NHTSA owner reports · September 18, 2026 snapshot.
Interior Lighting complaints
13 reportsClear category filterMileage unknown · Feb 13, 2005
Air BagsElectrical SystemEngine And Engine CoolingCrashFireInjury
THIS COMPLAINT IS CONCERNING CLARIFICATION OF OUR PREVIOUS COMPLAINTS TO NHTSA REGARDING THE 2000 FORD FOCUS : #10104088 AND #10107840. I AM EXTREMELY CONCERNED ABOUT THE MISINTERPRETATION OF DATA COLLECTED BY YOUR AGENCY AND POSTED FOR PUBLIC REVIEW. DEATHS ARE NOT POSTED, NOR ARE THEY INCLUDED AS INJURIES. THIS MISREP…
Read full complaint
THIS COMPLAINT IS CONCERNING CLARIFICATION OF OUR PREVIOUS COMPLAINTS TO NHTSA REGARDING THE 2000 FORD FOCUS : #10104088 AND #10107840. I AM EXTREMELY CONCERNED ABOUT THE MISINTERPRETATION OF DATA COLLECTED BY YOUR AGENCY AND POSTED FOR PUBLIC REVIEW. DEATHS ARE NOT POSTED, NOR ARE THEY INCLUDED AS INJURIES. THIS MISREPRESENTS THE SERIOUSNESS OF THE VEHICLE AND EQUIPMENT FAILURES REPORTED. *JB
NHTSA ODI #10110471
30,700 miles · Aug 30, 2004
EquipmentInterior Lighting
THE DOME LIGHT BLEW OUT INSIDE THE VEHICLE'S COMPARTMENT. FOLLOWING THAT, A FACTORY INSTALLED SECURITY SYSTEM FOR THE DOOR LOCKS BEGAN TO PERFORM ERRATICALLY. DOORS PREVENTED ENTRY FROM THE OUTSIDE AND EXIT FROM THE INSIDE, EXCEPT FOR THE HATCHBACK. EVEN IF THE DOOR LOCKS WERE PUSHED THEY FAILED TO OPEN. *AK *NM
NHTSA ODI #10081695
34,000 miles · Oct 15, 2003
Electrical SystemExterior LightingInterior Lighting
AT IDLE THE HEAD LIGHTS, DASH BOARD LIGHTS, AND INTERNAL DOME LIGHT FLICKER WITH CYCLE OF ENGINE. FORD CERTIFIED MECHANIC DOES NOT ACKNOWLEDGE THE PROBLEM, NOR A REMEDY TO THE FLICKERING. FLICKERING STILL EXISTS! *LA
NHTSA ODI #10042954
Mileage unknown · Apr 17, 2003
Interior Lighting
THE VEHICLE WAS TAKEN TO THE DEALER FOR A MAINTENANCE CHECK. TWO DAYS LATER THE VEHICLE SAFETY LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN BACK TO THE DEALER BUT THEY COULD NOT DETERMINE THE PROBLEM. *NLM
NHTSA ODI #10016097
Mileage unknown · Jun 7, 2002
Electrical SystemInterior Lighting
I WANT TO REPORT A PROBLEM WITH MY FOCUS. MY CAR SEEMS TO HAVE A PROBLEM THAT THE DEALER IS NOT ABLE TO PINPOINT. WHENEVER I HAVE MY LIGHTS ON AT NIGHT I HAVE A BAD POBLEM WITH THE HEADLIGHTS FLICKERING ALONG WITH MY DASH LIGHTS. THE DEALER SAYS IT CANT DUPLICATE THE PROBLEM BUT IT HAPPENS EVERY TIME I TURN THE LIGHTS ON. MY NI…
Read full complaint
I WANT TO REPORT A PROBLEM WITH MY FOCUS. MY CAR SEEMS TO HAVE A PROBLEM THAT THE DEALER IS NOT ABLE TO PINPOINT. WHENEVER I HAVE MY LIGHTS ON AT NIGHT I HAVE A BAD POBLEM WITH THE HEADLIGHTS FLICKERING ALONG WITH MY DASH LIGHTS. THE DEALER SAYS IT CANT DUPLICATE THE PROBLEM BUT IT HAPPENS EVERY TIME I TURN THE LIGHTS ON. MY NIECE ALSO HAS A 2000 FOCUS AND IT DOES THE SAME THING. I THINK THERE IS A PROBLEM WITH THE ELECTRICAL SYSTEM ON THIS CAR ALONG WITH THE MANY OTHER PROBLEMS WITH THIS CAR. HAVE YOU GOTTEN ANY OTHER COMPLAINTS OF THIS NATURE. IT SEEMS TO BE A GROUND PROBLEM. I HAVE ALSO NOTICED IT ON THE ROAD WITH OTHER FOCUSES THAT I SEE DRIVING AT NIGHT. PLEASE LET ME KNOW IF OTHER PEOPLE HAVE COMPLAINED ABOUT THIS PROBLEM THANK YOU HOWARD K. LAMB. *AK
NHTSA ODI #762806
Mileage unknown · Mar 5, 2002
Interior LightingPower TrainService Brakes, Hydraulic
AFTER 6 MONTHS OF PURCHASE, THE BRAKE SYSTEM SPECIFICALLY ROTORS FAILED. WHILE APPLYING BRAKES THERE WAS A CONSTANT GRINDING NOISE, RESULTING IN EXTENDED STOPPING DISTANCE BEFORE VEHICLE CAME TO A COMPLETE STOP. MECHANIC STATED FORD FOCUS HAD THESE COMMON PROBLEMS, ALSO EXPERIENCING OTHER PROBLEMS SUCH AS ERRATIC SPEEDOMETER FAI…
Read full complaint
AFTER 6 MONTHS OF PURCHASE, THE BRAKE SYSTEM SPECIFICALLY ROTORS FAILED. WHILE APPLYING BRAKES THERE WAS A CONSTANT GRINDING NOISE, RESULTING IN EXTENDED STOPPING DISTANCE BEFORE VEHICLE CAME TO A COMPLETE STOP. MECHANIC STATED FORD FOCUS HAD THESE COMMON PROBLEMS, ALSO EXPERIENCING OTHER PROBLEMS SUCH AS ERRATIC SPEEDOMETER FAILURE, AN THE INTERIOR LIGHT FELL OUT FROM ROOF OF VEHICLE, AND 2 INCHES OF WATER ENTERING FROM SIDE OF DOOR. *AK *TT
NHTSA ODI #8005005
Mileage unknown · Feb 14, 2002
Electrical SystemInterior Lighting
WHILE DRIVING IN THE DARK DASHBOARD AND REAR LIGHTS WILL GO OFF WITHOUT A PRIOR WARNING, AND HEADLIGHTS WILL DI. HAD TAKEN VEHICLE TO DEALER AND THEY FOUND OUT THAT ELECTRICAL WIRING WAS CORRODED AND HAD TO BE REPLACED TO CORRECT THE PROBLEM. PLEASE PROVIDE MORE INFORMATION. *AK
NHTSA ODI #8004091
Mileage unknown · Dec 18, 2001
Interior Lighting
INSIDE COURTESY LIGHT WOULD COME ON AND REMAIN ON INTERMITTENTLY WHILE DRIVING. DEALER NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION ON THIS MATTER. *AK
NHTSA ODI #8000892
Mileage unknown · Dec 7, 2001
Interior LightingPower TrainStructure
NOTHING BUT PROBLEMS WITH THE CAR. FIRST NOTICED LEAK IN THE FLOORBOARD ON THE FRONT PASSENGER SIDE AS THE DEALER DETAILED CAR. INTERIOR DOME LIGHT FELL OFF SOON AFTER, FOLLOWED BY THE FUEL GATE DOOR AND THE LEFT DRIVERS SIDE MIRROR. NOW MY TRANSMISSION HAS BLOWN UP, ALL WHILE GOING 25 MPH OR UNDER, AND ALL UNDER 21,000 MILES! …
Read full complaint
NOTHING BUT PROBLEMS WITH THE CAR. FIRST NOTICED LEAK IN THE FLOORBOARD ON THE FRONT PASSENGER SIDE AS THE DEALER DETAILED CAR. INTERIOR DOME LIGHT FELL OFF SOON AFTER, FOLLOWED BY THE FUEL GATE DOOR AND THE LEFT DRIVERS SIDE MIRROR. NOW MY TRANSMISSION HAS BLOWN UP, ALL WHILE GOING 25 MPH OR UNDER, AND ALL UNDER 21,000 MILES! WE'VE HAD A MAJOR RECALL ON AVERAGE EVERY OTHER MONTH TOO. WHAT A LEMMON! *AK (TIRESIZE: P195/60R15)
NHTSA ODI #755382
Mileage unknown · Jul 16, 2001
Interior LightingStructure
DRIVER'S DOOR SENSOR WOULD INDICATE THAT THE DOOR WOULD BE AJAR WHEN ITS NOT. THIS CAUSES INTERIOR LIGHTS TO STAY ON. ITS AN INTERMITTENT PROBLEM. OWNER DISABLED MECHANISM FOR INTERIOR LIGHTS. TOOK VEHICLE TO DEALERSHIP, INFORMED BY MECHANIC THAT PROBLEM COULD NOT BE LOCATED.*AK
NHTSA ODI #892959
Official recalls
11Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Dec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
Consequence & remedy
Consequence: THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Oct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Oct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Aug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
Remedy: DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Dec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA04023 · Rear Door Latch Failure
Opened Aug 18, 2004 · Closed Feb 4, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004 AS PE04-033 AND UPGRADED ON AUGUST 18, 2004 TO EA04-023.THE COMPLAINANTS ALLEGED THAT THE REAR DOOR LATCHES FAILED TO KEEP THE DOORS IN A CLOSED POSITION, RESULTING IN REAR DOORS COMING OPEN WHILE THE VEHICLES WERE BEING DRIVEN.SOME COMPLAINANTS REPORTED THAT AT TIMESA REAR DOOR, OR DOORS, COULD BE DIFFICULT TO CLOSE.OTHERS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD HAS IDENTIFIED A CONDITION OF CORROSION IN THE PAWL PIVOT AREA OF THE DOOR LATCH ASSEMBLY THAT PREVENTS PROPER ENGAGEMENT OF THE DOOR LATCH CATCH TO THE LATCH STRIKER ON THE VEHICLE BODY.BY LETTER OF FEBRUARY 1, 2005, FORD MOTOR COMPANY NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL ON MODEL YEAR 2000 THROUGH 2002 FOUR AND FIVE-DOOR FOCUS VEHICLES REGISTERED IN, OR ORIGINALLY SOLD IN, CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. DEALERS WILL INSPECT REAR DOOR LATCHES AND REPLACE BINDING LATCHES AS REQUIRED.DEALERS WILL ALSO LUBRICATE ALL REAR DOOR LATCHES TO PREVENT FUTURE CORROSION AND BINDING.A LOWER ROCKER SEAL WILL ALSO BE ADDED TO THE REAR DOORS. SEE SAFETY RECALL 05V030 FOR DETAILS.
PE04033 · Rear Door Latch Failure
Opened Apr 8, 2004 · Closed Aug 20, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004, BASED ON 17 REPORTS THAT ONE OR BOTH REAR DOOR LATCHES DID NOT FUNCTION PROPERLY.THE COMPLAINANTS ALLEGED THAT THE DOORS WERE DIFFICULT TO CLOSEAND THAT THE DOOR LATCHES WOULD NOT REMAIN LATCHED WHILE THE VEHICLES WERE BEING DRIVEN, RESULTING IN A DOOR COMING OPEN.SEVERAL OF THE COMPLAINANTS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD'S RESPONSE TO THE PRELIMINARY EVALUATION INFORMATION REQUEST PROVIDED 19 CONSUMER REPORTS AND 28 WARRANTY CLAIMS ATTRIBUTED TO THE DOOR LATCH WHERE THE DOORS CAME OPEN WHILE THE VEHICLES WERE BEING DRIVEN.THREE (3) OF THE 17 OPENING ODI REPORTS WERE DUPLICATED IN FORD'S RESPONSE.THIS INVESTIGATION HAS BEEN UPGRADED TO ENGINEERING ANALYSIS EA04-023 FOR FURTHER STUDY.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02032 · Engine Compartment Fires
Opened Mar 12, 2002 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
PE02016 · Rear Wheel Bearing
Opened Feb 8, 2002 · Closed Nov 8, 2002
Status: closed (inferred from source dates) · Wheels
There is no summary currently available
Illustration