Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 43 of 381 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel/propulsion System. Review the 131 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports4 fire reports10 injury reports
What owners actually said
381 reports
Mileage unknown · Oct 26, 2025
Fuel/propulsion System
What component or system failed or malfunctioned, and is it available for inspection upon request? Cylinder 4 fuel injector failed while driving 70 MPH down the highway. The dealer or manufacturer will have the faulty parts for inspection. How was your safety or the safety of others put at risk? Loss of power and acceleration p…
Read full complaint
What component or system failed or malfunctioned, and is it available for inspection upon request? Cylinder 4 fuel injector failed while driving 70 MPH down the highway. The dealer or manufacturer will have the faulty parts for inspection. How was your safety or the safety of others put at risk? Loss of power and acceleration put me and others at risk; I could not go over 40 MPH on the highway, the car was lurching the entire time. Inattentive drivers being the main concern, with low speeds and driving/sitting still on the shoulder of the road. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the dealership I had it towed to confirmed the injector failed. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The manufacturer is aware of the issue. There is a TSB issued that asks the dealer to send the faulty parts back to them. They are fully aware of the issue and are choosing to replace faulty parts with equally faulty parts. The dealer told me the replacement injectors “are not supposed to have the factory defect” but confirmed they are the same parts. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes, the engine light came on and I lost power/acceleration simultaneously.
NHTSA ODI #11695644
Mileage unknown · Oct 16, 2025
Unknown Or Other
Car goes into limp mode and will not accelerate over 25 mph. This has happened 5 times while driving in traffic. It is very unsafe and could be the cause of an accident. Fortunately we found a place to pull off the road, wait a while, and restart the car.
NHTSA ODI #11693841
Mileage unknown · Oct 11, 2025
Fuel/propulsion SystemService Brakes
It’s been three years now and I had “Brake system failure” happened two times in 3 years. When traveling the brake system warning appears and while driving, and stopped at sign brake releases slightly and car would start to move unless I apply brakes firmly again. When slowing down at traffic lights holding the brake doesn’t bri…
Read full complaint
It’s been three years now and I had “Brake system failure” happened two times in 3 years. When traveling the brake system warning appears and while driving, and stopped at sign brake releases slightly and car would start to move unless I apply brakes firmly again. When slowing down at traffic lights holding the brake doesn’t bring car to complete stop. I had apply brake, slightly release and then apply again until car comes to full stop. I was told they need to replace IEB module and brake pedal module replacement. I checked in Reddit and other platforms where users had seen the issue multiple times on their vehicles. Also had an issue with Fuel system like replacement of Egr valve which seems to be common on multiple Vehicles.
NHTSA ODI #11692674
Mileage unknown · Sep 29, 2025
Service Brakes
I took the vehicle to the service station because it takes a long time to stop, and I braked close to a vehicle on several occasions. They replaced the brake pads, and when I took the baby in, it was worse. When they finally agreed to let me take the baby in for another inspection, they said they would have to remove and reinsta…
Read full complaint
I took the vehicle to the service station because it takes a long time to stop, and I braked close to a vehicle on several occasions. They replaced the brake pads, and when I took the baby in, it was worse. When they finally agreed to let me take the baby in for another inspection, they said they would have to remove and reinstall the parts. Two months later, my baby started doing the same thing.
NHTSA ODI #11690235
Mileage unknown · Sep 27, 2025
Electrical System
Both horns needed to be replaced three times due to both stopped working and I listed the dates below. First time replacement: 4-6-24, Second time replacement: 10-9-24, Third time replacement: 1-16-25. Now on 9-26-25 both horns stopped worknig again, I checked the horn fuse and that is good. I now need to call the dealer to hav…
Read full complaint
Both horns needed to be replaced three times due to both stopped working and I listed the dates below. First time replacement: 4-6-24, Second time replacement: 10-9-24, Third time replacement: 1-16-25. Now on 9-26-25 both horns stopped worknig again, I checked the horn fuse and that is good. I now need to call the dealer to have both horns replaced for the fourth time. I also contacted Hyundai's national customer service to log a complaint as well. To me this is a safty issue since the horn is used to possible prevent an accident. I check the horns when I drive the car since they go bad so often and I have under 28,000 miles on the vehicle.
