2023 Jeep Wrangler

After the 68c recall the power of the electric drive is limited. Frequent power loss occurs on highway driving during acceleration (merging onto highway or passing other cars). Despite the battery being charged up to 50% there is only 25% power available. The car is a plug in hybrid vehicle. The internal combustion engine starts in these cases with several seconds delay. During that time the car does not accelerate sufficiently to safely merge onto a highway or pass other cars. The power loss happens without warning during critical drive situations like merging onto a highway or passing other cars. The driver expects a continuous level of power by the car, not a sudden power loss. This is reported by countless other drivers on all social media platforms as a consequence of the 68C recall that affects 350 000 Jeep Wrangler 4xe and Grand Cherokee 4xe. Jeep does not respond to customer complaints or requests for clarification.

I own a 2023 Jeep Wrangler 4-Door Sahara 4xe (VIN [XXX], plug-in hybrid). Since new, this vehicle has had repeated electrical and high-voltage (HV) hybrid battery system failures. About eight months after purchase, at approximately 6,590 miles, the vehicle lost power and would not restart in a parking lot ("Service Charging System" warning) and had to be towed to the dealer (Repair Order #[XXX], 10/18/2023–10/20/2023); a 12V battery failure was diagnosed. On February 9–10, 2026, the dealer performed Recall Campaign 68C (JL/WL PHEV HV Battery) on this vehicle — a software/module update to the BPCM, HCP, AHCP, PCM, TCM, and IDCM, plus an HV battery diagnostic analysis (Repair Order #[XXX]). On [XXX], at approximately 22,692 miles, the check engine light illuminated and the dealer diagnosed a hybrid (HV) battery failure. The manufacturer (Stellantis/FCA US LLC) subsequently opened a warranty case (#[XXX]) and a lemon-law repurchase case (#[XXX]), confirming the vehicle could not be repaired and offering repurchase or $15,000 cash compensation. As of this filing, the vehicle remains at the dealership, out of service, well past the dealer's own promised repair completion date. Across its ownership, this vehicle has been out of service for HV-battery- and electrical-system-related repairs for a documented cumulative total of approximately 50 days. I am filing this report because a vehicle losing propulsion/electrical power unexpectedly, and a manufacturer needing to run an HV battery software recall campaign on this same vehicle only six months before a full HV battery failure, both raise safety concerns beyond an ordinary warranty repair, and I want this pattern on record in case other owners of this model are experiencing the same failures. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving, my 2023 Jeep Wrangler 4xe suddenly loses drive power without warning. The car is a plug in hybrid vehicle. The vehicle routinely displays 'Electric Temporarily Unavailable'. When it happens, I press the accelerator and the vehicle does not respond; there is a delay of several seconds with little or no power before the gas engine engages. This is a serious safety hazard — the loss of power is sudden and unpredictable, and the delay leaves me unable to accelerate when merging or pulling into traffic. The condition is reproducible and began after the 68C recall software update. The driver expects a continuous level of power by the car, not a sudden power loss. This is reported by countless other drivers on all social media platforms as a consequence of the 68C recall that affects 350,000 Jeep Wrangler 4xe and Grand Cherokee 4xe. I have taken the vehicle to the dealer multiple times; each visit results in 'no codes found' and 'operating as designed,' and it has not been repaired. Jeep does not respond to customer complaints or requests for clarification.

Failed Component: Powertrain (PCM/TCM/HCP software calibration) & Electrical/Steering (Fire Recalls). Safety Risk & Description: Following recent mandatory manufacturer software updates, this vehicle has developed a severe, dangerous drivetrain defect. Under light acceleration from a complete stop, the vehicle exhibits an extreme throttle lag and hard delay before violently surging forward, creating a high risk of intersection collisions. Furthermore, at sustained highway speeds (52–63 MPH), the vehicle abruptly drops out of Electric Mode, causing the gas engine to violently spike to 5,000 RPMs before dropping back. This erratic cycling causes the vehicle to lurch, jerk, and pull, actively disrupting lane control. Compounding this, due to consecutive, unresolved fire safety recalls—including Recall 68C (Battery Fires) and the June 2026 Power Steering Pump wiring fire recall—the vehicle cannot be safely parked inside my garage or near structures while turned off. It represents a total loss of normal use and a severe safety liability. Dealer Confirmation & History: The driving defect was formally duplicated and confirmed by a certified technician on 06/09/2026 at Ryan Auto Mall (Repair Order #471599). The technician explicitly documented the electric mode dropouts and acceleration lag in writing. However, because the vehicle’s software masking prevents standard Diagnostic Trouble Codes (DTCs) from triggering, the dealer closed the ticket stating it is "operating as designed." The vehicle's electrical and hybrid systems have been repeatedly altered via mandatory safety recalls: Recall 23A/04B (05/14/2024), Recall 95B (05/27/2025), and Recall 68C (02/11/2026). No dashboard warning lights are present; the dangerous handling is entirely coded into the manufacturer's latest software updates. Vehicle is intact and available for inspection.

The hybrid propulsion system in my 2023 Jeep Wrangler 4xe intermittently malfunctions while driving. The “D” (Drive) indicator on the gear selector begins flashing, and the engine RPMs suddenly decrease without warning. During these events, the vehicle loses propulsion power and responsiveness. After several seconds, the vehicle may return to normal operation. This failure affects the hybrid powertrain and transmission system. The vehicle is available for inspection upon request. This condition creates a serious safety risk because the sudden loss of propulsion reduces the vehicle’s ability to accelerate or maintain speed in traffic. This is especially dangerous when merging, crossing intersections, or driving at highway speeds, as it increases the risk of collision due to loss of power and reduced vehicle control. The vehicle has been evaluated by a Jeep dealership service department. The dealership has not provided a permanent repair, and the manufacturer recall affecting the hybrid system remains open and unresolved. The recall repair has not been performed, and the hybrid malfunction continues to occur. The vehicle has been inspected by dealership personnel, but the issue remains unresolved. The dealership indicated that replacing the 12-volt battery may help, but no definitive root cause has been identified, and the hybrid system malfunction continues. There were no battery warning lights prior to or during the failure. The primary symptom is the flashing “D” indicator and sudden decrease in RPMs, followed by temporary recovery. This indicates a malfunction of the hybrid propulsion system. This unresolved hybrid system failure presents an ongoing safety hazard and loss of propulsion while driving.

The contact owns a 2023 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 25V741000 (Electrical System). The contact stated that recently the vehicle started hesitating while driving at various speeds while depressing the accelerator pedal. The contact stated that the check engine warning light was illuminated. The contact noticed that white smoke was coming from the exhaust pipe. Additionally, the contact stated that after shifting into reverse(R), the indicator on the instrument cluster and the console started to flash, and the vehicle failed to reverse as intended. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 25V741000 (Electrical System). The manufacturer was not informed of the failure. The failure mileage was approximately 56,000.