NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
56 reportsClear category filterMileage unknown · Mar 12, 2024
SteeringSuspension
When driving the vehicle at 60mph or faster, the steering wheel will begin to shake uncontrollably and continue to rattle for approximately 30 seconds until the vehicle is reduced speed to about 40mph or less. If I resume speed again, the shaking vibrations will continue to happen repeatedly. This puts my safety at risk when …
Read full complaint
When driving the vehicle at 60mph or faster, the steering wheel will begin to shake uncontrollably and continue to rattle for approximately 30 seconds until the vehicle is reduced speed to about 40mph or less. If I resume speed again, the shaking vibrations will continue to happen repeatedly. This puts my safety at risk when I attempt to drive on the freeway and approach the speed limit and causes me to reduce my speed to an unsafe speed far lower than the flow of traffic on the freeway. In addition, while the vehicle is vibrating/shaking, there is a lack of control of the vehicle and puts the driver in a panic state, because it feels like a flat/blown tire at such a high speed. The vehicle was taken into the dealership and they would not check the problem until I paid for an alignment maintenance fee of over $300. Therefore, I proceeded with the costs and they discovered some parts that need to be replaced by the factory. In spite of this, the dealership is holding me responsible for the process of elimination charges because the extended warranty XF1 and recall V41 are not attached to my VIN on this vehicle. However, these recalls are attached to vehicles made on or before November 2020 and my vehicle was built November 2022. I am aware of this issue, because my prior jeep wrangler vehicle was a 2019 and I experienced the same safety issues, and I brought it in and found out about the recall issued and it was repaired for my safety. However, the same safety issues are occurring in my 2023 jeep wrangler with only 25,000 miles on it, but no recalls are attached to my VIN to assist with the problem. Each time the vehicle malfunctions there is no warning lamps, no messages or any other symptoms of the problem prior to failure. The incident first started to appear around 2/2/2024 & continued to happen more frequently with time. I scheduled the repair at the jeep dealership on 2/27/2024 and they currently still have my vehicle for this malfunction.
NHTSA ODI #11576878
Mileage unknown · Mar 4, 2024
Steering
steering wobble, dealer gives us the run around, finally gives us 18 weeks lead time for new steering vibration dampener, car shakes on highways and is not save to drive, dealing with Jeep is unacceptable
NHTSA ODI #11575280
Mileage unknown · Feb 14, 2024
SteeringSuspension
My 2023 Jeep Wrangler is experiencing the "Death Wobble" while driving down the highway or on uneven paved roads. During the "Death Wobble", the steering wheel starts shaking uncontrollably. I have to decelerated to regained control of the vehicle, at which point the shaking of the steering wheel stops. This has become a persist…
Read full complaint
My 2023 Jeep Wrangler is experiencing the "Death Wobble" while driving down the highway or on uneven paved roads. During the "Death Wobble", the steering wheel starts shaking uncontrollably. I have to decelerated to regained control of the vehicle, at which point the shaking of the steering wheel stops. This has become a persistent failure. The vehicle was taken to the dealer where it was diagnosed as having defective tires from Bridgestone. The dealership is requesting the consumer buy new tires to remediated the death wobble and defective tires from Bridgestone.
NHTSA ODI #11572010
Mileage unknown · Jan 12, 2024
SteeringWheels
Experiencing the "Death Wobble" when driving on uneven paved roads/bumps/railroad tracks at speeds as low at 40 miles per hour.
NHTSA ODI #11565039
Mileage unknown · Jan 5, 2024
Steering
Since new in December 2023 this vehicle has excessive wander while driving straight. This requires constant correction of the steering wheel just to go straight. Anything less than 100% attention can result in loss of control. The wander is related to excessive free play of the steering wheel which allows approximately 2” in …
Read full complaint
Since new in December 2023 this vehicle has excessive wander while driving straight. This requires constant correction of the steering wheel just to go straight. Anything less than 100% attention can result in loss of control. The wander is related to excessive free play of the steering wheel which allows approximately 2” in each direction from center before the tires move. Three visits to two Jeep dealers resulted in “functioning normally” diagnosis summaries. This is a safety issue in my opinion and Jeep at least needs a documented procedure for dealerships to measure the steering free play.
NHTSA ODI #11563867
Mileage unknown · Dec 27, 2023
SteeringSuspensionWheels
Violent shaking of the front end (wheels/tires and steering wheel) after hitting a bump in the road. The “death wobble” occurred twice since I bought the vehicle new from a dealership about a year ago. The miles are low (2,000) as the Jeep is my extra vehicle, and no modifications have been done. The first time it happened I …
Read full complaint
Violent shaking of the front end (wheels/tires and steering wheel) after hitting a bump in the road. The “death wobble” occurred twice since I bought the vehicle new from a dealership about a year ago. The miles are low (2,000) as the Jeep is my extra vehicle, and no modifications have been done. The first time it happened I was going about 55 mph, and the second time about 65 mph. After the second incident I reviewed the internet and saw the death wobble class action suit that does not cover post-2020 Wranglers. Both incidents occurred during the day on dry and well maintained roads. I made a dealership appointment after the second occurrence, but can’t get in until 1/9/2024. Loss of steering/control in traffic makes this a serious issue.
NHTSA ODI #11562038
Mileage unknown · Dec 22, 2023
SteeringStructureUnknown Or Other
Going over a bump at 45 mph or greater results in the death wobble. Will not stop shaking until the vehicle slows down.
NHTSA ODI #11561577
Mileage unknown · Dec 19, 2023
SteeringSuspensionUnknown Or Other
Our jeep is a leased vehicle with approx 5,200 miles. While riding on the highway going approx 65 mph the vehicle began to death wobble causing the driver to nearly lose control of the car. We were on a 4 lane interstate that could have resulted in a severe accident had the driver actually lost control. With so few miles on the …
Read full complaint
Our jeep is a leased vehicle with approx 5,200 miles. While riding on the highway going approx 65 mph the vehicle began to death wobble causing the driver to nearly lose control of the car. We were on a 4 lane interstate that could have resulted in a severe accident had the driver actually lost control. With so few miles on the vehicle there is no reason other than a manufacturing defect that would explain how this vehicle could already be experiencing death wobble, a known issue with jeeps
NHTSA ODI #11560841
Mileage unknown · Dec 6, 2023
EngineSteering
When vehicle is in drive gear, the steering system has a high pitch squeal. It gets louder when the steering wheel is turned. It makes the squealing noise when the tires are straight, when turned a little left or right, and all the way left and right. No warning lights are on or have ever turned on. The engine area also makes …
Read full complaint
When vehicle is in drive gear, the steering system has a high pitch squeal. It gets louder when the steering wheel is turned. It makes the squealing noise when the tires are straight, when turned a little left or right, and all the way left and right. No warning lights are on or have ever turned on. The engine area also makes a loud tapping noise only when in gear. Loud enough to hear in the cab. I took it to the dealership, after they had it for over 8 hours, I was told all was normal, and even another new model makes the same noises. It must be the new electrical steering system sounds. To have an inspection done, I had to wait 2 weeks for an appointment, after I had asked if it was normal and the service manager heard and confirmed, a service mechanic and the lead mechanic. All came out at a different time said something sounds like it might be off. The steering issue puts me at risk and other drivers, mainly truck drivers because this vehicle is my daily driver,and I put about 40-80 miles daily, at least 3/4 of the time is driving on a major highway. Our highway has had a ton of roadwork recently, which puts workers at risk.
