2013 Ford Flex

What component or system failed or malfunctioned, and is it available for inspection upon request? INTERNAL WATER PUMP/ TIMING CHAINS/ VVT SOLENOIDS/ CAM PHASERS/ CAM SENSORS/ RELATED SEALS How was your safety or the safety of others put at risk? ENGINE FAILURE - SUDDEN STOP OF VEHICLE Has the problem been reproduced or confirmed by a dealer or independent service center? YES, IS AWARE AND HAS ACKNOWLEDGED VIA SERVICE AND TECH BULLETINS THAT THIS IS A KNOWN AND REPEATED ISSUE. ISSUE IS KNOWN AND COMMON WITH ALL 3.7L AND 3.5L FORD ENGINES. MANUFACTURER HAS HAD PETTY AND CLASS ACTION SUITS RELATED TO THIS FAILURE AND IS NOT TAKING ANY ACTION TO REMEDY ASIDE FROM A "EXTENDED WARRANTY" FOR CERTIAN COUNTRIES BUT SAID WARRANTY DOES NOT HELP THOSE WHO PURCHASED VEHICLES USED AND HAVE NO VEHICLE HISTORY TO SEE IF THE "SERVICE INTERVALS" WERE MET LEAVING THOUSANDS OF OWNERS WITH REPAIR BILLS THAT COST AT MINIMUM OVER FOUR THOUSAND DOLLARS. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? YES. MULTIPLE TECHNICIANS ON MY VEHICLE AD WELL AS THOUSANDS OF COMPLAINTS ACROSS THE WORLD. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO LAMPS. ONLY POSSIBLE WAY YOU CAN EVEN TELL IS BY THE TIME ITS TOO LATE AND THE COOLANT AND OIL MIX RESULTING IN MILKY LIKE MIXTURE ON DIPSTICK OR IN OIL PAN OR ENGINE FAILURE.

What component or system failed or malfunctioned, and is it available for inspection upon request? MULTIPLE DRIVER AID FUNCATIONS IN-OP. DRIVER DOOR LOCKS WILL NOT LOCK OR UNLOCK, DRIVER DOOR LOCK AND UNLOCK SWITCH WILL NOT OPERATE ANY LOCKS, PASSENGER DOOR MIRROR WILL NOT MOVE, SEAT MEMORY WILL NOT SAVE, REAR VIEW MIRROR WILL NOT AUTO DIM AND THERE IS NO MANUAL OPTION TO ADJUST THE MIRROR RESULTING IN IMPACTED NIGHT VISABLITY, REAR VIEW CAMERA DOES NOT DISPLAY ON SCREEN BUT WILL BEEP WHEN CLOSE TO AN OBJECT. NOT CODES OR DASH WARNINGS DISPLAYED TO STORED. How was your safety or the safety of others put at risk? IMPACTED VISIBLY WHILE DRIVING. UNABLE TO ADUST PASSENGER MIRROR TO SEE BLINK SPOT OR ALONG PASSENGER SIDE OF VEHICLE. UNABLE TO LOCK OR UNLOCK DRIVER DOOR, IF LOCKED ITS NOT ALLOWING ME TO ENTER THE VEHICLE AND HAVE TO ENTER VIA PASSENGER DOOR. AUTO DIM IMPACTS VISABLITY WITH DRIVING AT NIGHT. REAR BACK UP CAMERA IN-OP IS DAMGEROUS IN NUMEROUS ASPECTS. Has the problem been reproduced or confirmed by a dealer or independent service center? PROBLEM IS CONSTANT. NOT TAKING TO A DEALER DUE TO RIDICULOUS PRICES AND DIAG FEES. I'M A TECH AND TRIED TO DIAGNOSE ISSUES WITH NO ANSWERS. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NOT YET. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? UNKNOWN. PURCHASED PRIVATE PARTY WITH ISSUES (05/01/2026). LOOKED AT 3 OTHER FORD FLEXS FROM THIS GENERATION THAT ALL HAD THE SAME ISSUES WHEN LOOKING TO PURCHASE A VEHICLE AND NO ONE HAD A SOLUTION FOR IT.

The contact owns a 2013 Ford Flex. The contact stated that while driving at an undisclosed speed, the steering wheel seized, with the power steering fault warning light illuminated. The vehicle was restarted; however, the failure reoccurred, and the steering wheel became difficult to turn. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the steering rack and steering angle and torque sensors had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure, and several cases were filed. The failure mileage was approximately 140,000.

The contact owns a 2013 Ford Flex. The vehicle was taken to a dealer for a recall repair. The contact stated the dealer declined to perform the recall repair because the vehicle was unable to be started. The contact received notification of NHTSA Campaign Number: 20V072000 (SUSPENSION). The vehicle was currently at the dealer. The vehicle was not repaired. The manufacturer was not made aware of the issue. The failure mileage was 127,000.

On Sunday, February 22, 2026, I was driving my 2013 Ford Flex with the driver’s seat heater activated. After a period of use, I began to notice an unusual electrical burning smell inside the vehicle. There were no dashboard warning lights or system alerts. I turned the seat heater off immediately once I detected the smell. I did not initially notice an injury at that time. The following day, I experienced significant pain and discovered burns on my buttocks in the area consistent with seat contact. I sought medical evaluation three days later and was diagnosed with second- to third-degree burns. Prescription treatment was provided. The vehicle has not yet been inspected for the cause of the overheating or odor. Based on the location and pattern of injury, and the timing of the electrical smell while the heated seat was activated, the burn appears to have resulted from a malfunction of the seat heating element.

While driving, the power steering warning light illuminated and steering assist was lost. The steering became extremely hard, especially at low speeds. The vehicle makes grinding/whining noises when turning, and the car vibrates while in Drive. This creates a serious safety concern, especially during turns and parking maneuvers. Issue appears to be electric power steering (EPAS) failure.

Power steering. While I was driving in my neighborhood the power steering went out and I could not make a turn. It locked up while driving. I could have got into a head on collision/accident becasue the road turns. Yes, I reported it to Ford and they told me my flex did not have a recall despite the ford website stating that some 2013 ford flex are affected. The description of 15s18 sterring recall matches my same issue and it poses a serious safety hazard. Yes, i took it to a mechanic at an auto shop and her is telling me that he can't fix recalls. At the time of the accident, i got No pre warning just the message that states: "Steering Lock Malfunction Service Now: The steering lock system has detected a condition that requires service." This happened on or around 11/23/25. I am requesting that Ford pay for my power steering to be fixed.

THE REAR- VIEW BACK UP CAMERA DOES NOT OPERATE PROPERLY WHEN VEHICLE IS PUT IN REVERSE. IT WORKS INTEMITTEDLY. SOMETIMES IMAGE IS BLACK, SOMETIMES UPSIDE DOWN, SOMETIME, WORKS PROPERLY, SOMETIME IMAGE FREEZES, AND SOMETIMES SHOWS ERROR CAMERA NOT WORKING CONTACT DEALERSHIP. REDUCES THE THE ABILITY TO SEE WHAT IS BEHIND THE VEHICLE WHEN BACKIN UP AND INCREASES THE RISK OF CRASH.