IllustrationEMPLOYEE WAS UTILIZING SIDE STEP TO OBTAIN AN ITEM FROM THE TOOLBOX WHEN THE PLASTIC PORTION OF THE STEP BROKE AWAY, CAUSING THE EMPLOYEE TO LOSE BALANCE AND FALL TO THE GROUND. THE VEHICLE WAS STATIONARY.
2019 Ford F-250 Sd
Owner reports · Recalls · Investigations
More warning signs than most F-250 Sd years
Owner complaints for the 2019 Ford F-250 Sd are substantially higher than the model-year median of 89.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-250 Sd years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
3710–25K
18525–50K
2350–75K
1875–100K
15100–150K
10150K+
622 reports with mileage · 542 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 776 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 678 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Wheels. Review the 87 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports11 fire reports12 injury reports
What owners actually said
1,164 reportsAT 19,000 MILES MY TRUCK WOULD SHAKE IF YOU HIT ANY KIND OF BUMP OVER 45 MPH. AT LOWER SPEEDS IT FEELS 35MPH AND LOWER LIKE THE WHOLE FRONT END RATTLES. TOOK I TO THE DEALER AND THEY SAID IT WAS JUST THE STEERING STABILIZER AND THAT ALL OTHER JOINT AND BUSHINGS WERE TIGHT AND OK. 3,000 MILES LATER I AM ON A TRIP TO SPOKANE WA. T…
Read full complaint
AT 19,000 MILES MY TRUCK WOULD SHAKE IF YOU HIT ANY KIND OF BUMP OVER 45 MPH. AT LOWER SPEEDS IT FEELS 35MPH AND LOWER LIKE THE WHOLE FRONT END RATTLES. TOOK I TO THE DEALER AND THEY SAID IT WAS JUST THE STEERING STABILIZER AND THAT ALL OTHER JOINT AND BUSHINGS WERE TIGHT AND OK. 3,000 MILES LATER I AM ON A TRIP TO SPOKANE WA. THEN BACK TO HELENA, MT. APPROX 630 MILES ROUND TRIP. ON THE WAY TO SPOKANE THE FRONT END SEEMED TO BOUNCING AROUND ANY TIME WE HIT A BUMP OR UNEVEN BRIDGE DECK. ON THE WAY BACK TO HELENA IT ONLY GOT WORSE. I ALMOST LOST CONTROL ON MY TRUCK 5 TIMES AS IT SEEMED LIKE THE WHOLE FRONT END WAS GOING TO FALL OFF THE TRUCK. MY WIFE WAS SO SCARED THAT SHE WANTED ME TO STOP AND LET HER OUT. THIS IS MY WIFE'S DAILY DRIVER AND NOW SHE IS TO SCARED TO EVEN DRIVE IT ANYWHERE. I WENT TO FORD AND TOLD THEM THAT I HAD RESEARCHED THE PROBLEMS THAT PEOPLE ARE HAVING WITH THE SAME ISSUE AND IT SOUNDS LIKE FORD JUST THROWS PARTS AT THEM HOPING IT WILL FIX IT. THESE TRUCK ARE GOING TO KILL SOMEONE IF THEY DONE GET IT FIGURED OUT. I NOW HAVE A $50,000 TRUCK SITTING IN THE GARAGE BECAUSE I AM TO SCARED TO LET IT OUT ON THEW ROAD CAUSE I DO NOT WANT TO BE RESPONSIBLE FOR THE DEATH OF MY FAMILY OR THE MOTORING PUBLIC. I AM THANKFUL THAT I WAS DRIVING AND NOT MY WIFE.
TRAVELING ON A FREEWAY RAMP TO MERGE ONTO ANOTHER FREEWAY TRAVELING ABOUT 55-60 MPH, AND WENT OVER A ROUGH PATCH, STEERING WHEEL STARTED WOBBLING UNCONTROLLABLY. SLOWED DOWN TO ABOUT 40 AND WOBBLING STOPPED. RESUMED NORMAL TRAVEL, NEVER WENT OVER POSTED SPEED LIMIT OF 65 MPH AND SLOWED DOWN FOR BUMPS AND ROUGH PATCHES.
FRONT WHEELS SHAKE AND STEERING WHEEL SHAKES AFTER HITTING ROUGH SPOT OR UNEVEN AREA ON ROAD AT SPEEDS ABOVE 60 MPH. THIS CONDITION IS COMMONLY REFERRED TO AS A "DEATH WOBBLE." IT IS VERY DANGEROUS AND NEEDS TO BE REPAIRED OR CORRECTED. IT OCCURS WHEN GOING AROUND A CURVE, BUT CAN HAPPEN WHEN GOING STRAIGHT.
I HAVE LOST STEERING CONTROL ONCE AT 70MPH AND ONCE AT 45-50 MPH AFTER HITTING MINOR PAVEMENT BUMPS. THE SO CALLED DREADED DEATH WOBBLE AND BOTH TIMES NEARLY CAUSED AN ACCIDENT THE DEALER SUPPOSEDLY FIXED PROBLEM BACK IN FALL AND NOW IT'S DOING AGAIN AND NO LONGER UNDER WARRANTY I KNOW LONGER FEEL SAFE DRIVING THIS TRUCK AND THA…
Read full complaint
I HAVE LOST STEERING CONTROL ONCE AT 70MPH AND ONCE AT 45-50 MPH AFTER HITTING MINOR PAVEMENT BUMPS. THE SO CALLED DREADED DEATH WOBBLE AND BOTH TIMES NEARLY CAUSED AN ACCIDENT THE DEALER SUPPOSEDLY FIXED PROBLEM BACK IN FALL AND NOW IT'S DOING AGAIN AND NO LONGER UNDER WARRANTY I KNOW LONGER FEEL SAFE DRIVING THIS TRUCK AND THAT'S RIDICULOUS FOR A 2019 VEHICLE BY THE NUMBER OF COMPLAINTS YOU SEE ON THIS I CAN'T BELIEVE THERE HAS NOT BEEN A RECALL ISSUED WHEN THIS IS BY FAR THE MOST DANGEROUS OF THE FOUR RECALLS I HAVE RECEIVED ON MY TRUCK LAUGHABLE REALLY WHAT IS FORD WAITING FOR SOMEONE TO BE KILLED I WAS VERY NEAR REAR ENDED TWICE WHEN SLOWING DOWN AS FAST AS POSSIBLE SO AS NOT TO LOSE CONTROL AND EITHER GO OFF THE ROAD OR HIT VEHICLE BESIDE ME
WHILE DRIVING ON HIGHWAY MY NEW 2019 F250 FRONT END SHAKES OUT OF CONTROL.. LESS THAN 20 THOUSAND MILES
DEATH WOBBLE. STEERING WHEEL SHAKES VIOLENTLY AND IS EASY TO LOSE CONTROL OF VEHICLE. REQUIRES IMMEDIATE SLAM ON BREAKS TO STOP. HAS OCCURRED AT SPEEDS 50 MPH TO 70 MPH ON ANY STREET SURFACE. FIRST OCCURRENCE WAS AT APPROXIMATELY 10,000 MILES AND OCCURRED EVERY TIME DRIVEN UNTIL WARRANTY DEPARTMENT REPLACED STEERING STABILIZ…
Read full complaint
DEATH WOBBLE. STEERING WHEEL SHAKES VIOLENTLY AND IS EASY TO LOSE CONTROL OF VEHICLE. REQUIRES IMMEDIATE SLAM ON BREAKS TO STOP. HAS OCCURRED AT SPEEDS 50 MPH TO 70 MPH ON ANY STREET SURFACE. FIRST OCCURRENCE WAS AT APPROXIMATELY 10,000 MILES AND OCCURRED EVERY TIME DRIVEN UNTIL WARRANTY DEPARTMENT REPLACED STEERING STABILIZER. IT TOOK 3 WEEKS TO OBTAIN REPLACEMENT STABILIZER. SECOND OCCURRENCE OCCURRED AT 13,000 MILES. VEHICLE CANNOT BE DRIVEN AND IS IN BACK IN SERVICE DEPARTMENT FOR REPAIR CURRENTLY. SERIOUS SAFETY ISSUE.
THIS IS A NEW 2019 FORD 250 SUPER DUTY TRUCK. IN FEBRUARY 2019 TRAVELING AT ABOUT 75 MPH( ON A MAJOR HIGHWAY) & I HIT A GROOVE AND MY FRONT END WENT IN TO A HORRIBLE HEAVY HEAD SHAKE.IT WAS NOT THE FIRST TIME BUT THIS WAS THE WORST BY FAR. IN DALLAS TRAFFIC SURROUNDED ON ALL SIDES. THE ONLY WAY TO STOP THIS HEAD SHAKE IS BY HIT…
Read full complaint
THIS IS A NEW 2019 FORD 250 SUPER DUTY TRUCK. IN FEBRUARY 2019 TRAVELING AT ABOUT 75 MPH( ON A MAJOR HIGHWAY) & I HIT A GROOVE AND MY FRONT END WENT IN TO A HORRIBLE HEAVY HEAD SHAKE.IT WAS NOT THE FIRST TIME BUT THIS WAS THE WORST BY FAR. IN DALLAS TRAFFIC SURROUNDED ON ALL SIDES. THE ONLY WAY TO STOP THIS HEAD SHAKE IS BY HITTING THE BRAKES HARD. TO DO THAT ON A MAJOR HIGHWAY WITH TRAFFIC ON ALL SIDES IS HORRIFYING. TOOK IT TO NORTH CENTRAL FORD AND THERE IS A DAMPER RECALL (AMONG OTHERS). THEY REPLACED THE DAMPER. THESE DAMPERS ARE NOT MUCH BIGGER THAN A GOLF CLUB. ARE NOT MADE OR RATED TO SUPPORT A TRUCK WITH OVER A 10,000 LB WEIGHT LIMIT. NOW HERE WE ARE IN JULY AND ITS BACK IN THE SHOP. SINCE MARCH THERE HAS BEEN 2/3 MORE UPGRADES TO THIS DAMPER. BECAUSE OF THE STRONG HEAD SHAKE? IT RUINED OTHER THINGS CONNECTED TO DAMPER (DRAG LINK/BUSHING). EVEN WITH THIS NEW UPGRADED DAMPER THEY EXPECT IT'LL BE BACK IN. THEY OFFER A AFTER MARKET " DUAL-DAMPER" (700$) THAT SHOULD CORRECT THE PROBLEM. THIS IS A NEW TRUCK AND IT SHOULD COME WITH SUPER DUTY PARTS!!! SOMEONE IS GOING TO HURT THEMSELVES AND OR OTHERS BECAUSE OF NEGLIGENCE. TRUCK SHOULD BE OUT OF SHOP TOMORROW, I CALLED CORPORATE TO TRY AND GET THE DUAL DAMPER APPROVED AND I AM ON HOLD. SO AS IT STANDS THIS WILL BE THE 3RD DAMPER THAT HAS BEEN REPLACED SINCE GETTING IT IN OCTOBER 2019.
ON JULY 3, 2020 AT 7:10 AM, I WAS DRIVING MY 2019 F250 WITH 14,500 MILES ON THE ODOMETER WHEN I EXPERIENCED THE DEATH WOBBLE AS THE PROBLEM IS KNOW. I WAS DRIVING 65 MPH WHEN I HIT A ROUGH PATCH ON I45 SOUTH IN HOUSTON,TX. AND MY VEHICLE'S STEERING WENT VIOLENTLY WRONG. THE STEERING WHEEL SHOOK SIDE TO SIDE AS IF MY FRONT LEFT T…
Read full complaint
ON JULY 3, 2020 AT 7:10 AM, I WAS DRIVING MY 2019 F250 WITH 14,500 MILES ON THE ODOMETER WHEN I EXPERIENCED THE DEATH WOBBLE AS THE PROBLEM IS KNOW. I WAS DRIVING 65 MPH WHEN I HIT A ROUGH PATCH ON I45 SOUTH IN HOUSTON,TX. AND MY VEHICLE'S STEERING WENT VIOLENTLY WRONG. THE STEERING WHEEL SHOOK SIDE TO SIDE AS IF MY FRONT LEFT TIRE FELT LIKE IT WAS ABOUT TO FLY OFF. I APPLIED LIGHT BRAKING AS MY VEHICLE UNCONTROLLABLY VEERED RIGHT INTO ANOTHER VEHICLE THAT WAS BESIDE ME. LUCKILY THE OTHER VEHICLE WAS ABLE TO BRAKE AND LET ME INTO THEIR LANE WITHOUT CREATING AN ACCIDENT THAT WOULD HAVE CAUSED A MULTI-CAR ACCIDENT. ONCE I FINALLY GAINED CONTROL OF MY VEHICLE I WAS INCHES AWAY FROM COLLIDING INTO THE CEMENT BARRIER ALONG THE FEEDER ROAD. I HAVE ALWAYS NOTICED A BIT OF AN ISSUE IN THE STEERING BUT ONLY THOUGHT IT WAS A STOUT SUSPENSION IN BEING A 4X4 F250 DIESEL. AFTER DOING SOME RESEARCH THE "DEATH WOBBLE" ISSUE SEEMS TO IN THE STEERING COMPONENTS AND ALIGNMENT FROM THE FACTORY.
I HAVE EXPERIENCED THE DEATH RATTLE/WOBBLE WITH THIS VEHICLE WHICH I BOUGHT BRAND NEW IN NOVEMBER 2019. THE STEERING WHEEL SHAKES UNCONTROLLABLY AND SO DOES THE UNDERCARRIAGE. I AM NOT A MECHANIC SO I DON'T KNOW IF IT'S THE SUSPENSION, STEERING WHEEL OR THE WHEELS THEMSELVES. WHEN I GO OVER 25 MILES AN HOUR AFTER HITTING A BUMP …
Read full complaint
I HAVE EXPERIENCED THE DEATH RATTLE/WOBBLE WITH THIS VEHICLE WHICH I BOUGHT BRAND NEW IN NOVEMBER 2019. THE STEERING WHEEL SHAKES UNCONTROLLABLY AND SO DOES THE UNDERCARRIAGE. I AM NOT A MECHANIC SO I DON'T KNOW IF IT'S THE SUSPENSION, STEERING WHEEL OR THE WHEELS THEMSELVES. WHEN I GO OVER 25 MILES AN HOUR AFTER HITTING A BUMP ON THE ROAD I EXPERIENCE THIS RATTLING. ALSO I HEAR THE RATTLING BELOW THE ENGINE LIKE A LOOSE MUFFLER WHEN I GO OVER THIS SPEED.
Official recalls
1125V572000 · Back Over Prevention: Sensing System: Camera
Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
23V420000 · Equipment:other:owners/service/other Manual
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
22V644000 · Back Over Prevention: Sensing System: Camera
Aug 26, 2022
Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.
Consequence & remedy
Consequence: Lack of a clear rearview camera image can reduce the driver's visibility of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Ford customer service at 1-800-1-866-436-7332. Ford's number for this recall is 22S51.
22V252000 · Back Over Prevention: Sensing System: Camera
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2019 F-150, Super Duty F-250, F-350, F-450, and F-550 vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that displays a blank or distorted image can reduce the drivers view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
22V087000 · Power Train:driveline:driveshaft; Structure:frame And Members:underbody Shields
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
21V155000 · Tires
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.
19V880000 · Seat Belts:pretensioner; Structure:body:roof And Pillars
Dec 11, 2019
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
Additional source detail variants (2)
Seat Belts:pretensioner
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
Structure:body:roof And Pillars
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
19V864000 · Latches/locks/linkages:tailgate:latch
Dec 4, 2019
Ford Motor Company (Ford) is recalling certain 2017-2019 Super Duty F-250, F-350, and F-450 trucks equipped with an electric tailgate latch release switch mounted in the tailgate handle. Water may enter the electrical wiring system and cause a short circuit, activating the switch and releasing the tailgate latches.
Consequence & remedy
Consequence: Unintended tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits and will install a new tailgate handle release switch, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S48.
19V808000 · Exterior Lighting:headlights
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2018-2019 F-250, F-350 and F-450 Super Duty trucks. The Daytime Running Lights (DRL) may not dim when the headlight switch is moved into the "On" position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford has notified owners, and dealers will reprogram the Body Control Module (BCM) software, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C10.
19V278000 · Engine; Equipment:electrical
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
18V802000 · Power Train:automatic Transmission
Nov 14, 2018
Ford Motor Company (Ford) is recalling certain 2019 Ford F-250 Super Duty, F-350 Super Duty and F-450 Super Duty vehicles. An incorrect transmission case casting may cause the park pawl assembly to not be secured, possibly resulting in unintended vehicle movement.
Consequence & remedy
Consequence: Unintended vehicle movement can increase the risk of a crash.
Remedy: Ford will notify owners and dealers will inspect the transmission case, replacing the transmission as necessary, free of charge. The recall began December 7, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S36.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE24014 · Sogefi Secondary Diesel Fuel Filter Leak
Opened May 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ21001 · Power Tailgate Release Systems
Opened Jan 15, 2021 · Closed Jan 10, 2024
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Structure:body:door
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18011 · Power Tailgate Opens Unintended
Opened Oct 12, 2018 · Closed Dec 12, 2019
Status: closed (inferred from source dates) · Electrical System:wiring; Structure:body:tailgate:hinge And Attachments
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.
Additional source detail variants (2)
Electrical System:wiring
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.
Structure:body:tailgate:hinge And Attachments
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.