NHTSA ODI #11690103
Mileage unknown · Sep 25, 2025
Fuel/propulsion System
Taken car to work, driving down highway check engine light come on with loss of power. Took to dealership reported cylinder number 3 fuel injector was stuck open. Replaced all 4 injectors. Found TSB for it
NHTSA ODI #11689676
30,000 miles · Sep 24, 2025
Back Over PreventionEquipmentPower Train
The contact owns a 2022 Hyundai Tucson. The contact stated that there was a delay in the operation of the rearview camera to provide an image while reversing. The contact stated that the rearview camera remained activated temporarily while the vehicle was in drive(D). The contact stated that the infotainment system screen turned…
Read full complaint
The contact owns a 2022 Hyundai Tucson. The contact stated that there was a delay in the operation of the rearview camera to provide an image while reversing. The contact stated that the rearview camera remained activated temporarily while the vehicle was in drive(D). The contact stated that the infotainment system screen turned off and activated functions unintendedly while driving. The vehicle was taken to the dealer, where the infotainment system and the rearview camera were replaced twice; however, the failure persisted. Additionally, the contact stated that while attempting to shift from reverse(R), the gear shifter was sticking and failed to shift to drive(D). The contact was able to shift to drive(D) after several attempts. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 30,000.
NHTSA ODI #11689354
Mileage unknown · Sep 23, 2025
Air BagsSeat Belts
Had my car scanned it said air control unit. With that light on if I have a collision my ai bags won't deploy and my safety belts will not lock.
NHTSA ODI #11689250
Mileage unknown · Sep 17, 2025
Forward Collision AvoidanceUnknown Or Other
The computer(s) responsible for many of the safety systems have faulty software. The computer vision system incorrectly assess condition of the roadway and issues warnings that obscure the instrument cluster. The computer vision system also incorrectly determines that a collision is imminent (despite no obstacles being present) …
Read full complaint
The computer(s) responsible for many of the safety systems have faulty software. The computer vision system incorrectly assess condition of the roadway and issues warnings that obscure the instrument cluster. The computer vision system also incorrectly determines that a collision is imminent (despite no obstacles being present) and activates the braking system. Hyundai has been aware of this issue since 2022 and has previously released a software patch to correct it. However, unpatched vehicles are still being sold (and resold) by Hyundai dealerships without being fixed because Hyundai has chosen to rescind the availability of the update. Unpatched vehicles are on the road preventing drivers from properly monitoring vehicle operation as a result of the continuous warning obscuring the cluster and are jeopardizing the occupants and other road users when the vehicles spontaneously initiate panic stops for phantom obstacles. Hyundai refuses requests to provide the existing update files because a future update with an uncertain release date is planned; release of the "upcoming" update has seemingly already been delayed 8 months.
NHTSA ODI #11687766
Mileage unknown · Sep 11, 2025
Fuel/propulsion System
I went to fill up the gas and the gas cap door would not open. The gas station attendant tried to help with no luck. I drove to the dealer - the fuel release actuator had failed. Part was replaced under warranty. I am lucky I had enough gas to get to the dealer. Very scary when you can’t put gas in your car!
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 Tucson vehicles equipped with an optional Mobis tow hitch wiring harness. The wiring harness may have been installed incorrectly, allowing water into the control module. Moisture accumulation may cause the trailer lighting to fail or an electrical short circuit.
Consequence & remedy
Consequence: Nonfunctioning trailer lights can increase the risk of a crash. A short circuit can increase the risk of a fire.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will remove the trailer wiring harness and install a dust cap over the wiring receptacle, free of charge. Owner notification letters were mailed May 11, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 290. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 20, 2025.
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.
Consequence & remedy
Consequence: A detached roof molding could become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.
Additional source detail variants (2)
Structure:critical Fasteners
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.
Consequence: A detached roof molding could become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.
Structure:body:roof And Pillars
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.
Consequence: A detached roof molding could become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.
Consequence & remedy
Consequence: Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.
Remedy: Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.
Additional source detail variants (2)
Electrical System:software
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.
Consequence: Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.
Remedy: Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.
Exterior Lighting
Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.
Consequence: Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.
Remedy: Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration