I was driving around 55 and suddenly lost control and fish tailed to the right, then to the left over the center line, then back to the right. Luckily no other vehicles on the road. The rear driver side toe link broke. I discovered there's a recall for this exact problem with the exact possible worst case scenario that I went t…
Read full complaint
I was driving around 55 and suddenly lost control and fish tailed to the right, then to the left over the center line, then back to the right. Luckily no other vehicles on the road. The rear driver side toe link broke. I discovered there's a recall for this exact problem with the exact possible worst case scenario that I went through. [FORD RECALL CODE: 2oSo4] This recall includes "2013-18 Ford Flex and Lincoln MKT vehicles built at Oakville Assembly Plant, Sept. 12, 2011, to June 1, 2017" My vehicle was manufactured at the same plant in 02/12 but for some reason is not qualified. I think my 2012 model needs to be included in this recall, obviously. I talked with Ford Dealer and Ford Customer Service and they said they would pass this info to NHTSA. I had both links replaced at a local mechanic and hope to get reimbursed in the future.
NHTSA ODI #11588893
Mileage unknown · Dec 11, 2021
Suspension
I am writing you in regards to NHTSA # 20V-072, Ford Recall # 20S04. I own a 2012 Ford Flex. It was not included in this recall. The recall included Ford Flex years 2013 through 2018. Though my SUV wasn’t included in the recall for the defective toe links, my SUV’s toe links were found to be defective on June 1, 2015 at Tayl…
Read full complaint
I am writing you in regards to NHTSA # 20V-072, Ford Recall # 20S04. I own a 2012 Ford Flex. It was not included in this recall. The recall included Ford Flex years 2013 through 2018. Though my SUV wasn’t included in the recall for the defective toe links, my SUV’s toe links were found to be defective on June 1, 2015 at Taylor Ford in Michigan. At that time my vehicle had 56,071 miles on it and was still under warranty. My toe links were replaced with part 5A972 which is the same part that is now the cause of Ford Recall 20S04. On 11-6-21 we took my SUV, with 96,930 miles, into Belle Tire for brake work and tire rotation. At that time we were told that the toe links were defective and needed to be replaced and that my tires were bad and needed replacement too. The tires and toe links had been replaced at Ford 40,859 miles prior! At this point we investigated and found the recall for the toe links. We had never been notified by Ford even though part 5A972 which was later found to be defective, had been put on our SUV in 2015. A Ford Part Employee has confirmed that this part is defective. The defective part is a welded part and the part Ford is using to replace this part is a forged part. Defective toe links are very dangerous. The defect can cause loss of steering/control of SUV. I have contacted multiple levels of Ford Customer Care with no response and no assistance offered. My SUV is currently at a Ford Service Center waiting for Ford to respond so that my SUV can be repaired. I'm unable to drive while waiting because this is very dangerous. It is also very expensive to repair.
NHTSA ODI #11443458
102,407 miles · Apr 8, 2021
Suspension
MY VEHICLE WAS MANUFACTURED JUST A FEW MONTHS SHY OF A RECALL FOR BAD TOE LINKS IN THIS MAKE AND MODEL. I HAVE HAD MY CAR DIAGNOSED WITH HAVING BAD TOE LINKS AND WOULD LIKE TO SEE ABOUT GETTING MY VEHICLE INCLUDED IN THE RECALL SINCE IT WAS MANUFACTURED AROUND THE SAME TIME AS THE VEHICLES INCLUDED IN THE RECALL.
Ford Motor Company (Ford) is recalling certain model year 2009-2012 Ford Flex, 2008 and 2010-2012 Ford Taurus, 2008-2009 Ford Taurus X, 2008 Mercury Sable, 2009 and 2011 Lincoln MKS vehicles. The driver frontal air bag may improperly inflate during second-stage deployment in the event of a high speed crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An improperly inflated air bag increases the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the driver's frontal air bag module, as necessary, free of charge. The recall is expected to begin on June 13, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C06.
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2012 Ford Flex Problems, Complaints & Recalls | Skip That Year
Illustration