NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
59 reportsClear category filterMileage unknown · Jan 23, 2024
Fuel/propulsion System
There seems to be a fuel leak on my vehicle's fuel tank. When the tank is half full and more there is a noticable fuel smell around my car and fuel dripping under my car. When the fuel is less than half full, the fuel seems to stop leaking. I believe the seam in the gas tank is leaking. I have heard of other people with my same …
Read full complaint
There seems to be a fuel leak on my vehicle's fuel tank. When the tank is half full and more there is a noticable fuel smell around my car and fuel dripping under my car. When the fuel is less than half full, the fuel seems to stop leaking. I believe the seam in the gas tank is leaking. I have heard of other people with my same year and vehicle having the same issues so I figured it was worth reporting.
NHTSA ODI #11567204
Mileage unknown · May 24, 2023
Electrical SystemFuel/propulsion SystemUnknown Or Other
Have difficulty fueling vehicle. “Fuel fill inlet” warning stays on dash. Strong fuel mixture smell in cabin. Fuel will overspill if you try to pump gas at full force. Smells like fuel is leaking. Concerned about possible explosion. Many other drivers having the same issues. Strange clicking sounds from front end.
NHTSA ODI #11523595
36,000 miles · Feb 14, 2020
Fuel/propulsion System
THIRD TIME HAVING THE FUEL PUMP REPLACED . PUMP FAILS EVERY 20-30K MILES. CAR WILL STOP RUNNING WHILE DRIVING ON ROADWAYS, UNABLE TO RESTART VEHICLE. HAD TO PULL OVER TO SIDE OF ROAD AND WAIT FOR TOW. 1ST TIME 36,000 MILES 2ND 53,000, 3RD 90,000. ALL REPAIRS WERE PERFORMED BY FORD SERVICE CENTER
NHTSA ODI #11309111
Mileage unknown · Dec 11, 2019
Exterior LightingFuel/propulsion System
NOW REPLACING THE FUEL MODUAL SENSOR FOR THE 3RD TIME IN 5YRS. THIS IS A KNOWN ISSUE FOR OTHER FORD VEHICLES. CAR WILL NOT START AND NEEDS TO BE TOWED EACH TIME. FRONT PASSENGER DOOR SENSOR DOESN'T WORK AND INTERIOR LIGHT REMAINS ON UNTIL VEHICLE REACHES 10MPH. INTERIOR LIGHT WILL NOT TURN OFF AND BATTERY DRAINS.
NHTSA ODI #11288445
93,000 miles · Dec 3, 2019
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2013 FORD FLEX. WHILE DRIVING 30 MPH ON THE HIGHWAY, THE VEHICLE LOST POWER. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND HAD IT TOWED BACK TO HER HOME. THE CONTACT ATTEMPTED TO FILL UP THE FUEL TANK AND NOTICED FUEL LEAKING UNDERN…
Read full complaint
TL* THE CONTACT OWNS A 2013 FORD FLEX. WHILE DRIVING 30 MPH ON THE HIGHWAY, THE VEHICLE LOST POWER. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND HAD IT TOWED BACK TO HER HOME. THE CONTACT ATTEMPTED TO FILL UP THE FUEL TANK AND NOTICED FUEL LEAKING UNDERNEATH THE VEHICLE. THE FUEL INLET WARNING INDICATOR ILLUMINATED WHEN THE CONTACT ATTEMPTED TO RESTART THE VEHICLE ON THE SIDE OF THE HIGHWAY. RON CARTER FORD (8837 3005, FM 528 RD, ALVIN, TX 77511, (281) 715-7318) WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE CONTACT JUST BOUGHT THE VEHICLE USED THREE MONTHS AGO. THE MANUFACTURER ALSO STATED THAT THERE WAS NO RECALL. THE FAILURE MILEAGE WAS 93,000.
NHTSA ODI #11286601
50,000 miles · Nov 15, 2019
Fuel/propulsion System
I TRIED STARTING THE CAR IT WOULD START THEN SPUTTER OUT VERY SHORTLY AFTER, AFTER HAVING THIS OCCUR 3 TIMES THE CAR WOULD NOT TURN OVER AT ALL AND HAD TO GET A TOW. I HAD IT TOWED TO THE DEALERSHIP, IT SAT FOR A DAY THE DEALERSHIP STATED THE CAR STARTED UP AND THEY WERE ABLE TO MOVE THE CAR WITHOUT AN ISSUE. THEY PRICED THE W…
Read full complaint
I TRIED STARTING THE CAR IT WOULD START THEN SPUTTER OUT VERY SHORTLY AFTER, AFTER HAVING THIS OCCUR 3 TIMES THE CAR WOULD NOT TURN OVER AT ALL AND HAD TO GET A TOW. I HAD IT TOWED TO THE DEALERSHIP, IT SAT FOR A DAY THE DEALERSHIP STATED THE CAR STARTED UP AND THEY WERE ABLE TO MOVE THE CAR WITHOUT AN ISSUE. THEY PRICED THE WORK AT $700+ TO BE COMPLETED. THE RECALL NUMBER 16V621000 (OR 16S31) DID NOT SHOW THOUGH IT IS THE SAME EXACT ISSUE HE DESCRIBED.
NHTSA ODI #11280259
70,000 miles · Oct 8, 2019
Fuel/propulsion SystemSeat BeltsSeats
FORD HAS ALREADY RECALLED THE FUEL PUMP REGULATOR MODULE ON CERTAIN VEHICLES AND MINE WAS NOT INCLUDED. FUEL PUMP REGULATOR MODULE LEFT MR AND DISABLED CHILE STRANDED ON HIGHWAY. NO HELP FROM FORD. PASSENGER DOOR SENSOR OUT, LIGHTS WON'T GO OFF INSIDE CAB UNTIL YOU REACH 10 MPH. IMPOSSIBLE TO SEE TO BACK UP AT NIGHT OR TO SEE …
Read full complaint
FORD HAS ALREADY RECALLED THE FUEL PUMP REGULATOR MODULE ON CERTAIN VEHICLES AND MINE WAS NOT INCLUDED. FUEL PUMP REGULATOR MODULE LEFT MR AND DISABLED CHILE STRANDED ON HIGHWAY. NO HELP FROM FORD. PASSENGER DOOR SENSOR OUT, LIGHTS WON'T GO OFF INSIDE CAB UNTIL YOU REACH 10 MPH. IMPOSSIBLE TO SEE TO BACK UP AT NIGHT OR TO SEE OUT OF VEHICLE TO DRIVE. DRIVER SEAT WONT MOVE FORWARD OR BACKWARD IMPOSSIBLE TO GET IT TO MOVE. 2ND ROW DRIVER SIDE SEATBELT BROKEN FORD WONT REPAIR.
NHTSA ODI #11267006
Mileage unknown · Sep 30, 2019
Electronic Stability Control (esc)EngineFuel/propulsion System
THE ENGINE STALLS WITHOUT WARNING WHILE DRIVING, EVEN ON HIGHWAY OR INTERSECTION OR FILLING GAS AND THE VEHICLE DON'T RESTART RIGHT AWAY ' ENGINE LIGHTS MISFIRE. AND ENGINE THROTTLE BODY SENSORS/OXYGEN SENSORS BROKE. HAVE FIXED WITHOUT RESOLVE TO ISSUES (RECURRENT). ON MULTIPLE DATES AND MULTIPLE TIMES A DAY.
NHTSA ODI #11258971
1,000 miles · Jul 29, 2019
EngineFuel/propulsion SystemUnknown Or Other
MY 2013 FORD FLEX HAS HAD THE SAME ISSUE AS THE FORD EXPLORER. I PURCHASED THE VEHICLE NEW FROM SANDERSON FORD IN GLENDALE AZ AND NOTICED AFTER A HARD ACCELERATION WITH THE AIR CONDITIONING SET TO RECIRCULATE. THE DEALER STATED THEY COULD NOT RECREATE THE ISSUE AND I TOOK IT BACK HOME. YEARS PAST AND IT WAS TAKEN BACK AGAIN AND …
Read full complaint
MY 2013 FORD FLEX HAS HAD THE SAME ISSUE AS THE FORD EXPLORER. I PURCHASED THE VEHICLE NEW FROM SANDERSON FORD IN GLENDALE AZ AND NOTICED AFTER A HARD ACCELERATION WITH THE AIR CONDITIONING SET TO RECIRCULATE. THE DEALER STATED THEY COULD NOT RECREATE THE ISSUE AND I TOOK IT BACK HOME. YEARS PAST AND IT WAS TAKEN BACK AGAIN AND SAME THING THEY COULD NOT RE-CREATE DUE TO THERE WAS NO MECHANIC THAT COULD DRIVE IT AT HIGHER SPEEDS. I INCLUDED A FORD FLEX FORUM THAT EXPLAINS THE ISSUE AND SHOWS THAT IT DOES EXIST OUT THERE. PLEASE ADD THE FORD FLEX TO THE "RECALL" FIX OF THESE ISSUES. IN THE FEDERAL REGULATIONS UNDER 49 CFR 393.83 THE EXHAUST SHALL NOT LEAK / DISCHARGE SO THAT IT ENTERS A SLEEPER COMPARTMENT OF A TRUCK TRACTOR. WE HAVE THE SAME THING HERE THE EXHAUST LEAKS INTO THE COMPARTMENT OF WHERE THE DRIVER IS AT. HTTPS://WWW.FORDFLEX.NET/FORUMS/VIEWTOPIC.PHP?T=17923
NHTSA ODI #11240399
75,000 miles · Jul 17, 2019
Fuel/propulsion System
THERE WAS A RECALL ON THE FUEL PUMP FOR MY MODEL YEAR BUT NOT MY VIN. I HAD THE SAME STALLING ISSUE. IT WAD STATIONARY WHEN IT HAPPENED, THE FINAL TIME, WAS IN A PARKING LOT AND JUST WOULDNT START.
NHTSA ODI #11232694
Official recalls
6Feb 10, 2020
Ford Motor Company (Ford) is recalling certain 2013-2018 Lincoln MKT and Ford Flex and Taurus vehicles with the Police Interceptor or SHO Performance Pack. The rear suspension toe links may fracture due to stress on the rear suspension.
Consequence & remedy
Consequence: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, free of charge. Remedy parts are not currently available. Owners were notified about the recall on March 3, 2020. A second notice will be mailed when remedy parts become available, which is currently expected to be the end of September 2020. The recall began October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332 or Lincoln customer service at 1-800-521-4140. Ford's number for this recall is 20S04.
Aug 25, 2016
Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Taurus, Ford Flex, Lincoln MKS and Lincoln MKT vehicles equipped with 3.5L GTDI Ecoboost engines and 2013-2015 Ford Taurus Police Interceptor vehicles. A component within the fuel pump electric module (PEM) may overheat causing a loss of electrical power to the fuel pump.
Consequence & remedy
Consequence: A loss of power to the fuel pump will cause the engine to stall or prevent the vehicle from starting, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the fuel PEM part number and replace the fuel PEM, as necessary, free of charge. The recall began on December 1, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S31.
Dec 2, 2015
Ford Motor Company (Ford) is recalling certain model year 2013 Explorer, Explorer Police Utility, Taurus, Taurus Police Interceptor, Flex, Lincoln MKS, and Lincoln MKT vehicles. In the affected vehicles, the fuel delivery module may crack, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on December 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 13S04-S1.
Jun 2, 2015
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.
Jul 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2012-2014 Ford Edge and Lincoln MKX vehicles manufactured September 2, 2010, to November 30, 2013; 2013-2014 Ford Taurus and Lincoln MKS vehicles manufactured August 25, 2011, to November 30, 2013; and 2013-2014 Ford Flex and Lincoln MKT vehicles manufactured September 12, 2011, to November 30, 2013. In the affected vehicles, the halfshaft retention circlip may not have been properly installed, and as a result, the halfshaft may move outward and disengage from the linkshaft while driving and without prior warning.
Consequence & remedy
Consequence: If the halfshaft and linkshaft become disengaged while driving, power will no longer be transmitted to the wheels, increasing the risk of a vehicle crash. Additionally, if the parking brake is not applied before exiting the vehicle, the vehicle may roll away despite the transmission being placed in 'Park', increasing the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the vehicles to make sure that the halfshaft is properly retained. If it is not, dealers will replace the linkshaft and also replace the halfshaft if it shows evidence of spline damage, free of charge. The recall began on August 4, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S10.
May 31, 2013
Ford is recalling certain model year 2013 Explorer, Taurus, Flex, Fusion, Police Interceptor Sedan and Police Interceptor Utility vehicles; and certain model year 2013 Lincoln MKS, MKT, and MKZ vehicles. In the affected vehicles, the fuel delivery module may develop a crack, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on July 20, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332. Ford's recall campaign number is 13S04.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration