage unknown · Jul 17, 2025
Electrical System
I've had the Electric Coolant Heater Module (ECH) replaced three times in under three months, and had to pay $853 the last time for a wiring harness connector that the dealership & Jeep said was not covered under the warranty. I couldn't continue to safely drive the vehicle with a Check Engine Light on given the other reported p…
Read full complaint
I've had the Electric Coolant Heater Module (ECH) replaced three times in under three months, and had to pay $853 the last time for a wiring harness connector that the dealership & Jeep said was not covered under the warranty. I couldn't continue to safely drive the vehicle with a Check Engine Light on given the other reported problems with the 4xe Hybrid Battery system so I had no choice but to pay for the part out of pocket, even though the item the connector was attached to was deemed to be covered by the 100,000 miles hybrid system warranty.
NHTSA ODI #11674411
Mileage unknown · Jul 3, 2025
Unknown Or Other
I was driving on the highway and all of a sudden the vehicle fell dead and I can’t put it into gear.
NHTSA ODI #11671105
Mileage unknown · Jun 30, 2025
SteeringSuspensionWheels
STATEMENT OF FACTS 1.I am the registered owner of a 2023 Jeep Wrangler Rubicon (VIN: [XXX]), purchased for approximately $75,000 USD, inclusive of all taxes and registration, in cash. 2.I have been driving different cars for over 25 years and have owned multiple vehicles. This Jeep Wrangler is the most expensive vehicle I have e…
Read full complaint
STATEMENT OF FACTS 1.I am the registered owner of a 2023 Jeep Wrangler Rubicon (VIN: [XXX]), purchased for approximately $75,000 USD, inclusive of all taxes and registration, in cash. 2.I have been driving different cars for over 25 years and have owned multiple vehicles. This Jeep Wrangler is the most expensive vehicle I have ever owned, and the only one to cause severe safety issues for me and my family. 3.I primarily drive this vehicle on weekends with my two young children (ages [XXX] and [XXX]) seated in the rear seats. The persistent and unresolved mechanical issues with this vehicle have directly jeopardized our physical safety and my livelihood( I couldn’t go to work during many weeks) 4.There are new problems related to manufacturing defects that keep poping up every month since last 6 months while the car is only used for 25k and under basic warranty (Example on top of serious DEATH WOBBLE issue , there are incidents of COOLANT ISSUES, 95B SAFETY RECALL, BATTERY PACK ISSUES- REFER below Photos, in addition I have phone messages and VIDEOS of DEATH WOBBLE as Evidence) ISSUES AND SERVICE HISTORY 4.At approximately 5,000 miles of use, the vehicle began exhibiting significant technical issues. 5.The first major defect was related to the battery pack, which rendered the vehicle inoperable. The dealership held the vehicle for approximately two months in 2023 to address this issue. 6.Over the last six months, the vehicle developed a recurring and dangerous condition widely referred to as the "death wobble" – a violent and uncontrollable shaking of the vehicle while driving on the freeway. 7.This defect has occurred multiple times, forcing me to immediately pull over on the freeway, placing me, my children, and surrounding drivers at serious risk of harm or collision. 8.I have documented multiple instances of the death wobble via video and have submitted evidence to both: oThe Jeep dealership oJeep Customer Care / FCA US LLC 9.Despite my repeat INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION
NHTSA ODI #11670405
Mileage unknown · Jun 24, 2025
Electrical System
Driving roughly 20 MPH coming off of a highway off ramp, the vehicle lerched and went into "turtle mode". Pulled to side of ramp and engine stalled. Would not crank over when attempting to start. Brand new 12V battery that morning due to vehicle not starting in driveway.
NHTSA ODI #11669028
Mileage unknown · May 31, 2025
Electrical System
I've had the Electric Coolant Heater (ECH) replaced three times in less than three months under the Hybrid Battery Warranty. The third repair included having to pay $853 to replace the ECV connector, which was not picked up by the Hybrid Battery Warranty, and the dealer required buying the entire harness just to get a new connec…
Read full complaint
I've had the Electric Coolant Heater (ECH) replaced three times in less than three months under the Hybrid Battery Warranty. The third repair included having to pay $853 to replace the ECV connector, which was not picked up by the Hybrid Battery Warranty, and the dealer required buying the entire harness just to get a new connector.
NHTSA ODI #11664123
Mileage unknown · May 20, 2025
EngineUnknown Or Other
I recently rented this vehicle from Budget. I had the vehicle for 3 weeks before I found out it had a recall on it. I took a look into it and the recall was out there since September of 2024. Not only that it was a major issue. The vehicle could’ve caught fire. This is very alarming to me because I had the vehicle for so long. I…
Read full complaint
I recently rented this vehicle from Budget. I had the vehicle for 3 weeks before I found out it had a recall on it. I took a look into it and the recall was out there since September of 2024. Not only that it was a major issue. The vehicle could’ve caught fire. This is very alarming to me because I had the vehicle for so long. I rented the vehicle in April of 2025. This vehicle should not have been available to rent. I tried to attach the conversation I had with the locations manager on the day I returned it stating that the vehicle was on the recall list but I reached out to him no one from Budget contacted me. I have supporting documents but I’m not able to attach them. I have my rental contract that states the date and also the email between the manager at the location. Kind Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11662085
Mileage unknown · May 5, 2025
Unknown Or Other
While driving my 2023 Jeep Wrangler on a road traveling at approx 15 to 20 mph the “Auto Park “ feature activated and the vehicle came to an abrupt stop in the middle of the road.The D indicator was blinking and in order to proceed I had to place the shift in Park and then back in Drive. The car was flat bedded to the dealer who…
Read full complaint
While driving my 2023 Jeep Wrangler on a road traveling at approx 15 to 20 mph the “Auto Park “ feature activated and the vehicle came to an abrupt stop in the middle of the road.The D indicator was blinking and in order to proceed I had to place the shift in Park and then back in Drive. The car was flat bedded to the dealer who was unable to fix it. The dealer was unable to assure me this would not happen again. The dealer did disconnect the wiring to the door which gave my wife and I some comfort and peace of mind. One of two things could have caused this to happen;1 a malfunction in the module in the door or 2 a malfunction in the computer. I have a severely degenerated cervical spine; a rear end collision could cause me severe injury. It is absolutely necessary that this function be turned off in my vehicle. I have been patiently awaiting for Jeep Wave and my local dealer to fix this problem. In the meantime, my wife and I have had no window operation nor keyless entry nor mirror operation on the driver’s side. It was only by the Grace of God that no vehicle was following us that day.
NHTSA ODI #11658969
Mileage unknown · Apr 15, 2025
Electrical System
See attached document for complaint.
NHTSA ODI #11654662
Mileage unknown · Apr 10, 2025
SteeringSuspension
We have been experiencing a bouncing and shaking in the front end of our vehicle while driving at highway speeds. This happens when hitting the slightest bump or transitions from pavement to concrete. Last week while driving on the highway the shaking and bouncing was so violent that I can't believe I didn't lose control. I brou…
Read full complaint
We have been experiencing a bouncing and shaking in the front end of our vehicle while driving at highway speeds. This happens when hitting the slightest bump or transitions from pavement to concrete. Last week while driving on the highway the shaking and bouncing was so violent that I can't believe I didn't lose control. I brought the vehicle to the dealer and for the second time they replaced more suspension items in the front end. After doing some research I found out that this has been a problem with these vehicles for quite some time and that it's known as the "Death Wobble". After what I experienced I can understand why. I called Jeep and spoke to multiple people in different departments and as they acknowledge the problem they don't seem to care how unsafe the issue is. I can't believe there haven't been any deaths related to this and I'm hoping you might investigate these issues further before that happens.
NHTSA ODI #11653842
Official recalls
14Jun 4, 2026
Chrysler (FCA US, LLC) is recalling certain 2021-2025 Jeep Wrangler, Wrangler 4XE, and Jeep Gladiator vehicles. The electric hydraulic power steering pump wiring may overheat and cause a vehicle fire, even when the vehicle is parked with the ignition in the "Off" position.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures, until their vehicle is repaired. Dealers will inspect and replace the wiring and electric hydraulic power steering pump, as necessary, free of charge. Owner notification letters are expected to be mailed July 9, 2026. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 21D. The Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on June 11, 2026.
Oct 30, 2025
Chrysler (FCA US, LLC) is recalling certain 2020-2025 Jeep Wrangler 4Xe and 2022-2026 Grand Cherokee 4Xe vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.
Consequence & remedy
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures and not to charge their vehicles until the remedy is completed. Dealers will update the high voltage battery software, and replace the high voltage battery, as necessary, free of charge. Some owner notification letters were mailed beginning December 17, 2025. The remaining owner notification letters will be mailed at a later date. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 68C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 6, 2025. Vehicles that were previously recalled for the same issue under NHTSA Recalls 24V720 and 23V787 will need to have the new remedy performed.
Sep 12, 2024
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.
Exterior Lighting:brake Lights
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.
Sep 5, 2024
Chrysler (FCA US, LLC) is recalling certain 2020-2024 Jeep Gladiator and 2018-2024 Jeep Wrangler vehicles. The instrument panel cluster may experience an internal short circuit and fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Controls and Displays."
Consequence & remedy
Consequence: An instrument panel that fails to display critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Remedy: Dealers will replace the instrument panel cluster, free of charge. Owner notification letters were mailed between October 3, 2024, and January 23, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is 30B.
Mar 14, 2024
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2023-2024 Ram 1500, Jeep Wrangler, Jeep Wagoneer, Jeep Grand Wagoneer, Chrysler Pacifica, Ram 3500, Ram 3500 cab chassis, Ram 2500, Ram 4500 cab chassis, Ram 5500 cab chassis, 2023 Jeep Gladiator, Jeep Grand Cherokee, Jeep Grand Cherokee L, Ram 3500 Cab Chassis with a GVWR less than 10,000 lbs., and Chrysler Voyager vehicles. The steering column control module may not be welded properly, which can prevent the driver's air bag from deploying in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An air bag that does not deploy in a crash can increase the risk of injury.
Remedy: Dealers will inspect and replace the steering column control module, as necessary free of charge. Some owner notification letters were mailed April 11, 2024 through June 20, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 14B, 33B, 34B, 35B, 36B.
Additional source detail variants (2)
Air Bags:frontal:driver Clockspring/spiral Cassette
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2023-2024 Ram 1500, Jeep Wrangler, Jeep Wagoneer, Jeep Grand Wagoneer, Chrysler Pacifica, Ram 3500, Ram 3500 cab chassis, Ram 2500, Ram 4500 cab chassis, Ram 5500 cab chassis, 2023 Jeep Gladiator, Jeep Grand Cherokee, Jeep Grand Cherokee L, Ram 3500 Cab Chassis with a GVWR less than 10,000 lbs., and Chrysler Voyager vehicles. The steering column control module may not be welded properly, which can prevent the driver's air bag from deploying in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An air bag that does not deploy in a crash can increase the risk of injury.
Remedy: Dealers will inspect and replace the steering column control module, as necessary free of charge. Some owner notification letters were mailed April 11, 2024 through June 20, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 14B, 33B, 34B, 35B, 36B.
Steering:column
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2023-2024 Ram 1500, Jeep Wrangler, Jeep Wagoneer, Jeep Grand Wagoneer, Chrysler Pacifica, Ram 3500, Ram 3500 cab chassis, Ram 2500, Ram 4500 cab chassis, Ram 5500 cab chassis, 2023 Jeep Gladiator, Jeep Grand Cherokee, Jeep Grand Cherokee L, Ram 3500 Cab Chassis with a GVWR less than 10,000 lbs., and Chrysler Voyager vehicles. The steering column control module may not be welded properly, which can prevent the driver's air bag from deploying in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An air bag that does not deploy in a crash can increase the risk of injury.
Remedy: Dealers will inspect and replace the steering column control module, as necessary free of charge. Some owner notification letters were mailed April 11, 2024 through June 20, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 14B, 33B, 34B, 35B, 36B.
Feb 15, 2024
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Jeep Wrangler and 2022-2024 Jeep Grand Cherokee vehicles. A hybrid control processor (HCP) software error may cause the defrosting and defogging system to be inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence & remedy
Consequence: An inoperative windshield defrosting and defogging system may decrease the driver's visibility, increasing the risk of a crash.
Remedy: Dealers will update the HCP software, free of charge. Owner notification letters were mailed February 29, 2024. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 04B.
Nov 22, 2023
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler Plug-In Hybrid Electric (PHEV) vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.
Consequence & remedy
Consequence: A vehicle fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack software and replace the battery pack assembly if necessary, free of charge. Owner notification letters were mailed March 7, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 89A. This recall is superseded by NHTSA Recall 24V-720.
Sep 18, 2023
Chrysler (FCA US), LLC is recalling certain 2022-2023 Jeep Wrangler and Gladiator vehicles equipped with a manual transmission. The rearview camera may fail to display the rearview image and the reverse lights may not illuminate when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A disabled rearview image can decrease the driver's visibility of the rear view, and disabled reverse lights may not alert others that the vehicle is reversing, increasing the risk of injury or crash.
Remedy: Dealers will replace the gear position sensor, free of charge. Owner notification letters were mailed November 16, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 92A.
Aug 10, 2023
Chrysler (FCA US, LLC) is recalling certain 2023 Jeep Wrangler vehicles. The spare tire may obstruct the view of the center high-mount brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A brake light that is obstructed may not be visible to other drivers to indicate the intention to slow or stop, increasing the risk of a crash.
Remedy: Dealers will replace the spare tire carrier assembly, free of charge. Owner notification letters were mailed September 28, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 84A.
Apr 27, 2023
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Jeep Wrangler Plug-In Hybrid Electric vehicles (PHEV). The high voltage (HV) battery pack assembly was built with incorrect fasteners to secure the 200-amp fuse, which can generate excessive heat.
Consequence & remedy
Consequence: Excessive heat may cause the fuse to fail and result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the HV battery fuse, as necessary. Dealers will also inspect the battery assembly for damage and replace it, if necessary. Repairs will be performed free of charge. Owner notification letters were mailed May 23, 2023. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 53A. This recall is an expansion of previous recall 22V-768.
Apr 13, 2023
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler, Gladiator, and 2022-2023 Ram 1500 vehicles equipped with a 3.0L diesel engine. The high pressure fuel pump (HPFP) may fail.
Consequence & remedy
Consequence: Fuel pump failure can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the HPFP and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 01A.
Feb 23, 2023
Chrysler (FCA US, LLC) is recalling certain 2018-2023 Jeep Wrangler, and 2020-2023 Jeep Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.
Consequence & remedy
Consequence: Overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.
Remedy: Dealers will replace the clutch assembly and update the software, free of charge. Owner notification letters were mailed from November 16, 2023 through July 25, 2024. Owners may contact (FCA US, LLC) customer service at 1-800-853-1403. FCA US LLC's number for this recall is 19A. This recall expands and replaces previous recall 21V-028. Vehicles previously repaired under recall 21V-028 will need to have the new remedy completed.
Nov 23, 2022
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler 4xe vehicles equipped with 2.0L Plug-In Hybrid Electric Vehicle engines. A loss of communication may cause an engine shutdown.
Consequence & remedy
Consequence: An engine shutdown can cause a loss of drive power, increasing the risk of a crash.
Remedy: There is more than one involved component and calibration software. Updating the calibration software in the Transmission Control Module, Hybrid Control Processor and Auxiliary Hybrid Control Processor that changes fail safe from shut down to limp home. Dealers will update the transmission control module software, Hybrid Control Processor and Auxiliary Hybrid Control Processor, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall ZB7.
Oct 13, 2022
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Jeep Wrangler Plug-In Hybrid Electric (PHEV) vehicles. The high voltage (HV) battery pack assembly was built with incorrect fasteners to secure the 200-amp fuse, which can generate excessive heat.
Consequence & remedy
Consequence: Excessive heat may cause the fuse to fail and result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the HV battery fuse, as necessary. Dealers will also inspect the battery assembly for damage and replace it, if necessary. Repairs will be performed free of charge. Owner notification letters were mailed December 8, 2022. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z71.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24024 · Underhood Fires
Opened Sep 6, 2024 · No close date supplied
Status: open (inferred from source dates) · Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) has received 9 Vehicle Owner's Questionnaire (VOQ) reports, 1 Death and Injury report, and multiple field reports alleging incidents of engine compartment fires in model year (MY) 2021-2023 Jeep Wrangler and Gladiator vehicles. The majority of the reports describe a fire occurring while the ignition in the vehicle was in an ‘OFF’ state with a suspected origin at the passenger front side of the engine compartment. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. ODI has contacted the vehicle manufacturer, Fiat Chrysler Automobiles (FCA), and learned of several thermal events originating at the power steering pump electrical connector in recent model year Jeep Wrangler and Gladiator vehicles. The location of the pump connector is located at the passenger front side of the engine compartment, coinciding with the majority of fire reports known to ODI. ODI is opening this Preliminary Evaluation (PE) to assess the cause, scope, and frequency of the alleged defect. To review the ODI reports cited in the Opening Resume ODI Report Identification Numbers document, go to NHTSA.gov.
RQ24012 · Loss Of Motive Power
Opened Jul 5, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System; Engine
The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures and failures in vehicles not included within the scope of 22V-865. An analysis comparing complaints received before the issuance of recall 22V-865 and complaints outside the scope of the recall has been conducted. The results show the current complaint rate is higher in the out of scope vehicles than it was for vehicles that were later covered by the recall. ODI is opening this Recall Query (RQ) to assess the severity of the alleged defect in vehicles not included in recall 22V-865.ODI will also assess the scope and remedy effectiveness of the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical System
The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures and failures in vehicles not included within the scope of 22V-865. An analysis comparing complaints received before the issuance of recall 22V-865 and complaints outside the scope of the recall has been conducted. The results show the current complaint rate is higher in the out of scope vehicles than it was for vehicles that were later covered by the recall. ODI is opening this Recall Query (RQ) to assess the severity of the alleged defect in vehicles not included in recall 22V-865.ODI will also assess the scope and remedy effectiveness of the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures and failures in vehicles not included within the scope of 22V-865. An analysis comparing complaints received before the issuance of recall 22V-865 and complaints outside the scope of the recall has been conducted. The results show the current complaint rate is higher in the out of scope vehicles than it was for vehicles that were later covered by the recall. ODI is opening this Recall Query (RQ) to assess the severity of the alleged defect in vehicles not included in recall 22V-865.ODI will also assess the scope and remedy effectiveness of the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration