Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
700–25K
8025–50K
4150–75K
2475–100K
21100–150K
8150K+
244 reports with mileage · 30 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports4 fire reports6 injury reports
What owners actually said
274 reports
Mileage unknown · Dec 8, 2017
Suspension
FRONT END VIBRATION WHILE DRIVING AROUND 60MPH WHICH TURNS INTO A REAL BAD SHIMMY SOMETIMES. STEERING WHEEL SHAKES VIOLENTLY. HAVE RECEIVED A COUPLE OF NOTICES FROM FORD MOTOR CO. THAT TELL ME THEY ARE AWARE AND TO JUST SLOW DOWN WHEN IT HAPPENS. THIS HAS HAPPENED SEVERAL TIMES SINCE I HAD THE TRUCK SINCE 2011. NO SPECIFIC DATES…
Read full complaint
FRONT END VIBRATION WHILE DRIVING AROUND 60MPH WHICH TURNS INTO A REAL BAD SHIMMY SOMETIMES. STEERING WHEEL SHAKES VIOLENTLY. HAVE RECEIVED A COUPLE OF NOTICES FROM FORD MOTOR CO. THAT TELL ME THEY ARE AWARE AND TO JUST SLOW DOWN WHEN IT HAPPENS. THIS HAS HAPPENED SEVERAL TIMES SINCE I HAD THE TRUCK SINCE 2011. NO SPECIFIC DATES.
NHTSA ODI #11053449
Mileage unknown · Jun 26, 2017
Unknown Or Other
CPSC: THE RIGHT FRONT TIRE DEVELOPED A TERRIBLE BOUNCE ATSPEEDS LESS THAN 30 MPH. I RETURNED THE TRUCK TO RICK'S TIRES AND HE CONTACTED FREESERVICE TIRES. *BF THE CONSUMER WAS ADVISED THE BELTS SEPARATED ON THE LEFT. THE TIRE WAS REPLACED. THE RIGHT REAR TIRE EXPLODED WHILE TOWING A BOAT. THE TIRED HAD A LARGE HOLE AND PART…
Read full complaint
CPSC: THE RIGHT FRONT TIRE DEVELOPED A TERRIBLE BOUNCE ATSPEEDS LESS THAN 30 MPH. I RETURNED THE TRUCK TO RICK'S TIRES AND HE CONTACTED FREESERVICE TIRES. *BF THE CONSUMER WAS ADVISED THE BELTS SEPARATED ON THE LEFT. THE TIRE WAS REPLACED. THE RIGHT REAR TIRE EXPLODED WHILE TOWING A BOAT. THE TIRED HAD A LARGE HOLE AND PART OF THE TREAD SEPARATED FROM THE INNER TIRE. THIS CAUSED DAMAGE TO THE RIGHT PICK UP BED OUTER WALL AND BRACING SUPPORTS. UPDATED 06/28/2017*JS
NHTSA ODI #11002169
188,000 miles · May 22, 2017
Fuel/propulsion System
FUEL TANK STRAPS FAILED DUE TO CORROSION AND FUEL TANK FELL TO GROUND WHILE IN MOTION ON A HIGHWAY
NHTSA ODI #10990988
85,000 miles · Apr 15, 2017
Service BrakesCrash
EMERGENCY BRAKES DO NOT HOLD. HAVE HAD THEM CHECKED FOR ADJUSTMENT SEVERAL TIMES. IS A MAJOR PROBLEM WITH A MANUAL TRANSMISSION AS IT HAS NO PARK PINS. ALTHOUGH MY INSURANCE COVERED IT, IT ACTUALLY ROLLED INTO ANOTHER BUILDING ON MY PROPERTY. I HAVE TO US A WOOD BLOCK AGAINST THE WHEEL TO STOP IT FROM ROLLING ON ALL BUT THE …
Read full complaint
EMERGENCY BRAKES DO NOT HOLD. HAVE HAD THEM CHECKED FOR ADJUSTMENT SEVERAL TIMES. IS A MAJOR PROBLEM WITH A MANUAL TRANSMISSION AS IT HAS NO PARK PINS. ALTHOUGH MY INSURANCE COVERED IT, IT ACTUALLY ROLLED INTO ANOTHER BUILDING ON MY PROPERTY. I HAVE TO US A WOOD BLOCK AGAINST THE WHEEL TO STOP IT FROM ROLLING ON ALL BUT THE SLIGHTEST INCLINE. THERE HAVE BEEN SEVERAL OCCURRENCES WHEN THIS HAS HAPPENED.
NHTSA ODI #10978627
120,155 miles · Jul 20, 2016
Suspension
WHILE DRIVING AND GOING OVER A BUMP BETWEEN 60 AND 70 MPH ON THE HIGHWAY, THE TRUCKS FRONT END STARTS TO VIOLENTLY SHAKE CAUSING THE TRUCK TO LOSE CONTROL. NOTE ONLY DRIVING POSTED SPEED LIMIT. THIS HAS HAPPENED ON THREE (3) OCCASIONS MOSTLY RECENTLY 7/17/16 AND 7/19/16 WHILE TRAVELING S/B ON INTERSTATE 95 AND TRAVELING N/B ON I…
Read full complaint
WHILE DRIVING AND GOING OVER A BUMP BETWEEN 60 AND 70 MPH ON THE HIGHWAY, THE TRUCKS FRONT END STARTS TO VIOLENTLY SHAKE CAUSING THE TRUCK TO LOSE CONTROL. NOTE ONLY DRIVING POSTED SPEED LIMIT. THIS HAS HAPPENED ON THREE (3) OCCASIONS MOSTLY RECENTLY 7/17/16 AND 7/19/16 WHILE TRAVELING S/B ON INTERSTATE 95 AND TRAVELING N/B ON INTERSTATE 95. THE DEFECT CAUSES YOU TO DRIVE AT REDUCED SPEEDS ON THE HIGHWAY. HAVE DONE RESEARCH AND IT IS A COMMON PROBLEM WITH FORD TRUCK WITH STRAIGHT FRONT AXLES. FORD IS AWARE OF THE PROBLEM.
NHTSA ODI #10886051
22,000 miles · Jul 14, 2016
Tires
I HAVE BF GOODRICH RUGGED TRAIL T/A 275 70 R18 TIRES ON MY 2006 FORD F250 WHICH WERE PURCHASED 25 MONTHS AGO AND HAVE 22000 MILES ON THEM. WHILE TOWING MY TRAVEL TRAILER I EXPERIENCED A SLIGHT VIBRATION WHILE DRIVING. I IMMEDIATELY PULLED OVER AND CHECKED THE VEHICLE AND CAMPER FOR NY VISIBLE SIGNS OF A PROBLEM. EVERYTHING A A…
Read full complaint
I HAVE BF GOODRICH RUGGED TRAIL T/A 275 70 R18 TIRES ON MY 2006 FORD F250 WHICH WERE PURCHASED 25 MONTHS AGO AND HAVE 22000 MILES ON THEM. WHILE TOWING MY TRAVEL TRAILER I EXPERIENCED A SLIGHT VIBRATION WHILE DRIVING. I IMMEDIATELY PULLED OVER AND CHECKED THE VEHICLE AND CAMPER FOR NY VISIBLE SIGNS OF A PROBLEM. EVERYTHING A APPEARED TO BE IN GOOD WORKING ORDER SO I CONTINUED ON DRIVING SLOWER. AFTER ABOUT 10 MILES THE TIRE COMPLETELY BLEW UP DAMAGING MY VEHICLE AND SENDING THE TREAD OF THE TIRE ACROSS THE OTHER LANES TRAFFIC WHICH ALMOST CAUSED A MAJOR VEHICULAR ACCIDENT. I THOUGHT IT WAS BAD LUCK. I CHANGED THE TIRE AND CONTINUED DOWN THE ROAD. AFTER APPROXIMATELY ANOTHER 200 MILES I STARTED GETTING THE SAME VIBRATION FROM THE REAR DRIVERS SIDE TIRE. FEARING ANOTHER BLOW OUT AND HAVING NO SPARE TIRE I PULLED OVER AND SPENT THE NIGHT IN A CAMPGROUND. THE NEXT MORNING I WENT OUT TO GET TIRES AND UPON THE TIRE PERSONAL INSPECTING THE TIRE THEY SAID THAT IT HAD A AIR BUBBLE UNDER THE TREAD AND THAT IT TOO WOULD HAVE MORE THAN LIKELY BLOWN OUT ON ME. I DIDN'T THINK THAT THIS WAS COINCIDENCE ANYMORE. SO UPON GETTING HOME I CALLED BF GOODRICH AND MADE A COMPLAINT. THEN I RESEARCHED THE TIRES AND SAW THAT A BUNCH OF THEM WERE RECALLED. JUST THAT MINE WAS NOT WITHIN THE THE MANUFACTURE'S DATE CODE WITH IN A FEW WEEKS. I FEEL THAT IF I HADN'T HAD THAT CAMPER BEHIND ME THAT I PROBABLY COULD HAVE LOST CONTROL OF MY TRUCK WITH POSSIBLE CATASTROPHIC CONSEQUENCES.
NHTSA ODI #10884819
155,000 miles · Jun 16, 2016
Engine
HEADS WENT BAD NOW I HAVE TO REPLACE THE HEADS AND NEW HEAD STUDS BECAUSE THE OLD HEAD STUDS STRETCHED AND THE HEADS WARPED , ALSO HAD TO DO AN EGR DELETE . I WAS TOLD IT WAS BUILT PROOFING AND IT HAS TO BE DONE TO ALL 6.0 LTRS.
NHTSA ODI #10874521
5,000 miles · May 5, 2016
Unknown Or Other
LIKE TOYOTA CARS, IF "WINTER-STYLED, RUBBER FLOOR MAT ON DRIVERS SIDE BECOMES UNHOOKED & SLIDES FORWARD, IT CAN LODGE THE ACCELERATOR DOWN CAUSING A HIGH SPEED. IT HAS HAPPENED TO ME SEVERAL TIMES, ALMOST CAUSING ME TO LOOSE CONTROL. THESE ARE FORD FACTORY INSTALLED MATS I PAID EXTRA FOR AT TIME VEHICLE WAS PURCHASED NEW. OCCU…
Read full complaint
LIKE TOYOTA CARS, IF "WINTER-STYLED, RUBBER FLOOR MAT ON DRIVERS SIDE BECOMES UNHOOKED & SLIDES FORWARD, IT CAN LODGE THE ACCELERATOR DOWN CAUSING A HIGH SPEED. IT HAS HAPPENED TO ME SEVERAL TIMES, ALMOST CAUSING ME TO LOOSE CONTROL. THESE ARE FORD FACTORY INSTALLED MATS I PAID EXTRA FOR AT TIME VEHICLE WAS PURCHASED NEW. OCCURS WHEN I ACCELERATED HARD, SUCH AS TO PASS ANOTHER CAR OR ENTER/MERGE ONTO AN INTERSTATE. HAD TO PUT CAR IN NEUTRAL AND PULL MAT BACK. HAS HAPPENED SEVERAL TIMES SINCE VEHICLE WAS PURCHASED.
NHTSA ODI #10863294
120,498 miles · Oct 12, 2015
Wheels
MY FACTORY 20" WHEEL CRACKED ON ME AND AFTER A GOOGLE SEARCH SEEMS TO BE A NORMAL PROBLEM
NHTSA ODI #10781421
60,000 miles · Jul 9, 2015
Service Brakes
IN LATE 2011, WHILE DRIVING MY TRUCK DOWN HIGHWAY 90 EAST IN PASCAGOULA, MS, THE TRUCK BEGAN SLOW DOWN AND PULL DRAMATICALLY TO THE RIGHT AFTER APPLYING THE BRAKES. I MANAGED TO WRESTLE WITH THE STEERING WHEEL AND, IN COMBINATION WITH THE SLOWING SPEED, BROUGHT THE TRUCK SAFELY TO A STOP IN A WALMART PARKING LOT IN ABOUT 1 MILE…
Read full complaint
IN LATE 2011, WHILE DRIVING MY TRUCK DOWN HIGHWAY 90 EAST IN PASCAGOULA, MS, THE TRUCK BEGAN SLOW DOWN AND PULL DRAMATICALLY TO THE RIGHT AFTER APPLYING THE BRAKES. I MANAGED TO WRESTLE WITH THE STEERING WHEEL AND, IN COMBINATION WITH THE SLOWING SPEED, BROUGHT THE TRUCK SAFELY TO A STOP IN A WALMART PARKING LOT IN ABOUT 1 MILE. I INSPECTED THE TRUCK AND THE FRONT RIGHT ROTOR WAS SMOKING AND GLOWING RED HOT. APPARENTLY THE BRAKE CALIPER HAD SEIZED AFTER APPLICATION. I WENT INSIDE WALMART TO KILL TIME AND LET THE BRAKES COOL OFF, HOPING THAT WHEN COOLED, THE CALIPER WOULD RELEASE AND THE TRUCK WOULD BE DRIVABLE. AFTER APPROXIMATELY 1-1/2 HOURS, I RETURNED TO THE TRUCK AND NOTED THAT THE WHEEL WAS NOT SMOKING, BUT WAS STILL RADIATING HEAT. I BEGAN TO DRIVE THE TRUCK AND IT DROVE WITHOUT ANY NOTICEABLE ISSUES UNTIL I APPLIED THE BRAKES AGAIN TO STOP AT A TRAFFIC LIGHT. AFTER RELEASING THE BRAKE, THE TRUCK WAS NOW PULLING TO THE LEFT. EXPECTING A SIMILAR ISSUE, I DECIDED TO DRIVE DIRECTLY TO THE FORD DEALERSHIP IN PASCAGOULA. HOWEVER, UPON NEEDING TO APPLY THE BRAKES AGAIN, THEY DID NOT WORK AT ALL. I HAD TO USE THE PARKING BRAKE TO BRING THE TRUCK TO A STOP AS THE REGULAR BRAKES HAD COMPLETELY FAILED. I CONTINUED TO EXPERIENCE SIMILAR BRAKE ISSUES (PULLING AND HEATING FROM SEIZED CALIPERS) AND IN JUNE 2015 HAD A SIMILAR EXPERIENCE TO THE ONE IN 2011. LOOKING AT BLOGS AND COMPLAINT SITES, FORD'S SUPER DUTY SERIES OF TRUCKS, AS WELL AS F-150S, ARE KNOWN TO HAVE BRAKE ISSUES. THIS IS A SERIOUS PROBLEM THAT FORD NEEDS TO BE HELD ACCOUNTABLE TO FIX. PLEASE HELP. I'M TIRED OF SHELLING OUT $2,000+ WHEN ALL I SHOULD HAVE TO DO IS REPLACE THE BRAKE PADS DUE TO NORMAL WEAR AND TEAR. DUE TO THE SUDDEN AND SEVERE "PULL" AND SUBSEQUENT LOSS OF STOPPING ABILITY, THIS HAS THE POTENTIAL TO BE A VERY SERIOUS SAFETY PROBLEM.
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
2006 Ford F-250 Sd Problems, Complaints & Recalls | Skip That Year
Illustration