NHTSA owner reports · September 18, 2026 snapshot.
Visibility complaints
118 reportsClear category filter128,600 miles · Jul 9, 2012
Visibility
TL* THE CONTACT OWNS A 2000 FORD FOCUS. THE CONTACT STATED THAT THE REAR WINDOWS COULD NOT BE CLOSED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE FAILURE WAS LOCATED AT THE WINDOW ACTUATOR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DENIED ASSISTANCE WITH THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FA…
Read full complaint
TL* THE CONTACT OWNS A 2000 FORD FOCUS. THE CONTACT STATED THAT THE REAR WINDOWS COULD NOT BE CLOSED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE FAILURE WAS LOCATED AT THE WINDOW ACTUATOR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DENIED ASSISTANCE WITH THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 128,600 AND THE CURRENT MILEAGE WAS 128,900.
NHTSA ODI #10464672
93,000 miles · Aug 19, 2010
Engine And Engine CoolingVisibility
TL* THE CONTACT OWNS A 2000 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE WOULD INTERMITTENTLY STALL WHEN ATTEMPTING A TURN AT ANY SPEED, IN EITHER DIRECTION. THE FAILURE WOULD OCCUR MOST OFTEN WHEN ATTEMPTING LEFT TURNS. ONCE THE CONTACT WAS ABLE TO RESTART THE VEHICLE IT WOULD OPERATE AS NORMAL. THE VEHICLE WAS TAKEN TO A…
Read full complaint
TL* THE CONTACT OWNS A 2000 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE WOULD INTERMITTENTLY STALL WHEN ATTEMPTING A TURN AT ANY SPEED, IN EITHER DIRECTION. THE FAILURE WOULD OCCUR MOST OFTEN WHEN ATTEMPTING LEFT TURNS. ONCE THE CONTACT WAS ABLE TO RESTART THE VEHICLE IT WOULD OPERATE AS NORMAL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE HE WAS INFORMED THAT THE CRANK SHAFT WAS SHIFTING BACK AND FORTH, CAUSING THE CRANK SHAFT POSITION SENSOR TO FAIL. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE POWER WINDOWS WERE INOPERABLE EXCEPT FOR THE FRONT DRIVER WINDOW. THE FAILURE MILEAGE WAS 93,000 AND THE CURRENT MILEAGE WAS 117,000.
NHTSA ODI #10350600
118,764 miles · Oct 3, 2009
Visibility
FORD FOCUS ELECTRIC WINDOW MOTOR REPLACEMENT BECAUSE OF PLASTIC PARTS. MUST REPLACE THE MOTOR TO GET THE PLASTIC WINDOW PARTS. THIS HAS HAPPEN TO 3 OUT OF FOUR WINDOWS AND THE PRICE TO REPLACE IS $200 - $300 EACH WINDOW. THIS IS A COMMON PROBLEM WITH ALL FOCUS OWNERS ALL OVER THE NATION. *TR
NHTSA ODI #10286177
34,000 miles · Jul 15, 2008
Visibility
DRIVING ALONG, ROLLED DOWN DRIVER SIDE REAR WINDOW FOR FRESH AIR, WINDOW FELL OUT OF TRACK, APPROX 1 MONTH LATER SAME THING HAPPENED TO PASSENGER REAR WINDOW SAME THING. *TR
NHTSA ODI #10234463
72,000 miles · Jul 8, 2008
Visibility
AFTER TWO DAYS OF RAIN MY PASSENGER SIDE OF MY 2000 FORD FOCUS FILLED UP WITH WATER. THEN WHEN I WENT TO TURN ON THE AIR CONDITIONING WATER CAME POURING OUT OF THE FLOOR VENTS. I ALWAYS HESITATE TO TAKE IT INTO A DEALERSHIP SO I USED THE INTERNET TO SEARCH FOR SIMILAR COMPLAINTS. AFTER LOOKING AROUND I FOUND AROUND 25 COMPLAI…
Read full complaint
AFTER TWO DAYS OF RAIN MY PASSENGER SIDE OF MY 2000 FORD FOCUS FILLED UP WITH WATER. THEN WHEN I WENT TO TURN ON THE AIR CONDITIONING WATER CAME POURING OUT OF THE FLOOR VENTS. I ALWAYS HESITATE TO TAKE IT INTO A DEALERSHIP SO I USED THE INTERNET TO SEARCH FOR SIMILAR COMPLAINTS. AFTER LOOKING AROUND I FOUND AROUND 25 COMPLAINTS JUST ON ONE WEBSITE HTTP://WWW.CARSURVEY.ORG/VIEWMORECOMMENTS_REVIEW_8122_2.HTML . ON THIS SITE MANY PEOPLE REFERRED TO THE POLLEN FILTER WHERE THERE WAS NOT A TIGHT SEAL OR SOME TYPE OF DEFECTIVE PART THAT WOULD CAUSE WATER TO ENTER INTO THE VENT SYSTEM OF THE CAR THEN FILL THE PASSENGER SIDE OF THE INTERIOR. THIS SOUNDS LIKE A HUGE PROBLEM AND I WOULD APPRECIATE IT IF YOU WOULD LOOK INTO IT. *TR
NHTSA ODI #10233588
107,000 miles · Jun 2, 2008
Visibility
I HAVE A 2000 FORD FOCUS AS DOES MY EX BOTH HAVING THE SAME YEAR MAKE AND MODEL OF THE FORD FOCUS! THE PROBLEM IN WHICH WE BOTH HAVE ENCOUNTERED IS THAT 3 OUT OF THE 4 WINDOWS IN OUR CARS NO LONGER WORK THE WINDOWS AT FIRST WOULD MAKE A POPPING SOUND ON SOME OTHERS JUST BROKE SUDDENLY. NOW WHEN I SAY BROKE THE MOTORS TO ALL THE …
Read full complaint
I HAVE A 2000 FORD FOCUS AS DOES MY EX BOTH HAVING THE SAME YEAR MAKE AND MODEL OF THE FORD FOCUS! THE PROBLEM IN WHICH WE BOTH HAVE ENCOUNTERED IS THAT 3 OUT OF THE 4 WINDOWS IN OUR CARS NO LONGER WORK THE WINDOWS AT FIRST WOULD MAKE A POPPING SOUND ON SOME OTHERS JUST BROKE SUDDENLY. NOW WHEN I SAY BROKE THE MOTORS TO ALL THE WINDOWS STILL WORK BUT THE PLASTIC CLIP THAT HOLDS THE WINDOW ON THE TRACKS. I RECENTLY TOOK MY CAR TO HAVE SAFETY AND ADMISSIONS DONE AND WAS NOT ABLE TO PASS SAFETY DO TO THE FACT THAT MY DRIVERS SIDE WINDOW DOES NOT ROLE DOWN. WHAT I HAVE BEEN FORCED TO DO IS ALL THREE OF THE WINDOWS NOT WORKING ARE EITHER HELD UP BY TAPE OR A DOOR STOP FROM THE INSIDE. DO TO MY WINDOWS HAVING TO BE HELD IN THE MANNER THEY ARE I AM CONSTANTLY WORRIED ABOUT MY CAR BEING AN EASY TARGET FOR A BREAK IN THUS I DON'T HAVE THE COMFORT LEVEL I FEEL I SHOULD WITH MY OWN VEHICLE. I HAVEN'T BEEN ABLE TO FIX THE WINDOWS YET DUE TO THE HIGH COST OF NEARLY $200 PER WINDOW. AS I SEE IT THIS WOULD HAVE TO BE A FACTORY DEFAULT SEEING IF IT HAD ONLY HAPPENED TO ONE WINDOW MAYBE A FLUKE BUT THREE OF MY FOUR ALSO THREE OF THE FOUR ON MY EX'S VEHICLE TOO!!! *TR
NHTSA ODI #10229610
12,500 miles · Nov 1, 2007
Electrical SystemFuel System, GasolineLatches/locks/linkages
ON 10/23/07 I INSERTED KEY INTO IGNITION OF MY FORD FOCUS AND IMMEDIATLEY THE LIGHTS AND GAUGES WENT HAYWIRE-VEHICLE FAILED TO START. TO MAKE A LONG STORY SHORT ,AFTER UNPLUGING THE BATTERY CABLES AND GOING BACK TO THE STRANDED CAR THE NEXT EVENING, IT STARTED . 2 DAYS LATER MY WIPERS CAME ON BY THEMSELVES AND WOULD NOT STOP UNT…
Read full complaint
ON 10/23/07 I INSERTED KEY INTO IGNITION OF MY FORD FOCUS AND IMMEDIATLEY THE LIGHTS AND GAUGES WENT HAYWIRE-VEHICLE FAILED TO START. TO MAKE A LONG STORY SHORT ,AFTER UNPLUGING THE BATTERY CABLES AND GOING BACK TO THE STRANDED CAR THE NEXT EVENING, IT STARTED . 2 DAYS LATER MY WIPERS CAME ON BY THEMSELVES AND WOULD NOT STOP UNTIL I TURNED THE CAR OFF AND RESTARTED. ON 10/31/07 WHILE DRIVING MY DAUGHTER HOME, THE VEHICLE BEGAN ACCELERATING AND DECCELERTAING UNCONTROLLABLY. I PULLED OF THE HIGHWAY AND WHEN I OPENED THE DRIVERS DOOR, THE SEATBELT LIGHT BEGAN BLINKING AND MAKING A LOUD TICKING NOISE. THIS HAD HAPPENED THE NIGHT PRIOR, BUT I THOUGHT MAYBE THE BUTTON WAS DEPRESSED. MY DOME LIGHTS MAKE A SCREECHING NOISE AND BLINK ON AND OFF. THIS IS A SERIOUS PROBLEM THAT NEEDS TO BE LOOKED INTO. WHENEVER SOMETHING LIKE THIS HAPPENS I AM DRIVING HOME LATE AT NIGHT AND OF COURSE THE DEALER IS NOT OPEN TO HELP ME . MY CAR IS ALMOST PAID OFF AND I WILL NOT INVEST MORE THAN WHAT IT IS WORTH, WHICH IS ONLY ABOUT $2,500.TOO BAD I HAVE PAID ABOUT $18,000 FOR IT. I WOULD ALSO LIKE TO KNOW WHY I HAVE NOT RECEIVED RECALLS FOR THE FOLLOWING PROBLEMS: 1. 1ST MONTH AFTER PURCHASE, ELECTRICAL SYSTEM RUNNING AIRBAGS, MIRRORS, DOORS ETC. FAILED. 2. 37,000 MILES- TRANSMISSION FAILED 3. 42,000 MILES- POWER DOOR LOCKS FAILED AND SOON AFTER PASSENGER DOORS STUCK IN THE LOCK POSITION. 4. ALL WINDOW TRACKS HAVE FAILED. 5. WHEEL BEARINGS REPLACED. 6. TRUNK LATCH FAILED 7. IGNITION FAILED AND WAS REPLACED AND IS GOING AGAIN. 8. BROUGHT IN FOR 1 RECALL (FUEL FILTER) AND STILL DIDN'T CORRECT PROBLEM WITH VIBRATION AND LURCHING. THIS IS A VEHICLE THAT EXCEEDS HIGHWAY SAFTEY RATINGS? SOMETHING WILL BE DONE ABOUT THIS IF I MUST HIRE AN ATTORNEY- I AM OUT A LOT OF MONEY AND NO VEHICLE. *TR
NHTSA ODI #10207593
Mileage unknown · Apr 10, 2007
Fuel System, GasolineVisibility
THERE HAVE BEEN SEVERAL PROBLEMS REGARDING 2000 FORD FOCUS CONCERNING GAS MILEAGE DETERIORATION. ALL CARS LOST SOME FORM OF MPG ESTIMATES OVER YEARS OF USE, BUT THE FOCUS HAD TERRIBLE DETERIORATION. . I HAVE SPOKEN TO MANY OWNERS OF 2000 FORD FOCUS' THAT HAVE EXPERIENCED THE SAME PROBLEM. ESTIMATED MPG HAD BEEN FROM 15 TO 22, W…
Read full complaint
THERE HAVE BEEN SEVERAL PROBLEMS REGARDING 2000 FORD FOCUS CONCERNING GAS MILEAGE DETERIORATION. ALL CARS LOST SOME FORM OF MPG ESTIMATES OVER YEARS OF USE, BUT THE FOCUS HAD TERRIBLE DETERIORATION. . I HAVE SPOKEN TO MANY OWNERS OF 2000 FORD FOCUS' THAT HAVE EXPERIENCED THE SAME PROBLEM. ESTIMATED MPG HAD BEEN FROM 15 TO 22, WITH MINE FLUCTUATED FROM 10 TO 20. NO MECHANICAL PROBLEMS COULD BE FOUND THROUGH NORMAL MEANS. THERE WAS NO EXPLANATION REGARDING THE LOSS OF GOOD GAS MILEAGE, WITH THE EXCEPTION OF A PROBLEM WITH THE PROGRAMMING OF THE BRAIN BOX. ALSO, THIS CAR SUDDENLY DEVELOPED CRACKS IN THE WINDSHIELD - THEY WEREN'T CRACKS THAT WERE FORMED FROM THE OUTSIDE SURFACE OR THE INSIDE SURFACE. THEY ACTUALLY FORMED IN THE GLASS, BETWEEN THE LAYERS. THEY CANNOT BE FELT ON THE OUTSIDE OR THE INSIDE OF THE GLASS.*AK
NHTSA ODI #10187532
42,000 miles · Dec 11, 2006
Visibility
DT*: THE CONTACT STATED WHILE ATTEMPTING TO ENGAGE THE POWER WINDOW CONTROL, THE FRONT DRIVER SIDE POWER WINDOW FAILED TO OPEN WITHOUT WARNING. AFTER INITIAL INSPECTION BY THE CONTACT, THE LEFT REAR PASSENGER SIDE POWER WINDOW FAILED TO OPERATE AS WELL. THE VEHICLE WAS INSPECTED BY A DEALER, WHO DETERMINED THE POWER WINDOWS WE…
Read full complaint
DT*: THE CONTACT STATED WHILE ATTEMPTING TO ENGAGE THE POWER WINDOW CONTROL, THE FRONT DRIVER SIDE POWER WINDOW FAILED TO OPEN WITHOUT WARNING. AFTER INITIAL INSPECTION BY THE CONTACT, THE LEFT REAR PASSENGER SIDE POWER WINDOW FAILED TO OPERATE AS WELL. THE VEHICLE WAS INSPECTED BY A DEALER, WHO DETERMINED THE POWER WINDOWS WERE WORN, AND FAILED DUE TO NORMAL WEAR AND TEAR. THE MANUFACTURER WAS NOT ALERTED.
NHTSA ODI #10175836
Mileage unknown · Oct 5, 2006
Visibility
MY HUSBAND WENT TO THE STORE WITH DAUGHTER ON A RAINY DAY. THE PASSENGER SIDE WINDOW CAME CRASHING DOWN. IN TRYING TO FIX THE PROBLEM. WE FOUND THAT THE 2 BRACKETS THAT HOLD THE WINDOW UP HAS 2 PLASTIC ARMS WHICH HAD BROKEN. I HAVE CONTACTED FORD ABOUT THE ISSUE AND HAS SAID THAT AT THIS POINT THERE IS NO RECALL. SO THEY ARE GOI…
Read full complaint
MY HUSBAND WENT TO THE STORE WITH DAUGHTER ON A RAINY DAY. THE PASSENGER SIDE WINDOW CAME CRASHING DOWN. IN TRYING TO FIX THE PROBLEM. WE FOUND THAT THE 2 BRACKETS THAT HOLD THE WINDOW UP HAS 2 PLASTIC ARMS WHICH HAD BROKEN. I HAVE CONTACTED FORD ABOUT THE ISSUE AND HAS SAID THAT AT THIS POINT THERE IS NO RECALL. SO THEY ARE GOING TO DO ANYTHING ABOUT IT. I BELIEVE THAT A BROKEN WINDOW IN THE SNOW BELT IS A SAFETY ISSUE. SO I'M BRINGING THIS ISSUE TO YOU. THANK YOU R.BATTLES. *NM
NHTSA ODI #10170030
Official recalls
11Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Dec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
Consequence & remedy
Consequence: THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Oct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Oct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Aug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
Remedy: DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Dec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA04023 · Rear Door Latch Failure
Opened Aug 18, 2004 · Closed Feb 4, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004 AS PE04-033 AND UPGRADED ON AUGUST 18, 2004 TO EA04-023.THE COMPLAINANTS ALLEGED THAT THE REAR DOOR LATCHES FAILED TO KEEP THE DOORS IN A CLOSED POSITION, RESULTING IN REAR DOORS COMING OPEN WHILE THE VEHICLES WERE BEING DRIVEN.SOME COMPLAINANTS REPORTED THAT AT TIMESA REAR DOOR, OR DOORS, COULD BE DIFFICULT TO CLOSE.OTHERS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD HAS IDENTIFIED A CONDITION OF CORROSION IN THE PAWL PIVOT AREA OF THE DOOR LATCH ASSEMBLY THAT PREVENTS PROPER ENGAGEMENT OF THE DOOR LATCH CATCH TO THE LATCH STRIKER ON THE VEHICLE BODY.BY LETTER OF FEBRUARY 1, 2005, FORD MOTOR COMPANY NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL ON MODEL YEAR 2000 THROUGH 2002 FOUR AND FIVE-DOOR FOCUS VEHICLES REGISTERED IN, OR ORIGINALLY SOLD IN, CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. DEALERS WILL INSPECT REAR DOOR LATCHES AND REPLACE BINDING LATCHES AS REQUIRED.DEALERS WILL ALSO LUBRICATE ALL REAR DOOR LATCHES TO PREVENT FUTURE CORROSION AND BINDING.A LOWER ROCKER SEAL WILL ALSO BE ADDED TO THE REAR DOORS. SEE SAFETY RECALL 05V030 FOR DETAILS.
PE04033 · Rear Door Latch Failure
Opened Apr 8, 2004 · Closed Aug 20, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004, BASED ON 17 REPORTS THAT ONE OR BOTH REAR DOOR LATCHES DID NOT FUNCTION PROPERLY.THE COMPLAINANTS ALLEGED THAT THE DOORS WERE DIFFICULT TO CLOSEAND THAT THE DOOR LATCHES WOULD NOT REMAIN LATCHED WHILE THE VEHICLES WERE BEING DRIVEN, RESULTING IN A DOOR COMING OPEN.SEVERAL OF THE COMPLAINANTS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD'S RESPONSE TO THE PRELIMINARY EVALUATION INFORMATION REQUEST PROVIDED 19 CONSUMER REPORTS AND 28 WARRANTY CLAIMS ATTRIBUTED TO THE DOOR LATCH WHERE THE DOORS CAME OPEN WHILE THE VEHICLES WERE BEING DRIVEN.THREE (3) OF THE 17 OPENING ODI REPORTS WERE DUPLICATED IN FORD'S RESPONSE.THIS INVESTIGATION HAS BEEN UPGRADED TO ENGINEERING ANALYSIS EA04-023 FOR FURTHER STUDY.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02032 · Engine Compartment Fires
Opened Mar 12, 2002 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
PE02016 · Rear Wheel Bearing
Opened Feb 8, 2002 · Closed Nov 8, 2002
Status: closed (inferred from source dates) · Wheels
There is no summary currently available
Illustration