IllustrationBreak lights won't work and was almost hit by another car, changed break lights changed light break switch checked fuses and wiring everything is good
2002 Ford Focus
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Ford Focus do not stand out strongly from the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1480–25K
13425–50K
13950–75K
8375–100K
74100–150K
26150K+
604 reports with mileage · 335 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 277 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
82 crash reports20 fire reports60 injury reports
What owners actually said
939 reportsSunroof Exploded. Empty Road, temp low 40s. No warning. I have owned the car since 2004. Though older car, <120,000 miles.
The drivers door will not open. It is stuck shut. Turning the key in the lock does not work. Broke outer handle trying to open door to assist elderly party out of drivers seat. Power lock fuse is fine. Took door panel off partly to expose cable, cannot push or pull cable to force open. Safety issue because owner is elderly. Cann…
Read full complaint
The drivers door will not open. It is stuck shut. Turning the key in the lock does not work. Broke outer handle trying to open door to assist elderly party out of drivers seat. Power lock fuse is fine. Took door panel off partly to expose cable, cannot push or pull cable to force open. Safety issue because owner is elderly. Cannot reasonably crawl in and out through passenger side. Emergency personnel would not be able to reach occupants in case of an accident.
I drive a 2002 Ford Focus Sedan. My engine light is on, warning light for trunk door ajar light is on (even though the trunk is securely locked, my front headlights due not work consistently (sometimes work, sometimes don't). My trunk does not always latch secure after I close it as well. I took my car to Advanced Auto Parts …
Read full complaint
I drive a 2002 Ford Focus Sedan. My engine light is on, warning light for trunk door ajar light is on (even though the trunk is securely locked, my front headlights due not work consistently (sometimes work, sometimes don't). My trunk does not always latch secure after I close it as well. I took my car to Advanced Auto Parts and had my engine light diagnosed. Engine codes that resulted were: B1318, B1881, C1947, B2438, B2434, P0457. The representative tested my battery and found that the voltage was slightly lower than it should be. My concern is for my safety as well as the safety of others. Do we have some manufacturer defects on this particular vehicle? Have other concerns which could be the result of vehicle wear and tear, or/and due to manufacturer defects as well. Inner tie rods need replaced as well as control arms/bushings, as reported to me by a mechanic. I have seen recall reports related to the 2002 Ford Focus in which there has been issues directly related to what I'm reporting, which is another reason I'm filing a report. Thank you. The contact wanted to add that the wipers are experiencing an electrical issue as well. When in use, the wipers cannot be switched off when it is at the highest position because it will not return in the downward position.
TL* THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE SLIPPED OUT OF DRIVE INTO NEUTRAL. THE CONTACT CALLED FAIRWAY FORD (2761 E STONE DR, KINGSPORT, TN 37660), AND INFORMED THE DEALER OF THE FAILURE. THE DEALER INFORMED THE CONTACT THAT HE HAD TO PAY A DIAGNOSTIC FEE. THE VEHICLE WAS NOT TAK…
Read full complaint
TL* THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE SLIPPED OUT OF DRIVE INTO NEUTRAL. THE CONTACT CALLED FAIRWAY FORD (2761 E STONE DR, KINGSPORT, TN 37660), AND INFORMED THE DEALER OF THE FAILURE. THE DEALER INFORMED THE CONTACT THAT HE HAD TO PAY A DIAGNOSTIC FEE. THE VEHICLE WAS NOT TAKEN TO A DEALER DUE TO THE DIAGNOSTIC AND REPAIR COSTS. THE CONTACT ALSO STATED THAT THE VEHICLE INDEPENDENTLY SHIFTED TO NEUTRAL WHILE STOPPED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT SUBJECTED TO A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 137,000.
HUSBAND WAS DRIVING APPROX. 35 MPH WITH HIS MOTHER IN THE PASSENGER SEAT DOWN A COUNTRY ROAD. DRIVER SIDE AND PASSENGER SIDE AIRBAGS DEPLOYED WITH NO ACCIDENT. PASSENGER SIDE AIRBAG OR COVER BROKE WINDSHIELD. HUSBAND HIT BRAKES.
VEHICLE HAS ABOUT 108,000 MILES. I DID REPLACE THE TIE RODS CONTROL ARMS AND SWAY BAR OF THE FRONT SUBFRAME. THE MECHANIC SAID THAT THE SUBFRAME IS VERY RUSTED AND THE ENGINE COULD FALL OF IF THE VEHICLE IS NOT SERVICED IMMEDIATELY. I BOUGHT THE CAR AROUND 90,000 MILES AND HAVE ALREADY REPLACED FUEL PUMP AND OTHER PARTS UNDER T…
Read full complaint
VEHICLE HAS ABOUT 108,000 MILES. I DID REPLACE THE TIE RODS CONTROL ARMS AND SWAY BAR OF THE FRONT SUBFRAME. THE MECHANIC SAID THAT THE SUBFRAME IS VERY RUSTED AND THE ENGINE COULD FALL OF IF THE VEHICLE IS NOT SERVICED IMMEDIATELY. I BOUGHT THE CAR AROUND 90,000 MILES AND HAVE ALREADY REPLACED FUEL PUMP AND OTHER PARTS UNDER THE CAR.
AT SPEED OF 40+MPH AND UNEVEN HIGHWAY OR WHEN ENCOUNTERING A MANHOLE COVER THE REAR OF THE CAR SWAYS AND SHIMMIES LEFT TO RIGHT IN AN EXTREME MANNER. NOTICED MUCH WORSE WITH NEW TIRES THAT GRIP WELL. HAVE HAD IT INSPECTED BY A PROFESSIONAL WHO SAYS ALL VITAL PARTS LOOK OKAY. 4 WHEEL ALIGNMENT DID NOT REMEDY. I SEE REFERENCES TO …
Read full complaint
AT SPEED OF 40+MPH AND UNEVEN HIGHWAY OR WHEN ENCOUNTERING A MANHOLE COVER THE REAR OF THE CAR SWAYS AND SHIMMIES LEFT TO RIGHT IN AN EXTREME MANNER. NOTICED MUCH WORSE WITH NEW TIRES THAT GRIP WELL. HAVE HAD IT INSPECTED BY A PROFESSIONAL WHO SAYS ALL VITAL PARTS LOOK OKAY. 4 WHEEL ALIGNMENT DID NOT REMEDY. I SEE REFERENCES TO A DESIGN ISSUE WITH THE UPPER CONTROL MEMBERS THAT MAKE IT IMPOSSIBLE TO REACH A CORRECT CAMBER SETTING. I DON'T TRUST MUCH ON THE INTERNET THOUGH, AND WOULD LIKE NHTSA GUIDANCE OR FURTHER INFORMATION. THANKS FOR ANY HELP YOU CAN PROVIDE, I APPRECIATE IT.
REAR RIGHT PASSENGER DOOR WILL NOT UNLOCK/OPEN. WHEN TRYING TO UNLOCK I DON'T HEAR THE SOLENOID MOVING. WHEN TRYING TO OPEN FROM EITHER INSIDE OR OUT IF FEELS LIKE THE HANDLE ISN'T MOVING ANYTHING.
ANTITHEFT HAS CAR LOCKING UP WHILE DRIVING
Official recalls
105V030000 · Latches/locks/linkages:doors:latch
Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available