2023 Ford F-150

The contact owns a 2023 Ford F-150. The contact stated that while driving in a rainstorm, rainwater leaked into the vehicle from the front driver’s side windshield seal onto the dashboard. The contact was concerned that the water might eventually cause electrical failures inside the dashboard. The cause of the failure was not yet determined. The local dealer was notified of the failure, and an appointment was scheduled. The failure mileage was 31,000.

The contact owns a 2023 Ford F-150. The contact stated that while driving at 60 MPH, there was an exploding sound coming from the vehicle. The contact became aware that the front glass panel in the panoramic sunroof had shattered without impact. The contact pulled over and discovered that shattered glass was all over the sunroof liner. The vehicle was initially driven back to the residence, and the hole in the glass was covered. The vehicle was then taken to the dealer, where the failure was confirmed. However, the contact was informed that there were no recalls or warranties on the vehicle to cover the repair. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact was provided with a case number. The failure mileage was 36,793.

The contact owns a 2023 Ford F-150. The contact stated that on several occasions while while driving at various speeds, the driver’s window switch was depressed; however, the window froze momently and failed to work as intended. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 32,000.

The contact owns a 2023 Ford F-150. The contact stated while driving 55 MPH on a flat road surface, the vehicle made an abnormal exploding sound, and the contact noticed that the panoramic sunroof rear glass panel had shattered without impact. The contact stated that the shattered glass did not fall into the interior of the vehicle because the sunroof interior canvas cover was closed. The contact pulled over to the side of the road and assessed the damage. The vehicle was driven to the nearest dealer, where it was determined that the panoramic sunroof rear glass panel needed to be replaced. The dealer informed the contact that the autobody repair department would perform the extensive repair. The vehicle was not repaired. The manufacturer was notified of the failure and declined to cover the repair under warranty. The failure mileage was approximately 29,000.

The contact owns a 2023 Ford F-150. The contact stated that the driver's side sideview mirror housing had melted after the vehicle had been exposed to the sun. The vehicle was taken to the dealer, where it was determined that the housing needed to be replaced, and the contact was charged a fee because the repair was not covered under warranty. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that there would be no assistance because the failure was due to the elements. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 5,650.

The contact owns a 2023 Ford F-150. The contact stated that while operating the vehicle, the check engine warning light had remained illuminated, and the speed erroneously increased and decreased while driving. The vehicle was taken to the local dealer who diagnosed that the turbo was faulty. The vehicle was not yet repaired. The contact had also experienced several electrical failures, including the rear window becoming inoperable, failing to open and close as needed. The vehicle was not yet repaired. The manufacturer was not yet notified of the failure. The failure mileage was 9,000.

the blower in my Truck seems to be malfunctioning. while the AC or heater will turn it when first started, approx. 20 minutes into driving and it quits blowing. you can hear it blowing but nothing comes out of the vents. this first happened at 300 miles while running the heater and I had no defrost! I repeatedly had to stop and wipe down the windshield in order to see! when sent in for repair they kept truck for 1 week. no error codes showed. Service tech told me I didn't know how to run the AC correctly. today I carried it in again with same complaint and they said they might get it into service in couple of weeks but made no attempt to schedule an appt. again, they made me feel as though I did not know what I am talking about. there are many forums online with same issue and no resolution.

The ac fan is blowing but no air is coming out looked on line there are a lot of people with same problem but when you cut the truck off and restart it the ac works fine his problem only occurs various sporadic but dealerships and Ford will not fix it because when they look at it, it does not do the issue. The issue does not come up. It is not a on-demand issue. There are no codes online flap sensor that allows the air to come through, Ford wants to leave the truck for 3 to 4 weeks and then when they start it don’t do it then you’re just been without your truck for no reason whatsoever to recall so you actually have your vehicle fixed thank you thank you

I recently purchased a new 2023 Ford F150, XL Trim, Crew Cab truck. This weekend on a trip, the vehicle's air conditioning began to malfunction. After operating for less than an hour and without adjusting the fan motor speed, the volume of air coming out of the vents gradually decreases to nothing and the cab of the vehicle begins to warm. With only 350 miles on the vehicle, I pulled off of the road, turned off the engine, and let the vehicle set for 20 minutes, hoping everything would reset. After the 20-minute period, I started the vehicle and the AC seemed to be working as it should. After driving another 20-30 minutes, the cab began to warm again and upon checking the air coming from the vents, it was minimal to none. I turned up the fan to max speed and the volume of air coming from the vents remained minimal and the temperature in the cab continued to rise. This time I turned the system AC off (no compressor) and left the fan on to bring in outside air in hopes of dropping the cabin temp. Immediately after turning the AC system off the air flow from the vents increased to a normal level. After operating with the AC off for 20 minutes, I turned the AC back on and the system, and yet again, the AC System operated as it should. This went on for my entire 8-hour trip. Not only an uncomfortable inconvenience, but this issue could also be safety issue (visibility) when depending on the vehicle's defog/defrost system as the AC system (compressor and condenser) is used for defogging/defrosting the vehicles windows. A similar issue has been noted in previous year models under Ford Tech Service Bulletin 22-2089. Being my issue is duplicated in the issue section of the service bulletin, the year model of my vehicle is not included. In performing some internet research, it seems that many owners of 2023 Ford F150 models are experiencing this exact issue. This issue does not cause panel lights to illuminate. Currently awaiting call back from Ford Dealer.

We just purchased this truck through our business and have complained to the dealer. The dealer made a claim through Ford and Ford responded by stating they will not repair/replace the windshield. They claim that our issue with the extremely distorted view when the sun hits is caused by an outside force. This is extremely disappointing to say the least and leaves us with a bad impression/customer experience. This truck was delivered to us this way, brand new and we made the complaint right away. We have not had an incident yet, but as the sun is more apparent the probability of an accident becomes more likely. If there is anyway you can help, please advise.