IllustrationWHILE FILLING THE FUEL TANK FUEL GUSHES OUT OF THE FILLER NECK INSTEAD OF THE NOZZLE SHUTTING OFF. FUEL SPILLS ALL OVER THE SIDE OF THE VEHICLE AND ON THE GROUND. *TR
2005 Jeep Wrangler
Owner reports · Recalls · Investigations
More warning signs than most Wrangler years
Owner complaints for the 2005 Jeep Wrangler are substantially higher than the model-year median of 265.
About this comparison →How this year compares
Owner complaints by model year
Compare all Wrangler years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1010–25K
16425–50K
15650–75K
6775–100K
33100–150K
12150K+
533 reports with mileage · 117 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 346 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports9 fire reports10 injury reports
Fuel System, Gasoline complaints
346 reportsFUEL OVERFLOWS WHEN FILLING AT THE PUMP. I HAVE A 19 GALLON TANK AND AT AROUND 15 GALLONS THE HANDLE RELEASES AND GAS SPEWS ALL OVER THE PLACE. TALKED TO MANASSAS VA JEEP AND THEY SAID THERE WAS NOTHING THEY COULD DO. *TR
FUEL OVERFLOWS AND SPILLS EVERY TIME THE VEHICLE IS REFUELED. PROBLEM HAS BEEN IDENTIFIED AS A BAD CHECK VALVE IN THE GAS TANK WHICH REQUIRES THE GAS TANK TO BE REPLACED. SAME TANK AND JUST A MATTER OF TIME UNTIL IT RECURS. THIS IS A SAFETY HAZARD AND AN ENVIRONMENTAL CONCERN AS APPROXIMATELY 1 CUP OF FUEL IS SPILLED ON THE OPER…
Read full complaint
FUEL OVERFLOWS AND SPILLS EVERY TIME THE VEHICLE IS REFUELED. PROBLEM HAS BEEN IDENTIFIED AS A BAD CHECK VALVE IN THE GAS TANK WHICH REQUIRES THE GAS TANK TO BE REPLACED. SAME TANK AND JUST A MATTER OF TIME UNTIL IT RECURS. THIS IS A SAFETY HAZARD AND AN ENVIRONMENTAL CONCERN AS APPROXIMATELY 1 CUP OF FUEL IS SPILLED ON THE OPERATOR. *TR
EACH TIME I PUT FUEL IN MY 2005 JEEP WRANGLER UNLIMITED FUEL SPLASHES OUT COVERING THE FILLER CAP, THE SIDE OF THE VEHICLE, AND WHATEVER IS NEARBY. I DO NOT "TOP OFF" THE TANK. IT DOES IT ON THE FIRST SHUTOFF CLICK OF THE NOZZLE. *TR
GAS OVERFLOW. *TR
GASOLINE POURS OUT EVERY SINGLE TIME I FULLY FILL IT UP. IT HAPPENS ON EVERY WRANGLER SINCE 2003. *TR
WHEN FUELING MY 2005 JEEP WRANGLER , AND ALLOWING THE FUEL PUMP TO AUTOMATICALLY TURN OFF WHEN THE GAS TANK REACHES THE FULL LEVEL, FUEL WILL OFTEN OVERFLOW OUT OF THE FILL PORT. MY JEEP DEALER SAYS THAT THE FIX IS TO REPLACE THE GAS TANK AND THAT THEY ARE AWARE OF THIS PROBLEM, COST FOR NEW GAS TANK $800.00. *TR
WHEN FUEL TANK IS NEARING THE "FULL" LEVEL THE FUEL TANK SPEWS OUT EXCESS FUEL WHEN FILLING TANK SPRAYING ME IF I AM STANDING ANYWHERE NEAR THE VEHICLE.. THIS HAPPENS ON EVERY FILL UP. I UNDERSTAND THIS IS A WELL DOCUMENTED PROBLEM WITH JEEP VEHICLES. *TR
1- EVERY TIME I FILL UP MY 2005 JEEP WRANGLER UNLIMITED IT OVERFILLS. 2- IT HAPPENS ALL THE TIME! EVERY TIME I FILL UP. IT OVERFILLS. TO THE POINT WHERE I JUST STOP IT WHEN IT REACHES 18 GALLONS. 3- MY JEEP IS OUT OF WARRANTY, MY DEALER WILL NOT CORRECT THE PROBLEM WITH OUT ME PAYING FOR MISTAKE DONE BY CHRYSLER. I REALLY …
Read full complaint
1- EVERY TIME I FILL UP MY 2005 JEEP WRANGLER UNLIMITED IT OVERFILLS. 2- IT HAPPENS ALL THE TIME! EVERY TIME I FILL UP. IT OVERFILLS. TO THE POINT WHERE I JUST STOP IT WHEN IT REACHES 18 GALLONS. 3- MY JEEP IS OUT OF WARRANTY, MY DEALER WILL NOT CORRECT THE PROBLEM WITH OUT ME PAYING FOR MISTAKE DONE BY CHRYSLER. I REALLY QUESTION MY SAFETY. AND THE SAFETY OF MY VEHICLE. *TR
EVERYTIME I FILL UP MY JEEP WITH GAS, NO MATTER AT WHICH STATION, THE TANK OVERFLOWS. THE AUTO SHUT OFF IS NOT RUNNING AND THIS HAS LED TO GAS SPILLING ALL OVER THE SIDE OF MY JEEP AND DISCOLORING THE WHEEL COVER., *TR
Official recalls
105V460000 · Power Train:automatic Transmission
Oct 6, 2005
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Consequence & remedy
Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.