Multiple safety recalls issued for many models of hyundai cars. most recent that affects the 2014 hyundai elantra and other models is faulty ABS system which could result in engine compartment fire while parked or driving. There is no available repair for this problem. I received notice in the mail on 01/03/2024. I noticed that …
Read full complaint
Multiple safety recalls issued for many models of hyundai cars. most recent that affects the 2014 hyundai elantra and other models is faulty ABS system which could result in engine compartment fire while parked or driving. There is no available repair for this problem. I received notice in the mail on 01/03/2024. I noticed that the safety recall was issued in September of 2023. How is it acceptable that I was informed of a serious safety issue 4 months after it was found out? As I stated previously, there is not an available repair for this serious safety issue and fire risk. They are not offering free services to determine if this issue is affecting my car. Seriously negligent of Hyundai.
NHTSA ODI #11563861
Mileage unknown · Jun 21, 2023
EngineStructureInjury
Engine light has been on for almost a year with NO prior failure or issues after car hit a dangerous pot hole in the road which caused coil packs and spark plug replacements. After the repair, the engine light stayed on for almost a year and the car has been taken to multiple shops and a Hyundai dealer & diagnosed by Hyundai sam…
Read full complaint
Engine light has been on for almost a year with NO prior failure or issues after car hit a dangerous pot hole in the road which caused coil packs and spark plug replacements. After the repair, the engine light stayed on for almost a year and the car has been taken to multiple shops and a Hyundai dealer & diagnosed by Hyundai same answer of "maybe" leak and gas cap being loose. gas cap has been tightened and even replaced few times. Engine light stays on and no one can figure out why . The battery eventually died months later and when battery was replaced engine light came off and then back on days later. same result from mechanics of not knowing true reason engine light is on. 1 month after battery died alternator went out and no signs of knowing and safety concern because engine light stays on but not indicating true reason. 1 day after alternator went out car begin overheating on and off. the engine alert has still been on and never comes on for true reason which can indicate safety concern. problems within vehicle is starting to rise back to back . The signs of a leak but unaware to find is a safety issue
NHTSA ODI #11528095
Mileage unknown · Jul 24, 2021
Structure
My front passenger car door handle completely broke without doing anything!
NHTSA ODI #11426289
117,920 miles · Oct 28, 2020
StructureSuspensionWheelsCrash
AT 8AM COMING BACK FROM KINSTONE NC DRIVING ON HEY 70 AT 60MPH SECOND LANE MY 2014 HYUNDAI ELANTRA SUDDENLY BRAKED ON ME. CAR STARTED SLIDING FROM ONE SIDE TO ANOTHER SPIN AROUND TWICE BEFORE WENT DOWN HILL.
NHTSA ODI #11366901
40,000 miles · Oct 2, 2019
Structure
SINCE I BOUGHT MY 2014 HYUNDAI ELANYRA IT HAS HAD A PROBLEM WITH LEAKING WATER TO THE INSIDE OF THE VEHICLE ON THE PASSENGERS SIDE. APPARENTLY IT'S A LEAK FROM THE AC HOSE AND IT'S CLOGGED? NOW MY FLOOR IS WEAK AND IT IS ROTTING OUT DUE TO THE WATER DAMAGE. I'VE HAD IT REPAIRED BUT IT CONTINUES TO LEAK AFTER SEVERAL WEEKS OF BEI…
Read full complaint
SINCE I BOUGHT MY 2014 HYUNDAI ELANYRA IT HAS HAD A PROBLEM WITH LEAKING WATER TO THE INSIDE OF THE VEHICLE ON THE PASSENGERS SIDE. APPARENTLY IT'S A LEAK FROM THE AC HOSE AND IT'S CLOGGED? NOW MY FLOOR IS WEAK AND IT IS ROTTING OUT DUE TO THE WATER DAMAGE. I'VE HAD IT REPAIRED BUT IT CONTINUES TO LEAK AFTER SEVERAL WEEKS OF BEING FIXED! I'VE HAD ENOUGH!!! THE WATER ONLY FLOWS WHEN ITS MOVING AROUND ANY CORNER... NO ONE CAN SIT IN THE FRONT SEAT BECAUSE THEY GET A SHOWER EVERY FEW SECONDS!!!
NHTSA ODI #11265629
40,000 miles · Aug 18, 2019
Structure
HATCH DOOR RECALL. ON HOT DAYS THE REAR SPOILER ON THE HATCH DOOR SWELLS AND AS A RESULT IT WILL STICK AND JAM PREVENTING THE REAR HATCH FROM OPENING. THE JAMMING CAUSED THE BODY TO DENT AND CHIP THE PAINT, THIS COULD RESULT IN FUTURE PRE-MATURE RUSTING OF THE BODY.
NHTSA ODI #11244785
71,000 miles · Jan 6, 2019
Electronic Stability Control (esc)EngineStructureCrashInjury
TAKATA RECALL ON 9/23/2018, ABOUT AN HOUR AFTER A RAINSTORM (CAR WAS GARAGED DURING STORM) MY CAR WAS IN MOTION AT 40 MPH IN THE LEFT LANE ON A CURVE OF A SOUTHBOUND INTERSTATE EXIT I275. THE CAR SUDDENLY WENT SIDEWAYS, AND BEGAN FISHTAILING. I TRIED TO PUMP THE BREAKS BUT THEY WERE NOT WORKING. THE VEHICLE THEN SMASHED THE FRO…
Read full complaint
TAKATA RECALL ON 9/23/2018, ABOUT AN HOUR AFTER A RAINSTORM (CAR WAS GARAGED DURING STORM) MY CAR WAS IN MOTION AT 40 MPH IN THE LEFT LANE ON A CURVE OF A SOUTHBOUND INTERSTATE EXIT I275. THE CAR SUDDENLY WENT SIDEWAYS, AND BEGAN FISHTAILING. I TRIED TO PUMP THE BREAKS BUT THEY WERE NOT WORKING. THE VEHICLE THEN SMASHED THE FRONT SIDE OF BUMPER INTO THE GUARD RAIL, AND PUSHED ME ACROSS TWO TRAFFIC LANES. THE VEHICLE STOPPED IN THE RIGHT LANE, FACING NORTH IN A SOUTHBOUND EXIT. I TRIED TO PUT IT IN REVERSE TO GET INTO THE SHOULDER, AND THERE WAS NO ACCELERATION. THE ENGINE HAD SHUT OFF ON ME WHILE DRIVING ON THE INTERSTATE. I DO NOT KNOW WHAT FAILED THE ENGINE, OR WHY IT SHUT OFF. HYUNDAI CORPORATE WAS CONTACTED AND THEY OPENED A CASE, AND PERFORMED A FULL INSPECTION. ON 11/12/18 HYUNDAI CLAIMED "WE CANNOT AGREE THAT THE ACCIDENT INVOLVED A PRODUCT DEFECT AND ARE DECLINING ANY FINANCIAL ASSISTANCE." A THIRD PARTY MECHANIC WAS THEN CONTACTED, AND FOUND CODE C1555 AND A FAILING VVTI CYLINOID. THERE IS NO RECALL. THERE IS NO WAY TO PROVE THIS CAR IS UNSAFE WITH THE ROUTES I HAVE TAKEN SO FAR. I WILL NOT ACCEPT THIS ANSWER. THE ENGINE OF THIS CAR SHUT OFF AND COULD HAVE BEEN FATAL. IT IS ALSO TERRIFYING TO THINK ABOUT WHO WOULD TO BE BLAMED FOR SUCH A FATAL OR DANGEROUS ACCIDENT SINCE HYUNDAI "COULDN'T FIND ANY DEFECT." I ASKED FOR RESULTS OF THE SCAN AND THE CASE MANAGER, CHRISTINA REPLIED THAT I AM NOT AUTHORIZED TO SEE THEM, FOR "RESULTS ARE FOR PROPRIETARY USE ONLY." THIS COMPANY NEEDS TO OWN UP TO THEIR RISKY PRODUCT!
NHTSA ODI #11165490
24,000 miles · May 5, 2015
Structure
TL* THE CONTACT OWNS A 2014 HYUNDAI ELANTRA. WHILE DRIVING APPROXIMATELY 60 MPH, A LOUD POPPING NOISE EMITTED INSIDE THE VEHICLE. THE INTERIOR CEILING CROSS MEMBERS WERE VISIBLE. IN ADDITION, THE FRONT DRIVER SIDE DOOR EXHIBITED A CREASE NEAR THE WINDOW GLASS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIF…
Read full complaint
TL* THE CONTACT OWNS A 2014 HYUNDAI ELANTRA. WHILE DRIVING APPROXIMATELY 60 MPH, A LOUD POPPING NOISE EMITTED INSIDE THE VEHICLE. THE INTERIOR CEILING CROSS MEMBERS WERE VISIBLE. IN ADDITION, THE FRONT DRIVER SIDE DOOR EXHIBITED A CREASE NEAR THE WINDOW GLASS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 24,000.
NHTSA ODI #10714625
200 miles · May 1, 2014
StructureTires
HYUNDAI VEHICLES DO NOT COME WITH A SPARE TIRE. INSTEAD YOU GET AN AIR COMPRESSOR AND FIX A FLAT. THIS IS A SAFETY CONCERN AS TIRE DAMAGE THAT CAN NOT BE SEALED WITH FIX A FLAT LEAVES THE DRIVER STRANDED, UNABLE TO PUT ON A SPARE TIRE AND GO. THIS PRESENTS A SAFETY HAZARD AS IT LEAVES DRIVERS STRANDED ON THE ROAD. THIS SHOUL…
Read full complaint
HYUNDAI VEHICLES DO NOT COME WITH A SPARE TIRE. INSTEAD YOU GET AN AIR COMPRESSOR AND FIX A FLAT. THIS IS A SAFETY CONCERN AS TIRE DAMAGE THAT CAN NOT BE SEALED WITH FIX A FLAT LEAVES THE DRIVER STRANDED, UNABLE TO PUT ON A SPARE TIRE AND GO. THIS PRESENTS A SAFETY HAZARD AS IT LEAVES DRIVERS STRANDED ON THE ROAD. THIS SHOULD NOT BE ALLOWED. *TR
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
Hyundai Motor Company (Hyundai) is recalling certain 2013-2014 Elantra sedan, coupe and GT vehicles. The brake pedal stopper pad can deteriorate allowing the brake light switch plunger to remain extended when the brake pedal is released. This will allow the brake lights to remain illuminated continuously. It can also allow the shift lever to be moved without depressing the brake pedal, or activate the engine management brake pedal override feature.
Consequence & remedy
Consequence: If the brake light switch plunger does not retract as it should when the brake pedal is not being pressed, the brake lights may stay illuminated preventing accurate communication to following vehicles that the vehicle is slowing or stopping. Additionally, if the brake switch plunger is not retracted, then the transmission can be shifted out of PARK without depressing the brake pedal. Either condition increases the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the brake pedal stopper pad, free of charge. The recall is expected to begin February 8, 2018. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 170. This campaign expands recall 16V574.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
Illustration