Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 43 of 381 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel/propulsion System. Review the 131 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports4 fire reports10 injury reports
What owners actually said
381 reports
Mileage unknown · Nov 12, 2025
Unknown Or OtherFire
During the early morning of December 23, 2024, at 2am, the vehicle caught fire in the carport of my house. Upon waking up to the noise, I proceeded to evacuate my family from the house due to the amount of smoke inside. The fire damaged approximately one-third of the house. Prior to this incident, the vehicle showed no defects,…
Read full complaint
During the early morning of December 23, 2024, at 2am, the vehicle caught fire in the carport of my house. Upon waking up to the noise, I proceeded to evacuate my family from the house due to the amount of smoke inside. The fire damaged approximately one-third of the house. Prior to this incident, the vehicle showed no defects, and all its services were performed by the same Hyundai dealership workshop where I bought the vehicle.
NHTSA ODI #11698988
Mileage unknown · Nov 10, 2025
Back Over PreventionCrash
My camera and backup system have not been working correctly since early March of 2024. It has been in service seven times since then, at two different dealers and no service department has been able to fix the problem. There were no warning signs at all, the camera and backup just stopped working. It has been fixed 7 times and e…
Read full complaint
My camera and backup system have not been working correctly since early March of 2024. It has been in service seven times since then, at two different dealers and no service department has been able to fix the problem. There were no warning signs at all, the camera and backup just stopped working. It has been fixed 7 times and each time it has worked leaving the dealership from six through ten days. Occasionally it has gone out, comes back on, but never lasts for more than a day or two. I have notified Hyundai Corporation and have been working with a customer service representative but she has not been able to be terribly helpful. Hyundai tells the service department what parts to order, they do, but the problem has never been fixed successfully. The vehicle has been examined and fixed by two Hyundai service departments. I hit a pole in the West Palm Beach Airport, my camera and back up system were not working, the pole was below the view of the mirrors and it resulted in 2000.00 worth of damage which I paid for out of pocket. The date of this incident was March 23, 2025. I did not call the police as it did not involve another car so technically I guess it was an incident rather than an accident. I do not feel safe driving this car, especially during evening hours.
NHTSA ODI #11698631
Mileage unknown · Nov 8, 2025
Fuel/propulsion System
I just bought this car back in february. It has 50k miles on it. Five minutes after starting it, and in the middle of a busy road, my accelerator suddenly stopped working, my car started shaking, and then it died. My dash lit up and it turns out, it was an issue with the factory fuel injectors.
NHTSA ODI #11698356
Mileage unknown · Nov 5, 2025
Fuel/propulsion System
Driving on Interstate 64 in southern Indiana approximately 70 mph in left lane when engine died without any warning signs. Was able to safely maneuver vehicle to shoulder without incident. Paid to have the vehicle towed 60 miles to Hyundai dealer. Dealer stated engine failure was due to injector issue known by Hyundai as a tec…
Read full complaint
Driving on Interstate 64 in southern Indiana approximately 70 mph in left lane when engine died without any warning signs. Was able to safely maneuver vehicle to shoulder without incident. Paid to have the vehicle towed 60 miles to Hyundai dealer. Dealer stated engine failure was due to injector issue known by Hyundai as a technical issue was released.
NHTSA ODI #11697741
Mileage unknown · Nov 3, 2025
Fuel/propulsion System
All four GDI injectors failed resulting in the car completely stopping on the highway.
NHTSA ODI #11697294
Mileage unknown · Nov 3, 2025
Unknown Or Other
January 2023-driving down the road and the car was shaking and wouldn’t give much gas when pressing the accelerator. When we got it towed to the dealer, they said it was the fuel injector. July 2024-driving on a major highway, car starting doing the same thing and stopped on the highway I pulled to the shoulder. I was not safe…
Read full complaint
January 2023-driving down the road and the car was shaking and wouldn’t give much gas when pressing the accelerator. When we got it towed to the dealer, they said it was the fuel injector. July 2024-driving on a major highway, car starting doing the same thing and stopped on the highway I pulled to the shoulder. I was not safe at all. The tow truck took over 2 hours to come. It was a hot summer day. When it finally got towed it was confirmed it was a second fuel injector. November 2025-driving and the car did the same thing, currently at the dealership and it’s the 3rd fuel injector. I’ve never felt so unsafe in a car. It only has 30k miles on it. I don’t drive on the highway because I get anxiety about it stopping again. There’s another fuel injector that “needs” to fail to complete all 4.
NHTSA ODI #11697187
Mileage unknown · Nov 3, 2025
Fuel/propulsion System
Fuel injectors failed after 4 years of having the car. This led to misfiring, shaking of car, and complete shut down of car within 10 seconds of starting the vehicle.
NHTSA ODI #11697144
Mileage unknown · Oct 31, 2025
Fuel/propulsion System
Two separate times over the last year I’ve had a fuel injector go bad after using the auto start feature in semi colder temperatures. I’m not sure if the auto start has something to do with it but seems to be a cold weather issue.
NHTSA ODI #11696719
Mileage unknown · Oct 28, 2025
Engine
I am submitting this complaint regarding an ongoing and dangerous issue with my 2022 Hyundai Tucson involving repeated fuel injector failures that have caused the vehicle to stall and lose power while driving, without any prior warning indicators. The first incident occurred in October 2023, at approximately 16,000 miles, when …
Read full complaint
I am submitting this complaint regarding an ongoing and dangerous issue with my 2022 Hyundai Tucson involving repeated fuel injector failures that have caused the vehicle to stall and lose power while driving, without any prior warning indicators. The first incident occurred in October 2023, at approximately 16,000 miles, when the car suddenly died while I was driving. There were no warning lights or signs of a problem before the stall occurred. The vehicle had to be towed to the dealership, where they replaced two fuel injectors. Just two weeks later, the same issue happened again—the car died while driving and was towed back to the dealership. The remaining injectors were then replaced. Unfortunately, this problem has continued. In November 2024, at around 26,000 miles, the vehicle again stalled while driving, with no warning, due to another fuel injector failure ( more failed injectors). Most recently, on October 18, 2025, with 31,000 miles on the odometer, my Tucson lost power and died while I was merging onto an interstate—once again with no warning or alert of any kind. I am still waiting for confirmation of how many injectors have failed this time. This is an extremely serious safety hazard. Losing engine power unexpectedly, especially while merging into highway traffic, puts both the driver and others on the road at significant risk of a collision or serious injury. Despite multiple occurrences, Hyundai has not identified the root cause of the injector failures and continues only to replace the faulty parts, which clearly does not resolve the underlying issue. It is unacceptable that a relatively new vehicle would experience repeated fuel system failures of this nature, and it is clear that there is a systemic defect affecting safety and reliability. I urge the NHTSA to investigate this issue to determine whether other Hyundai Tucson owners are experiencing similar failures and whether a recall or safety action is warranted.
NHTSA ODI #11696131
Mileage unknown · Oct 27, 2025
Unknown Or Other
On [XXX] at approximately [XXX] we were traveling west on [XXX] in Canida when we heard an explosion and could hear air rushing into the vehicle. As soon as we could safely pull to the right and into the breakdown lane my wife got out and noticed a large hole in the panoramic sunroof. The glass was shattered but the glass staye…
Read full complaint
On [XXX] at approximately [XXX] we were traveling west on [XXX] in Canida when we heard an explosion and could hear air rushing into the vehicle. As soon as we could safely pull to the right and into the breakdown lane my wife got out and noticed a large hole in the panoramic sunroof. The glass was shattered but the glass stayed within the cloth cover. We were in shock but decided to continue on to our medical appointment in Manchester. We had not been near an overpass and we felt no debris flying from the road or another vehicle. we called our insurance company, Amica Mutual and reported the incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 Tucson vehicles equipped with an optional Mobis tow hitch wiring harness. The wiring harness may have been installed incorrectly, allowing water into the control module. Moisture accumulation may cause the trailer lighting to fail or an electrical short circuit.
Consequence & remedy
Consequence: Nonfunctioning trailer lights can increase the risk of a crash. A short circuit can increase the risk of a fire.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will remove the trailer wiring harness and install a dust cap over the wiring receptacle, free of charge. Owner notification letters were mailed May 11, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 290. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 20, 2025.
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.
Consequence & remedy
Consequence: A detached roof molding could become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.
Additional source detail variants (2)
Structure:critical Fasteners
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.
Consequence: A detached roof molding could become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.
Structure:body:roof And Pillars
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.
Consequence: A detached roof molding could become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.
Consequence & remedy
Consequence: Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.
Remedy: Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.
Additional source detail variants (2)
Electrical System:software
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.
Consequence: Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.
Remedy: Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.
Exterior Lighting
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.
Consequence: Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.
Remedy: Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration