NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
652 reports151,000 miles · Aug 20, 2026
Engine
The contact owns a 2012 Hyundai Elantra. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and stalled. The check engine warning light illuminated after the failure. The vehicle was taken to an independent mechanic, where the vehicle was diagnosed with a failed crankshaft sensor. The ve…
Read full complaint
The contact owns a 2012 Hyundai Elantra. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and stalled. The check engine warning light illuminated after the failure. The vehicle was taken to an independent mechanic, where the vehicle was diagnosed with a failed crankshaft sensor. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the independent mechanic, and the contact was advised to take the vehicle to the dealer. The contact was informed of an unknown recall; however, the VIN was not associated with a recall associated with the failure. The dealer was made aware of the failure. The contact was informed that the repair was not covered under warranty because the mileage was 3,000 miles over the mileage limitation. The vehicle was scheduled for a diagnostic test with the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 151,000.
NHTSA ODI #11758279
59,000 miles · Aug 3, 2026
Service Brakes, Hydraulic
The contact owns a 2012 Hyundai Elantra. The contact stated that while operating the vehicle, the brake pedal felt spongy while depressed. After parking the vehicle, the contact later restarted the vehicle, and the brake pedal extended to the floor while depressed. While inspecting under the hood, the contact discovered that the…
Read full complaint
The contact owns a 2012 Hyundai Elantra. The contact stated that while operating the vehicle, the brake pedal felt spongy while depressed. After parking the vehicle, the contact later restarted the vehicle, and the brake pedal extended to the floor while depressed. While inspecting under the hood, the contact discovered that there was no brake fluid inside the brake fluid reservoir. The cause of the failure was not yet determined. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 23V651000 (SERVICE BRAKES, HYDRAULIC), and a fuse was replaced. The manufacturer and the local dealer were notified of the failure. The failure mileage was 59,000.
NHTSA ODI #11754439
Mileage unknown · Jul 14, 2026
Electrical System
Apparently a VERY common crankshaft angle sensor malfunction caused the engine to stall out at a stoplight, putting me in harm's way
NHTSA ODI #11750199
Mileage unknown · Jun 11, 2026
Air BagsVehicle Speed ControlCrashInjury
I was going down the bridge on settlers landing road the yellow school bus was in the right turning lane with right turning signal on .as I approached the light in the middle straight lane to keep toward the landing (hotel) on settlers landing Hampton va the bus some what merged back towards the middle lane and that when the b…
Read full complaint
I was going down the bridge on settlers landing road the yellow school bus was in the right turning lane with right turning signal on .as I approached the light in the middle straight lane to keep toward the landing (hotel) on settlers landing Hampton va the bus some what merged back towards the middle lane and that when the bus crashed into the car it went under the bus it’s totaled the windshield and my sunroof collided the airbags did not deploy something needs to be done about that that was dangerous.I got glass in my face my right hand had glass my head hit the steering wheel my body jerked. I hit my legs my whole body is hurting and very sore all over I can’t hardly walk my hand is swollen. Liability suit of airbag default needs to happen
NHTSA ODI #11743488
Mileage unknown · Jun 1, 2026
Service Brakes
*Wife litely drives this car avg 4k miles a year* She left the house for the grocery store the other day and after the first stop light, noticed the brakes were engaging on their own. Luckily she called me before going any further and damaging the pads and rotors, or worse - causing a fire or having an accident. I slowly drove i…
Read full complaint
*Wife litely drives this car avg 4k miles a year* She left the house for the grocery store the other day and after the first stop light, noticed the brakes were engaging on their own. Luckily she called me before going any further and damaging the pads and rotors, or worse - causing a fire or having an accident. I slowly drove it home and inspected fuses, brake fluid and checked online resources for anyone with similar issue. Turns out this is common? Very dangerous. Have never experienced this issue with any other car make. I had the car towed to HQ Hyundai (local dealer in Sanford FL) to address 2 open recall bulletins on this car. They immediately forced me to accept a $200 inspection fee (key ransom) just to do the recalls - siting safety of staff!?! They were informed that the brakes were remaining engaged and that they needed to disconnect the battery, but they left it in the tow yard over the weekend. I am sure they will try to sell us a battery now. Very upset with the response to this extremely unsafe issue, that we didn't cause from excessive, hard driving.
NHTSA ODI #11741232
Mileage unknown · Apr 27, 2026
EngineFire
The contact owned a 2012 Hyundai Elantra. The contact stated that around 4:00 o'clock in the morning, she was awoken by the sound of her dogs barking; she then discovered that her vehicle had caught fire and had burned to the ground. The fire spread, which caught fire to a nearby mobile home and a 4-wheeler. The authorities were…
Read full complaint
The contact owned a 2012 Hyundai Elantra. The contact stated that around 4:00 o'clock in the morning, she was awoken by the sound of her dogs barking; she then discovered that her vehicle had caught fire and had burned to the ground. The fire spread, which caught fire to a nearby mobile home and a 4-wheeler. The authorities were called to the scene, and the fire department managed to extinguish all three fires. No injuries were reported, and a police report was not filed. A neighbor's Ring doorbell camera captured the footage of the fire, which showed that the fire had started from underneath the hood of the vehicle. The manufacturer was notified of the failure, and a case was filed. The vehicle was a total loss and remained in the contact's possession. The failure mileage was unknown.
NHTSA ODI #11734107
80,000 miles · Apr 6, 2026
EngineFire
The contact’s son owns a 2012 Hyundai Elantra. The contact stated that while the contact’s son was driving at an undisclosed speed, the vehicle unexpectedly stalled, and the rear of the vehicle caught fire. The contact’s son pulled the vehicle over to the side of the road, and the fire extinguished on its own. No fire or police…
Read full complaint
The contact’s son owns a 2012 Hyundai Elantra. The contact stated that while the contact’s son was driving at an undisclosed speed, the vehicle unexpectedly stalled, and the rear of the vehicle caught fire. The contact’s son pulled the vehicle over to the side of the road, and the fire extinguished on its own. No fire or police report was filed. The contact was informed by local police that a trail of oil had leaked from the contact’s son’s vehicle while driving. The vehicle was towed to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and refused to replace the engine under an unknown related engine recall. The approximate failure mileage was 80,000.
NHTSA ODI #11729506
101,000 miles · Mar 31, 2026
Air Bags
The contact owns a 2012 Hyundai Elantra. The contact stated that while attempting to start the vehicle, the air bag warning light illuminated. Neither an independent mechanic nor a dealer was contacted. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed or repaired. The vehicle was not repaired. The…
Read full complaint
The contact owns a 2012 Hyundai Elantra. The contact stated that while attempting to start the vehicle, the air bag warning light illuminated. Neither an independent mechanic nor a dealer was contacted. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed or repaired. The vehicle was not repaired. The manufacturer was not notified of the failure and opened a case. The approximate failure mileage was 101,000.
NHTSA ODI #11728339
Mileage unknown · Feb 27, 2026
Engine
To Whom It May Concern, I am submitting this complaint regarding a 2012 Hyundai Elantra equipped with the 1.8L Nu engine, which is experiencing premature internal engine damage that presents a potential safety risk. Vehicle details: Year/Make/Model: 2012 Hyundai Elantra Mileage: Approximately 134,500 miles Issue description: Th…
Read full complaint
To Whom It May Concern, I am submitting this complaint regarding a 2012 Hyundai Elantra equipped with the 1.8L Nu engine, which is experiencing premature internal engine damage that presents a potential safety risk. Vehicle details: Year/Make/Model: 2012 Hyundai Elantra Mileage: Approximately 134,500 miles Issue description: The engine produces a persistent ticking/knocking noise, most pronounced at cold start but now continuing even after the engine has warmed. A Hyundai dealership diagnosed the vehicle with piston slap and confirmed significant scarring on the cylinder walls, stating that the only repair is full engine replacement. Despite the presence of internal engine damage, no warning lights are illuminated. I am concerned this condition could lead to sudden engine seizure or loss of power while driving, creating a safety hazard. Additional observations include: Excessive crankcase blow-by observed when removing the oil fill cap while the engine is running Strong exhaust fumes at cold start Noise most noticeable at idle and low RPM Regular oil changes using manufacturer-recommended oil viscosity The dealership advised the condition was not repairable short of engine replacement and did not submit the concern for Hyundai corporate technical review (Techline), despite the known history of engine defects in Hyundai Nu engines. I am filing this complaint to document a pattern of premature internal engine wear that may not be adequately addressed through recalls or warranty programs, and which could result in sudden engine failure. Thank you for your attention to this matter.
NHTSA ODI #11721058
Mileage unknown · Feb 12, 2026
Engine
Car check engine light illuminated and car began shaking and stalled at 79284 miles. Local mechanic said engine was dry and would need full replacement, no dashboard lights indicating oil level or engine issues prior to this point.
NHTSA ODI #11717574
Official recalls
4Sep 22, 2023
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
Jul 2, 2020
Hyundai Motor America (Hyundai) is recalling certain 2011-2012 Hyundai Elantra and Sonata Hybrid, 2012 Accent and Veloster vehicles. The 12V accessory socket outlet may have been over-tightened during installation, possibly disabling the thermal fuse and allowing the outlet to overheat with prolonged use, such as by using the Tire Mobility Kit air compressor to inflate a tire.
Consequence & remedy
Consequence: An overheated accessory outlet increases the risk of fire.
Remedy: Hyundai will notify owners, and dealers will replace the Tire Mobility Kit accessory outlet plug with a direct-to-battery connection wire harness kit, free of charge. The recall began September 28, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 193.
Dec 23, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2011-2012 Elantra vehicles manufactured October 29, 2010, to October 25, 2011. Due to an electronic stability control (ESC) sensor malfunction, the brakes for one or more wheels may be applied unexpectedly and the engine power may be reduced. These symptoms will be accompanied by illumination of the ESC indicator lamp in the instrument cluster.
Consequence & remedy
Consequence: If the one or more of the brakes are inappropriately applied, control of the vehicle may be lost, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will verify the proper operation of the ESC sensors, and update the ESC system's calibration, free of charge. The recall began June 6, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 137.
Apr 1, 2013
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence & remedy
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Additional source detail variants (2)
Structure
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Air Bags:side/window
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
EA12008 · Headliner Bracket Detachment
Opened Sep 13, 2012 · Closed Dec 9, 2013
Status: closed (inferred from source dates) · Air Bags:side/window; Structure:body:roof And Pillars; Unknown Or Other
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Additional source detail variants (3)
Air Bags:side/window
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Structure:body:roof And Pillars
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Unknown Or Other
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
PE12012 · Side Curtain Air Bag Improper Deployment
Opened May 10, 2012 · Closed Sep 17, 2012
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
The Office of Defects Investigation (ODI) is aware of one incident of an improper deployment of the driver-side curtain air bag that deployed as a result of a crash involving a model year (MY) 2012 Hyundai Elantra.An inspection of this vehicle showed that a metal bracket (stiffener) in the headliner assembly had detached and was forced downward by the deploying air bag.The metal bracket caused a laceration to the driver's ear and other possible injuries.Approximately 75,000 MY 2012 Hyundai Elantra vehicles, built in Korea and sold in the U.S., have stiffeners in the headliners while the MY 2012 Elantra vehicles built in the U.S. utilize a different headliner that does not use a stiffener. Thus, the latter vehicles are not included in this investigation.Hyundai has inspected the headliner assemblies from eight Elantra vehicles (which were sold in the Korean market) with production dates in the same range as the field incident vehicle.Hyundai reported to ODI that the metal brackets from these vehicles were found to be securely attached to the headliners.Hyundai also has conducted several static deployment tests in attempts to replicate the field incident. In one test, the metal bracket detached from the headliner but the test condition did not replicate or explain the condition observed in the incident vehicle.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-008) to further assess whether incidents like the single field incident could potentially occur with other subject vehicles.In addition to the subject vehicles, ODI also will collect and review information on MY 2011 and 2013 Elantra vehicles that have headliners with stiffeners similar to those in the subject vehicles. To date, there have been no reports on the MY 2011 and 2013 vehicles.The ODI report cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Additional source detail variants (2)
Air Bags
The Office of Defects Investigation (ODI) is aware of one incident of an improper deployment of the driver-side curtain air bag that deployed as a result of a crash involving a model year (MY) 2012 Hyundai Elantra.An inspection of this vehicle showed that a metal bracket (stiffener) in the headliner assembly had detached and was forced downward by the deploying air bag.The metal bracket caused a laceration to the driver's ear and other possible injuries.Approximately 75,000 MY 2012 Hyundai Elantra vehicles, built in Korea and sold in the U.S., have stiffeners in the headliners while the MY 2012 Elantra vehicles built in the U.S. utilize a different headliner that does not use a stiffener. Thus, the latter vehicles are not included in this investigation.Hyundai has inspected the headliner assemblies from eight Elantra vehicles (which were sold in the Korean market) with production dates in the same range as the field incident vehicle.Hyundai reported to ODI that the metal brackets from these vehicles were found to be securely attached to the headliners.Hyundai also has conducted several static deployment tests in attempts to replicate the field incident. In one test, the metal bracket detached from the headliner but the test condition did not replicate or explain the condition observed in the incident vehicle.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-008) to further assess whether incidents like the single field incident could potentially occur with other subject vehicles.In addition to the subject vehicles, ODI also will collect and review information on MY 2011 and 2013 Elantra vehicles that have headliners with stiffeners similar to those in the subject vehicles. To date, there have been no reports on the MY 2011 and 2013 vehicles.The ODI report cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Air Bags:side/window
The Office of Defects Investigation (ODI) is aware of one incident of an improper deployment of the driver-side curtain air bag that deployed as a result of a crash involving a model year (MY) 2012 Hyundai Elantra.An inspection of this vehicle showed that a metal bracket (stiffener) in the headliner assembly had detached and was forced downward by the deploying air bag.The metal bracket caused a laceration to the driver's ear and other possible injuries.Approximately 75,000 MY 2012 Hyundai Elantra vehicles, built in Korea and sold in the U.S., have stiffeners in the headliners while the MY 2012 Elantra vehicles built in the U.S. utilize a different headliner that does not use a stiffener. Thus, the latter vehicles are not included in this investigation.Hyundai has inspected the headliner assemblies from eight Elantra vehicles (which were sold in the Korean market) with production dates in the same range as the field incident vehicle.Hyundai reported to ODI that the metal brackets from these vehicles were found to be securely attached to the headliners.Hyundai also has conducted several static deployment tests in attempts to replicate the field incident. In one test, the metal bracket detached from the headliner but the test condition did not replicate or explain the condition observed in the incident vehicle.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-008) to further assess whether incidents like the single field incident could potentially occur with other subject vehicles.In addition to the subject vehicles, ODI also will collect and review information on MY 2011 and 2013 Elantra vehicles that have headliners with stiffeners similar to those in the subject vehicles. To date, there have been no reports on the MY 2011 and 2013 vehicles.The ODI report cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Illustration