NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
56 reportsClear category filterMileage unknown · Oct 25, 2023
Steering
When hitting bumps on the highway, my Jeep gets what is referred to as the “death wobble”. The steering wheel (and wheels themselves) shake violently. This is such a well known occurance that it actually had the term “death wobble” assigned to it. It is very hard to maintain control of the vehicle when this happens, creating …
Read full complaint
When hitting bumps on the highway, my Jeep gets what is referred to as the “death wobble”. The steering wheel (and wheels themselves) shake violently. This is such a well known occurance that it actually had the term “death wobble” assigned to it. It is very hard to maintain control of the vehicle when this happens, creating a hazard for me and others in vehicles around me. Many times I have to come to a complete stop to stop the shaking. This is also a problem because I have to decrease speed quickly and pull off the road, creating a collision risk if anyone is following closely or cannot get over into another lane. This has occurred on multiple occasions.
NHTSA ODI #11551740
Mileage unknown · Oct 13, 2023
Steering
While driving on the highway @ 65-8ph and if I drive over a rough patch on the road, the steering wheel vibrates for about 20 seconds after clearing the rough patch.
NHTSA ODI #11549879
Mileage unknown · Sep 13, 2023
Power TrainSteering
On the evening of Sept. 13th I was driving in-town appx. 25mph, pulling into a Walmart shopping center, when my 2023 Jeep Wrangler Sahara 4xe (Purchased in July of 2023) unexpectedly, with NO WARNING shut down! It reduced speed immediately and went into a "coasting mode" almost causing the car behind me to rear-end me. I immedia…
Read full complaint
On the evening of Sept. 13th I was driving in-town appx. 25mph, pulling into a Walmart shopping center, when my 2023 Jeep Wrangler Sahara 4xe (Purchased in July of 2023) unexpectedly, with NO WARNING shut down! It reduced speed immediately and went into a "coasting mode" almost causing the car behind me to rear-end me. I immediately put on my hazard lights and was attempting to turn the corner to pull it into the parking lot when my steering column seized and the vehicle shut off completely. There were warning lights on the instrument panel, however, I was unable to focus on what they were as I was in sheer panic mode trying not hit or be hit by the sudden shut down of my vehicle. The only warning I can recall was to put the car in park, which I was unable to do because I was in the middle of the road, with no area to pull over too. I have owned my vehicle for just over two months and at the time of the incident this evening the vehicle has 2, 727 miles, 1/2 tank of gas, the battery voltage was normal and it had a small amount of charge. I have read numerous articles stating, including one from NHTSA, that the recall does not affect my jeep as it was manufactured in Oct. 2022. This is incorrect information and if anyone had bothered to do any investigations would find that there are hundreds of complaints on Jeep forums for Jeep Wrangler 4xe's manufactured AFTER the 8/17/22 having this problem. The bigger issue is that there is NO RECALL for the issue because it is past the "end" date for the recall. THIS VEHICLE IS DANGEROUS!! I drive on the highway EVERY DAY to go to work and I can't imagine what would have happened if I had been in the left hand, passing lane when this occurred. SOMEONE COULD BE KILLED! I am bringing my vehicle to Lee Auto Mall Dealership/Service Center in Westbrook, ME first thing tomorrow morning to have the issue looked into / corrected and to inquire if this particular recall had been completed for this vehicle.
NHTSA ODI #11544429
Mileage unknown · Aug 25, 2023
Air BagsElectrical SystemSteering
I was driving down a side street when I received several warning lights for service shifter, airbags, seatbelts as well as the engine and all gauges cutting in and out. Following that my power steering went out and I could barely steer the vehicle. I had to call roadside assistance to tow the vehicle. The following fault codes …
Read full complaint
I was driving down a side street when I received several warning lights for service shifter, airbags, seatbelts as well as the engine and all gauges cutting in and out. Following that my power steering went out and I could barely steer the vehicle. I had to call roadside assistance to tow the vehicle. The following fault codes wers pulled via obdii: U0001, U0151, U0155, U017E, U0418, U1442. Each code related to a malfunction with "CAN BUS C" or what the dealership referred to as a "star connector". After further research it is apparent that this part has continued to fail on many jeep wranglers dating back to 2018 and every report I have seen the person has stated the same issue of losing power steering. My jeep is a 2023 and now needs this part replaced. Why hasn't there been a recall on these vehicles for this faulty part? Why does chrysler continue to use these faulty parts on current vehicles when they know of their failure rate? This is a serious safety issue and should have been addressed years ago. Something must be done before someone gets hurt or killed.
NHTSA ODI #11540831
Mileage unknown · Aug 17, 2023
SteeringSuspensionWheels
After hitting a bump driving normal highway speeds 45+ mph the car begins to shake and vibrate vigorously. It feels like you will lose control of the vehicle and the only way to stop these vibrations is to slow down to 30-40mph. Stopping like this on the freeway seems extremly unsafe when traffic is flowing. The dealership re…
Read full complaint
After hitting a bump driving normal highway speeds 45+ mph the car begins to shake and vibrate vigorously. It feels like you will lose control of the vehicle and the only way to stop these vibrations is to slow down to 30-40mph. Stopping like this on the freeway seems extremly unsafe when traffic is flowing. The dealership referred to this issue as the "Jeep Death Wobble" and it is apparently a known issue. The vehicle has been into the shop already twice and they have failed to correct the issue. The first time they replaced the stabilizer and the second time they were unable to replicate the issue to the traffic in the area and being not able to drive at highway speeds. Stellantis/FCA have requested I continue to to Drive this vehicle even with these issues saying this is not a safety issue.
NHTSA ODI #11539248
400 miles · Aug 3, 2023
SteeringStructure
The contact owns a 2023 Jeep Wrangler. The contact stated that the vehicle rooftop was made of fiber glass that dropped on the vehicle occupants while driving. The contact stated that the fiber glass could cause health issues if inhaled. The contact stated that the dealer had replaced the rooftop once, and the freedom panels twi…
Read full complaint
The contact owns a 2023 Jeep Wrangler. The contact stated that the vehicle rooftop was made of fiber glass that dropped on the vehicle occupants while driving. The contact stated that the fiber glass could cause health issues if inhaled. The contact stated that the dealer had replaced the rooftop once, and the freedom panels twice; however, the failure persisted as the replacement parts were made of the same materials. The contact stated that the dealer informed him that the top was made from trust and bonded fiber glass. Additionally, the contact stated while driving 40-60 MPH, the steering wheel was shuddering back and forth, causing the vehicle to vibrate and to sway. The contact also stated that while driving at highway speeds, the vehicle pulled to the left side. The contact turned the steering to the right in order to keep the vehicle in the lane. There was no warning light illuminated. The vehicle was taken to the dealer, where the steering wheel was realigned twice; however, the failure persisted. The manufacturer was notified of the failure and a case was opened. The vehicle was not repaired. The failure mileage was approximately 400.
NHTSA ODI #11536270
Mileage unknown · Jul 30, 2023
SteeringSuspension
Intermitent severe shaking in steering wheel "Death Wobble". This happen around 10 times now and still dealer dont know how to fix it. During the event it cause you to panic and potential accident.
NHTSA ODI #11535293
6,000 miles · Jul 14, 2023
Steering
The contact owns a 2023 Jeep Wrangler. The contact stated while attempting to start the vehicle, the vehicle would not start immediately. The contact stated that after several attempts the vehicle started. While driving out a parking lot, the vehicle lost power steering functionality. There was no warning light illuminated. The …
Read full complaint
The contact owns a 2023 Jeep Wrangler. The contact stated while attempting to start the vehicle, the vehicle would not start immediately. The contact stated that after several attempts the vehicle started. While driving out a parking lot, the vehicle lost power steering functionality. There was no warning light illuminated. The contact was able to drive the vehicle to the residence. The vehicle was taken to the dealer but no cause for the failure was found. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was 6,000.
NHTSA ODI #11532366
10,000 miles · Jun 30, 2023
Parking BrakeService BrakesSteeringCrash
The contact owns a 2021 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, the steering wheel locked, causing him to momentarily lose control of the vehicle. Upon attempting to bring the vehicle to a stop, the contact stated that the brake pedal was stuck in its resting position, prompting him to pull …
Read full complaint
The contact owns a 2021 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, the steering wheel locked, causing him to momentarily lose control of the vehicle. Upon attempting to bring the vehicle to a stop, the contact stated that the brake pedal was stuck in its resting position, prompting him to pull the parking brake, which also failed to bring the vehicle to a stop. As a result, the contact stated that he collided with the vehicle ahead. An unknown warning light was illuminated on the instrument panel prior to the failure being experienced. The air bags did deploy. A police report was filed, and no injuries were reported. The vehicle was towed to the contact's residence and later towed to the dealer, who declined to diagnose the vehicle due to the body damage. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 10,000.
NHTSA ODI #11529801
Mileage unknown · Jun 28, 2023
Steering
The power steering pump squeaks and squeals at low speeds when turning the vehicle. Potential for power steering failure resulting in loss of control. Dealer stated the squeaking noise is normal. Dealer refused to do a proper inspection only an audio inspection. No warning lights.
NHTSA ODI #11529416
Official recalls
14Jun 4, 2026
Chrysler (FCA US, LLC) is recalling certain 2021-2025 Jeep Wrangler, Wrangler 4XE, and Jeep Gladiator vehicles. The electric hydraulic power steering pump wiring may overheat and cause a vehicle fire, even when the vehicle is parked with the ignition in the "Off" position.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures, until their vehicle is repaired. Dealers will inspect and replace the wiring and electric hydraulic power steering pump, as necessary, free of charge. Owner notification letters are expected to be mailed July 9, 2026. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 21D. The Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on June 11, 2026.
Oct 30, 2025
Chrysler (FCA US, LLC) is recalling certain 2020-2025 Jeep Wrangler 4Xe and 2022-2026 Grand Cherokee 4Xe vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.
Consequence & remedy
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures and not to charge their vehicles until the remedy is completed. Dealers will update the high voltage battery software, and replace the high voltage battery, as necessary, free of charge. Some owner notification letters were mailed beginning December 17, 2025. The remaining owner notification letters will be mailed at a later date. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 68C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 6, 2025. Vehicles that were previously recalled for the same issue under NHTSA Recalls 24V720 and 23V787 will need to have the new remedy performed.
Sep 12, 2024
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.
Exterior Lighting:brake Lights
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.
Sep 5, 2024
Chrysler (FCA US, LLC) is recalling certain 2020-2024 Jeep Gladiator and 2018-2024 Jeep Wrangler vehicles. The instrument panel cluster may experience an internal short circuit and fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Controls and Displays."
Consequence & remedy
Consequence: An instrument panel that fails to display critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Remedy: Dealers will replace the instrument panel cluster, free of charge. Owner notification letters were mailed between October 3, 2024, and January 23, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is 30B.
Mar 14, 2024
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2023-2024 Ram 1500, Jeep Wrangler, Jeep Wagoneer, Jeep Grand Wagoneer, Chrysler Pacifica, Ram 3500, Ram 3500 cab chassis, Ram 2500, Ram 4500 cab chassis, Ram 5500 cab chassis, 2023 Jeep Gladiator, Jeep Grand Cherokee, Jeep Grand Cherokee L, Ram 3500 Cab Chassis with a GVWR less than 10,000 lbs., and Chrysler Voyager vehicles. The steering column control module may not be welded properly, which can prevent the driver's air bag from deploying in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An air bag that does not deploy in a crash can increase the risk of injury.
Remedy: Dealers will inspect and replace the steering column control module, as necessary free of charge. Some owner notification letters were mailed April 11, 2024 through June 20, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 14B, 33B, 34B, 35B, 36B.
Additional source detail variants (2)
Air Bags:frontal:driver Clockspring/spiral Cassette
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2023-2024 Ram 1500, Jeep Wrangler, Jeep Wagoneer, Jeep Grand Wagoneer, Chrysler Pacifica, Ram 3500, Ram 3500 cab chassis, Ram 2500, Ram 4500 cab chassis, Ram 5500 cab chassis, 2023 Jeep Gladiator, Jeep Grand Cherokee, Jeep Grand Cherokee L, Ram 3500 Cab Chassis with a GVWR less than 10,000 lbs., and Chrysler Voyager vehicles. The steering column control module may not be welded properly, which can prevent the driver's air bag from deploying in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An air bag that does not deploy in a crash can increase the risk of injury.
Remedy: Dealers will inspect and replace the steering column control module, as necessary free of charge. Some owner notification letters were mailed April 11, 2024 through June 20, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 14B, 33B, 34B, 35B, 36B.
Steering:column
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2023-2024 Ram 1500, Jeep Wrangler, Jeep Wagoneer, Jeep Grand Wagoneer, Chrysler Pacifica, Ram 3500, Ram 3500 cab chassis, Ram 2500, Ram 4500 cab chassis, Ram 5500 cab chassis, 2023 Jeep Gladiator, Jeep Grand Cherokee, Jeep Grand Cherokee L, Ram 3500 Cab Chassis with a GVWR less than 10,000 lbs., and Chrysler Voyager vehicles. The steering column control module may not be welded properly, which can prevent the driver's air bag from deploying in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An air bag that does not deploy in a crash can increase the risk of injury.
Remedy: Dealers will inspect and replace the steering column control module, as necessary free of charge. Some owner notification letters were mailed April 11, 2024 through June 20, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 14B, 33B, 34B, 35B, 36B.
Feb 15, 2024
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Jeep Wrangler and 2022-2024 Jeep Grand Cherokee vehicles. A hybrid control processor (HCP) software error may cause the defrosting and defogging system to be inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence & remedy
Consequence: An inoperative windshield defrosting and defogging system may decrease the driver's visibility, increasing the risk of a crash.
Remedy: Dealers will update the HCP software, free of charge. Owner notification letters were mailed February 29, 2024. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 04B.
Nov 22, 2023
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler Plug-In Hybrid Electric (PHEV) vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.
Consequence & remedy
Consequence: A vehicle fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack software and replace the battery pack assembly if necessary, free of charge. Owner notification letters were mailed March 7, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 89A. This recall is superseded by NHTSA Recall 24V-720.
Sep 18, 2023
Chrysler (FCA US), LLC is recalling certain 2022-2023 Jeep Wrangler and Gladiator vehicles equipped with a manual transmission. The rearview camera may fail to display the rearview image and the reverse lights may not illuminate when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A disabled rearview image can decrease the driver's visibility of the rear view, and disabled reverse lights may not alert others that the vehicle is reversing, increasing the risk of injury or crash.
Remedy: Dealers will replace the gear position sensor, free of charge. Owner notification letters were mailed November 16, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 92A.
Aug 10, 2023
Chrysler (FCA US, LLC) is recalling certain 2023 Jeep Wrangler vehicles. The spare tire may obstruct the view of the center high-mount brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A brake light that is obstructed may not be visible to other drivers to indicate the intention to slow or stop, increasing the risk of a crash.
Remedy: Dealers will replace the spare tire carrier assembly, free of charge. Owner notification letters were mailed September 28, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 84A.
Apr 27, 2023
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Jeep Wrangler Plug-In Hybrid Electric vehicles (PHEV). The high voltage (HV) battery pack assembly was built with incorrect fasteners to secure the 200-amp fuse, which can generate excessive heat.
Consequence & remedy
Consequence: Excessive heat may cause the fuse to fail and result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the HV battery fuse, as necessary. Dealers will also inspect the battery assembly for damage and replace it, if necessary. Repairs will be performed free of charge. Owner notification letters were mailed May 23, 2023. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 53A. This recall is an expansion of previous recall 22V-768.
Apr 13, 2023
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler, Gladiator, and 2022-2023 Ram 1500 vehicles equipped with a 3.0L diesel engine. The high pressure fuel pump (HPFP) may fail.
Consequence & remedy
Consequence: Fuel pump failure can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the HPFP and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 01A.
Feb 23, 2023
Chrysler (FCA US, LLC) is recalling certain 2018-2023 Jeep Wrangler, and 2020-2023 Jeep Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.
Consequence & remedy
Consequence: Overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.
Remedy: Dealers will replace the clutch assembly and update the software, free of charge. Owner notification letters were mailed from November 16, 2023 through July 25, 2024. Owners may contact (FCA US, LLC) customer service at 1-800-853-1403. FCA US LLC's number for this recall is 19A. This recall expands and replaces previous recall 21V-028. Vehicles previously repaired under recall 21V-028 will need to have the new remedy completed.
Nov 23, 2022
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler 4xe vehicles equipped with 2.0L Plug-In Hybrid Electric Vehicle engines. A loss of communication may cause an engine shutdown.
Consequence & remedy
Consequence: An engine shutdown can cause a loss of drive power, increasing the risk of a crash.
Remedy: There is more than one involved component and calibration software. Updating the calibration software in the Transmission Control Module, Hybrid Control Processor and Auxiliary Hybrid Control Processor that changes fail safe from shut down to limp home. Dealers will update the transmission control module software, Hybrid Control Processor and Auxiliary Hybrid Control Processor, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall ZB7.
Oct 13, 2022
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Jeep Wrangler Plug-In Hybrid Electric (PHEV) vehicles. The high voltage (HV) battery pack assembly was built with incorrect fasteners to secure the 200-amp fuse, which can generate excessive heat.
Consequence & remedy
Consequence: Excessive heat may cause the fuse to fail and result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the HV battery fuse, as necessary. Dealers will also inspect the battery assembly for damage and replace it, if necessary. Repairs will be performed free of charge. Owner notification letters were mailed December 8, 2022. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z71.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24024 · Underhood Fires
Opened Sep 6, 2024 · No close date supplied
Status: open (inferred from source dates) · Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) has received 9 Vehicle Owner's Questionnaire (VOQ) reports, 1 Death and Injury report, and multiple field reports alleging incidents of engine compartment fires in model year (MY) 2021-2023 Jeep Wrangler and Gladiator vehicles. The majority of the reports describe a fire occurring while the ignition in the vehicle was in an ‘OFF’ state with a suspected origin at the passenger front side of the engine compartment. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. ODI has contacted the vehicle manufacturer, Fiat Chrysler Automobiles (FCA), and learned of several thermal events originating at the power steering pump electrical connector in recent model year Jeep Wrangler and Gladiator vehicles. The location of the pump connector is located at the passenger front side of the engine compartment, coinciding with the majority of fire reports known to ODI. ODI is opening this Preliminary Evaluation (PE) to assess the cause, scope, and frequency of the alleged defect. To review the ODI reports cited in the Opening Resume ODI Report Identification Numbers document, go to NHTSA.gov.
RQ24012 · Loss Of Motive Power
Opened Jul 5, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System; Engine
The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures and failures in vehicles not included within the scope of 22V-865. An analysis comparing complaints received before the issuance of recall 22V-865 and complaints outside the scope of the recall has been conducted. The results show the current complaint rate is higher in the out of scope vehicles than it was for vehicles that were later covered by the recall. ODI is opening this Recall Query (RQ) to assess the severity of the alleged defect in vehicles not included in recall 22V-865.ODI will also assess the scope and remedy effectiveness of the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical System
The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures and failures in vehicles not included within the scope of 22V-865. An analysis comparing complaints received before the issuance of recall 22V-865 and complaints outside the scope of the recall has been conducted. The results show the current complaint rate is higher in the out of scope vehicles than it was for vehicles that were later covered by the recall. ODI is opening this Recall Query (RQ) to assess the severity of the alleged defect in vehicles not included in recall 22V-865.ODI will also assess the scope and remedy effectiveness of the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures and failures in vehicles not included within the scope of 22V-865. An analysis comparing complaints received before the issuance of recall 22V-865 and complaints outside the scope of the recall has been conducted. The results show the current complaint rate is higher in the out of scope vehicles than it was for vehicles that were later covered by the recall. ODI is opening this Recall Query (RQ) to assess the severity of the alleged defect in vehicles not included in recall 22V-865.ODI will also assess the scope and remedy effectiveness of the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration