Electrical System. Review the 1,343 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 474 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 406 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

248 crash reports118 fire reports129 injury reports

Visibility complaints

118 reports

Clear category filter

Mileage unknown · Jun 18, 2002

Visibility

RECALL 01V288000 REPAIR PARTS ARE NOT AVAILABLE. DEALER: SHEEHY FORD, MARLOW HGTS, MD; 301-423 0041. *AK

NHTSA ODI #8012008

Mileage unknown · Jun 16, 2002

Service Brakes, HydraulicSteeringSuspension

Read full complaint

I WORK FOR A GOODYEAR CO. AND EVERYTIME THERE IS A PROBLEM I HAVE ONE OF OUR TECHS. CHECK IT OUT FOR ME. FIRST IT WAS THE BRAKES I WAS TAKING MY CHILDREN TO THE MOVIES,AS I WAS TURNING INTO THE PARKING SPACE I HEARD A GRINDING NOISE.THE NEXT DAY AT WORK I HAVE AUTO TECH. INSPECT MY BRAKES I HAD LESS THAN 10% LEFT ALL AROUND AND THE FRONT ROTORS WERE CRACKED! MY CHILDREN AND I COULD HAVE DIED! I TOOK THE CAR TO THE DEALER TO MARINA FORD THEY REPLACED FRONT ROTORS,PADS AND REAR SHOES. THREE WEEKS LATER PADS WERE DOWN TO 10% I DID NOT BOTHER GOING BACK TO THE DEALER. OUR TECH. AT MY PLACE OF EMPLOYMENT REPLACED MY BRAKES WITH GOOD QUALITY PADS AND SHOES. I HAD TH ISIDE PANEL REPLACED,THE WINDSHIELD WIPER MOTOR REPLACED AND THE RIGHT FRONT WHEEL BEARING REPLACED! NOW MY LEFT FRONT TIE-ROD IS BENT,MY CAR SHUTS OFF WHEN THE GAS IS AT THE 3/4 MARK AND WHEN MAKING RIGHT TURNS,THE EMISSION LIGHTS UP AND THE CAR STOPS! THIS IS A PROBLEM CAR THE FORD FOCUS. I FOUND A WEB SITE AND THER IS OVER A THOUSAND CONSUMERS WHO ARE NOT PLEASED WITH THEIR FOCUS TOO!

NHTSA ODI #763129

Mileage unknown · Jun 11, 2002

Visibility

WHILE TRAVELING ON HIGHWAY AND WITHOUT WARNING PASSENGER'S SIDE DOOR WILL SLIDE OPEN . DEALERSHIP IS AWARE OF PROBLEM.*AK

NHTSA ODI #8011544

Mileage unknown · Jun 7, 2002

EquipmentService Brakes, HydraulicSteering

Read full complaint

WHEN SLIPPERY OUT, THE BRAKES WILL NOT GRASP PROPERLY. THEREFORE, THE VEHICLE WILL SLIDE. DEALER CAN NOT DUPLICATE PROBLEM.*AK CONSUMER ALSO EXPERIENCED THESE DIFFICULTIES AS FOLLOWED, POWER STEERING SYSTEM (EXPLODED, W/3-4 WEEK REPAIRS), TRUNK LOCK WAS BROKEN, KEYLESS ENTRY SYSTEM WORKS IMPROPERLY, THE TRUNK LOCK HAS BEEN REPLACED TWICE, THE RADIO HAS BEEN REPLACED 3 TIMES & STILL OCCURS, THE WINSHIELD ARM RECENTLY BROKE, AND CONCLUDES THAT THE VEHICLE ALSO SLIDES IN DRY WEATHER. CONSUMER ADDS THAT SHE HAD FILED A COMPLAINT W/ BOARD OF FORD, THE CASE WAS LOST AFTER RECIEVING A LOANER CAR (DUE TO TAKING VEHICLE IN FOR REPAIRS) AND SAYS THAT SHE CANNOT AFFORD TO BUY OUT THE LEASE (WILL HAVE TO WAIT UNTIL OCT 2002) *SCC

NHTSA ODI #8011293

Mileage unknown · Jun 7, 2002

Power TrainSuspensionVisibility

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ODI #762784

Mileage unknown · Apr 26, 2002

Fuel System, OtherService Brakes, HydraulicVisibility

Read full complaint

I HAVE TAKEN THE CAR BACK SEVERAL TIMES WHEN I FIRST PURCHASED IT TO FIX THE BRAKES AND HEMBORG FORD TOLD ME, "THAT'S JUST THE WAY FORD BRAKES ARE, METAL ON METAL".. I'VE HAD SO MANY PROBLEMS WITH THIS CAR IT'S UNBELIEVABLE.. I FEEL UNSAFE DRIVING THIS CAR.. AS IT HAS LOCKED ME IN MANY TIMES..THE WINDOWS WILL NOT ROLL DOWN HALF THE TIME.. THE GAS GAUGE ONLY WORKS HALF THE TIME.. I WISH I HAD NEVER PURCHASED THIS HORRIBLE PRODUCT.. I WILL NEVER PURCHASE ANOTHER FORD VEHICLE AGAIN AND I ENCOURAGE FRIENDS AND FAMILY NOT TO BUY THEIR PRODUCT EITHER! *AK

NHTSA ODI #761248

Mileage unknown · Apr 6, 2002

Service Brakes, HydraulicTiresVisibility

THIS CAR HAS HAD SO MANY PROBLEMS IT MAKES ME SICK. A QUICK LIST: AIR CONDITIONING LEAKED ALL OVER MY INTERIOR, ONE TIRE REPLACED, ONE WINDSHIELD REPLACED, NOW NEED NEW BRAKES, HAD TRANSMISSION REPLACED ON FRIDAY, IS ALWAYS HAVING STRANGE LITTLE PROBLEMS, CD PLAYER SKIPS AFTER 45 MINUTES OF USE, BRAKES HAVE ALWAYS SQUEAKED UNBE…

Read full complaint

NHTSA ODI #760351

Mileage unknown · Apr 4, 2002

Visibility

WINDSHIELD WIPERS WORK ONLY INTERMITTENTLY. DEALER CANNOT DUPLICATE THE PROBLEM.*AK

NHTSA ODI #8006909

Mileage unknown · Mar 22, 2002

Air BagsService Brakes, HydraulicStructureCrashInjury

Read full complaint

VEHICLE HAS BEEN GIVEN CONSUMER TROUBLE SINCE PURCHASING IT. 2ND DAY AFTER PURCHASE VEHICLE WAS IN DEALER'S SHOP FOR 2 WEEKS. WHEN PUTTING ON BRAKES VEHICLE SHAKES. ALSO, DRIVER CANNOT SEE TO MAKE TURNS BECAUSE TRUCK IS VERY HIGH.*AK WHILE DRIVING, THE CONSUMER AND HIS DAUGHTER WERE HURT DUE TO BRAKES AND WIPERS FAILED IN THE RAIN. THE REAR WINDOW IS VERY HIGH AND THE DRIVER WAS UNABLE TO SEE VEHICLES FROM BEHIND. BRAKES FAILED MORE THAN THREE TIMES, HOWEVER THE DEALER REFUSED TO FIX IT AFTER THE FIRST REPAIR THERE WERE 2 INJURIES, CONSUMER ALSO STATES THE AIRBAGS FAILED. *YH

NHTSA ODI #8006252

Mileage unknown · Mar 12, 2002

Engine And Engine CoolingService Brakes, HydraulicSuspension

Read full complaint

BRAKES HAVE SQUEALED FRON ABOUT 1500 MILES. HAVE HAD PADS REPLACED, BUT SQUEALS DID NOT GO AWAY. FRONT BRAKES GRIND, AT SHOP NOW. IN NOVEMBER 2001 HAD TO HAVE STRUTS REPLACED WHILE HAVING RECALL WORK DONE. STRUTS LITTLE OVER A YEAR OLD. ENGINE MAKES A CHIRPING NOISE AT ABOUT 1000-2500 RPM, BUT DEALER UNABLE TO DUPLICATE. ALSO SQUEALS OR WHINES WHEN MAKING RIGHT TURNS. WINDSHIELD CRACKED WHEN A SMALL STONE HIT IT. WILL HAVE INSURANCE REPLACE. OVERALL, NOT HAPPY WITH CAR. BEEN IN THE SHOP THREE TIMES IN THE LAST YEAR!!

NHTSA ODI #759254

Official recalls

05V030000 · Latches/locks/linkages:doors:latch

Feb 1, 2005

CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.

Consequence & remedy

Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.

Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

03V482000 · Fuel System, Gasoline

Nov 19, 2003

ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.

Consequence & remedy

Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.

Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

02V288000 · Electrical SYSTEM:12V/24V/48V Battery:cables

Nov 6, 2002

CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.

Consequence & remedy

Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.

Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

02V289000 · Steering:linkages

Nov 6, 2002

CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.

Consequence & remedy

Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

01V258000 · Visibility:windshield Wiper/washer:motor

Aug 8, 2001

VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.

Consequence & remedy

Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

00V418000 · Seats:front Assembly:recliner

Dec 14, 2000

VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.

Consequence & remedy

Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.

00V411000 · Electrical System:wiring

Dec 6, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.

Consequence & remedy

Consequence: THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.

00V302000 · Vehicle Speed Control:cables

Oct 12, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.

Consequence & remedy

Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

00V303000 · Wheels:lugs/nuts/bolts/studs

Oct 12, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.

Consequence & remedy

Consequence: THIS CONDITION COULD RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

00V218000 · Structure:frame And Members

Aug 11, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.

Remedy: DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.

99V346000 · Vehicle Speed Control

Dec 3, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.

Consequence & remedy

Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ10001 · Fleet Vehicle Recall Completion Audit

Opened Nov 18, 2010 · Closed Dec 28, 2015

Status: closed (inferred from source dates) · Unknown Or Other

On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.

EA04023 · Rear Door Latch Failure

Opened Aug 18, 2004 · Closed Feb 4, 2005

Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch

THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004 AS PE04-033 AND UPGRADED ON AUGUST 18, 2004 TO EA04-023.THE COMPLAINANTS ALLEGED THAT THE REAR DOOR LATCHES FAILED TO KEEP THE DOORS IN A CLOSED POSITION, RESULTING IN REAR DOORS COMING OPEN WHILE THE VEHICLES WERE BEING DRIVEN.SOME COMPLAINANTS REPORTED THAT AT TIMESA REAR DOOR, OR DOORS, COULD BE DIFFICULT TO CLOSE.OTHERS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD HAS IDENTIFIED A CONDITION OF CORROSION IN THE PAWL PIVOT AREA OF THE DOOR LATCH ASSEMBLY THAT PREVENTS PROPER ENGAGEMENT OF THE DOOR LATCH CATCH TO THE LATCH STRIKER ON THE VEHICLE BODY.BY LETTER OF FEBRUARY 1, 2005, FORD MOTOR COMPANY NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL ON MODEL YEAR 2000 THROUGH 2002 FOUR AND FIVE-DOOR FOCUS VEHICLES REGISTERED IN, OR ORIGINALLY SOLD IN, CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. DEALERS WILL INSPECT REAR DOOR LATCHES AND REPLACE BINDING LATCHES AS REQUIRED.DEALERS WILL ALSO LUBRICATE ALL REAR DOOR LATCHES TO PREVENT FUTURE CORROSION AND BINDING.A LOWER ROCKER SEAL WILL ALSO BE ADDED TO THE REAR DOORS. SEE SAFETY RECALL 05V030 FOR DETAILS.

PE04033 · Rear Door Latch Failure

Opened Apr 8, 2004 · Closed Aug 20, 2004

Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch

THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004, BASED ON 17 REPORTS THAT ONE OR BOTH REAR DOOR LATCHES DID NOT FUNCTION PROPERLY.THE COMPLAINANTS ALLEGED THAT THE DOORS WERE DIFFICULT TO CLOSEAND THAT THE DOOR LATCHES WOULD NOT REMAIN LATCHED WHILE THE VEHICLES WERE BEING DRIVEN, RESULTING IN A DOOR COMING OPEN.SEVERAL OF THE COMPLAINANTS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD'S RESPONSE TO THE PRELIMINARY EVALUATION INFORMATION REQUEST PROVIDED 19 CONSUMER REPORTS AND 28 WARRANTY CLAIMS ATTRIBUTED TO THE DOOR LATCH WHERE THE DOORS CAME OPEN WHILE THE VEHICLES WERE BEING DRIVEN.THREE (3) OF THE 17 OPENING ODI REPORTS WERE DUPLICATED IN FORD'S RESPONSE.THIS INVESTIGATION HAS BEEN UPGRADED TO ENGINEERING ANALYSIS EA04-023 FOR FURTHER STUDY.

EA02022 · Engine Stalling

Opened Sep 9, 2002 · Closed Jan 16, 2004

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages

CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.

Additional source detail variants (3)

Fuel System, Gasoline:delivery:fuel Pump

Fuel System, Other:delivery:fuel Pump

Vehicle Speed Control:linkages

EA02023 · Front Susp Collapse/wheel Separation

Opened Sep 9, 2002 · Closed Feb 19, 2003

Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint

SEE ATTACHED REPORT.

Additional source detail variants (4)

Suspension:front:control Arm

SEE ATTACHED REPORT.

Suspension:front:control Arm:lower Arm

SEE ATTACHED REPORT.

Suspension:front:control Arm:lower Ball Joint

SEE ATTACHED REPORT.

Suspension:front

SEE ATTACHED REPORT.

EA02017 · Burn Injuries Due To Air Bag Deployment

Opened Aug 16, 2002 · Closed Aug 15, 2003

Status: closed (inferred from source dates) · Air Bags

ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

EA02014 · Engine Compartment Fires

Opened Jul 31, 2002 · Closed Nov 13, 2002

Status: closed (inferred from source dates) · Electrical System

There is no summary currently available

PE02044 · Front Suspension Lower Control Arm

Opened May 1, 2002 · Closed Sep 9, 2002

Status: closed (inferred from source dates) · Suspension

There is no summary currently available

PE02040 · Engine Stalling

Opened Apr 4, 2002 · Closed Sep 9, 2002

Status: closed (inferred from source dates) · Engine And Engine Cooling

THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.

PE02032 · Engine Compartment Fires

Opened Mar 12, 2002 · Closed Jul 31, 2002

Status: closed (inferred from source dates) · Electrical System

No summary supplied.

PE02026 · Inappropriate Air Bag Deployment

Opened Feb 28, 2002 · Closed Sep 18, 2002

Status: closed (inferred from source dates) · Air Bags

There is no summary currently available

PE02020 · Air Bag Burn Injuries/vehicle Fires

Opened Feb 11, 2002 · Closed Aug 16, 2002

Status: closed (inferred from source dates) · Air Bags

INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.

PE02016 · Rear Wheel Bearing

Opened Feb 8, 2002 · Closed Nov 8, 2002

Status: closed (inferred from source dates) · Wheels

There is no summary currently available