NHTSA ODI #11558690
Mileage unknown · Nov 28, 2023
Power TrainSteeringVehicle Speed Control
As I was driving home at around 45 mph, I noticed a flashing light on the dashboard. The light was instructing me to switch to 'P' to start. Additionally, there was a light indicating a plug-in, and the 'D' was flashing. I wasn't sure what was happening, but I knew something was wrong. Gradually, the acceleration slowed down, an…
Read full complaint
As I was driving home at around 45 mph, I noticed a flashing light on the dashboard. The light was instructing me to switch to 'P' to start. Additionally, there was a light indicating a plug-in, and the 'D' was flashing. I wasn't sure what was happening, but I knew something was wrong. Gradually, the acceleration slowed down, and I started to feel uneasy. I quickly pulled over to the side of the road. Luckily, the car behind me wasn't speeding, and they were able to slow down and give me space. I put the car in park, turned it off, and then turned it on again. After doing so, I waited for a few seconds, hoping that the problem would be resolved. To my relief, the flashing lights disappeared, and the car started normally. I checked the dashboard again, and everything seemed to be in order. I resumed driving but couldn't shake off the feeling of unease. Now, driving on the highway in Orlando worries me.
NHTSA ODI #11557154
Official recalls
14Jun 4, 2026
Chrysler (FCA US, LLC) is recalling certain 2021-2025 Jeep Wrangler, Wrangler 4XE, and Jeep Gladiator vehicles. The electric hydraulic power steering pump wiring may overheat and cause a vehicle fire, even when the vehicle is parked with the ignition in the "Off" position.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures, until their vehicle is repaired. Dealers will inspect and replace the wiring and electric hydraulic power steering pump, as necessary, free of charge. Owner notification letters are expected to be mailed July 9, 2026. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 21D. The Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on June 11, 2026.
Oct 30, 2025
Chrysler (FCA US, LLC) is recalling certain 2020-2025 Jeep Wrangler 4Xe and 2022-2026 Grand Cherokee 4Xe vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.
Consequence & remedy
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures and not to charge their vehicles until the remedy is completed. Dealers will update the high voltage battery software, and replace the high voltage battery, as necessary, free of charge. Some owner notification letters were mailed beginning December 17, 2025. The remaining owner notification letters will be mailed at a later date. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 68C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 6, 2025. Vehicles that were previously recalled for the same issue under NHTSA Recalls 24V720 and 23V787 will need to have the new remedy performed.
Sep 12, 2024
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.
Exterior Lighting:brake Lights
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.
Sep 5, 2024
Chrysler (FCA US, LLC) is recalling certain 2020-2024 Jeep Gladiator and 2018-2024 Jeep Wrangler vehicles. The instrument panel cluster may experience an internal short circuit and fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Controls and Displays."
Consequence & remedy
Consequence: An instrument panel that fails to display critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Remedy: Dealers will replace the instrument panel cluster, free of charge. Owner notification letters were mailed between October 3, 2024, and January 23, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is 30B.
Mar 14, 2024
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2023-2024 Ram 1500, Jeep Wrangler, Jeep Wagoneer, Jeep Grand Wagoneer, Chrysler Pacifica, Ram 3500, Ram 3500 cab chassis, Ram 2500, Ram 4500 cab chassis, Ram 5500 cab chassis, 2023 Jeep Gladiator, Jeep Grand Cherokee, Jeep Grand Cherokee L, Ram 3500 Cab Chassis with a GVWR less than 10,000 lbs., and Chrysler Voyager vehicles. The steering column control module may not be welded properly, which can prevent the driver's air bag from deploying in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An air bag that does not deploy in a crash can increase the risk of injury.
Remedy: Dealers will inspect and replace the steering column control module, as necessary free of charge. Some owner notification letters were mailed April 11, 2024 through June 20, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 14B, 33B, 34B, 35B, 36B.
Additional source detail variants (2)
Air Bags:frontal:driver Clockspring/spiral Cassette
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2023-2024 Ram 1500, Jeep Wrangler, Jeep Wagoneer, Jeep Grand Wagoneer, Chrysler Pacifica, Ram 3500, Ram 3500 cab chassis, Ram 2500, Ram 4500 cab chassis, Ram 5500 cab chassis, 2023 Jeep Gladiator, Jeep Grand Cherokee, Jeep Grand Cherokee L, Ram 3500 Cab Chassis with a GVWR less than 10,000 lbs., and Chrysler Voyager vehicles. The steering column control module may not be welded properly, which can prevent the driver's air bag from deploying in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An air bag that does not deploy in a crash can increase the risk of injury.
Remedy: Dealers will inspect and replace the steering column control module, as necessary free of charge. Some owner notification letters were mailed April 11, 2024 through June 20, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 14B, 33B, 34B, 35B, 36B.
Steering:column
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2023-2024 Ram 1500, Jeep Wrangler, Jeep Wagoneer, Jeep Grand Wagoneer, Chrysler Pacifica, Ram 3500, Ram 3500 cab chassis, Ram 2500, Ram 4500 cab chassis, Ram 5500 cab chassis, 2023 Jeep Gladiator, Jeep Grand Cherokee, Jeep Grand Cherokee L, Ram 3500 Cab Chassis with a GVWR less than 10,000 lbs., and Chrysler Voyager vehicles. The steering column control module may not be welded properly, which can prevent the driver's air bag from deploying in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An air bag that does not deploy in a crash can increase the risk of injury.
Remedy: Dealers will inspect and replace the steering column control module, as necessary free of charge. Some owner notification letters were mailed April 11, 2024 through June 20, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 14B, 33B, 34B, 35B, 36B.
Feb 15, 2024
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Jeep Wrangler and 2022-2024 Jeep Grand Cherokee vehicles. A hybrid control processor (HCP) software error may cause the defrosting and defogging system to be inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence & remedy
Consequence: An inoperative windshield defrosting and defogging system may decrease the driver's visibility, increasing the risk of a crash.
Remedy: Dealers will update the HCP software, free of charge. Owner notification letters were mailed February 29, 2024. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 04B.
Nov 22, 2023
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler Plug-In Hybrid Electric (PHEV) vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.
Consequence & remedy
Consequence: A vehicle fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack software and replace the battery pack assembly if necessary, free of charge. Owner notification letters were mailed March 7, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 89A. This recall is superseded by NHTSA Recall 24V-720.
Sep 18, 2023
Chrysler (FCA US), LLC is recalling certain 2022-2023 Jeep Wrangler and Gladiator vehicles equipped with a manual transmission. The rearview camera may fail to display the rearview image and the reverse lights may not illuminate when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A disabled rearview image can decrease the driver's visibility of the rear view, and disabled reverse lights may not alert others that the vehicle is reversing, increasing the risk of injury or crash.
Remedy: Dealers will replace the gear position sensor, free of charge. Owner notification letters were mailed November 16, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 92A.
Aug 10, 2023
Chrysler (FCA US, LLC) is recalling certain 2023 Jeep Wrangler vehicles. The spare tire may obstruct the view of the center high-mount brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A brake light that is obstructed may not be visible to other drivers to indicate the intention to slow or stop, increasing the risk of a crash.
Remedy: Dealers will replace the spare tire carrier assembly, free of charge. Owner notification letters were mailed September 28, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 84A.
Apr 27, 2023
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Jeep Wrangler Plug-In Hybrid Electric vehicles (PHEV). The high voltage (HV) battery pack assembly was built with incorrect fasteners to secure the 200-amp fuse, which can generate excessive heat.
Consequence & remedy
Consequence: Excessive heat may cause the fuse to fail and result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the HV battery fuse, as necessary. Dealers will also inspect the battery assembly for damage and replace it, if necessary. Repairs will be performed free of charge. Owner notification letters were mailed May 23, 2023. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 53A. This recall is an expansion of previous recall 22V-768.
Apr 13, 2023
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler, Gladiator, and 2022-2023 Ram 1500 vehicles equipped with a 3.0L diesel engine. The high pressure fuel pump (HPFP) may fail.
Consequence & remedy
Consequence: Fuel pump failure can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the HPFP and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 01A.
Feb 23, 2023
Chrysler (FCA US, LLC) is recalling certain 2018-2023 Jeep Wrangler, and 2020-2023 Jeep Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.
Consequence & remedy
Consequence: Overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.
Remedy: Dealers will replace the clutch assembly and update the software, free of charge. Owner notification letters were mailed from November 16, 2023 through July 25, 2024. Owners may contact (FCA US, LLC) customer service at 1-800-853-1403. FCA US LLC's number for this recall is 19A. This recall expands and replaces previous recall 21V-028. Vehicles previously repaired under recall 21V-028 will need to have the new remedy completed.
Nov 23, 2022
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler 4xe vehicles equipped with 2.0L Plug-In Hybrid Electric Vehicle engines. A loss of communication may cause an engine shutdown.
Consequence & remedy
Consequence: An engine shutdown can cause a loss of drive power, increasing the risk of a crash.
Remedy: There is more than one involved component and calibration software. Updating the calibration software in the Transmission Control Module, Hybrid Control Processor and Auxiliary Hybrid Control Processor that changes fail safe from shut down to limp home. Dealers will update the transmission control module software, Hybrid Control Processor and Auxiliary Hybrid Control Processor, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall ZB7.
Oct 13, 2022
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Jeep Wrangler Plug-In Hybrid Electric (PHEV) vehicles. The high voltage (HV) battery pack assembly was built with incorrect fasteners to secure the 200-amp fuse, which can generate excessive heat.
Consequence & remedy
Consequence: Excessive heat may cause the fuse to fail and result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the HV battery fuse, as necessary. Dealers will also inspect the battery assembly for damage and replace it, if necessary. Repairs will be performed free of charge. Owner notification letters were mailed December 8, 2022. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z71.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24024 · Underhood Fires
Opened Sep 6, 2024 · No close date supplied
Status: open (inferred from source dates) · Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) has received 9 Vehicle Owner's Questionnaire (VOQ) reports, 1 Death and Injury report, and multiple field reports alleging incidents of engine compartment fires in model year (MY) 2021-2023 Jeep Wrangler and Gladiator vehicles. The majority of the reports describe a fire occurring while the ignition in the vehicle was in an ‘OFF’ state with a suspected origin at the passenger front side of the engine compartment. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. ODI has contacted the vehicle manufacturer, Fiat Chrysler Automobiles (FCA), and learned of several thermal events originating at the power steering pump electrical connector in recent model year Jeep Wrangler and Gladiator vehicles. The location of the pump connector is located at the passenger front side of the engine compartment, coinciding with the majority of fire reports known to ODI. ODI is opening this Preliminary Evaluation (PE) to assess the cause, scope, and frequency of the alleged defect. To review the ODI reports cited in the Opening Resume ODI Report Identification Numbers document, go to NHTSA.gov.
RQ24012 · Loss Of Motive Power
Opened Jul 5, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System; Engine
The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures and failures in vehicles not included within the scope of 22V-865. An analysis comparing complaints received before the issuance of recall 22V-865 and complaints outside the scope of the recall has been conducted. The results show the current complaint rate is higher in the out of scope vehicles than it was for vehicles that were later covered by the recall. ODI is opening this Recall Query (RQ) to assess the severity of the alleged defect in vehicles not included in recall 22V-865.ODI will also assess the scope and remedy effectiveness of the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical System
The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures and failures in vehicles not included within the scope of 22V-865. An analysis comparing complaints received before the issuance of recall 22V-865 and complaints outside the scope of the recall has been conducted. The results show the current complaint rate is higher in the out of scope vehicles than it was for vehicles that were later covered by the recall. ODI is opening this Recall Query (RQ) to assess the severity of the alleged defect in vehicles not included in recall 22V-865.ODI will also assess the scope and remedy effectiveness of the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures and failures in vehicles not included within the scope of 22V-865. An analysis comparing complaints received before the issuance of recall 22V-865 and complaints outside the scope of the recall has been conducted. The results show the current complaint rate is higher in the out of scope vehicles than it was for vehicles that were later covered by the recall. ODI is opening this Recall Query (RQ) to assess the severity of the alleged defect in vehicles not included in recall 22V-865.ODI will also assess the scope and remedy effectiveness of the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration