IllustrationI know that the 2015-2019 Ford Flex is being recalled for rear camera issues and "B" pillar mldgs. coming loose. My 2014 Flex has these same issues. What about earlier models?
2014 Ford Flex
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2014 Ford Flex do not stand out strongly from the model-year median of 139.
About this comparison →How this year compares
Owner complaints by model year
Compare all Flex years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
3125–50K
4650–75K
3575–100K
28100–150K
4150K+
163 reports with mileage · 86 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports2 fire reports8 injury reports
Structure complaints
12 reportsLIGHTS WILL NOT GO OFF INSIDE CAR SAYS THERE IS A DOOR OPEN MAKES IT VERY UNSAFE FOR ME TO DRIVE RUNS DOWN CAR BATTERY ALARM GOES OFF EVERY NIGHT DUE TO THIS ELECTRICAL FLAW
VEHICLE CENTER CONSOLE (ALSO KNOWN BY FORD AS THE GLOVE BOX) LATCH ATTACHMENT, HAS SEPARATED PER FORD TECH AND WILL NO LONGER SECURE LATCH ASSEMBLY TO ARMREST ASSEMBLY. THIS FAILURE RESULTS IN THE CENTER CONSOLE LATCH NOT SECURING THE ARMREST. AS THE ARMREST IS NOT SECURED, IT ENTERS THE AREA AROUND THE DRIVER AND IMPEDES DRIVIN…
Read full complaint
VEHICLE CENTER CONSOLE (ALSO KNOWN BY FORD AS THE GLOVE BOX) LATCH ATTACHMENT, HAS SEPARATED PER FORD TECH AND WILL NO LONGER SECURE LATCH ASSEMBLY TO ARMREST ASSEMBLY. THIS FAILURE RESULTS IN THE CENTER CONSOLE LATCH NOT SECURING THE ARMREST. AS THE ARMREST IS NOT SECURED, IT ENTERS THE AREA AROUND THE DRIVER AND IMPEDES DRIVING, IMPACTING SAFETY WHILE VEHICLE IS IN MOTION. THIS IS A KNOWN FAILURE THAT HAS REPORTEDLY OCCURRED ON MULTIPLE VEHICLES UP TO ABOUT MODEL YEAR 2014 (FORD FLEX), REF NHTSA REPORT 11152858 FOR EXAMPLE. VEHICLE IS UNDER WARRANTY BY FORD AND REPAIR IS UNDER REVIEW CURRENTLY BY FORD, AS IT WAS INITIALLY DECLINED TO BE COVERED FOR UNEXPLAINED REASONS. PER DEALERSHIP, ENTIRE ARMREST ASSEMBLY REQUIRES REPLACEMENT AS THE ATTACHING POINTS ARE NON-REPAIRABLE. FAILURE MILEAGE WAS APPROXIMATELY 44,000 MILES. FAILURE WAS NOT CAUSED BY OWNER'S ACTIONS THAT WOULD BE CONSIDERED AS NEGLIGENT.
THE SENSOR ON MY PASSENGER DOOR HAS GONE OUT, CAUSING THE CAR TO BELIEVE THE DOOR IS OPEN EVEN WHEN IT IS NOT. THERE IS ALSO A CONSISTENT ISSUE WITH ONE SEATBELT, SOMETIMES IT WILL LOCK INTO PLACE WHEN NOT IN USE, AND SOMETIMES IT WILL NOT ALLOW ME TO BUCKLE IT.
CENTER CONSOLE LATCH DOES NOT MOVE GETS STUCK CAUSING THE DOOR TO BREAK OFF. VEHICLE WAS PARKED
WHEN TEMPERATURES ARE LESS THAN 40 DEGREES F, THE REAR HATCH WILL NOT LATCH WHEN CLOSED AFTER BEING OPENED. THE HATCH OPENS FINE, BUT IT WILL NOT LATCH UNLESS WARMED. I HAVE HAD IT CHECKED BY A FORD DEALER AND AN INDEPENDENT MECHANIC, BUT NO SOLUTION HAS BEEN FOUND. THIS MORNING, I HAD TO USE A HAIR DRYER TO WARM THE LATCH IN…
Read full complaint
WHEN TEMPERATURES ARE LESS THAN 40 DEGREES F, THE REAR HATCH WILL NOT LATCH WHEN CLOSED AFTER BEING OPENED. THE HATCH OPENS FINE, BUT IT WILL NOT LATCH UNLESS WARMED. I HAVE HAD IT CHECKED BY A FORD DEALER AND AN INDEPENDENT MECHANIC, BUT NO SOLUTION HAS BEEN FOUND. THIS MORNING, I HAD TO USE A HAIR DRYER TO WARM THE LATCH IN ORDER TO GET IT TO CLOSE. TEMPERATURES WERE AROUND FREEZING. THE VEHICLE IS ALWAYS STATIONARY WHEN I OPEN THE HATCH, AND I WILL NOT MOVE IT AS LONG AS THE HATCH WILL NOT LATCH.
FORD FLEX VIN [XXX] PASSENGER DOOR WHEN CLOSED TIGHT, SHOWS DOOR AJAR AND ALL DOORS WON'T LOCK. OCCASIONALLY, WHILE UNDERWAY, DOOR AJAR NOTICE WILL TURN OFF AND DOORS WILL LOCK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
FRONT PASSENGER DOOR OPEN LIGHT WILL REMAIN ON, DESPITE BEING SECURED CLOSED CAUSING INTERIOR LIGHTS TO REMAIN ON UNTIL 10 MPH. THIS IS A PROBLEM WHEN REVERSING AT NIGHT. WE DON'T REVERSE ABOVE 10MPH AND IT IS DIFFICULT TO SEE. IT IS ALSO A PROBLEM DRIVING IN TRAFFIC AT NIGHT. WE ALSO WORRY THE LIGHT WILL DRAIN OUR BATTERY.
POWER STEERING QUIT WHILE IN A PARKING LOT. I STOPPED, SHUT OFF THE VEHICLE, AND IT RESET. THE PASSENGER SIDE DOOR AJAR LIGHT CONSTANTLY STAYS ON, EVEN THOUGH THE DOOR IS SHUT. THIS WILL NOT ALLOW THE DOORS TO BE LOCKED, AND THE INTERIOR LIGHTS STAY ON UNTIL THE VEHICLE REACHES 15 MPH. IT HAS ALSO CAUSED THE LIGHTS TO STAY ON IN…
Read full complaint
POWER STEERING QUIT WHILE IN A PARKING LOT. I STOPPED, SHUT OFF THE VEHICLE, AND IT RESET. THE PASSENGER SIDE DOOR AJAR LIGHT CONSTANTLY STAYS ON, EVEN THOUGH THE DOOR IS SHUT. THIS WILL NOT ALLOW THE DOORS TO BE LOCKED, AND THE INTERIOR LIGHTS STAY ON UNTIL THE VEHICLE REACHES 15 MPH. IT HAS ALSO CAUSED THE LIGHTS TO STAY ON INSIDE THE CAR, DRAINING THE BATTERY.
OUR 2014 FORD FLEX INDICATES PASSENGER DOOR AJAR (RIGHT FRONT DOOR) ON THE INSTRUMENT PANEL, EVEN THOUGH THE DOOR APPEARS PROPERLY CLOSED. REPEATED ATTEMPTS (UP TO 50 OR MORE) ARE REQUIRED TO GET THE DOOR TO CLOSE WITH THE INDICATOR LIGHT TURNING OFF. ONCE THE DOOR IS CLOSED PROPERLY, WITH THE INDICATOR LIGHT OFF, THE DOOR AJA…
Read full complaint
OUR 2014 FORD FLEX INDICATES PASSENGER DOOR AJAR (RIGHT FRONT DOOR) ON THE INSTRUMENT PANEL, EVEN THOUGH THE DOOR APPEARS PROPERLY CLOSED. REPEATED ATTEMPTS (UP TO 50 OR MORE) ARE REQUIRED TO GET THE DOOR TO CLOSE WITH THE INDICATOR LIGHT TURNING OFF. ONCE THE DOOR IS CLOSED PROPERLY, WITH THE INDICATOR LIGHT OFF, THE DOOR AJAR LIGHT MAY TURN ON AGAIN WHILE THE CAR IS OFF AND NOT MOVING, CAUSING THE ALARM TO SOUND. IN ADDITION, WHILE DRIVING, THE PASSENGER DOOR AJAR LIGHT MAY SUDDENLY TURN ON, CAUSING THE NEED TO PULL OVER TO INSURE THE DOOR IS CLOSED PROPERLY. THIS HAS HAPPENED ON TURNS AND ON STRAIGHT ROADS. THIS IS A SAFETY HAZARD, AS PARKING ALONG THE SIDE OF A HIGHWAY OR ROADWAY CAN CAUSE A DANGEROUS SITUATION NOT ONLY FOR THE PASSENGER RIDING IN THE FRONT SEAT BUT ALSO FOR ALL PASSENGERS IN THE CAR. WE ARE CONCERNED THAT AT SOME POINT THE DOOR LATCH MAY FAIL AND THE DOOR MAY OPEN WHILE MOVING. THIS ISSUE OCCURS EACH TIME THE DOOR IS OPENED AND INTERMITTENTLY WHILE MOVING OR PARKED. WE HAVE DISCUSSED THIS ISSUE WITH THE LOCAL FORD SERVICE DEPARTMENT PRIOR TO THE SEPTEMBER EXPANSION OF THE DOOR LATCH RECALL AND THEY INDICATED THAT OUR VEHICLE IS NOT COVERED BY THE CURRENT RECALLS EVEN THOUGH THE REPRESENTATIVE WAS VERY AWARE OF THE PROBLEM OCCURRING. HIS INDICATION WAS THAT IT "MOSTLY HAPPENED ON THE DRIVER DOOR". WE BELIEVE THAT OUR VEHICLE SHOULD ALSO BE COVERED BY THE RECALL.
Official recalls
420V072000 · Suspension:rear
Feb 10, 2020
Ford Motor Company (Ford) is recalling certain 2013-2018 Lincoln MKT and Ford Flex and Taurus vehicles with the Police Interceptor or SHO Performance Pack. The rear suspension toe links may fracture due to stress on the rear suspension.
Consequence & remedy
Consequence: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, free of charge. Remedy parts are not currently available. Owners were notified about the recall on March 3, 2020. A second notice will be mailed when remedy parts become available, which is currently expected to be the end of September 2020. The recall began October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332 or Lincoln customer service at 1-800-521-4140. Ford's number for this recall is 20S04.
16V621000 · Fuel System, Gasoline:delivery:fuel Pump
Aug 25, 2016
Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Taurus, Ford Flex, Lincoln MKS and Lincoln MKT vehicles equipped with 3.5L GTDI Ecoboost engines and 2013-2015 Ford Taurus Police Interceptor vehicles. A component within the fuel pump electric module (PEM) may overheat causing a loss of electrical power to the fuel pump.
Consequence & remedy
Consequence: A loss of power to the fuel pump will cause the engine to stall or prevent the vehicle from starting, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the fuel PEM part number and replace the fuel PEM, as necessary, free of charge. The recall began on December 1, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S31.
14V710000 · Seats
Nov 7, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 Ford F-150 and Flex vehicles manufactured March 1, 2014, to May 31, 2014. The affected vehicles were manufactured with a reduced clearance between the seat frame and the seat track assembly. This can cause the Occupant Classification System (OCS) to inaccurately register passenger weight and improperly suppress the passenger front airbag when the passenger seat is occupied by an adult passenger. Thus, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) No. 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Improper suppression of the passenger airbag increases the risk of an injury to the seat occupant in the event of a crash necessitating deployment of the front passenger airbag.
Remedy: Ford will notify owners, and dealers will widen the gap between the seat frame and seat track assembly and recalibrate the seat OCS, free of charge. The recall began November 25, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C10.
14V393000 · Power Train:axle Assembly:axle Shaft
Jul 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2012-2014 Ford Edge and Lincoln MKX vehicles manufactured September 2, 2010, to November 30, 2013; 2013-2014 Ford Taurus and Lincoln MKS vehicles manufactured August 25, 2011, to November 30, 2013; and 2013-2014 Ford Flex and Lincoln MKT vehicles manufactured September 12, 2011, to November 30, 2013. In the affected vehicles, the halfshaft retention circlip may not have been properly installed, and as a result, the halfshaft may move outward and disengage from the linkshaft while driving and without prior warning.
Consequence & remedy
Consequence: If the halfshaft and linkshaft become disengaged while driving, power will no longer be transmitted to the wheels, increasing the risk of a vehicle crash. Additionally, if the parking brake is not applied before exiting the vehicle, the vehicle may roll away despite the transmission being placed in 'Park', increasing the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the vehicles to make sure that the halfshaft is properly retained. If it is not, dealers will replace the linkshaft and also replace the halfshaft if it shows evidence of spline damage, free of charge. The recall began on August 4, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S10.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.