2013 Ford Flex

FRONT PASSENGER DOOR SENSOR THINKS THAT THE DOOR IS OPEN WHEN IT IS CLOSED. THE SENSOR HAS ALREADY BEEN REPLACED ON THE DRIVERS SIDE REAR DOOR. THIS APPEARS TO BE A COMMON PROBLEM ON THE 2013 FORD FLEX AS EVIDENT WHEN SEARCHING FOR ANSWERS. THIS SENSOR CAUSES THE LIGHTS TO REMAIN ON AND DRAIN THE BATTERY. IT IS ALSO AFFECTING THE CAR ALARM.

FRONT SEAT TRACKS WEAR PREMATURELY DUE TO POORLY DESIGNED TEETH. AS A RESULT THE SEAT BECOMES 'WOBBLY' CAUSING IT TO ROCK FORWARDS AND BACK WHICH COULD CAUSE SERIOUS INJURY IN AN ACCIDENT WHERE THE SEAT SHOULD REMAIN FIRMLY IN PLACE. MANY PEOPLE ARE EXPERIENCING THIS ISSUE ACROSS A WIDE RANGE OF FORD PRODUCTS VS SPECIFICALLY WITH ONE PARTICULAR VEHICLE.

TL* THE CONTACT OWNS A 2013 FORD FLEX. WHEN THE VEHICLE WAS STARTED, THE POWER STEERING ASSIST FAILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS ABLE TO RETRIEVE THE FOLLOWING DIAGNOSTIC TROUBLE CODES: U3000-49 (CONTROL MODULE INTERNAL ELECTRONIC FAILURE), U3000-72 (POWER STEERING CONTROL MODULE FAILURE), U0401 (INVALID DATA RECEIVED FROM ECM/PCM), U0401-72 (LOST COMMUNICATION WITH BCM), AND B1215 (BODY CONTROL MODULE FAILURE). THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TAKEN TO BUTCH OUSTALET FORD (LOCATED AT 9274 US 49, GULFPORT, MS 39503, (228) 863-5525) FOR CONSULTATION AND THE CONTACT ASKED WHAT PARTS WERE NECESSARY TO HAVE THE VEHICLE REPAIRED. THE CONTACT WAS REFERRED TO THE PARTS DEPARTMENT. THE CONTACT WAS INFORMED THAT THE STEERING GEAR ASSEMBLY NEEDED TO BE REPLACED (PN: EG12*3504*H). THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.

THE EPASS ELECTRONIC DRIVE BY WIRE STEERING SYSTEM FAILED AFTER 60K MILES. THIS WAS THE SAME EPASS SYSTEM IN THE OTHER 2013 FORD FLEX THAT WERE PART OF THE RECALL FOR THE EPASS FAILURE. WHEN THE EPASS SYSTEM FAILED THE VEHICLE LOST POWER STEERING AND COULDN'T BE DRIVEN. I SPENT $2,500 ON THE NEW PARTS AND MY CAR WAS IN THE SHOP FOR A WEEK.

2013 FORD FLEX WITH ~130,000 MILES. SLOW RIGHT HAND TURN INTO PARKING LOT, COMPLETE LOSS OF POWER STEERING IN COMBINATION WITH "POWER STEERING FAILURE" AND "CHECK ADVANCETRAC" WARNING LIGHTS. RESEARCH INDICATES A RECALL (NHTSA ID: 15V340000,FORD 15S18, NHTSA) FOR MY VEHICLE BUILT BETWEEN 9/7/2010 AND 2/28/2012. AS MY BUILD DATE WAS 12/12 IT DOES NOT FALL UNDER THE RECALL. I HAVE CONFIRMED THIS WITH MY PERSONAL MECHANIC, A LOCAL FORD DEALERSHIP (VARSITY FORD, ANN ARBOR MI) AS WELL AS WITH FORD CUSTOMER SERVICE. SYMPTOMS OF MY FAILURE ARE IDENTICAL TO THOSE DESCRIBED IN THE RECALL. MECHANIC FOLLOWED TECHNICIAN INSTRUCTIONS FOR THE RECALL, BY FLASHING/UPDATING PSCM MODULE SOFTWARE. STEERING APPEARED TO BE WORKING NORMAL. SUBSEQUENT WARNING LIGHT ~3DAYS LATER OF "SERVICE POWER STEERING" APPEARED, BUT STEERING WAS STILL FUNCTIONING. MY CONCERN IS THAT THE SOFTWARE UPGRADE IS "BANDAID", IF COMPLETE LOSS OF STEERING OCCURS IN THE FUTURE, THE SITUATION MIGHT BE DIFFERENT RESULTING AN ACCIDENT AND/OR INJURY. IT APPEARS THE STEERING PROBLEM CONTINUED ON CARS BUILT AFTER FEB 2012, I HAVE INFORMED FORD CUSTOMER SERVICE AND COMPLAINT HAS BEEN "ESCALATED" TO FORD REGIONAL CUSTOMER SERVICE MANAGER. I FEEL THAT THE BUILD DATE FOR COVERED REPAIRS SHOULD BE EXTENDED.

DRIVING OUR FORD FLEX WHEN THE POWER STEERING INTERMITTENTLY GAVE OUT. IT BECAME HARD TO STEER. LUCKILY IT WAS AT LOW SPEED PULLING INTO A PARKING LOT. AS A RESULT I HIT A LOW PLANTER AND SUFFERED BODY DAMAGE. NOW THE STEERING JUST GROANS WHEN I TURN THE WHEEL. DEALER STATES NOTHING IS WRONG AND THE NOISE IS NORMAL. IN DOING MY RESEARCH I HAVE NOTED THAT FORD ADDRESSED THIS PROBLEM IN THESE VEHICLES BY A RECALL. MY VEHICLE WAS JUST OUT OF RANGE AND NOW MY LOCAL FORD DEALER IS TELLING ME THAT THEY CAN NOT DO ANYTHING FOR ME. I CANNOT BELIEVE THAT FORD CAN ARBITRARILY PICK A DATE AND CUT OFF WHEN THERE ARE OBVIOUSLY STILL PROBLEMS WITH THIS STEERING SYSTEM AND BELIEVE ALL 2013 FLEX'S USED THE SAME PARTS.

HAVE HAD MULTIPLE DOOR LATCH/SENSOR ASSEMBLIES FAIL WHICH RESULTS IN: DOOR AJAR MESSAGE CONSTANTLY BEING GIVEN. THIS RESULTS IN DOME LIGHTING STAYING ON WHILE DOOR IS CLOSED AND DEPLETING THE BATTERY CAUSING AN UNMONITORED ELECTRICAL USE. IT ALSO IS A DISTRACTION TO THE DRIVER DUE TO BOTH THE WARNING LIGHT BUT ALSO THE AUDIO ALERT THAT PLAYS WHEN UNDER A CERTAIN SPEED TELLING YOU TO PARK AND CLOSE THE DOOR. THIS TAKES AWAY FROM OTHER POSSIBLE ALERTS THE CARS COULD GIVE YOU DUE TO OVERLY ALERTING THE DRIVER.

TL* THE CONTACT OWNS A 2013 FORD FLEX. THE CONTACT STATED THAT ALL OF THE SECOND ROW SEAT BELTS FAILED TO RETRACT, LATCH, AND UNLATCH. THE VEHICLE WAS TAKEN TO PERRY FORD OF POWAY (12740 POWAY RD, POWAY, CA 92064, (858) 748-1400), BUT WAS NOT DIAGNOSED. THE SEAT BELTS WERE REPLACED FIVE TIMES; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT UNDER WARRANTY. IN ADDITION, THE SECOND ROW DRIVER'S SIDE SEAT BELT JAMMED AND UNJAMMED INDEPENDENTLY. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 86,000. *LN CONSUMER STATED FORD EVENTUALLY BOUGHT BACK MY CAR UNDER THE LEMON LAW BUT NEVER SENT ME A PRE-AID MAIL PACKAGE TO SHIP BACK THE DAMAGED AIRBAG-SEATBELT COMPONENTS I HAD REPLACED FROM MY CAR THE YEAR PRIOR. *JB *BF *JB