NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,200 reports91,274 miles · Jul 24, 2004
Power Train
THE TRANSMISSION ON MY 1998 ACCORD IS SLIPPING BETWEEN GEARS. IT HESITATES WHEN ACCELERATING AND SOMETIMES ACCELERATES AND DECELERATES WITHOUT NOTICE. THE CAR HAS 90,000 MILES ON IT AND HAS BEEN SCRUPULOUSLY MAINTAINED ACCORDING TO THE MANUFACTURER'S MAINTENANCE SCHEDULE. THE TRANSMISSION IS SUPPOSED TO LAST AT LEAST 120,000 MIL…
Read full complaint
THE TRANSMISSION ON MY 1998 ACCORD IS SLIPPING BETWEEN GEARS. IT HESITATES WHEN ACCELERATING AND SOMETIMES ACCELERATES AND DECELERATES WITHOUT NOTICE. THE CAR HAS 90,000 MILES ON IT AND HAS BEEN SCRUPULOUSLY MAINTAINED ACCORDING TO THE MANUFACTURER'S MAINTENANCE SCHEDULE. THE TRANSMISSION IS SUPPOSED TO LAST AT LEAST 120,000 MILES, BUT I HAVE RESEARCHED THE PROBLEM ON THE INTERNET AND FOUND MANY REFERENCES TO DEFECTIVE TRANSMISSIONS ON LATE MODEL HONDAS THAT HAVE FAILED WITH EVEN VERY LOW MILEAGE. REPLACEMENT IS COSTING OWNERS UPWARDS OF $4,000 AND HONDA IS EXTENDING THE WARRANTY ON ONLY A LIMITED NUMBER OF MODELS AND YEARS, ALTHOUGH THE SAME TRANSMISSION IS IN MANY OF ITS OTHER CARS. MY MECHANIC IS RECOMMENDING A COMPLETE REPLACEMENT. I AM AFRAID TO DRIVE THE CAR FOR FEAR IT WLLL FAIL ON THE FREEWAY AND CAUSE AN ACCIDENT.*AK
NHTSA ODI #10082564
Mileage unknown · Jul 19, 2004
Seats
PROBLEM INVOLVING BROKEN SEAT RAILS ON 1998 HONDA ACCORD.*MR THE CONSUMER FOUND A RECALL THROUGH A HONDA SERVICE UPDATE 03-034 CONCERNING SEAT LINKAGE ASSEMBLY. THE PROBLEM THAT THE UPDATE INDICATED WAS THE SAME TYPE OF FAILURE THAT THE CONSUMER'S CAR EXHIBITED. THE CONSUMER WAS TOLD THAT ALTHOUGH HIS VEHICLE WAS BUILT BETWEE…
Read full complaint
PROBLEM INVOLVING BROKEN SEAT RAILS ON 1998 HONDA ACCORD.*MR THE CONSUMER FOUND A RECALL THROUGH A HONDA SERVICE UPDATE 03-034 CONCERNING SEAT LINKAGE ASSEMBLY. THE PROBLEM THAT THE UPDATE INDICATED WAS THE SAME TYPE OF FAILURE THAT THE CONSUMER'S CAR EXHIBITED. THE CONSUMER WAS TOLD THAT ALTHOUGH HIS VEHICLE WAS BUILT BETWEEN THE DATES GIVEN THAT HIS VEHICLE WAS NOT INCLUDED IN THE SERVICE UPDATE DUE TO VIN. THE CONSUMER CONTACTED THAT MANUFACTURER FOR ASSISTANCE BUT THEY WERE UNWILLING TO PROVIDE ANY FINANCIAL ASSISTANCE. *NM
NHTSA ODI #10083367
104,000 miles · Jul 16, 2004
Power Train
I HAVE A 1998 HONDA ACCORD V6 COUPE WITH 108,000 MILES. UPON REACHING AROUND 104,000 MILES, THE TRANSMISSION SHIFTED ABRUPTLY AT LOWER GEARS. HAD IT FLUSHED AND THE PROBLEM SOMEWHAT WENT AWAY BUT THE PROBLEM CAME BACK AFTER 2 WEEKS. THE ABRUPT SHIFTING IS MORE PRONOUNCED WHEN I GET STUCK IN A STOP AND GO TRAFFIC. IT DOESN'T DO T…
Read full complaint
I HAVE A 1998 HONDA ACCORD V6 COUPE WITH 108,000 MILES. UPON REACHING AROUND 104,000 MILES, THE TRANSMISSION SHIFTED ABRUPTLY AT LOWER GEARS. HAD IT FLUSHED AND THE PROBLEM SOMEWHAT WENT AWAY BUT THE PROBLEM CAME BACK AFTER 2 WEEKS. THE ABRUPT SHIFTING IS MORE PRONOUNCED WHEN I GET STUCK IN A STOP AND GO TRAFFIC. IT DOESN'T DO THAT WHEN IT'S RAN COLD LIKE IN THE MORNING. I'M TAKING IT IN TO THE DEALER FOR COMPUTER DIAGNOSTICS. I'M AFRAID THEY WILL TELL ME THAT I NEED A NEW OR REBUILT TRANSMISSION.*AK
NHTSA ODI #10081203
Mileage unknown · Jul 15, 2004
Electrical System
AFTER THE IGNITION SWITCH REPAIR WAS PERFORMED NHTSA RECALL #03V423000. THE CAR WAS IN WORSE SHAPE THAN IT WAS BEFORE. HONDA REFUSED TO REPAIR THE CAR, DESPITE THE FACT THAT THE VEHICLE WAS FINE WHEN IT WAS BROUGHT INTO THE DEALERSHIP. *JB
NHTSA ODI #10082035
Mileage unknown · Jul 9, 2004
Power Train
1. VEHICLE WAS SHIFTING VERY HARD, CLUNKING IN TO GEAR, AND NOT WANTING TO GO INTO GEAR. 2. DEALER DETERMINED FAILURE TO BE THE TRANSMISSION 3. WILL REQUIRE COMPLETE REPLACEMENT OF THE TRANSMISSION. *AK
NHTSA ODI #10080669
Mileage unknown · Jul 8, 2004
Electrical System
1998 HONDA ACCORD WAS TURNED OFF AND KEY REMOVED WHILE VEHICLE WAS IN DRIVE. AFTER LEAVING THE CAR, IT ROLLED BACKWARDS INTO A GUARDRAIL, CAUSING DAMAGE TO LEFT REAR BUMPER AND LEFT REAR PANEL. THIS OCCURRED ON 2/11/04. TWO DAYS LATER WE RECEIVED RECALL NOTICE FROM HONDA ACKNOWLEDGING IGNITION FAILURES THAT COULD POTENTIALLY CAU…
Read full complaint
1998 HONDA ACCORD WAS TURNED OFF AND KEY REMOVED WHILE VEHICLE WAS IN DRIVE. AFTER LEAVING THE CAR, IT ROLLED BACKWARDS INTO A GUARDRAIL, CAUSING DAMAGE TO LEFT REAR BUMPER AND LEFT REAR PANEL. THIS OCCURRED ON 2/11/04. TWO DAYS LATER WE RECEIVED RECALL NOTICE FROM HONDA ACKNOWLEDGING IGNITION FAILURES THAT COULD POTENTIALLY CAUSE SUCH INCIDENTS. WE HAVE CONTACTED HONDA AND THEY ARE "DRAGGING THEIR HEELS" TO TAKE RESPONSIBILITY FOR THE COSTS TO HAVE THIS REPAIRED.*AK
NHTSA ODI #10080615
Mileage unknown · Jul 7, 2004
Tires
IN MARCH, 2003, I PURCHASED A 'USED' 1998 HONDA ACCORD, (EX), FROM ROSNER TOYOTA,3507 JEFFERSON DAVIS HWY, FREDERICKSBURG, VA 22408, 540-898-7900. THIS WAS A "LEASE" CAR THAT WAS TURNED IN FOR A TRADE.*AK THE CAR WAS HANDLING POORLY DURING THE WINTER OF 2003-2004. I WENT TO MY REGULAR AUTO REPAIR SHOP WHICH IS EXPRESS AUTO SE…
Read full complaint
IN MARCH, 2003, I PURCHASED A 'USED' 1998 HONDA ACCORD, (EX), FROM ROSNER TOYOTA,3507 JEFFERSON DAVIS HWY, FREDERICKSBURG, VA 22408, 540-898-7900. THIS WAS A "LEASE" CAR THAT WAS TURNED IN FOR A TRADE.*AK THE CAR WAS HANDLING POORLY DURING THE WINTER OF 2003-2004. I WENT TO MY REGULAR AUTO REPAIR SHOP WHICH IS EXPRESS AUTO SERVICES, 2101 JEFERSON DAVIS HWY, FREDERICKSBURG, VA 22401, 540-372-4422, SERVICE ATTENDANT-BRIAN. I WAS INFORMED BY BRIAN THAT THE TIRES THAT WERE MOUNTED ON THE CAR WERE ILLEGAL. THE TIRES WERE "WARRIOR' WITH A "T" SPEED RATING. THE MANUFACTURES RATING WAS A "V" SPEED RATING. I WAS ALSO INFORMED BY THE VIRGINIA STATE POLICE THAT THESE TIRES WERE IN FACT ILLEGAL, & IF I WERE IN AN ACCIDENT OR PULLED OVER FOR A MOVING VIOLATION, I WOULD BE CITED FOR "ILLEGAL EQUIPMENT." THE COMPLAINT IS CONCERNING THE TIRES. I HAD TO REPLACE THE (4) TIRES. I PURCHASED (4) MICHELIN TIRES FROM EXPRESS AUTO SERVICE, AT A TOTAL COST OF $545.58. NOTE: EXPRESS AUTO MADE A NOTATION ON THE INVOICE THAT THE TIRES WERE INCORRECT & THEY HAVE DIGITAL PICTURES OF THE OLD TIRES. I HAD COMMUNICATED MY CONCERNS WITH TOYOTA CORPORATE & THEY INFORMED ME THAT I WOULD HAVE TO STATE MY COMPLAINT TO THE DEALERSHIP, WHICH IS ROSNER TOYOTA. I RECEIVED A CALL FROM THE CUSTOMER SERVICE MANAGER OF ROSNER, (MIKE), WHO INFORMED ME THAT THEY WOULD PAY 1/2 OF THE THE CHARGES FOR THE TIRES. I TOLD THEM THAT THIS WAS UNACCEPTABLE. I WANTED TOTAL REIMBURSEMENT FOR ALL OF THE TIRES AND HE REFUSED. I TRIED TO GET TOYOTA CORP TO INTERVENE, BUT THEY STATE THAT THEY DO NOT INTERFERE WITH THIER DEALERSHIPS. I ALSO TRIED TO GET IN TOUCH WITH THE GENERAL MANAGER OF THE DEALERSHIP, BUT I AM TOLD THAT HE "IS NOT AVAILABLE". I WAS INFORMED BY THE VIRGINIA STATE POLICE TO FILE A COMPLAINT WITH YOU. THEREFORE, PLEASE LET ME KNOW IF YOU CAN ASSIST ME IN THIS MATTER. THE ONLY OTHER RECOURSE I HAVE IS TO GILE A CLAIM IN 'SMALL CLAIMS " COURT IN THE CITY OF FREDERICKSBURG, VA.
NHTSA ODI #10080499
81,000 miles · Jun 30, 2004
Electrical System
HORN WORKS ONLY ON RARE OCCASIONS, PRIMARILY WHEN WHEEL IS TURNED SHARPLY TO EITHER DIRECTION. DEALER HAS STATED THAT THIS IS A KNOWN PROBLEM, BUT IT WILL TAKE SEVERAL HUNDRED DOLLARS TO FIX, WHICH INCLUDES REPLACING PART OF THE DRIVER AIR BAG ASSEMBLY. OVER TIME, THE PROBLEM HAS WORSENED, AND DEALER SAYS IT IT LIKELY THE HORN W…
Read full complaint
HORN WORKS ONLY ON RARE OCCASIONS, PRIMARILY WHEN WHEEL IS TURNED SHARPLY TO EITHER DIRECTION. DEALER HAS STATED THAT THIS IS A KNOWN PROBLEM, BUT IT WILL TAKE SEVERAL HUNDRED DOLLARS TO FIX, WHICH INCLUDES REPLACING PART OF THE DRIVER AIR BAG ASSEMBLY. OVER TIME, THE PROBLEM HAS WORSENED, AND DEALER SAYS IT IT LIKELY THE HORN WILL EVENTUALLY FAIL COMPLETELY.*AK DUE TO FINANCIAL DIFFICULTIES, I DO NOT HAVE THE MONEY TO FIX, THUS I NO LONGER HAVE A WORKING HORN. I AM CONCERNED THAT THE AIR BAG MAY ALSO FAIL IN AN ACCIDENT. I NOTICE THAT THERE HAVE BEEN AT LEAST 5 OTHER COMPLAINTS ABOUT THIS PROBLEM, YET NO INVESTIGATION OR RECALL HAS BEEN INITIATED. THIS IS A SERIOUS AND KNOWN SAFETY DEFECT WHICH NEEDS TO BE ADDRESSED. MANY OWNERS OF THESE CARS MAY HAVE NON-WORKING HORNS AND NOT EVEN REALIZE IT UNTIL IT IS TOO LATE.
NHTSA ODI #10079088
80,000 miles · Jun 28, 2004
Power Train
I HAVE A 1998 HONDA ACCORD V6. THE TRANSMISSION SHIFTS REALLY HARD. HAD IT FLUSHED BUT THE PROBLEM STILL EXIST. THE SERVICE MANAGER AT THE DEALER TOLD ME THEY HAVE "A FEW" CAR WITH THE SAME PROBLEM. I WENT ONLINE AND FOUND THAT MANY PEOPLE HAVE THE SAME PROBLEM. IT SEEMS LIKE A BAD DESIGN TO ME. *AK
NHTSA ODI #10078939
43,456 miles · Jun 23, 2004
Air BagsVehicle Speed ControlCrash
WHILE PULLING INSIDE OF A PARKING LOT, THE VEHICLE SURGED FORWARD. THE CONSUMER APPLIED THE BRAKES, THE VEHICLE CONTINUED TO SPEED, AND CRASHED INTO A BRICK WALL. UPON IMPACT, BOTH AIR BAGS DEPLOYED. *AK *SC
NHTSA ODI #10071479
Official recalls
6Jan 17, 2020
Honda (American Honda Motor Co.) is recalling certain 1998 Acura 2.2CL, 1998-1999 Acura 2.3CL, 1998-1999 Acura 3.0CL, 2001 Acura 3.2CL and Acura MDX, 1998-2000 Honda Accord Coupe, Accord Sedan, Civic Sedan, Odyssey and Acura 3.5RL, 1999-2000 Acura 3.2TL, 1996-2000 Civic Coupe, 1997-2000 CR-V, 1997-1998 EV Plus, and 1998-1999 Isuzu Oasis vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the driver frontal air bag inflator, and replace it if necessary, with an inflator of a different design, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138 or Isuzu customer service at 1-800-255-6727.
Oct 27, 2003
ON CERTAIN PASSENGER VEHICLES AND MINI VANS, THE IGNITION SWITCH MAY WEAR EXCESSIVELY AND PREVENT PROPER INTERLOCK OPERATION, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO "PARK."
Consequence & remedy
Consequence: IF THE VEHICLE OPERATOR DOES NOT SHIFT TO "PARK" BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT DETERMINES THE AMOUNT OF CYLINDER BODY WEAR. IF SIGNIFICANT WEAR IS INDICATED, THE DEALER WILL REPLACE THE CYLINDER BODY, COLLAR, AND LATCH PLATE. IF NO SIGNS OF WEAR ARE INDICATED, DEALERS WILL REPLACE THE LATCH PLATE WITH A REDESIGNED PART. OWNER NOTIFICATION BEGAN DECEMBER 8, 2003. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
May 16, 2002
ON CERTAIN SEDANS, COUPES, HATCHBACKS, AND SPORT UTILITY VEHICLES, ELECTRICAL CONTACTS IN THE IGNITION SWITCH CAN DEGRADE DUE TO THE HIGH ELECTRICAL CURRENT PASSING THROUGH THE SWITCH WHEN THE VEHICLE IS STARTED.
Consequence & remedy
Consequence: WORN CONTACTS COULD CAUSE THE ENGINE TO STALL WITHOUT WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN JUNE 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
May 10, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES WERE MANUFACTURED WITH BALL JOINTS THAT CAN PREMATURELY WEAR OUT AND, IN THE WORSE CASE, THE BALL JOINT WOULD SEPARATE CAUSING THE FRONT SUSPENSION TO COLLAPSE.
Consequence & remedy
Consequence: THIS CONDITION WOULD RESULT IN VEHICLE DECELERATION AND A SUDDEN LOSS OF POWER. ALSO STEERING CONTROLLABILITY WOULD BE REDUCED.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS.
Feb 10, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES (HONDA ACCORD SEDANS MANUFACTURED FROM SEPTEMBER 18, 1997 TO JANUARY 10, 1998; COUPES MANUFACTURED DECEMBER 11, DECEMBER 15, 1997, AND JANUARY 5, 1998; ACURA 2.3CL MANUFACTURED OCTOBER 22, 1997 THROUGH JANUARY 7, 1998). DURING MANUFACTURING, THE CASTING DIE CAUSED AN IRREGULARITY IN THE RIGHT-SIDE TRANSMISSION COVER. THIS IRREGULARITY CAN LIMIT THE MOVEMENT OF THE PARKING PAWL ACTUATION LEVEL AND PREVENT ADEQUATE ENGAGEMENT OF THE PARKING GEAR PAWL. THIS DOES NOT COMPLY WITH FMVS NO. 114, "THEFT PROTECTION."
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE VEHICLE TO ROLL DOWN AN INCLINE WHEN THE TRANSMISSION IS LOCKED IN "PARK," INCREASING THE RISK OF PERSONAL INJURY AND/OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A COLLAR ON THE TRANSMISSION PARKING PAWL TO ENSURE PROPER MOVEMENT OF THE ACTUATION LEVER.
Dec 16, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONT PASSENGER SEAT BELT RETRACTOR MOUNTING BRACKET WAS IMPROPERLY WELDED.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE BRACKET TO SEPARATE FROM THE VEHICLE BODY IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPAIR THESE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA03017 · IGNITION-PARK Interlock
Opened Sep 9, 2003 · Closed Dec 17, 2003
Status: closed (inferred from source dates) · Electrical System:ignition:switch; Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Additional source detail variants (2)
Electrical System:ignition:switch
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
PE03014 · IGNITION-PARK Interlock System
Opened Apr 15, 2003 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF THE MANUFACTURER COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE NOTED INJURY OCCURRED WHEN A ROLLAWAY VEHICLE THAT HAD BEEN INADVERTENTLY PARKED IN NEUTRAL STRUCK THE EXITING OPERATOR.THE WARRANTY CLAIM COUNT SHOWN FOR OTHER REPRESENTS INCIDENTS WHERE HONDA'S ANALYSIS OF CLAIM DETAIL INDICATES THE INTERLOCK SYSTEM MALFUNCTIONED.THE INTERLOCK SYSTEM UTILIZES A LEVER TO BLOCK IGNITION KEY REMOVAL WHEN THE TRANSMISSION IS NOT IN PARK.HONDA HAS IDENTIFIED A WEAR CONDITION OF THE INTERLOCK LEVER THAT CAN CAUSE THE SYSTEM TO MALFUNCTION; WHEN WEAR OCCURS THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE SHIFTER IS IN A NON-PARK POSITION.HONDA DOCUMENTS INDICATE THAT A MANUFACTURING PROCESS MAY BE THE CAUSE OF INTERLOCK LEVER WEAR, AND THAT THIS PROCESS WAS REVISED IN JANUARY OF 2001.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER INVESTIGATE THIS CONCERN AND ITS SCOPE.
PE02072 · Seat Frame Bracket Failure
Opened Oct 2, 2002 · Closed Mar 28, 2003
Status: closed (inferred from source dates) · Seats
THIS PE WAS OPENED BASED ON 10 CONSUMER COMPLAINTS IN THE ODI DATABASE ALLEGING THAT THE POWER ASSISTED SEATS WERE FAILING IN CERTAIN 1998-2002 HONDA ACCORD VEHICLES.FAILURES ARE CONCENTRATED IN THE 1998-99 MODEL YEAR VEHICLES.THE BRACKET THAT ATTACHES THE SEAT BOTTOM TO THE SEAT BASE IS FRACTURING DUE TO: 1-THE WELD CONDITION OF BRACKET, 2-THE DRIVERS WEIGHT, AND 3-THE IMPACT ON THE SEAT WHEN THE DRIVER ENTERS THE VEHICLE AND SITS DOWN.OVER TIME THE BRACKET THAT ATTACHES THE SEAT MAY FAIL AT THE LEFT FRONT CORNER OF THE SEAT BOTTOM.THE OTHER 3 POINTS OF ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BASE STAY ATTACHED AND THE SEAT MOVEMENT IS LIMITED.THE ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BACK DOES NOT FAIL.THE CONDITION IS MOST APPARENT DURING RAPID ACCELERATION CAUSING THE SEAT TO TILT REARWARD.ALTHOUGH A FEW COMPLAINTS REPORT CONCERN OVER LOSS OF VEHICLE CONTROL, NO LOSS OF CONTROL INCIDENTS, CRASHES OR INJURIES ARE REPORTED.IN RESPONSE TO CUSTOMER COMPLAINTS, HONDA WILL PROVIDE OWNERS OF 1998 AND SOME 1999 ACCORDS A NO-COST REINFORCEMENT FOR THE SEAT AT THE LEFT FRONT CORNER.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration