2024 GMC Canyon

Vehicle alerted driver that ECS and. Rake assist was needed and disabled abs and forward collision while lighting up multiple warning lights on dashboard. Lights eventually turned off leaving a check engine light on. Multiple codes pulled from system using obd2 reader. Communication bus B offline and U0074, U0151, U0447,U0452 all at same time.

I first noticed the brakes squealing in August 2025 at 15,000 miles. The dealership said I needed to resurface the front rotors. I mistook this a coating and brake debris, but it was actually the rotors warping. By 21,000 the vehicle is pulsing heavily when stopping. I went back to the dealer and this time they told me all 4 rotors are warped. GM denied coverage of the pads and rotors. Normal driving, no collisions or towing.

Upper radiator hose connection to radiator is faulty causing leak of coolant. Yes it is available for inspection upon request. Truck began to run cooling fan at full speed in the middle of winter with no warnings of high heat or low coolant. After two weeks, check engine light finally cut on to indicate low coolant flow. Coolant reservoir was subsequently checked and found to be completely empty. It is apparent this reservoir had been extremely low / empty for at least two weeks with no warnings. Without proper warning and leaking coolant, truck could have overheated. Should this had happened in dead of summer, truck could have very well overheated with no warning. The problem was investigated and confirmed by dealer as leaking coolant at the connection of the upper radiator hose to the radiator. Was quoted $983 to replace the hose. No warning lights appeared until issue had been ongoing for over two weeks. A quick search of "GMC Canyon Upper Radiator Hose" will reveal many identical occurrences of this issue. This is a safety hazard / design flaw that GM is not acknowledging and is putting the burden on the vehicle owners for their own issue.

On 2 occasions the battery was drained and a tow truck had to jump the battery. On one occasion after the battery was jump started it took several hours before the brakes were able to be used and the car driven safely. Had to drive very slowly (under 50 mph) per note that appeared on dashboard. After nearly an hour of waiting Engine light stayed on and dealership ran diagnostic and found nothing wrong with the battery nor anything else. Have to start and run engine everyday to keep battery from dying. If not started in 24 to 36 hours, battery will die.

Upper radiator hose attachment is leaking due to faulty rubber gasket. This comes up across GMC Canyon groups on Facebook 10 times a day. It is happening to ALL of them mainly pre 2025 on 3rd gens. Part is on back order at all GMC dealers due to so much volume of issue. Happening as early as 10k-20k miles on brand new trucks causing over heating issues due to coolant leaking out. Hopefully a recall for the part is done before engines start blowing.

There are widespread reports of the O ring seals on the radiator and heater hoses failing and causing coolant leaks. These leaks are significant enough to render the vehicle inoperable and with no cabin heating or cooling. This could lead to life-threatening situations in adverse weather conditions. It could also create dangerous roadside failure situation in heavy traffic, particularly on interstate highways. Dealers are aware of the issue and are currently repairing vehicles under warranty. However some dealers are telling owners that the cooling system is not part of the engine and drivetrain, and therefor is not covered under the original factory warranty if the vehicle has exceeded the initial bumper to bumper warranty limits. Dealers are also telling owners that parts are on backorder due to high demand, and that repair wait times could take weeks. The vehicle is unsafe to operate with a known coolant leak. Video of leak (another owner) here. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)