Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
1925–50K
750–75K
475–100K
2100–150K
0150K+
52 reports with mileage · 2 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports2 injury reports
What owners actually said
54 reports
400 miles · Jun 28, 2016
Service BrakesSteering
TL* THE CONTACT OWNS A 2007 FORD F-250 SUPER DUTY. WHILE DRIVING AT ANY SPEED, THE VEHICLE SHOOK VIOLENTLY AND CAUSED THE DOOR TO OPEN. IT BECAME DIFFICULT TO STEER AND THE ENTIRE VEHICLE OSCILLATED. IN ADDITION, THE ABS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD F-250 SUPER DUTY. WHILE DRIVING AT ANY SPEED, THE VEHICLE SHOOK VIOLENTLY AND CAUSED THE DOOR TO OPEN. IT BECAME DIFFICULT TO STEER AND THE ENTIRE VEHICLE OSCILLATED. IN ADDITION, THE ABS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE FAILURES BEGAN WEEKS AFTER THE VEHICLE WAS PURCHASED IN 2007. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 400.
NHTSA ODI #10877122
52,000 miles · Sep 18, 2014
EngineSeat BeltsSteering
AT 52000 MILES ENGINE STARTED MAKING TAPPING NOISE? DRIVER SEATBELT NOT RETRACTING. FRONTEND SHIMMY AT SPEEDS OF 45 TO 65 MPH. *TR
NHTSA ODI #10637339
Mileage unknown · Mar 22, 2014
Tires
WE HAVE 3 OUT OF 4 TIRES SEPARATE WITH THE TREAD COMING COMPLETELY OFF OF ONE OF THE TIRES CAUSING MAJOR DAMAGE TO BED AND NUMBER OF OUR TRUCK. THE FIRST TIRE WAS WITH IN A COUPLE OF MONTHS OF PURCHASE. THE OTHER 2 TIRES HAPPEN WITH IN 30 MINUTES OF EACH OTHER. ALL UNDER 10,000 MILES OF USE. YOUR FORM DOESN'T SHOW CORRECT TI…
Read full complaint
WE HAVE 3 OUT OF 4 TIRES SEPARATE WITH THE TREAD COMING COMPLETELY OFF OF ONE OF THE TIRES CAUSING MAJOR DAMAGE TO BED AND NUMBER OF OUR TRUCK. THE FIRST TIRE WAS WITH IN A COUPLE OF MONTHS OF PURCHASE. THE OTHER 2 TIRES HAPPEN WITH IN 30 MINUTES OF EACH OTHER. ALL UNDER 10,000 MILES OF USE. YOUR FORM DOESN'T SHOW CORRECT TIRE TYPE. THIS COMPLAINT IS ON THE FEDERAL COURGIA M/T. THANK YOU. *TR
NHTSA ODI #10574165
99,744 miles · Sep 2, 2013
Steering
I WAS TOWING A CAR HAULER AT APPROXIMATELY 65 MPH ON I-94 OUTSIDE OF CHICAGO, IL WHEN MY VEHICLE BEGAN TO VEER SLIGHTLY TO THE RIGHT AND CROSS INTO THE OTHER LANE. I TRIED TO CORRECT STEER TO THE LEFT AND MY VEHICLE DID NOT RESPOND. I BEGAN TO CROSS INTO THE NEXT LANE OF TRAFFIC AND I BEGAN TO SPIN THE STEERING WHEEL EVEN HARD…
Read full complaint
I WAS TOWING A CAR HAULER AT APPROXIMATELY 65 MPH ON I-94 OUTSIDE OF CHICAGO, IL WHEN MY VEHICLE BEGAN TO VEER SLIGHTLY TO THE RIGHT AND CROSS INTO THE OTHER LANE. I TRIED TO CORRECT STEER TO THE LEFT AND MY VEHICLE DID NOT RESPOND. I BEGAN TO CROSS INTO THE NEXT LANE OF TRAFFIC AND I BEGAN TO SPIN THE STEERING WHEEL EVEN HARDER TO THE LEFT WITH NO CHANGE IN DIRECTION. I REALIZED THAT I HAD A LOSS OF STEERING AND BEGAN TO APPLY THE BRAKES TO AVOID HITTING THE BARRIER ON THE SIDE OF THE ROAD. I ENDED UP CROSSING FOUR LANES OF MODERATELY HEAVY LABOR DAY TRAFFIC WITH ZERO STEERING CONTROL AND CAME TO REST WITHIN INCHES OF THE RETAINING BARRIER ON THE SIDE OF THE ROAD. *JS
NHTSA ODI #10538371
22,400 miles · Jun 26, 2013
SteeringSuspension
HIT A BUMP ON THE ROAD AND MY FRONT END STARTED SHAKING VIOLENTLY. HAD DIFFICULTY CONTROLLING THE VEHICLE UNTIL REDUCING SPEED TO APPROXIMATELY 35 TO 40 MPH AT WHICH POINT THE SHAKING STOPPED. NOTICE A SLIGHT SHIMMY WHENEVER MAKING A RIGHT HAND TURN (NEGOTIATING RIGHT CURVES ON THE HIGHWAYS). TIRE INFLATION HAS BEEN CHECKED AND…
Read full complaint
HIT A BUMP ON THE ROAD AND MY FRONT END STARTED SHAKING VIOLENTLY. HAD DIFFICULTY CONTROLLING THE VEHICLE UNTIL REDUCING SPEED TO APPROXIMATELY 35 TO 40 MPH AT WHICH POINT THE SHAKING STOPPED. NOTICE A SLIGHT SHIMMY WHENEVER MAKING A RIGHT HAND TURN (NEGOTIATING RIGHT CURVES ON THE HIGHWAYS). TIRE INFLATION HAS BEEN CHECKED AND NOT THE ISSUE. THIS VEHICLE HAS NOT BEEN USED OFF-ROAD OR ABUSED.IT HAS A CREW CAB AND WAS PURCHASED TO TRANSPORT PERSONNEL AND SUPPLIES. *TR
NHTSA ODI #10521857
122,500 miles · May 28, 2013
SteeringStructureSuspension
I WOULD LIKE TO OFFICIALLY SUBMIT A COMPLAINT ABOUT OUR FORD F250 SUPER DUTY TRUCK. THERE IS SOMETHING SERIOUSLY WRONG WITH IT AND THE FORD DEALERSHIP HAS BEEN UNABLE TO FIX IT. WE HAVE HAD THE SAME ISSUE WITH IT FOR THE LAST FEW YEARS AND THE ISSUE HAS NOT BEEN RESOLVED! WE ARE EXPERIENCING TURBULENT WOBBLING WITH THIS TRUCK AN…
Read full complaint
I WOULD LIKE TO OFFICIALLY SUBMIT A COMPLAINT ABOUT OUR FORD F250 SUPER DUTY TRUCK. THERE IS SOMETHING SERIOUSLY WRONG WITH IT AND THE FORD DEALERSHIP HAS BEEN UNABLE TO FIX IT. WE HAVE HAD THE SAME ISSUE WITH IT FOR THE LAST FEW YEARS AND THE ISSUE HAS NOT BEEN RESOLVED! WE ARE EXPERIENCING TURBULENT WOBBLING WITH THIS TRUCK AND I CAN ASSURE YOU THIS IS NOT NORMAL! THE LAST INCIDENT OCCURRED 2 DAYS AGO ON MAY 26, 2013! I HAVE CHILDREN AND FEEL THAT OUR LIVES WERE ESPECIALLY IN DANGER WHEN WE RODE IN THIS TRUCK AS WE THOUGHT THIS ISSUE WAS RESOLVED AND NO LONGER EXISTED. AS WE WERE DRIVING ON THE INTERSTATE HIGHWAY WE DROVE OVER AN UNEVEN SECTION OF THE HIGHWAY AND OUR TRUCK SUDDENLY STARTED SHAKING DANGEROUSLY OUT OF CONTROL! THANKFULLY MY HUSBAND WAS ABLE TO CONTROL THE STEERING WHEEL AND STEPPED ON THE BRAKE TO SLOW IT DOWN, OTHERWISE WHO KNOWS WHAT WOULD HAVE HAPPENED! THERE WAS TRAFFIC EVERYWHERE AND WE WERE LUCKY ENOUGH NOT TO HAVE AN ACCIDENT! THEN IT HAPPENED AGAIN A FEW HOURS LATER WHEN WE AGAIN DROVE OVER AN UNEVEN SECTION OF THE INTERSTATE. I HAVE EXPERIENCED ENOUGH OF THESE THREATENING EPISODES AND I AM VERY CONCERNED AS THIS IS ABSOLUTELY NOT NORMAL AND I CAN HONESTLY SAY THERE IS SOMETHING VERY WRONG WITH THIS VEHICLE. THIS IS A SAFETY ISSUE AND PEOPLE CAN AND WILL LOSE THEIR LIVES OVER THIS IF THIS IS NOT RESOLVED IMMEDIATELY! I HAVE CONTACTED FORD HEADQUARTERS TO SUBMIT A FORMAL COMPLAINT AND THEY MERELY TOLD ME TO CONTINUE WORKING WITH THE DEALERSHIP THAT HAS UNRESOLVED MY ISSUE. I TRUST THAT YOU WILL TAKE THIS COMPLAINT SERIOUSLY AS LIVES ARE AT STAKE BECAUSE OF THIS ISSUE. *TR
NHTSA ODI #10513794
65,000 miles · Mar 28, 2013
SteeringSuspension
DRIVING MY 2007 F250 SD AND HIT A BUMP, FRONT END STARTED TO SHIMMY. SLOWED DOWN AND THE SHIMMY STOPPED. HAD RECEIVED A LETTER FROM FORD MOTOR COMPANY GIVING INFORMATION ABOUT THE FRONT END SHIMMY. SINCE THE FIRST INCIDENT, IT HAS OCCURED NUMEROUS TIMES. MY TRUCK IS CURRENTLY AT 87000 MILES AND THE SHIMMY HAPPENS NUMEROUS TIMES …
Read full complaint
DRIVING MY 2007 F250 SD AND HIT A BUMP, FRONT END STARTED TO SHIMMY. SLOWED DOWN AND THE SHIMMY STOPPED. HAD RECEIVED A LETTER FROM FORD MOTOR COMPANY GIVING INFORMATION ABOUT THE FRONT END SHIMMY. SINCE THE FIRST INCIDENT, IT HAS OCCURED NUMEROUS TIMES. MY TRUCK IS CURRENTLY AT 87000 MILES AND THE SHIMMY HAPPENS NUMEROUS TIMES A DAY WHEN I HIT BUMPS/DIPS IN THE ROAD. DIESEL SHOP TELLS ME TO KEEP TIRES INFLATED PROPERLY, ROTATE AND BALANCE TIRES AS WELL AS PROPER ALIGNMENT AND HAVE THE STEERING DAMPNER REPLACED. STEERING DAMPNER IS BRAND NEW (3 MONTHS OLD), TIRES ARE AT PROPER INFLATION AND BALANCED AS WELL AS ALIGNMENT DONE AND THE FRONT END STILL VIBRATES, SOMETIMES VIOLENTLY TO WHERE IT IS TOUGH TO CONTROL UNTIL SPEED DROPS UNDER 40 MPH. STILL WAITING ON A FIX FOR THIS ISSUE AS THE SHIMMY IS DAILY AND IS GETTING WORSE AND I GET THE SAME TEXTBOOK ANSWER FROM FORD EVERYTIME I CALL (TIRES, INFLATION, ALIGNMENT, STEERING DAMPNER). I'M AFRAID THAT THE VIBRATION WILL GET TO THE POINT THAT PARTS WILL START BECOMING LOOSE/BREAK AND CAUSE AN ACCIDENT. *TR
NHTSA ODI #10504810
30,000 miles · Dec 6, 2012
Steering
TL* THE CONTACT OWNS A 2007 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO SHAKE VIOLENTLY AS THE CONTACT TRAVELED OVER AN UNEVEN ROAD SURFACE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE M…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO SHAKE VIOLENTLY AS THE CONTACT TRAVELED OVER AN UNEVEN ROAD SURFACE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
NHTSA ODI #10487532
119,000 miles · Jun 20, 2012
Tires
TL* THE CONTACT OWNS A 2007 FORD F-250 SD WITH GOODYEAR WRANGLER AT/S TIRES, SIZE: LT275/65/20. WHILE ROTATING THE TIRES, THE CONTACT NOTICED THAT THE TREAD ON THE REAR PASSENGER TIRE WAS SEPARATING. THE CONTACT REPLACED THE TIRE AND NOTICED THAT THE TREAD ON THE FRONT PASSENGER TIRE HAD BEGUN TO SEPARATE AS WELL. THE FRONT PASS…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD F-250 SD WITH GOODYEAR WRANGLER AT/S TIRES, SIZE: LT275/65/20. WHILE ROTATING THE TIRES, THE CONTACT NOTICED THAT THE TREAD ON THE REAR PASSENGER TIRE WAS SEPARATING. THE CONTACT REPLACED THE TIRE AND NOTICED THAT THE TREAD ON THE FRONT PASSENGER TIRE HAD BEGUN TO SEPARATE AS WELL. THE FRONT PASSENGER TIRE WAS NOT REPLACED. THE DOT NUMBER WAS NOT AVAILABLE. THE MILEAGE ON THE VEHICLE AT THE TIME OF THE FAILURE WAS 119,000. THE APPROXIMATE FAILURE MILEAGE OF THE TIRE WAS 48,370.
NHTSA ODI #10462389
87,000 miles · May 17, 2012
Air BagsCrashInjury
TL* THE CONTACT OWNS A 2007 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, HE CRASHED INTO ANOTHER VEHICLE AND THE AIR BAGS DID NOT DEPLOY. TWO PASSENGERS FROM THE OTHER VEHICLE WERE INJURED AND TRANSPORTED TO THE HOSPITAL. THE ENTIRE FRONT END WAS BADLY DAMAGED AND THE VEHICLE WAS TOWED FROM THE SCENE. THERE WAS A…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, HE CRASHED INTO ANOTHER VEHICLE AND THE AIR BAGS DID NOT DEPLOY. TWO PASSENGERS FROM THE OTHER VEHICLE WERE INJURED AND TRANSPORTED TO THE HOSPITAL. THE ENTIRE FRONT END WAS BADLY DAMAGED AND THE VEHICLE WAS TOWED FROM THE SCENE. THERE WAS A POLICE REPORT IF NEEDED. THE INSURANCE COMPANY WAS NOTIFIED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WOULD SEND A REPRESENTATIVE TO INSPECT THE VEHICLE AND THE AIR BAGS. THE FAILURE MILEAGE WAS 87,000.
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
2007 Ford F-250 Sd Problems, Complaints & Recalls | Skip That Year
Illustration