IllustrationWhile driving I saw smoke and when I pulled over I seen fuel leaking from the gas tank area. Where it was leaking it ignited and the fire department had to put out the fire and the truck is totaled
2023 GMC Canyon
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2023 GMC Canyon do not stand out strongly from the model-year median of 38.
About this comparison →How this year compares
Owner complaints by model year
Compare all Canyon years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 12 of 60 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Forward Collision Avoidance. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports1 injury reports
Structure complaints
4 reportsAfter each rain or hand car washing, the OEM sunroof has a gurgling sound when driving at speeds above 25 mph. This does not clear for miles, or over time (at least 1 day without water). Water appears to be passing through the seal into the drainage gutter, but not completely draining out through the drains. Its been in service …
Read full complaint
After each rain or hand car washing, the OEM sunroof has a gurgling sound when driving at speeds above 25 mph. This does not clear for miles, or over time (at least 1 day without water). Water appears to be passing through the seal into the drainage gutter, but not completely draining out through the drains. Its been in service twice to have the drain lines cleared, and the issue remains. This has been present on other car manufacturers as a "wind pressure issue" where the force of driving causes wind pressure to push what water hasn't drained back up into the sunroof. Fix was extending the drain lines at output. GMC unable to repair.
The contact owns a 2023 GMC Canyon. The contact stated that while at a car wash, there was an abnormal sound coming from the roof. The contact inspected the vehicle and noticed that there was a dent in the roof panel. The vehicle was taken to a dealer where it was diagnosed and repaired under Customer Service Program: 23-NA-209.…
Read full complaint
The contact owns a 2023 GMC Canyon. The contact stated that while at a car wash, there was an abnormal sound coming from the roof. The contact inspected the vehicle and noticed that there was a dent in the roof panel. The vehicle was taken to a dealer where it was diagnosed and repaired under Customer Service Program: 23-NA-209. After the repair, the vehicle was taken to the car wash and the same failure occurred. The vehicle was taken back to the same dealer where it was diagnosed a second time and the contact was informed that the repair could not be performed because the part was not available, and to report the failure to the NHTSA Hotline. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 1,800.
The roof of the vehicle crackles and pops when it is in the blowing section of an automatic car wash. We have never had any experience like this before. The roof of the truck is so flimsy that it was actually dented by the hard blowing of air. I don’t feel like this car is solidly constructed and safe.
Official recalls
324V703000 · Seat Belts:critical Fasteners
Sep 19, 2024
General Motors, LLC (GM) is recalling certain 2023-2024 Chevrolet Colorado and 2023 GMC Canyon vehicles. The left or right front seat may have a seat belt buckle attachment bolt that was not tightened properly.
Consequence & remedy
Consequence: A loose seat belt may not properly restrain an occupant in a crash, increasing the risk of injury.
Remedy: Dealers will tighten the left and right front seat belt buckle attachment bolts, free of charge. Owner notification letters were mailed October 30, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N242453720.
24V237000 · Wheels:lugs/nuts/bolts/studs
Mar 28, 2024
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Colorado and GMC Canyon vehicles. The front wheel hub bolts may have been over-tightened and damaged during installation.
Consequence & remedy
Consequence: Damaged bolts may loosen or break, which can result in a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will replace the left and right front wheel hub bolts, free of charge. Owner notification letters were mailed April 10, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232431480.
24V133000 · Electrical System:adas:driver Monitoring:camera/sensor; Forward Collision Avoidance: Automatic Emergency Braking
Feb 22, 2024
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Colorado and GMC Canyon vehicles. The front camera module (FCM) system may falsely detect an obstacle, causing the automatic emergency braking (AEB) to engage unexpectedly.
Consequence & remedy
Consequence: Unexpected automatic emergency braking can cause the vehicle to abruptly stop or slow down, increasing the risk of a crash.
Remedy: Dealers will update the front camera module (FCM) software, free of charge. Owner notification letters were mailed April 5, 2024. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is A232424660.
Additional source detail variants (2)
Electrical System:adas:driver Monitoring:camera/sensor
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Colorado and GMC Canyon vehicles. The front camera module (FCM) system may falsely detect an obstacle, causing the automatic emergency braking (AEB) to engage unexpectedly.
Consequence: Unexpected automatic emergency braking can cause the vehicle to abruptly stop or slow down, increasing the risk of a crash.
Remedy: Dealers will update the front camera module (FCM) software, free of charge. Owner notification letters were mailed April 5, 2024. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is A232424660.
Forward Collision Avoidance: Automatic Emergency Braking
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Colorado and GMC Canyon vehicles. The front camera module (FCM) system may falsely detect an obstacle, causing the automatic emergency braking (AEB) to engage unexpectedly.
Consequence: Unexpected automatic emergency braking can cause the vehicle to abruptly stop or slow down, increasing the risk of a crash.
Remedy: Dealers will update the front camera module (FCM) software, free of charge. Owner notification letters were mailed April 5, 2024. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is A232424660.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA26006 · Electronic Brake Module Component Failure
Opened Aug 21, 2026 · No close date supplied
Status: open (inferred from source dates) · Service Brakes
On April 11, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE24011 after receiving complaints concerning a loss of brake assist in 2023 MY Cadillac Lyriq vehicles. These complaints allege a hard brake pedal, followed by a “Brake System Failure” message at start up or while driving. GM shared records regarding several internal investigations for loss of brake assist due to alleged spindle fractures in the eBoost system. GM has stated that in the event of a spindle fracture, anti-lock brakes (ABS), stability control, and traction control remain functional until the vehicle comes to a complete stop. At this point, ABS, brake assist, stability control, and traction control functions are lost. The loss of these functions causes the vehicle to set one of three Diagnostic Trouble Codes (DTCs) based on failed performance criteria for the Electronic Brake Control Module (EBCM). These DTCs, in turn, activate several driver alerts: an audible chime, a visual “Service Brake System” message in the display, and multiple illuminated Malfunction Indicator Lights (MILs) for the ABS, Traction Control, and Brakes informing the driver of loss of functionality. The vehicle speed will also be limited to 70 KPH (43 MPH). Since opening PE24011, ODI has continued to receive reports of loss of brake assist. Some of these reports describe symptoms inconsistent with GM’s description of a spindle failure. These reports allege an immediate loss of brake assist functionality as opposed to the loss occurring after the vehicle comes to a complete stop. The sudden loss of brake assist during a braking event could result in extended braking distance, which increases the risk of a crash or injury. ODI believes further analysis is necessary to assess the potential for failures in GM’s eBoost system to resulting in safety-related outcomes. At this time, ODI is aware of the following vehicles that are equipped with this eBoost system: 2023-2026 MY Cadillac Lyriq, Chevrolet Colorado, and GMC Canyon; 2024-2026 MY Buick Enclave, Envision; Chevrolet Blazer EV, Equinox EV, Traverse; Cruise Origin; and GMC Acadia; 2025-2026 MY Cadillac Celestiq and Optiq. ODI is also aware of 2024-2026 MY Acura ZDX and 2024-2026 MY Honda Prologue vehicles that were built with this system. The Acura and Honda vehicles were manufactured by GM in a joint venture with Honda, and will be included in the Engineering Analysis as peer vehicles. ODI is opening this Engineering Analysis to further assess the safety-related consequences of a failed eBoost system. In addition, ODI is expanding the scope of the investigation to encompass all GM vehicles that share this eBoost system. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.