NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
29 reportsClear category filter100,000 miles · Jan 31, 2021
Air BagsElectrical SystemSteeringCrashInjury
I WAS IN A BAD ACCIDENT I WAS IN THE FAR RIGHT LANE ON THE HIGHWAY I'M GOING 55MPH SOMEONE JUMPED IN FRONT OF ME I USED MY BREAKS THEN MY CAR JERKED RIGHT INTO THE OTHER PERSON CAR CAUSING MY CAR TO SPIN AROUND 2 TIME ON A 6 LANE HIGHWAY . THE AIRBAG NEVER DEPLOYED THE STARING WHEEL WAS NOT TURNING LOTS OF FLUIDS LEAKING …
Read full complaint
I WAS IN A BAD ACCIDENT I WAS IN THE FAR RIGHT LANE ON THE HIGHWAY I'M GOING 55MPH SOMEONE JUMPED IN FRONT OF ME I USED MY BREAKS THEN MY CAR JERKED RIGHT INTO THE OTHER PERSON CAR CAUSING MY CAR TO SPIN AROUND 2 TIME ON A 6 LANE HIGHWAY . THE AIRBAG NEVER DEPLOYED THE STARING WHEEL WAS NOT TURNING LOTS OF FLUIDS LEAKING OUT OF IT BUT IT WAS ALWAYS JERKING FOR SOME REASON EVEN WHEN THE MECHANIC SAYS THAT'S NATURAL..
NHTSA ODI #11390856
125,000 miles · Jul 23, 2015
Service BrakesSteeringWheels
WHILE I WAS CHANGING THE PASSENGER SIDE DRIVE AXLE OF A BROKEN CV JOINT BOOT LAST YEAR (JULY 2014), I NOTICED THAT THE SUBFRAME HAD RUSTED OUT (ABOUT 60% CAME THROUGH AND OFF WHEN I PUNCHED THE AREA WITH A SCREW DRIVER) WHERE THE STABILIZING BAR BRACKET AND LOWER CONTROL ARM PIVOT ARE MOUNTED TO THE FRAME. THE PROBLEM AREA OF TH…
Read full complaint
WHILE I WAS CHANGING THE PASSENGER SIDE DRIVE AXLE OF A BROKEN CV JOINT BOOT LAST YEAR (JULY 2014), I NOTICED THAT THE SUBFRAME HAD RUSTED OUT (ABOUT 60% CAME THROUGH AND OFF WHEN I PUNCHED THE AREA WITH A SCREW DRIVER) WHERE THE STABILIZING BAR BRACKET AND LOWER CONTROL ARM PIVOT ARE MOUNTED TO THE FRAME. THE PROBLEM AREA OF THE SUBFRAME IS RIGHT UNDER THE DRAIN HOLE FOR THE A/C EVAPORATOR. THE SUBFRAME TO THE DRIVER SIDE IS CLEAN AND HAS NO RUST ISSUE. THE LOCATION OF THE RUST AREA SUGGESTS THAT IT MAY BE RELATED TO THE DRAIN HOLE OF THE A/C SYSTEM OR/AND SOMETHING SIMILAR (SUCH AS RAIN) THAT HAD LED TO WATER STAYING IN THE AREA. THE RUST IS GETTING WORSE OVER TIME. I CHECKED IT TODAY (JULY 23, 2015) AFTER NOTICING YELLOWISH DRIPPING MARKS LEFT ON THE DRIVER WAY. MY WIFE DROVE THE CAR THE DAY BEFORE WHEN THERE WAS A HEAVY RAIN. THE CAR WAS PARKED ON THE DRIVE WAY (UP HILL ABOUT 15 DEGREES) OVER NIGHT. WHEN SHE PULLED THE CAR OUT OF THE DRIVE WAY THE NEXT DAY, WE SAW YELLOWISH WATER DRIPPING FROM UNDER THE CAR. SO, I LOOKED AT THE AREA. FOR SURE, IT'S GETTING WORSE THAN LAST YEAR. I PUNCHED AROUND AND GOT ABOUT A COUPLE OF SPOONFULS OF RUST OFF THE FRAME. I USED MY PRY BAR TO PRY AROUND THE AREA AND I CAN SEE THAT THE FRAME IS GETTING VERY WEAK. NOW I CAN SEE THE RUST IS PROGRESSING OVER TIME. AS THE AREA IS GETTING MORE RUSTED, THE STRUCTURE IS LOSING ITS STRENGTH. THE LOWER CONTROL ARM AND/OR THE STABILIZING BAR WILL COME OFF THE FRAME, CAUSING DISASTER ON THE ROAD. I SEARCHED THE INERNET ON THE ISSUE ("HONDA ACCORD SUBFRAME RUST"). THE ISSUE SEEMS VERY COMMON. THERE MUST BE A DESIGN FLAW (A/C DRAIN OR RAIN WATER) WITH THE CAR. IT SEEMS THAT THE ISSUE HAD NOT BEEN UNDERSTOOD AND TAKEN CARE OF BY HONDA. I AM URGING SOMEBODY LOOKING INTO THE ISSUE AND HAVE HONDA DO SOMETHING ABOUT IT BEFORE IT'S TOO LATE. THANKS.
NHTSA ODI #10736167
116,000 miles · Jul 8, 2015
Electrical SystemService BrakesSteering
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. WHILE DRIVING AT 40 MPH, THE VEHICLE STARTED TO SLOW DOWN AND THEN STALLED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE BRAKES FAILED AND THE STEERING WOULD NOT TURN. THE VEHICLE WAS RESTARTED, BUT THE FAILURE RECURRED. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD, WHERE AN INDEPEND…
Read full complaint
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. WHILE DRIVING AT 40 MPH, THE VEHICLE STARTED TO SLOW DOWN AND THEN STALLED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE BRAKES FAILED AND THE STEERING WOULD NOT TURN. THE VEHICLE WAS RESTARTED, BUT THE FAILURE RECURRED. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD, WHERE AN INDEPENDENT MECHANIC DIAGNOSED THAT THE IGNITION SWITCH WAS DEFECTIVE. THE VEHICLE WAS THEN TAKEN TO A DEALER, WHO DIAGNOSED THAT THE FAILURE WAS DUE TO A FAULTY WIRE HARNESS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 116,000.
NHTSA ODI #10732721
160,000 miles · Mar 21, 2015
SteeringStructureSuspension
HTTP://WWW.NEWSNET5.COM/NEWS/LOCAL-NEWS/INVESTIGATIONS/CENTER-FOR-AUTO-SAFETY-REQUESTING-RECALL-OF-1-5-MILLION-HONDA-ACCORDS-FOR-RUST-ISSUE-IN-SUB-FRAME. THIS IS WHAT HAPPENED
NHTSA ODI #10700888
192,000 miles · Nov 27, 2014
SteeringStructureSuspension
HEARD CLUNKING NOISE WHILE TURNING. FIGURED IT WAS A CV JOINT, TOOK IT TO MY VERY TRUSTED MECHANIC. HE CONFIRMED THE RIGHT JOINT WAS BAD, AND SAID THAT ON THE LEFT JOINT, THE BOOT WAS ALREADY OFF, AND IT IS SLINGING GREASE EVERYWHERE. MORE DISTURBING, HE ALSO SAID THAT THE FRONT SUBFRAME IS DANGEROUSLY RUSTED OUT. HE SPECIFI…
Read full complaint
HEARD CLUNKING NOISE WHILE TURNING. FIGURED IT WAS A CV JOINT, TOOK IT TO MY VERY TRUSTED MECHANIC. HE CONFIRMED THE RIGHT JOINT WAS BAD, AND SAID THAT ON THE LEFT JOINT, THE BOOT WAS ALREADY OFF, AND IT IS SLINGING GREASE EVERYWHERE. MORE DISTURBING, HE ALSO SAID THAT THE FRONT SUBFRAME IS DANGEROUSLY RUSTED OUT. HE SPECIFICALLY MENTIONED THAT THE "CRADLE", WHICH HOLDS UP THE FRONT OF THE ENGINE IS ALMOST COMPLETELY RUSTED THROUGH. HE SAID "YOU ARE ONE POT-HOLE AWAY FROM TOTAL FAILURE...THE ENGINE WILL FALL TO THE GROUND. DO NOT DRIVE IT." I LOOKED ONLINE AND SAW THAT THERE IS A RECALL FOR THE SAME MAKE/MODEL/YEAR, BUT MY CAR FALLS OUTSIDE OF THE COVERED DATES. MY VEHICLE WAS MADE IN DEC 1997, AND THE RECALL ONLY GOES THROUGH AUG 1997. QUITE FRANKLY, GIVEN THAT THE FAILURE MODE IS EXACTLY WHAT IS COVERED BY THE RECALL, I BELIEVE MY CAR SHOULD BE INCLUDED IN THE RECALL. WHILE I RECOGNIZE THAT THE CAR IS OLD, THE FRAME OF A 98 MODEL ACCORD SHOULDN'T CORRODE AND BREAK IN HALF, POTENTIALLY LEADING TO CATASTROPHIC RESULTS. *TR
NHTSA ODI #10661131
146,000 miles · Nov 7, 2014
SteeringStructureSuspension
SUB-FRAME IS RUSTED OUT ON THE PASSENGER SIDE BETWEEN THE CV AXLE AND TIE ROD. *TR
NHTSA ODI #10653242
Mileage unknown · Jul 30, 2014
SteeringStructureSuspension
UPON ROUTINE BRAKE INSPECTION VEHICLE WAS DEEMED UNSAFE TO DRIVE DUE TO PASSENGER SUB FRAME THAT HAS CRACKED DUE TO RUST. SUB FRAME IS CRACKED IN MULTIPLE PLACES. *TR
NHTSA ODI #10617774
173,000 miles · Jul 17, 2014
SteeringStructureSuspension
UPON SERVICING FRONT BRAKES, SAFETY INSPECTION REVEALED ACCELERATED CORROSION OFF THE PASSENGER SIDE SUB FRAME COMPONENT. THE DRIVER SIDE IS SOLID AND INTACT. DEEMED UNSAFE FOR HIGHWAY USE. *TR
NHTSA ODI #10611186
10,000 miles · Jun 25, 2014
Electrical SystemSteeringSuspensionCrashInjury
I HAD CAR ACCIDENT AND TWO DAYS AFTER I HAD PICKED UP CAR FROM BODY SHOP I NOTICE THAT A A NOISE . I CALLED THE INSURANCE AND THE REP. SAID TO TAKE CAR BACK TO SHOP. I DID AND FROM WHAT THE INSURANCE AND WE'RE TOLD THE CAR JUST NEEDED AN ALINGMENT., I REMEMBER HEARING A LOUD HEAVY SOUND ON LEFT FRONT END OF CAR ON PASSENGE…
Read full complaint
I HAD CAR ACCIDENT AND TWO DAYS AFTER I HAD PICKED UP CAR FROM BODY SHOP I NOTICE THAT A A NOISE . I CALLED THE INSURANCE AND THE REP. SAID TO TAKE CAR BACK TO SHOP. I DID AND FROM WHAT THE INSURANCE AND WE'RE TOLD THE CAR JUST NEEDED AN ALINGMENT., I REMEMBER HEARING A LOUD HEAVY SOUND ON LEFT FRONT END OF CAR ON PASSENGER SIDE AND ALL OF THE SUDDEN THE CAR LOOSES CONTROL . I REMEMBERD THE VEHICLE WAS ON ITS ROOF I, FELT ARM GETTING BURN BY FIRE . IT SEEMED THAT THE ROOF OF VEHICLE WAS NOT PROTECTED.AND DID NOT SERVER IT PURPOSE . MY SPEED WAS ABOUT 25 30 MPH . THE LEFT FRONT SIDE AND WHEEL WERE STICKING OUT FROM BODY FRAME OF CAR . THE SAME SIDE WHERE SHOP HAD MADE, REPAIRS AND THE ARM AXEL HAD BEEN REPLACED JUST FEW DAYS BEFORE PER INSURANCE REQUEST . THE INSURANCE HAD USED AND AFTER MARKET IN INVOICE . IF WE CHECK ALL OF THE PARTS THE CAR HAD PUT IN AND THE EXTEND OF THE DAMAGE AND THE WHEEL NOT ALIGN WITH BODY OF CAR ALONG WITH THE LOUD SOUND AND JOLT I FELT COULD ONLY SHOW THE NEGLECT AND THE LACK OF SAFETY . *TR
NHTSA ODI #10605805
98,753 miles · Dec 12, 2013
SteeringStructureSuspension
AFTER HEARING AND FEELING A CRACKING SOUND AND THEN INSPECTING UNDER THE CAR, I NOTICED THAT THE SUBFRAME OF THE CAR WAS RUSTED THRU AND A VISIBLE SEPARATION OF THE SUBFRAME. THE POINT OF THE RUST THRU IS AT THE PASSENGER SIDE REAR CORNER OF THE VEHICLE'S SUBFRAME. THE CAR IS AT THE MECHANIC'S BEING REPAIRED, HE STATED THE C…
Read full complaint
AFTER HEARING AND FEELING A CRACKING SOUND AND THEN INSPECTING UNDER THE CAR, I NOTICED THAT THE SUBFRAME OF THE CAR WAS RUSTED THRU AND A VISIBLE SEPARATION OF THE SUBFRAME. THE POINT OF THE RUST THRU IS AT THE PASSENGER SIDE REAR CORNER OF THE VEHICLE'S SUBFRAME. THE CAR IS AT THE MECHANIC'S BEING REPAIRED, HE STATED THE CAUSE IS THE DRAIN HOSE FOR CONDENSATION FROM THE AC AT THAT LOCATION. THIS CAR HAS BEEN AN EXCELLENT VEHICLE THROUGHOUT. THIS RUST THRU OF THE SUBFRAME COULD HAVE CAUSED A ACCIDENT. *TR
NHTSA ODI #10555895
Official recalls
6Jan 17, 2020
Honda (American Honda Motor Co.) is recalling certain 1998 Acura 2.2CL, 1998-1999 Acura 2.3CL, 1998-1999 Acura 3.0CL, 2001 Acura 3.2CL and Acura MDX, 1998-2000 Honda Accord Coupe, Accord Sedan, Civic Sedan, Odyssey and Acura 3.5RL, 1999-2000 Acura 3.2TL, 1996-2000 Civic Coupe, 1997-2000 CR-V, 1997-1998 EV Plus, and 1998-1999 Isuzu Oasis vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the driver frontal air bag inflator, and replace it if necessary, with an inflator of a different design, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138 or Isuzu customer service at 1-800-255-6727.
Oct 27, 2003
ON CERTAIN PASSENGER VEHICLES AND MINI VANS, THE IGNITION SWITCH MAY WEAR EXCESSIVELY AND PREVENT PROPER INTERLOCK OPERATION, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO "PARK."
Consequence & remedy
Consequence: IF THE VEHICLE OPERATOR DOES NOT SHIFT TO "PARK" BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT DETERMINES THE AMOUNT OF CYLINDER BODY WEAR. IF SIGNIFICANT WEAR IS INDICATED, THE DEALER WILL REPLACE THE CYLINDER BODY, COLLAR, AND LATCH PLATE. IF NO SIGNS OF WEAR ARE INDICATED, DEALERS WILL REPLACE THE LATCH PLATE WITH A REDESIGNED PART. OWNER NOTIFICATION BEGAN DECEMBER 8, 2003. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
May 16, 2002
ON CERTAIN SEDANS, COUPES, HATCHBACKS, AND SPORT UTILITY VEHICLES, ELECTRICAL CONTACTS IN THE IGNITION SWITCH CAN DEGRADE DUE TO THE HIGH ELECTRICAL CURRENT PASSING THROUGH THE SWITCH WHEN THE VEHICLE IS STARTED.
Consequence & remedy
Consequence: WORN CONTACTS COULD CAUSE THE ENGINE TO STALL WITHOUT WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN JUNE 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
May 10, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES WERE MANUFACTURED WITH BALL JOINTS THAT CAN PREMATURELY WEAR OUT AND, IN THE WORSE CASE, THE BALL JOINT WOULD SEPARATE CAUSING THE FRONT SUSPENSION TO COLLAPSE.
Consequence & remedy
Consequence: THIS CONDITION WOULD RESULT IN VEHICLE DECELERATION AND A SUDDEN LOSS OF POWER. ALSO STEERING CONTROLLABILITY WOULD BE REDUCED.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS.
Feb 10, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES (HONDA ACCORD SEDANS MANUFACTURED FROM SEPTEMBER 18, 1997 TO JANUARY 10, 1998; COUPES MANUFACTURED DECEMBER 11, DECEMBER 15, 1997, AND JANUARY 5, 1998; ACURA 2.3CL MANUFACTURED OCTOBER 22, 1997 THROUGH JANUARY 7, 1998). DURING MANUFACTURING, THE CASTING DIE CAUSED AN IRREGULARITY IN THE RIGHT-SIDE TRANSMISSION COVER. THIS IRREGULARITY CAN LIMIT THE MOVEMENT OF THE PARKING PAWL ACTUATION LEVEL AND PREVENT ADEQUATE ENGAGEMENT OF THE PARKING GEAR PAWL. THIS DOES NOT COMPLY WITH FMVS NO. 114, "THEFT PROTECTION."
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE VEHICLE TO ROLL DOWN AN INCLINE WHEN THE TRANSMISSION IS LOCKED IN "PARK," INCREASING THE RISK OF PERSONAL INJURY AND/OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A COLLAR ON THE TRANSMISSION PARKING PAWL TO ENSURE PROPER MOVEMENT OF THE ACTUATION LEVER.
Dec 16, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONT PASSENGER SEAT BELT RETRACTOR MOUNTING BRACKET WAS IMPROPERLY WELDED.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE BRACKET TO SEPARATE FROM THE VEHICLE BODY IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPAIR THESE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA03017 · IGNITION-PARK Interlock
Opened Sep 9, 2003 · Closed Dec 17, 2003
Status: closed (inferred from source dates) · Electrical System:ignition:switch; Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Additional source detail variants (2)
Electrical System:ignition:switch
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
PE03014 · IGNITION-PARK Interlock System
Opened Apr 15, 2003 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF THE MANUFACTURER COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE NOTED INJURY OCCURRED WHEN A ROLLAWAY VEHICLE THAT HAD BEEN INADVERTENTLY PARKED IN NEUTRAL STRUCK THE EXITING OPERATOR.THE WARRANTY CLAIM COUNT SHOWN FOR OTHER REPRESENTS INCIDENTS WHERE HONDA'S ANALYSIS OF CLAIM DETAIL INDICATES THE INTERLOCK SYSTEM MALFUNCTIONED.THE INTERLOCK SYSTEM UTILIZES A LEVER TO BLOCK IGNITION KEY REMOVAL WHEN THE TRANSMISSION IS NOT IN PARK.HONDA HAS IDENTIFIED A WEAR CONDITION OF THE INTERLOCK LEVER THAT CAN CAUSE THE SYSTEM TO MALFUNCTION; WHEN WEAR OCCURS THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE SHIFTER IS IN A NON-PARK POSITION.HONDA DOCUMENTS INDICATE THAT A MANUFACTURING PROCESS MAY BE THE CAUSE OF INTERLOCK LEVER WEAR, AND THAT THIS PROCESS WAS REVISED IN JANUARY OF 2001.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER INVESTIGATE THIS CONCERN AND ITS SCOPE.
PE02072 · Seat Frame Bracket Failure
Opened Oct 2, 2002 · Closed Mar 28, 2003
Status: closed (inferred from source dates) · Seats
THIS PE WAS OPENED BASED ON 10 CONSUMER COMPLAINTS IN THE ODI DATABASE ALLEGING THAT THE POWER ASSISTED SEATS WERE FAILING IN CERTAIN 1998-2002 HONDA ACCORD VEHICLES.FAILURES ARE CONCENTRATED IN THE 1998-99 MODEL YEAR VEHICLES.THE BRACKET THAT ATTACHES THE SEAT BOTTOM TO THE SEAT BASE IS FRACTURING DUE TO: 1-THE WELD CONDITION OF BRACKET, 2-THE DRIVERS WEIGHT, AND 3-THE IMPACT ON THE SEAT WHEN THE DRIVER ENTERS THE VEHICLE AND SITS DOWN.OVER TIME THE BRACKET THAT ATTACHES THE SEAT MAY FAIL AT THE LEFT FRONT CORNER OF THE SEAT BOTTOM.THE OTHER 3 POINTS OF ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BASE STAY ATTACHED AND THE SEAT MOVEMENT IS LIMITED.THE ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BACK DOES NOT FAIL.THE CONDITION IS MOST APPARENT DURING RAPID ACCELERATION CAUSING THE SEAT TO TILT REARWARD.ALTHOUGH A FEW COMPLAINTS REPORT CONCERN OVER LOSS OF VEHICLE CONTROL, NO LOSS OF CONTROL INCIDENTS, CRASHES OR INJURIES ARE REPORTED.IN RESPONSE TO CUSTOMER COMPLAINTS, HONDA WILL PROVIDE OWNERS OF 1998 AND SOME 1999 ACCORDS A NO-COST REINFORCEMENT FOR THE SEAT AT THE LEFT FRONT CORNER.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration