NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
36 reportsClear category filter238,000 miles · Aug 5, 2014
Fuel System, GasolineStructureSuspension
FAILED CLEAR COAT AND FADED PAINT WERE THE FIRST PROBLEMS TO OCCUR WITH MY SILVER HONDA ACCORD. NEXT WAS THE GAS TANK LEAK, WHERE FUMES AND LEAKED GAS COULD BE SMELLED AND SEEN ON THE GROUND WHEN FILLING THE TANK MORE THAN HALF FULL. FINALLY MY PASSENGER SIDE FRONT SUBFRAME REAR CROSS MEMBER RUSTED THRU AND NOW THE CAR ISN'T SA…
Read full complaint
FAILED CLEAR COAT AND FADED PAINT WERE THE FIRST PROBLEMS TO OCCUR WITH MY SILVER HONDA ACCORD. NEXT WAS THE GAS TANK LEAK, WHERE FUMES AND LEAKED GAS COULD BE SMELLED AND SEEN ON THE GROUND WHEN FILLING THE TANK MORE THAN HALF FULL. FINALLY MY PASSENGER SIDE FRONT SUBFRAME REAR CROSS MEMBER RUSTED THRU AND NOW THE CAR ISN'T SAFE TO DRIVE AND WON'T PASS INSPECTION WITHOUT MAJOR REPAIRS TO THE FRAME. NONE OF THE REST OF THE UNDER BODY IS RUSTED, JUST THAT SECTION. NOT HAPPY! *TR
NHTSA ODI #10618951
163,000 miles · Feb 10, 2014
Fuel System, Gasoline
NOTED EXCESSIVE SMELL OF GASOLINE IN AND IMMEDIATELY OUTSIDE THE VEHICLE, AND LATER DETERMINED GASOLINE MILEAGE HAD DROPPED DRAMATICALLY FROM 30+ MPG TO 18 MPG. UPON SECURING THE FIRST AVAILABLE DIAGNOSTIC CHECK FROM MY LOCAL MECHANIC IT WAS DETERMINED THERE WAS "FUEL LEAKING FROM THE TOP AREA OF FUEL TANK, BUT MANY ITEMS WOULD…
Read full complaint
NOTED EXCESSIVE SMELL OF GASOLINE IN AND IMMEDIATELY OUTSIDE THE VEHICLE, AND LATER DETERMINED GASOLINE MILEAGE HAD DROPPED DRAMATICALLY FROM 30+ MPG TO 18 MPG. UPON SECURING THE FIRST AVAILABLE DIAGNOSTIC CHECK FROM MY LOCAL MECHANIC IT WAS DETERMINED THERE WAS "FUEL LEAKING FROM THE TOP AREA OF FUEL TANK, BUT MANY ITEMS WOULD HAVE TO BE MOVED OUT OF THE WAY TO LOWER THE FUEL TANK TO MAKE A MORE SPECIFIC LOCATION OF THE SITE AND CAUSE OF THE LEAK, WHICH WOULD BE LABOR INTENSIVE AND COSTLY BECAUSE THE ENTIRE REAR CRADLE WOULD HAVE TO BE REMOVED WITH THE DANGER THAT OLD RUSTING BOLTS WOULD BREAK AND MIGHT NOT BE ABLE TO BE REPLACED. POSSIBLE ITEMS THAT MIGHT NEED TO BE REPLACED, INCLUDE THE FUEL TANK, FUEL FILLER NECK AND FUEL PUMP." *TR
NHTSA ODI #10563689
157,800 miles · Jul 20, 2013
Electrical SystemFuel System, GasolineSteering
1998 HONDA ACCORD: VEHICLE LOST POWER SEVERAL TIMES AT HIGHWAY SPEED. MOTOR STOPPED, POWERS STEERING AND BRAKES LOST, GAUGE NEEDLES SPUN TO ZERO, AS IF CAR WAS SHUT OFF AT DURING NORMAL OPERATION. WE DID NOT TOUCH KEY! ALMOST GOT RUN OVER BY CAR BEHIND US. PROBLEM OCCURRED SIX MORE TIMES BEFORE WE COULD GET TO LOCAL HONDA DEALER…
Read full complaint
1998 HONDA ACCORD: VEHICLE LOST POWER SEVERAL TIMES AT HIGHWAY SPEED. MOTOR STOPPED, POWERS STEERING AND BRAKES LOST, GAUGE NEEDLES SPUN TO ZERO, AS IF CAR WAS SHUT OFF AT DURING NORMAL OPERATION. WE DID NOT TOUCH KEY! ALMOST GOT RUN OVER BY CAR BEHIND US. PROBLEM OCCURRED SIX MORE TIMES BEFORE WE COULD GET TO LOCAL HONDA DEALERSHIP. THEY CHARGED ME $186.26 TO REPLACED DEFECTIVE IGNITION SWITCH AND THEY ADVISED THEY FIX A RECALL FOR SWITCH INTERLOCK WHILE CAR WAS IN SHOP FOR FOUR DAYS! WE SENT A LETTER TO HONDA,[XXX] FROM HONDA AMERICA CALIFORNIA CALLED ME TO DECLINE REIMBURSING MY COST! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10525902
Mileage unknown · Mar 17, 2013
Fuel System, GasolineStructure
I HAVE HAD SO MANY CORROSION ISSUES WITH THIS CAR, IT IS STRUCTURALLY DANGEROUS. THE CAR HAS 160,000 MILES ON IT BUT HAS BEEN KEPT IN A GARAGE AND HAS HAD THE UNDER CARRIAGE FREQUENTLY WASHED SINCE I LIVE IN THE NORTHEASTERN US. IN THE LAST 2 YEARS I HAVE HAD TO REPLACE BOTH THE BRAKE AND GAS LINES DO TO CORROSION. THE GAS LI…
Read full complaint
I HAVE HAD SO MANY CORROSION ISSUES WITH THIS CAR, IT IS STRUCTURALLY DANGEROUS. THE CAR HAS 160,000 MILES ON IT BUT HAS BEEN KEPT IN A GARAGE AND HAS HAD THE UNDER CARRIAGE FREQUENTLY WASHED SINCE I LIVE IN THE NORTHEASTERN US. IN THE LAST 2 YEARS I HAVE HAD TO REPLACE BOTH THE BRAKE AND GAS LINES DO TO CORROSION. THE GAS LINE RUPTURED DURING A DRIVE. FORTUNATELY THERE WAS NO FIRE. THE GAS TANK RUSTED THROUGH AND WAS REPLACED. IT WAS LEAKING FOR SOME TIME. THE LEAK WAS NEAR THE HALF WAY MARK AND ONLY LEAKED WHEN OVER HALF FULL AND DURING DRIVING OR GOING UP HILL. FORTUNATELY WE DID NOT HAVE A FIRE. I JUST FOUND OUT THE FRONT SUB FRAME IS COMPLETELY ROTTED OUT AND WILL NOT PASS INSPECTION THIS YEAR. BODY RUST IS MINIMAL AND NORMAL FOR AGE AND THE NORTHEAST WINTERS. THE CLEAR COAT IS PEALING OFF EVERYWHERE. I AM VERY DISAPPOINTED WITH MY FIRST AND PROBABLY ONLY HONDA. LOOKING BACK, I AM VERY LUCKY THAT THE CAR DIDN'T CATCH FIRE AND KILL SOMEONE. *TR
NHTSA ODI #10503371
134,043 miles · Jan 8, 2012
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
THE ENGINE FAILS WHILE DRIVING FOR NO APPARENT REASON. THE CAR IS RUNNING FINE, THEN AT DIFFERENT SPEEDS, THE ENGINE FAILS. ALL BRAKING AND POWER FUNCTIONS FAIL. THIS OCCURS AT DIFFERENT TIMES AND DATES. THERE DOES NOT SEEN TO BE ANY REASON FOR IT. THE ENGINE RUNS FINE WHEN IT IS RE-STARTED. *TR
NHTSA ODI #10442859
119,000 miles · Nov 22, 2011
Fuel System, Gasoline
TL* THE CONTACT OWNS A 1998 HONDA ACCORD LX. THE CONTACT WAS DRIVING 50 MPH WHEN THE CHECK ENGINE LIGHT ILLUMINATED AND THE SMELL OF FUEL EMITTED INSIDE OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 119,000 AND THE CURRENT MILEA…
Read full complaint
TL* THE CONTACT OWNS A 1998 HONDA ACCORD LX. THE CONTACT WAS DRIVING 50 MPH WHEN THE CHECK ENGINE LIGHT ILLUMINATED AND THE SMELL OF FUEL EMITTED INSIDE OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 119,000 AND THE CURRENT MILEAGE WAS 120,000.
NHTSA ODI #10436790
155,000 miles · May 23, 2011
Fuel System, Gasoline
1998 HONDA ACCORD SHUTS OFF BY ITSELF WHILE DRIVING. HAPPENS SPORADICALLY. REPLACED FUEL PUMP, FUEL IGNITER, CAP, ROTOR, PLUGS, WIRES, ETC. NOTHING FIXED IT. NOW THEY SAY IT MIGHT BE THE IGNITION SWITCH. THERE WAS A RECALL FOR THIS IN 2002 BUT MY VIN DOESN'T COME UP AS PART OF THAT RECALL SO I HAVE TO PAY TO HAVE IT REPLACED.…
Read full complaint
1998 HONDA ACCORD SHUTS OFF BY ITSELF WHILE DRIVING. HAPPENS SPORADICALLY. REPLACED FUEL PUMP, FUEL IGNITER, CAP, ROTOR, PLUGS, WIRES, ETC. NOTHING FIXED IT. NOW THEY SAY IT MIGHT BE THE IGNITION SWITCH. THERE WAS A RECALL FOR THIS IN 2002 BUT MY VIN DOESN'T COME UP AS PART OF THAT RECALL SO I HAVE TO PAY TO HAVE IT REPLACED. AND THAT MAY NOT FIX IT EITHER. *TR
NHTSA ODI #10402408
77,000 miles · Dec 9, 2010
Fuel System, Gasoline
THROTTLE BODY PULLEY. THE PULLEY FOR THE THROTTLE USES TWO CABLES, EACH ANCHORED IN THE PULLEYS. THE ANCHORING AREA FOR THE CRUISE CONTROL CABLE HAS BROKEN, POSSIBLY FROM CORROSION. THE SAME MATERIAL AND ASSEMBLY ALSO IS FOR THE ACCELERATOR PEDAL, SO THIS BREAK IN THE PULLEY COULD ALSO MEAN THE ACCELERATOR PEDAL WOULD NOT WORK…
Read full complaint
THROTTLE BODY PULLEY. THE PULLEY FOR THE THROTTLE USES TWO CABLES, EACH ANCHORED IN THE PULLEYS. THE ANCHORING AREA FOR THE CRUISE CONTROL CABLE HAS BROKEN, POSSIBLY FROM CORROSION. THE SAME MATERIAL AND ASSEMBLY ALSO IS FOR THE ACCELERATOR PEDAL, SO THIS BREAK IN THE PULLEY COULD ALSO MEAN THE ACCELERATOR PEDAL WOULD NOT WORK. BROKEN PART IS THE THROTTLE BODY PULLEY.
NHTSA ODI #10370200
90,000 miles · May 11, 2010
Engine And Engine CoolingFuel System, GasolineLatches/locks/linkages
HONDA ACCORD ACCELERATOR CABLE FAILURE. I PICKED UP MY SON FROM SCHOOL. I STARTED TO DRIVE AWAY FROM THE SCHOOL AND THE ACCELERATOR PEDAL STOPPED RESPONDING. I STEERED THE CAR BACK TO THE CURB USING THE REMAINING MOMENTUM, STOPPING NEAR THE CURB AT AN ANGLE. I OPENED THE ENGINE HOOD TO LOCATE ANY LOOSE CABLES GOING FROM THE ENG…
Read full complaint
HONDA ACCORD ACCELERATOR CABLE FAILURE. I PICKED UP MY SON FROM SCHOOL. I STARTED TO DRIVE AWAY FROM THE SCHOOL AND THE ACCELERATOR PEDAL STOPPED RESPONDING. I STEERED THE CAR BACK TO THE CURB USING THE REMAINING MOMENTUM, STOPPING NEAR THE CURB AT AN ANGLE. I OPENED THE ENGINE HOOD TO LOCATE ANY LOOSE CABLES GOING FROM THE ENGINE TO THE ACCELERATOR PEDAL. WHEN I TOUCHED THE ACCELERATOR CABLE, THE METAL CABLE WAS LOOSE AND FELL OUT OF THE HOUSING, REVEALING A BROKEN FRAYED CABLE. I CALLED A TOW TRUCK TO DELIVER THE CAR TO A HONDA DEALER FOR REPAIR. *TR
NHTSA ODI #10329837
170,000 miles · Apr 18, 2010
Engine And Engine CoolingFuel System, Gasoline
MY 1998 HONDA ACCORD 4 DOOR SEDAN L4 ENGINE STALLS AND THE ENGINE DIES WHILE DRIVING IN TRAFFIC. I AM VERY CONCERNED ABOUT THIS ISSUE AS IT RELATES TO MY SAFETY AND THE SAFETY OF MY FAMILY. THE FIRST TIME THIS EVENT HAPPENED THE CAR STALLED THEN DIED. THE CHECK ENGINE LIGHT CAME ON. AFTER I LET THE CAR SIT FOR AWHILE I ATTEMP…
Read full complaint
MY 1998 HONDA ACCORD 4 DOOR SEDAN L4 ENGINE STALLS AND THE ENGINE DIES WHILE DRIVING IN TRAFFIC. I AM VERY CONCERNED ABOUT THIS ISSUE AS IT RELATES TO MY SAFETY AND THE SAFETY OF MY FAMILY. THE FIRST TIME THIS EVENT HAPPENED THE CAR STALLED THEN DIED. THE CHECK ENGINE LIGHT CAME ON. AFTER I LET THE CAR SIT FOR AWHILE I ATTEMPTED TO START THE CAR. IT TOOK FOUR TIMES. I THEN SOUGHT SERVICE OR REPAIR. FOUR ATTEMPTS HAVE BEEN MADE TO CORRECT THIS PROBLEM. NONE OF WHICH ARE SUCCESSFUL. *TR
NHTSA ODI #10326248
Official recalls
6Jan 17, 2020
Honda (American Honda Motor Co.) is recalling certain 1998 Acura 2.2CL, 1998-1999 Acura 2.3CL, 1998-1999 Acura 3.0CL, 2001 Acura 3.2CL and Acura MDX, 1998-2000 Honda Accord Coupe, Accord Sedan, Civic Sedan, Odyssey and Acura 3.5RL, 1999-2000 Acura 3.2TL, 1996-2000 Civic Coupe, 1997-2000 CR-V, 1997-1998 EV Plus, and 1998-1999 Isuzu Oasis vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the driver frontal air bag inflator, and replace it if necessary, with an inflator of a different design, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138 or Isuzu customer service at 1-800-255-6727.
Oct 27, 2003
ON CERTAIN PASSENGER VEHICLES AND MINI VANS, THE IGNITION SWITCH MAY WEAR EXCESSIVELY AND PREVENT PROPER INTERLOCK OPERATION, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO "PARK."
Consequence & remedy
Consequence: IF THE VEHICLE OPERATOR DOES NOT SHIFT TO "PARK" BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT DETERMINES THE AMOUNT OF CYLINDER BODY WEAR. IF SIGNIFICANT WEAR IS INDICATED, THE DEALER WILL REPLACE THE CYLINDER BODY, COLLAR, AND LATCH PLATE. IF NO SIGNS OF WEAR ARE INDICATED, DEALERS WILL REPLACE THE LATCH PLATE WITH A REDESIGNED PART. OWNER NOTIFICATION BEGAN DECEMBER 8, 2003. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
May 16, 2002
ON CERTAIN SEDANS, COUPES, HATCHBACKS, AND SPORT UTILITY VEHICLES, ELECTRICAL CONTACTS IN THE IGNITION SWITCH CAN DEGRADE DUE TO THE HIGH ELECTRICAL CURRENT PASSING THROUGH THE SWITCH WHEN THE VEHICLE IS STARTED.
Consequence & remedy
Consequence: WORN CONTACTS COULD CAUSE THE ENGINE TO STALL WITHOUT WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN JUNE 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
May 10, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES WERE MANUFACTURED WITH BALL JOINTS THAT CAN PREMATURELY WEAR OUT AND, IN THE WORSE CASE, THE BALL JOINT WOULD SEPARATE CAUSING THE FRONT SUSPENSION TO COLLAPSE.
Consequence & remedy
Consequence: THIS CONDITION WOULD RESULT IN VEHICLE DECELERATION AND A SUDDEN LOSS OF POWER. ALSO STEERING CONTROLLABILITY WOULD BE REDUCED.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS.
Feb 10, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES (HONDA ACCORD SEDANS MANUFACTURED FROM SEPTEMBER 18, 1997 TO JANUARY 10, 1998; COUPES MANUFACTURED DECEMBER 11, DECEMBER 15, 1997, AND JANUARY 5, 1998; ACURA 2.3CL MANUFACTURED OCTOBER 22, 1997 THROUGH JANUARY 7, 1998). DURING MANUFACTURING, THE CASTING DIE CAUSED AN IRREGULARITY IN THE RIGHT-SIDE TRANSMISSION COVER. THIS IRREGULARITY CAN LIMIT THE MOVEMENT OF THE PARKING PAWL ACTUATION LEVEL AND PREVENT ADEQUATE ENGAGEMENT OF THE PARKING GEAR PAWL. THIS DOES NOT COMPLY WITH FMVS NO. 114, "THEFT PROTECTION."
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE VEHICLE TO ROLL DOWN AN INCLINE WHEN THE TRANSMISSION IS LOCKED IN "PARK," INCREASING THE RISK OF PERSONAL INJURY AND/OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A COLLAR ON THE TRANSMISSION PARKING PAWL TO ENSURE PROPER MOVEMENT OF THE ACTUATION LEVER.
Dec 16, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONT PASSENGER SEAT BELT RETRACTOR MOUNTING BRACKET WAS IMPROPERLY WELDED.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE BRACKET TO SEPARATE FROM THE VEHICLE BODY IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPAIR THESE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA03017 · IGNITION-PARK Interlock
Opened Sep 9, 2003 · Closed Dec 17, 2003
Status: closed (inferred from source dates) · Electrical System:ignition:switch; Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Additional source detail variants (2)
Electrical System:ignition:switch
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
PE03014 · IGNITION-PARK Interlock System
Opened Apr 15, 2003 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF THE MANUFACTURER COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE NOTED INJURY OCCURRED WHEN A ROLLAWAY VEHICLE THAT HAD BEEN INADVERTENTLY PARKED IN NEUTRAL STRUCK THE EXITING OPERATOR.THE WARRANTY CLAIM COUNT SHOWN FOR OTHER REPRESENTS INCIDENTS WHERE HONDA'S ANALYSIS OF CLAIM DETAIL INDICATES THE INTERLOCK SYSTEM MALFUNCTIONED.THE INTERLOCK SYSTEM UTILIZES A LEVER TO BLOCK IGNITION KEY REMOVAL WHEN THE TRANSMISSION IS NOT IN PARK.HONDA HAS IDENTIFIED A WEAR CONDITION OF THE INTERLOCK LEVER THAT CAN CAUSE THE SYSTEM TO MALFUNCTION; WHEN WEAR OCCURS THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE SHIFTER IS IN A NON-PARK POSITION.HONDA DOCUMENTS INDICATE THAT A MANUFACTURING PROCESS MAY BE THE CAUSE OF INTERLOCK LEVER WEAR, AND THAT THIS PROCESS WAS REVISED IN JANUARY OF 2001.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER INVESTIGATE THIS CONCERN AND ITS SCOPE.
PE02072 · Seat Frame Bracket Failure
Opened Oct 2, 2002 · Closed Mar 28, 2003
Status: closed (inferred from source dates) · Seats
THIS PE WAS OPENED BASED ON 10 CONSUMER COMPLAINTS IN THE ODI DATABASE ALLEGING THAT THE POWER ASSISTED SEATS WERE FAILING IN CERTAIN 1998-2002 HONDA ACCORD VEHICLES.FAILURES ARE CONCENTRATED IN THE 1998-99 MODEL YEAR VEHICLES.THE BRACKET THAT ATTACHES THE SEAT BOTTOM TO THE SEAT BASE IS FRACTURING DUE TO: 1-THE WELD CONDITION OF BRACKET, 2-THE DRIVERS WEIGHT, AND 3-THE IMPACT ON THE SEAT WHEN THE DRIVER ENTERS THE VEHICLE AND SITS DOWN.OVER TIME THE BRACKET THAT ATTACHES THE SEAT MAY FAIL AT THE LEFT FRONT CORNER OF THE SEAT BOTTOM.THE OTHER 3 POINTS OF ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BASE STAY ATTACHED AND THE SEAT MOVEMENT IS LIMITED.THE ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BACK DOES NOT FAIL.THE CONDITION IS MOST APPARENT DURING RAPID ACCELERATION CAUSING THE SEAT TO TILT REARWARD.ALTHOUGH A FEW COMPLAINTS REPORT CONCERN OVER LOSS OF VEHICLE CONTROL, NO LOSS OF CONTROL INCIDENTS, CRASHES OR INJURIES ARE REPORTED.IN RESPONSE TO CUSTOMER COMPLAINTS, HONDA WILL PROVIDE OWNERS OF 1998 AND SOME 1999 ACCORDS A NO-COST REINFORCEMENT FOR THE SEAT AT THE LEFT FRONT CORNER.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration