2024 Ford Maverick Hybrid

On March 18, 2024, my 2024 Ford Maverick XLT Hybrid had just over 1,000 miles on it. That same night, approximately 20 yards before an upcoming stop sign, I got a big red triangle message on the dash saying STOP SAFELY NOW. When I finally got stopped at the STOP sign, everything shut down. No accelerator, now power and the transmission dial locked after I put it in Park. I could not get it in Neutral to push it out of the intersection. Since it is a front wheel drive vehicle, the front wheels locked also. Thank goodness my husband was with me, family members were traveling behind me AND I know a tow truck owner. Tow truck owner came came and used a code reader. It indicated that there were 9 errors related to HYBRID. He was able to clear 6 of them, but the truck still wouldn't start. He had to drag it up onto the flat bed because the front wheel were locked. He towed it to a local Ford Dealership. They initially said the smart junction box (a module that controls the hybrid battery) had a bad circuit and needed to be replaced (I'm not sure if they meant the smart junction box or the circuit...). The next day, the dealership called again and said they replaced the control module for the Hybrid Battery System. I got the truck back on the 4th day with no charge as everything was covered by warranty, including the tow. Overall, I was satisfied with how the dealership handled the issue. However, the incident seems a bad way to start an automobile relationship. In a group forum for Ford Maverick Hybrid Owners, I met a man who said the same thing happened to him on the highway! The vehicle slowed so quickly he was almost rear-ended by a tractor trailer. If it had to happen to me, I'm glad it happened on a rural back road vs. the four lane highway where I commute approximately 300 miles over 5 days per week. That's my concern - I am worried the same thing might happen to me on the highway with different results than the first time!

On [XXX], I was traveling from Georgia to California in a 2024 Ford Maverick XLT 2.5L Hybrid with approximately 219 miles on the odometer, using cruise control set at 73 mph and in the ECO mode. I'd stopped for gas and upon returning to the highway [XXX]) the vehicle, still using cruise and in ECO mode, experienced an extreme reduction in power and the check engine light illuminated. I pulled over to the shoulder and shut down the engine; restarted the engine and tried to resume driving while changing to normal mode and not using cruise control. The check engine lights was still illuminated and the vehicle would not accelerate and could only travel at about 30 mph. Pulled off the highway at the next exit and had the vehicle towed to a Ford dealership in Birmingham AL. At the dealership, I informed the service advisor about the check engine light and that the Ford app indicated a problem with the high voltage battery coolant pump. During the initial troubleshoot, the mechanic relayed to me the following three potential faults: the high voltage battery cooling pump, a pump in the transmission, and a fault with the battery electronic control module (BECM). The two pumps were replaced and the BECM fault cleared, see attached service invoice. I picked up the vehicle on [XXX] and drove back to Georgia without issue. The odometer currently indicates 869 miles with no issues. Since the vehicle had limited power and was unable to accelerate, especially on an interstate, I consider this type of failure a safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)