98 HONDA ACCORD TRANSMISSION FAILURE. CAR LUNGES, MISSES GEARS AND NEEDS A REPLACEMENT. CAR HAS LESS THEN 100000 MILES AND IT NEEDS A REBUILD. KNOW OF OTHER PEOPLE WITH EXACT SAME PROBLEM. HONDA KNOWS ITS A PROBLEM AND WILL OFFER TO HELP PAY SOME OF PART COST BUT THAT'S IT. THE TRANSMISSION IS A FLOP AND HONDA SHOULD PAY FOR IT …
Read full complaint
98 HONDA ACCORD TRANSMISSION FAILURE. CAR LUNGES, MISSES GEARS AND NEEDS A REPLACEMENT. CAR HAS LESS THEN 100000 MILES AND IT NEEDS A REBUILD. KNOW OF OTHER PEOPLE WITH EXACT SAME PROBLEM. HONDA KNOWS ITS A PROBLEM AND WILL OFFER TO HELP PAY SOME OF PART COST BUT THAT'S IT. THE TRANSMISSION IS A FLOP AND HONDA SHOULD PAY FOR IT ALL. I WAS LIED TO AND DECEIVED BY HONDA. DEFINITELY FRAUDULENT. *NM
NHTSA ODI #10155440
Mileage unknown · Jan 3, 2006
Power Train
TRANSMISSION SLIPPING DAILY. *JB
NHTSA ODI #10146771
117,000 miles · Dec 3, 2005
Power Train
MY 1998 HONDA ACCORD 2.3L WITH ONLY 117K MILES DEVELOPED TRANSMISSION SHIFTING ISSUES THAT WOULD EITHER LEAVE ME WITHOUT POWER BY SLIPPING OR DROP ME FROM 4TH GEAR SUDDENLY INTO 2ND. THE FIRST TIME THIS HAPPENED I NEARLY RESULTED IN A SERIOUS ACCIDENT AS I WAS TRAVELING ON A FREEWAY AT 65 MPH. HONDA SAYS THERE IS NO RECALL OF …
Read full complaint
MY 1998 HONDA ACCORD 2.3L WITH ONLY 117K MILES DEVELOPED TRANSMISSION SHIFTING ISSUES THAT WOULD EITHER LEAVE ME WITHOUT POWER BY SLIPPING OR DROP ME FROM 4TH GEAR SUDDENLY INTO 2ND. THE FIRST TIME THIS HAPPENED I NEARLY RESULTED IN A SERIOUS ACCIDENT AS I WAS TRAVELING ON A FREEWAY AT 65 MPH. HONDA SAYS THERE IS NO RECALL OF THESE TRANSMISSIONS AND NO EXTENDED WARRANTY BUT THE NUMBER OF REPORTED FAILURES IN 1997 VERSUS 1998 MODELS SHOWS THAT THERE IS CLEARLY A SERIOUS POTENTIAL OF CATASTROPHIC FAILURES INTRODUCED IN 1998. HONDA REFUSED TO FIX THIS AND I HAD TO SPEND THOUSANDS OF DOLLARS TO REBUILD THE TRANSMISSION. *JB
NHTSA ODI #10144375
95,500 miles · Nov 29, 2005
Power Train
TRANSMISSION FAILURE. *NM
NHTSA ODI #10143859
118,000 miles · Oct 25, 2005
Power Train
AUTOMATIC TRANSMISSION FAILURE IN MY HONDA ACCORD EX-V6 COUPE. IT BEGAN TO HESITATE GOING FROM 2ND TO 3RD GEAR WHILE I WAS DRIVING. IT OCCURRED IMMEDIATELY AFTER THE FUSE TO MY RADIO BLEW. WAS TOLD BY HONDA NEEDED NEW TRANSMISSION $3-4K. *NM
NHTSA ODI #10140725
Mileage unknown · Oct 23, 2005
Power Train
I HAVE A 98 HONDA ACCORD AND AROUND 87,000 MILES MY TRANSMISSION WENT OUT. I TOOK IT TO AAMCO TO HAVE IT DIAGNOSED THEY SAID HAD TO REBUILD. $2900.00. AL MONTH LATER I HAD TO TAKE IT BACK FOR MORE TRANSMISSION PROBLEMS THERE WAS A LOUD KNOCKING NOISE IN THE GEAR BOX AND THEY FIXED IT. I TOOK IT BACK TWICE SINCE HAVING TRANNY REB…
Read full complaint
I HAVE A 98 HONDA ACCORD AND AROUND 87,000 MILES MY TRANSMISSION WENT OUT. I TOOK IT TO AAMCO TO HAVE IT DIAGNOSED THEY SAID HAD TO REBUILD. $2900.00. AL MONTH LATER I HAD TO TAKE IT BACK FOR MORE TRANSMISSION PROBLEMS THERE WAS A LOUD KNOCKING NOISE IN THE GEAR BOX AND THEY FIXED IT. I TOOK IT BACK TWICE SINCE HAVING TRANNY REBUILT NOW ITS A YEAR LATER AND THE CAR BEGAN TO SLIP AND JERK AND NOW THERE IS A METAL SCRAPING NOISE COMING FROM THE GEAR BOX WHEN IN GEAR. THIS IS THE 4TH TIME I WILL HAVE TO TAKE IT IN FOR TRANSMISSION PROBLEMS. *NM
NHTSA ODI #10140547
90,000 miles · Oct 17, 2005
Power Train
MY HONDA ACCORD AUTOMATIC TRANSMISSION HAS BEEN ACTING UP, NOT SHIFTING SMOOTHLY, JERKING, ETC. THE DEALER HAS DIAGNOSED IT AS NEEDING REPLACEMENT. THIS WILL COST $4,500.00 THIS IS A LOW MILEAGE CAR I BOUGHT NEW AND THAT HAS BEEN METICULOUSLY MAINTAINED WITH ALL SERVICE INTERVALS DONE BY A QUALIFIED HONDA DEALER (HUGGINS HONDA…
Read full complaint
MY HONDA ACCORD AUTOMATIC TRANSMISSION HAS BEEN ACTING UP, NOT SHIFTING SMOOTHLY, JERKING, ETC. THE DEALER HAS DIAGNOSED IT AS NEEDING REPLACEMENT. THIS WILL COST $4,500.00 THIS IS A LOW MILEAGE CAR I BOUGHT NEW AND THAT HAS BEEN METICULOUSLY MAINTAINED WITH ALL SERVICE INTERVALS DONE BY A QUALIFIED HONDA DEALER (HUGGINS HONDA, NORTH RICHLAND HILLS, TX) AFTER RESEARCHING THIS, I HAVE FOUND NUMEROUS EXACT SAME PROBLEMS AND IT IS OBVIOUS THAT HONDA HAS A SERIOUS MANUFACTURING DEFECT WITH THEIR AUTOMATIC TRANSMISSIONS. I HAVE NOT HAD IT REPAIRED YET BECAUSE I CANNOT AFFORD IT. I HAVE A 20 MILE COMMUTE TO AND FROM WORK EVERY DAY AND I AM CONCERNED THAT THE TRANSMISSION WILL FAIL COMPLETELY WHILE I AM COMMUTING. *JB
NHTSA ODI #10140058
85,960 miles · Aug 19, 2005
Power Train
(1) DRIVING FROM PENNSYLVANIA TO OCEAN CITY,MARYLAND FOR VACATION AND THE CHECK LIGHT CAME ON WHEN WE WERE ALMOST THERE. WE PULLED OVER ON SIDE OF ROAD AND CHECKED FLUIDS AND CAR AND EVERYTHING APPEARED TO BE OKAY UNTIL WE COULD MAKE IT TO GARAGE. STARTED DRIVING AGAIN IN 4TH GEAR AND TRANSMISSION STARTED TO SLIP AND CAR STARTED…
Read full complaint
(1) DRIVING FROM PENNSYLVANIA TO OCEAN CITY,MARYLAND FOR VACATION AND THE CHECK LIGHT CAME ON WHEN WE WERE ALMOST THERE. WE PULLED OVER ON SIDE OF ROAD AND CHECKED FLUIDS AND CAR AND EVERYTHING APPEARED TO BE OKAY UNTIL WE COULD MAKE IT TO GARAGE. STARTED DRIVING AGAIN IN 4TH GEAR AND TRANSMISSION STARTED TO SLIP AND CAR STARTED TO DOWNSHIFT AND RPM'S WENT UP. (2) LET CAR SIT AND THEN TRIED TO DRIVE AGAIN IN 3RD AND 4TH GEARS BUT SAME PROBLEM KEPT OCCURING. THEN WE PUT IT IN 2ND GEAR AND THAT WORKED FINE. WE DROVE IN 2ND GEAR GOING SLOW IN THE MIDDLE OF A PLACE WE DID NOT KNOW AND BARELY MADE IT TO THE BEACH WHERE MY CAR SAT THE WHOLE TIME AND WE COULD NOT DRIVE ANYWHERE. WE HAD TO HAVE THE CAR TOWED FROM OCEAN CITY TO HARRISBURG, PA (ABOUT A 4 HOUR DRIVE) (3) AFTER TALKING WITH A HONDA CERTIFIED TECHNICIAN AND OTHERS WE DETERMINED IT WAS THE TRANMISSION GOING OUT. MY CAR IS STILL SITTING AND I AM TRYING TO FIGURE OUT WHAT I AM GOING TO DO CONSIDERING A NEW TRANSMISSION COSTS 3 TO 4 THOUSAND DOLLARS AS I WAS TOLD BY HONDA. THIS IS GREAT CONSIDERING I HAVE ONLY HAD MY CAR FOR 2 YEARS AND STILL HAVE 3 YEARS TO PAY ON IT AND IT ONLY HAS 86,000 MILES ON IT.
NHTSA ODI #10133511
116,625 miles · Jul 27, 2005
Power Train
THE TRANSMISSION ON MY 1998 HONDA ACCORD V6 STARTED FAILING AT 116K MILES. THE CAR BEGAN MISSING OUT AND THEN LURCHING FORWARD WHEN DRIVING, CREATING A VERY UNSAFE SITUATION. THE TRANSMISSION HAD TO BE REBUILT AT A COST OF $2,200. I HAVE LEARNED THAT THIS IS A VERY COMMON PROBLEM WITH '98 HONDAS, AS WELL AS THE 200 AND 2001 M…
Read full complaint
THE TRANSMISSION ON MY 1998 HONDA ACCORD V6 STARTED FAILING AT 116K MILES. THE CAR BEGAN MISSING OUT AND THEN LURCHING FORWARD WHEN DRIVING, CREATING A VERY UNSAFE SITUATION. THE TRANSMISSION HAD TO BE REBUILT AT A COST OF $2,200. I HAVE LEARNED THAT THIS IS A VERY COMMON PROBLEM WITH '98 HONDAS, AS WELL AS THE 200 AND 2001 MODELS.
NHTSA ODI #10130276
93,000 miles · Jun 22, 2005
Power Train
I HAVE A 1998 HONDA ACCORD V6 WITH 103000 MILES ON IT AND SUSPECTED PROBLEMS WITH THE TRANSMISSION SINCE 93000 MILES. THE TRANSMISSION SLIPS AT 20, 30, AND 40 MPH. I CALLED THE HONDA CORP IN CA AND TOLD THEM MY HONDA ACCORD EX V6 TRANSMISSION WAS HAVING PROBLEM AND THEY TOLD ME TO TAKE IT TO A HONDA DEALER TO CHECK IT BEFORE I C…
Read full complaint
I HAVE A 1998 HONDA ACCORD V6 WITH 103000 MILES ON IT AND SUSPECTED PROBLEMS WITH THE TRANSMISSION SINCE 93000 MILES. THE TRANSMISSION SLIPS AT 20, 30, AND 40 MPH. I CALLED THE HONDA CORP IN CA AND TOLD THEM MY HONDA ACCORD EX V6 TRANSMISSION WAS HAVING PROBLEM AND THEY TOLD ME TO TAKE IT TO A HONDA DEALER TO CHECK IT BEFORE I CAN MAKE A CLAIM ON IT. THE HONDA DEALER LOOKED AT IT SAID I NEED A NEW TRANSMISSION AND THERE WILL BE A $90 FEE. THE DEALER AND I CALLED THE HONDA CORP TO PUT IN A CLAIM AND HE EXPLAINED THAT I HAVE COMPLETED ALL RECOMMENDED MAINTENANCE SCHEDULE AND A DAY LATER THE HONDA CORP CALLED THE DEALER AND DENIED TO ASSIST IN ANY WAY WITH MY CLAIM. I DID NOT EVEN RECEIVE A PHONE CALL BACK FROM THE HONDA CORP. THE DEALER CALLED ME TO TELL ME THE NEWS AND THEY GAVE ME A TRANSMISSION FOR OVER $4200. I CALL THE HONDA CORP AND SPOKE WITH KEVIN BROWN AND HE SAID CAN NOT DO ANYTHING TO HELP AND SORRY YOUR CASE IT CLOSED. HOW IS MY CASE CLOSED ONLY AFTER ONE DAY OF EVALUATION. KEVIN BROWN ALSO SAID THAT THE HONDA CORP HAS ASSISTED OTHER PEOPLE WITH 98 V6 ACCORDS WITH MORE MILES THAN I HAVE, BUT HE SAID THOSE CASES WERE DIFFERENT. HOW ARE OTHER CASES SO DIFFERENT WHEN I HAVE TAKEN GOOD CARE OF MY CAR. AFTER READING OTHER WEBSITES AND FORUMS, I CAN SEE THIS IS A MORE COMMON PROBLEM THEN I THOUGHT AND NOW I HAVE READ OVER 100 COMPLAINTS WITH HONDA ACCORD V6 98 AND 99 TRANSMISSIONS ON THE SITE. SOME ACTION NEEDS TO BE TAKEN NOW!!!!!!!!!*AK THE CONSUMER DISPUTES NHTSA'S ASSESSMENT OF THE 1998 HONDA ACCORDS TRANSMISSION FAILURES. THE CONSUMER FOUND SEVERAL ISSUES WHICH WERE VERY SIMILAR TO HIS VEHICLE. THE CONSUMER REQUESTED A REPLACEMENT TRANSMISSION. *SC *JB
Honda (American Honda Motor Co.) is recalling certain 1998 Acura 2.2CL, 1998-1999 Acura 2.3CL, 1998-1999 Acura 3.0CL, 2001 Acura 3.2CL and Acura MDX, 1998-2000 Honda Accord Coupe, Accord Sedan, Civic Sedan, Odyssey and Acura 3.5RL, 1999-2000 Acura 3.2TL, 1996-2000 Civic Coupe, 1997-2000 CR-V, 1997-1998 EV Plus, and 1998-1999 Isuzu Oasis vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the driver frontal air bag inflator, and replace it if necessary, with an inflator of a different design, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138 or Isuzu customer service at 1-800-255-6727.
ON CERTAIN PASSENGER VEHICLES AND MINI VANS, THE IGNITION SWITCH MAY WEAR EXCESSIVELY AND PREVENT PROPER INTERLOCK OPERATION, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO "PARK."
Consequence & remedy
Consequence: IF THE VEHICLE OPERATOR DOES NOT SHIFT TO "PARK" BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT DETERMINES THE AMOUNT OF CYLINDER BODY WEAR. IF SIGNIFICANT WEAR IS INDICATED, THE DEALER WILL REPLACE THE CYLINDER BODY, COLLAR, AND LATCH PLATE. IF NO SIGNS OF WEAR ARE INDICATED, DEALERS WILL REPLACE THE LATCH PLATE WITH A REDESIGNED PART. OWNER NOTIFICATION BEGAN DECEMBER 8, 2003. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
ON CERTAIN SEDANS, COUPES, HATCHBACKS, AND SPORT UTILITY VEHICLES, ELECTRICAL CONTACTS IN THE IGNITION SWITCH CAN DEGRADE DUE TO THE HIGH ELECTRICAL CURRENT PASSING THROUGH THE SWITCH WHEN THE VEHICLE IS STARTED.
Consequence & remedy
Consequence: WORN CONTACTS COULD CAUSE THE ENGINE TO STALL WITHOUT WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN JUNE 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES WERE MANUFACTURED WITH BALL JOINTS THAT CAN PREMATURELY WEAR OUT AND, IN THE WORSE CASE, THE BALL JOINT WOULD SEPARATE CAUSING THE FRONT SUSPENSION TO COLLAPSE.
Consequence & remedy
Consequence: THIS CONDITION WOULD RESULT IN VEHICLE DECELERATION AND A SUDDEN LOSS OF POWER. ALSO STEERING CONTROLLABILITY WOULD BE REDUCED.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES (HONDA ACCORD SEDANS MANUFACTURED FROM SEPTEMBER 18, 1997 TO JANUARY 10, 1998; COUPES MANUFACTURED DECEMBER 11, DECEMBER 15, 1997, AND JANUARY 5, 1998; ACURA 2.3CL MANUFACTURED OCTOBER 22, 1997 THROUGH JANUARY 7, 1998). DURING MANUFACTURING, THE CASTING DIE CAUSED AN IRREGULARITY IN THE RIGHT-SIDE TRANSMISSION COVER. THIS IRREGULARITY CAN LIMIT THE MOVEMENT OF THE PARKING PAWL ACTUATION LEVEL AND PREVENT ADEQUATE ENGAGEMENT OF THE PARKING GEAR PAWL. THIS DOES NOT COMPLY WITH FMVS NO. 114, "THEFT PROTECTION."
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE VEHICLE TO ROLL DOWN AN INCLINE WHEN THE TRANSMISSION IS LOCKED IN "PARK," INCREASING THE RISK OF PERSONAL INJURY AND/OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A COLLAR ON THE TRANSMISSION PARKING PAWL TO ENSURE PROPER MOVEMENT OF THE ACTUATION LEVER.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONT PASSENGER SEAT BELT RETRACTOR MOUNTING BRACKET WAS IMPROPERLY WELDED.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE BRACKET TO SEPARATE FROM THE VEHICLE BODY IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPAIR THESE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA03017 · IGNITION-PARK Interlock
Opened Sep 9, 2003 · Closed Dec 17, 2003
Status: closed (inferred from source dates) · Electrical System:ignition:switch; Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Additional source detail variants (2)
Electrical System:ignition:switch
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
PE03014 · IGNITION-PARK Interlock System
Opened Apr 15, 2003 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF THE MANUFACTURER COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE NOTED INJURY OCCURRED WHEN A ROLLAWAY VEHICLE THAT HAD BEEN INADVERTENTLY PARKED IN NEUTRAL STRUCK THE EXITING OPERATOR.THE WARRANTY CLAIM COUNT SHOWN FOR OTHER REPRESENTS INCIDENTS WHERE HONDA'S ANALYSIS OF CLAIM DETAIL INDICATES THE INTERLOCK SYSTEM MALFUNCTIONED.THE INTERLOCK SYSTEM UTILIZES A LEVER TO BLOCK IGNITION KEY REMOVAL WHEN THE TRANSMISSION IS NOT IN PARK.HONDA HAS IDENTIFIED A WEAR CONDITION OF THE INTERLOCK LEVER THAT CAN CAUSE THE SYSTEM TO MALFUNCTION; WHEN WEAR OCCURS THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE SHIFTER IS IN A NON-PARK POSITION.HONDA DOCUMENTS INDICATE THAT A MANUFACTURING PROCESS MAY BE THE CAUSE OF INTERLOCK LEVER WEAR, AND THAT THIS PROCESS WAS REVISED IN JANUARY OF 2001.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER INVESTIGATE THIS CONCERN AND ITS SCOPE.
PE02072 · Seat Frame Bracket Failure
Opened Oct 2, 2002 · Closed Mar 28, 2003
Status: closed (inferred from source dates) · Seats
THIS PE WAS OPENED BASED ON 10 CONSUMER COMPLAINTS IN THE ODI DATABASE ALLEGING THAT THE POWER ASSISTED SEATS WERE FAILING IN CERTAIN 1998-2002 HONDA ACCORD VEHICLES.FAILURES ARE CONCENTRATED IN THE 1998-99 MODEL YEAR VEHICLES.THE BRACKET THAT ATTACHES THE SEAT BOTTOM TO THE SEAT BASE IS FRACTURING DUE TO: 1-THE WELD CONDITION OF BRACKET, 2-THE DRIVERS WEIGHT, AND 3-THE IMPACT ON THE SEAT WHEN THE DRIVER ENTERS THE VEHICLE AND SITS DOWN.OVER TIME THE BRACKET THAT ATTACHES THE SEAT MAY FAIL AT THE LEFT FRONT CORNER OF THE SEAT BOTTOM.THE OTHER 3 POINTS OF ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BASE STAY ATTACHED AND THE SEAT MOVEMENT IS LIMITED.THE ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BACK DOES NOT FAIL.THE CONDITION IS MOST APPARENT DURING RAPID ACCELERATION CAUSING THE SEAT TO TILT REARWARD.ALTHOUGH A FEW COMPLAINTS REPORT CONCERN OVER LOSS OF VEHICLE CONTROL, NO LOSS OF CONTROL INCIDENTS, CRASHES OR INJURIES ARE REPORTED.IN RESPONSE TO CUSTOMER COMPLAINTS, HONDA WILL PROVIDE OWNERS OF 1998 AND SOME 1999 ACCORDS A NO-COST REINFORCEMENT FOR THE SEAT AT THE LEFT FRONT CORNER.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration