Hyundai Elantra electrical problems

THE KNOB ON TO TURN ON FAN FOR A/C STARTING TO NOT WORK UNLESS I TUNED IT ON AND OFF. THEN A FEW DAYS AGO, WHILE I WAS IDLING IN A PARKING LOT, THE KNOB GOT STUCK WITH THE A/C ON. I STARTED TO SMELL BURNING & WHEN I TRIED TO TURN IT OFF THE KNOB CAME OFF AND I SAW SMOKE COMING FROM WHERE THE KNOB WAS. I TURNED OFF MY VEHICLE, REMOVED THE FUSE FOR THE A/C AND DROVE HOME. WHEN I WENT TO REPLACE IT AND REMOVE THE OLD ONE, I NOTICED THAT THE PLUG THAT CONNECTS TO THE CLIMATE CONTROL UNIT IS ALSO BURNED. THE PLUG AND THE WIRES CONNECTED TO IT LEAD TO A BUNCH OF WIRES THAT ARE WIRED TOGETHER. AT THIS POINT, I AM AFRAID TO DRIVE MY VEHICLE, EVEN THOUGH THE FUSE FOR THE CLIMATE CONTROL UNIT ISN'T IN. IF I LEAVE THE UNIT DISCONNECTED, I WILL NOT BE ABLE TO USE BY HAZARDS. IF I HADN'T REMOVED THE FUSE OR IF I HAD BEEN ON A MAJOR HIGHWAY OR FREEWAY THE CAR MAY HAVE CAUGHT FIRE. I NOTICED THAT THERE ARE MANY PEOPLE REPLACING THIS PART. MAYBE IT COULD BE A SAFETY ISSUE.

WHEN DRIVING THE VEHICLE, THE EPS LIGHT WOULD ARBITRARILY TURN ON AND GO AWAY WHEN THE IGNITION KEY IS CYCLED OFF AND BACK ON. WHEN THE LIGHT COMES ON, IT IMMEDIATELY BECOMES DIFFICULT TO STEER. THE CAR REVERTS TO MANUAL STEERING MODE AND REQUIRES SIGNIFICANT AMOUNT OF EFFORT TO CONTROL. WE HAVE HAD THE EPS LIGHT TURN ON MULTIPLE TIMES WITHOUT WARNING WHILE DRIVING AND PUTTING US IN DANGEROUS, UNSAFE CONDITIONS ON THE ROAD. RECENTLY, THE EPS LIGHT IS STAYING ON AND NOT GOING AWAY. WE VISITED THE LOCAL DEALER TO REPORT THIS ISSUE AND THEIR DIAGNOSIS RESULTED IN ERROR CODES RELATED TO THE STEERING ANGLE SENSOR-ELECTRICAL, TORQUE SENSOR MAIN SIGNAL FAULT, ECU (BRAKE SYSTEM) HARDWARE ERROR, CAN TIME-OUT EMS, AND MOTOR. WHEN ASKED, THEY WERE NOT WILLING TO PERFORM AN EVALUATION AS PER THE TECHNICAL SERVICE BULLETIN. THEY RECALIBRATED THE STEERING ANGLE SENSOR AND STATED THAT IF THE PROBLEM REOCCURS, WE WOULD NEED TO RETURN TO THE DEALERSHIP TO REPLACE THE STEERING COLUMN (PART NUMBER 56310-2H250 AS1) AND PAY FULL COST OF REPAIR (PART AND LABOR). THIS PART NUMBER IS LISTED AS A REPLACEABLE ITEM PER THE TECHNICAL SERVICE BULLETIN. PLEASE NOTE THAT THE DEALERSHIP PERFORMED AN EPS S/W CHK/ECU UPGRADE IN 2015 WHEN NO ISSUES WERE PRESENT AND REFUSE TO FURTHER ASSIST WHEN THE ISSUE IS PRESENT WHEN THE RECALL CAMPAIGN INFORMATION LETTER IN MARCH 2015 CLEARLY STATES THAT THE FINAL REMEDY HAS NOT BEEN DEVELOPED AT THIS TIME. THE DIAGNOSIS SHOWS THAT A FAULTY PART WAS INSTALLED BY THE CAR MANUFACTURER, AS STATED IN THE RECALL, AND THE DEALERSHIP IS REFUSING TO ADDRESS THE ACTUAL ISSUE. INSTEAD OF SOLVING THE PROBLEM, THEY INSIST THAT WE DRIVE THIS POTENTIALLY UNSAFE VEHICLE UNTIL THE ISSUE REOCCURS. THIS IS A SAFETY RELATED CONCERN AS THERE IS NO WARNING TO WHEN THIS ISSUE WILL OCCUR. THEIR RECALL NOTICE STATES THAT THE EPS PROBLEMS COULD RESULT IN AN INCREASED RISK OF A CRASH.

TL* THE CONTACT OWNS A 2009 HYUNDAI ELANTRA. WHILE DRIVING APPROXIMATELY 45 MPH, THE POWER STEERING FAILED WITHOUT WARNING. THE CONTACT STATED THAT IT WAS DIFFICULT TO MANEUVER THE VEHICLE SAFELY. TAYLOR HYUNDAI (LOCATED AT 3233 WASHINGTON RD, AUGUSTA, GA 30907, (706) 868-1200) WAS CONTACTED BY PHONE AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS SUBJECTED TO NHTSA CAMPAIGN NUMBER: 15V100000 (STEERING). ADDITIONALLY, WHILE ATTEMPTING TO DRIVE TO THE DEALER TO HAVE THE RECALL REPAIR PERFORMED, THE POWER STEERING FAILED. THE VEHICLE WAS TOWED TO THE DEALER AND THE RECALL REPAIR WAS PERFORMED. AFTER THE FAILURE RECURRED, THE VEHICLE EXPERIENCED SEVERAL ELECTRICAL ISSUES PERTAINING TO THE INTERIOR LIGHTING BEING ACTIVATED WHEN THE HEADLIGHT SWITCH WAS TURNED TO THE ON POSITION. ADDITIONALLY, THE BATTERY WOULD DRAIN OVERNIGHT WHILE THE VEHICLE WAS PARKED. THE VEHICLE WAS TOWED BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BATTERY NEEDED TO BE REPLACED. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND PROVIDED CASE NUMBER: 15936968. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 149,000.

TL* THE CONTACT OWNS A 2017 HYUNDAI ELANTRA. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF. MOMENTS LATER, AFTER RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. FLINT HILLS HYUNDAI (7920 E. HIGHWAY 24, MANHATTAN, KS) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 65,000.

AROUND 5PM ON JULY 18TH AFTER STARTING UP MY PARKED CAR WITH NO ISSUES I PULLED OUT OF A PARALLEL PARKING SPOT AND MADE A LEFT TURN THROUGH A GREEN ARROW AT THE LIGHT. I WAS DRIVING STRAIGHT AND SLOWLY ACCELERATING TO ABOUT 30MPH. I TOOK MY FOOT OF THE GAS A BIT TO COAST. I WENT TO PUT MY FOOT BACK ON THE GAS BUT BEFORE I COULD WITHIN ABOUT 10SEC THE CAR SLOWED DOWN AND CAME TO A HALT IN THE MIDDLE OF THE ROAD. RIGHT AS THE CAR WAS SLOWING DOWN ALL OF THE EMERGENCY LIGHTS SUCH AS CHECK ENGINE AND ALL THE OTHER ONES ON THE DASHBOARD FLASHED. THE CAR WAS COMPLETELY SHUT OFF. THE HAZARD LIGHTS DID NOT EVEN COME ON. I IMMEDIATELY PRESSED THE BREAK AND TURNED THE CAR BACK ON. IT STARTED UP IMMEDIATELY AND I KEPT DRIVING. TOOK CAR TO HYUNDAI DEALER WHO FOUND NO ISSUES AFTER RUNNING A DIAGNOSTIC.

I DROVE MY 2013 HYUNDAI ELANTRA TUESDAY EVENING AND PARKED IT AT 9PM. WENT TO START MY CAR TO GO TO WORK AT 730AM AND IT WOULD NOT START. ALL OF THE LIGHTS CAME ON, HEADLIGHTS AND RADIO WORKED THE CAR JUST WOULD NOT START. I TRIED TO START IT 5 MORE TIMES, IT IS PUSH START. I CALLED AND HAD MY CAR TOWED THAT EVENING, THE TOW GUY CAME AND PUT IT IN NEUTRAL AND IT STARTED RIGHT UP. I STILL HAD THE CAR TOWED BECAUSE I HAVE HAD SO MANY ELECTRICAL ISSUES WITH THIS CAR. IT HAS BEEN AT THE HYUNDAI DEALERSHIP FOR 4 DAYS NOW AND NO ONE CAN TELL ME WHAT IS WRONG WITH IT. IT HAS STARTED A COUPLE TIMES FOR THE DEALERSHIP BUT NOT CONSISTENTLY. I KEEP CALLING AND ASKING WHAT THE ISSUE IS BUT THEY HAVE NO IDEA WHAT IT IS. I HAVE READ NUMEROUS COMMENTS ABOUT THE SAME ISSUE WITH THIS CAR. THIS NEEDS TO BE A RECALL THIS IS NOT FAIR TO US AS HYUNDAI CUSTOMERS. THIS SHOULD BE RECALLED AND PAID FOR BY HYUNDAI.