2005 Jeep Wrangler

THE PCM HAS A KNOWN HIGH FAILURE RATE DUE TO THE VIBRATION. THE COMPONENTS ARE COVERED IN A RESIN THAT YOU CAN NOT REMOVE. THE PCM IS 500-1300 TO GET A REPAIRED AND REPROGRAMED ONE. I HAVE A 2005 AND THE PCM HAS FAILED AND GIVES BAD PERFORMANCE AND DOES NOT RUN ON TEH 14.7 STOKES FOR AIR/FUEL/ IT DUMPS FUELS AND I DO NOT THINK IT MEETS EMISSON LEVELS IN THIS CONDITION.

: I AM THE OWNER OF A 2005 JEEP WRANGLER. FOR THE LAST 10+ YEARS MY ACCELERATOR HAS STUCK AT FULL THROTTLE 5-7 TIMES. EVERY TIME I HAVE TAKEN IT TO A SHOP - THEY HAVE TEST DRIVEN IT BUT NO STICKING. LAST WEDNESDAY (5/22) AT A 4 WAY STOP SIGN MY ACCELERATOR STUCK AGAIN AT FULL THROTTLE & I HIT A CAR. NO ONE WAS HURT, BUT I WAS GIVEN A CITATION WITH WITNESSES TO THE ACCELERATOR BEING STUCK. THE MAN AT THE SHOP TOLD ME HIS JEEP WRANGLER HAD A RECALL FOR THE SAME ISSUE. I CONTACTED JEEP CORPORATION & FILED A REPORT (CASE [XXX]) WITH A WORKER "ALY". SHE TOLD ME TO PARK MY JEEP AND AN INSPECTOR WOULD BE THERE TO INVESTIGATE. THAT WAS MORE THAN A WEEK AGO & 5 CALLS TO 1-877-426-5337. CAN YOU HELP ME? MY INSURANCE CO. WANTS ME TO GET ESTIMATES FOR MY DAMAGE BUT I DON'T KNOW IF I CAN DRIVE ON THE ROAD DUE TO THE ACCELERATOR STICKING & NOT BEING INSPECTED BY JEEP RECALL INSPECTORS. PLEASE HELP ME...'. (XXXX) PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

THE VEHICLE WAS IN MOTION AND PULLING FROM MY DRIVEWAY ONTO A CITY STREET WHEN THIS HAPPENED. BOTH DRIVERS AND PASSENGER CENTER SECTIONS OF THE FRAME RUSTED FROM THE INSIDE OUT WITH NO VISIBLE INDICATION ON THE OUTSIDE OF THE FRAME RAILS. WATER AND DEBRIS ENTER THROUGH HOLES USED IN THE MANUFACTURING PROCESS AND DUE TO NO DRAIN HOLES IN ANY OF THE LOWER POINTS THE WATER AND DEBRIS ROT THE FRAME AWAY. IN MY CASE THE TRANSMISSION PAN ON THE DRIVERS SIDE OF THE VEHICLE FELL FREE WHEN THE BOTTOM OF THE FRAME RAIL ON THAT SIDE CRUMBLED WHILE ENTERING A CITY ROAD FROM A PRIVATE DRIVE AT LESS THAN 5 MPH. DAMAGE WAS DONE TO THE TRANSMISSION, TRANSFER CASE, ONE AXLE, AND THE REAR DRIVE SHAFT. THE VEHICLE WAS TOWED TO A PRIVATE GARAGE BUT THEY WERE UNABLE TO PLACE IT ON A LIFT TO INSPECT THE DAMAGE AS THE FRAME WOULD HAVE CRUMBLED AND SNAPPED IN ADDITIONAL PLACES THUS CREATING A HAZARD AND POSSIBLY DEADLY SITUATION THE TECHNICIAN INSPECTING THE DAMAGE. THE VEHICLE WAS THEN PLACED ON A FLATBED AND BROUGHT BACK TO MY HOME.

TAKATA RECALL, OIL PUMP DRIVE GEAR, PCM POWERTERRAIN CONTROL MODULE I BELIEVE NEEDS TO BE REPROGRAMMED I HAVE A FAILURE OF POWER WHILE DRIVING DOWN THE ROAD LIKE ITS GETTING TO MUCH OR TO LITTLE FUEL AND LAST WEEK MY OIL PRESSURE WILL NOT BUDGE MY GAUGES ARE SLOWLY GOING OUT ON MY DASH AND THE AIRBAG LIGHT ON DASH BLINKS RAPIDLY WITH THE CHECK GAUGES BECAUSE OF MY OLD PRESSURE I HAVE TAKEN IT TO MULTIPLE PLACES TO GET IT DIAGNOSED AND THEY SAY IT IS THE OIL PUMP DRIVE GEAR AND THE PCM NEEDING TO BE REPROGRAMMED ALONG WITH THAT BEING OUT OF LINE MY GROUND CONNECTIONS SEEM TO BE BAD BUT I REPLACE ALL OF THEM FROM THE BATTERY TO THE ENGINE BLOCK THE DASH AND A COUPLE MORE IT HAS PRESSURE BUT DOESN'T SOUND LIKE IT. ALL OF THIS STARTED HAPPENING AT ABOUT 143,000 MILES I HAVE REPLACED MULTIPLE PARTS INCLUDING THE OIL PUMP OIL SENSOR ALL OF THE GROUND WIRES AND TERMINALS AND CHECKED AS MANY RELAYS AS I CAN. ALONG WITH MY DASH WHEN I HAD GOT IT IT HAD 130,000 MILES ON AND THE AIRBAG LIGHT HAS ALWAYS BLINKED AND NOTICED A LOSS IN POWER WHEN I DRIVE SINCE I'VE HAD IT, IT RUNS THROUGH SPARK PLUGS AND COILS PACKS MONTHLY AND HAS SINCE I'VE GOTTEN IT I DROVE IT TO GEORGIA AND BACK AND IT SOUNDED LIKE IT WAS GETTING WORSE AND JUST KEPT GETTING WORSE AND WORSE UNTIL LAST WEEK MY OIL PRESSURE GAUGE SAYS I HAVE NO PRESSURE AND THE ENGINE HAS OIL PRESSURE BUT YOU CAN TELL IT'S GOING MORE AND MORE OUT OF LINE. I KNOW WHEN I LOOK UP MY VIN NUMBER IT SAYS IT'S BEEN UPDATED SINCE MARCH 14, 2019 BUT WHEN I LOG INTO ANOTHER APP IT SAYS I HAVE RECALLS I DON'T KNOW WHAT TO DO OR HOW TO FIX IT BUT IT DEFINITELY IS THE THREE RECALLS THAT WAS PUT ON THE 2005 JEEP WRANGLER TJ.

I GET A CODE THAT POPS UP AFTER BEING ON THE HIGHWAY FOR A TIME THAT SAYS SOMETHING REGARDING TRANSMISSION. ALSO THE TRANSMISSION IS SLOW TO SHIFT BETWEEN DRIVE AND REVERSE SOMETIMES AND GRINDS (AUTO TRANS). THERE HAVE BEEN MULTIPLE REPORTS OF PCM ISSUES THAT REQUIRE REBUILD OR REPLACEMENT BUT AVAILABILITY IS SCARCE. COULD BE POOR DESIGN.

MY WRANGLER HAS SEVER RUST DAMAGE ON THE FRAME, WINDSHIELD FRAME, PASSENGER ROCKER, AND FIREWALL. THE FRAME HAS ROTTED FROM THE INSIDE OUT AND CAUSED THE TRANSFER CASE MOUNTING BOLTS TO PULL THROUGH. THE VEHICLE WAS IN MOTION WHEN THIS HAPPENED BUT LUCKILY I WAS PULLING OUT OF MY DRIVEWAY AND NOT ON THE HIGHWAY HEADED TO WORK. THE WINDSHIELD FRAME RUST CAUSED HOLES THAT ALLOWED WATER TO LEAK INSIDE THE VEHICLE CAUSING THE FLOOR TO RUST FROM THE INSIDE OUT AS WELL. THESE ISSUES CONTINUE TO HAPPEN AGAIN AND AGAIN WITH EACH NEW REVISION TO THIS MODEL. WHEN AND WHAT WILL IT TAKE FOR THE COMPANY TO BE HELD ACCOUNTABLE TO THEIR NEGLIGENCE?