NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
589 reports40,000 miles · Sep 9, 2026
Parking Brake
The contact owns a 2022 Ford F-150. The contact stated that while the vehicle was parked in the garage, the parking brake activated independently. The failure was a recurring failure. The contact associated the failure with NHTSA Campaign Number: 23V509000 (Parking Brake); however, the VIN was not included in the recall. The de…
Read full complaint
The contact owns a 2022 Ford F-150. The contact stated that while the vehicle was parked in the garage, the parking brake activated independently. The failure was a recurring failure. The contact associated the failure with NHTSA Campaign Number: 23V509000 (Parking Brake); however, the VIN was not included in the recall. The dealer was contacted and stated that the repair was not covered because the VIN was not included in the recall. The manufacturer was contacted by phone and was made aware of the failure. The failure mileage was approximately 40,000.
NHTSA ODI #11763028
Mileage unknown · Sep 7, 2026
Exterior Lighting
The daytime running lights are out. Vehicle is available for inspection. This puts my safety and the safety of others at risk by not being o by reducing visibility of the vehicle during low light scenarios where the headlights are off. Example I live in an area with lots of fog and drive a gray vehicle that is not clearly visibl…
Read full complaint
The daytime running lights are out. Vehicle is available for inspection. This puts my safety and the safety of others at risk by not being o by reducing visibility of the vehicle during low light scenarios where the headlights are off. Example I live in an area with lots of fog and drive a gray vehicle that is not clearly visible if headlights are off due to light exposure. Problem is consistent and able to be reproduced for inspection. Vehicle has not been inspected by any agent to this point but it is available and will be noticed upon inspection by direction. There are no warning lamps or messages alerting driver of malfunction which poses another safety risk. Problem has been consistent for past 3 weeks upon every start.
NHTSA ODI #11762636
20,000 miles · Sep 4, 2026
Electrical SystemExterior LightingFuel System, Gasoline
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds on several occasions, the vehicle experienced a temporary loss of motive power…
Read full complaint
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds on several occasions, the vehicle experienced a temporary loss of motive power while accelerating and turning. The contact stated that the failure was a recurring failure, and the contact needed to maintain a fuel level above half tank. The vehicle was taken to a dealer, where it passed the State Inspection, and the contact was advised to wait until the recall part was available for the repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Additionally, the contact became aware that the VIN was included in NHTSA Campaign Number: 26V104000 (Electrical System, Exterior Lighting); however, the contact had not received the recall notification. The failure mileage was approximately 20,000.
NHTSA ODI #11762226
78,500 miles · Sep 3, 2026
Fuel System, Gasoline
The contact owns a 2022 Ford F-150. While the contact’s daughter was driving 5 MPH and turning left from a four-way stop sign, the vehicle stalled. The accelerator pedal was continuously depressed to drive the vehicle to the residence. The contact notified the dealer of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). T…
Read full complaint
The contact owns a 2022 Ford F-150. While the contact’s daughter was driving 5 MPH and turning left from a four-way stop sign, the vehicle stalled. The accelerator pedal was continuously depressed to drive the vehicle to the residence. The contact notified the dealer of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The vehicle was towed to the dealer, and the vehicle was diagnosed with transmission failure pending the repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was contacted via e-mail and was made aware of the failure. The failure mileage was approximately 78,500.
NHTSA ODI #11761991
106,000 miles · Sep 3, 2026
Fuel System, Gasoline
The contact owns a 2022 Ford F-150. The contact stated that while driving 35 MPH, the vehicle unexpectedly loss power and decelerated 15 MPH. The failure was a recurring failure but became more frequent in hot weather. The dealer was contacted and associated the failure with NHTSA Campaign Number: 25V455000 (Fuel System, Gasolin…
Read full complaint
The contact owns a 2022 Ford F-150. The contact stated that while driving 35 MPH, the vehicle unexpectedly loss power and decelerated 15 MPH. The failure was a recurring failure but became more frequent in hot weather. The dealer was contacted and associated the failure with NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was reached by phone and was made aware of the failure. The failure mileage was approximately 106,000.
NHTSA ODI #11761875
Mileage unknown · Sep 1, 2026
Unknown Or OtherFire
i was driving on XXX south to grab some Mexican food for dinner. on the way at one point i smelled something burning like an oil smell. but didnt see anything and suspected it was the old car in front of me. and my f150 was running fine. when i got out at the restaurant i did not see or smell anything around the truck. i went i…
Read full complaint
i was driving on XXX south to grab some Mexican food for dinner. on the way at one point i smelled something burning like an oil smell. but didnt see anything and suspected it was the old car in front of me. and my f150 was running fine. when i got out at the restaurant i did not see or smell anything around the truck. i went in to find they were closing at 9:00pm and it was 8:40ish. so i left telling them id stop back another day. was driving north on XXX heading home when around the same area of [XXX] 51 I smelled something burning again. once again i didnt see any smoke around my truck, no one was beeping at me or anything. and the truck was running/working well. i figured maybe its someone with a fire in their yard. further down [XXX] about 300 ft before [XXX], i smelled smoke stronger this time and looked up and to my right and saw smoke pouring out of a vent or something on the headliner. realizing that the truck is obviously on fire i wanted to get it off the street asap so as to be less a danger to others. so i turned up [XXX] at the intersection and pulled off the side of the road as far off as i could get the truck. grabbed my phone from the passenger seat and exited the truck in a hurry. as i looked over at the truck i saw flames coming up from underneath between the cab and the bed of the truck - looked to be centered under the truck. i ran about 150 feet from the truck and called 911. i turned around as i was talking to the operator. and the truck was completely ingulfed in flames. thankfully i made it out when i did. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11761379
Mileage unknown · Aug 31, 2026
Exterior Lighting
Daytime running lights (LED) in headlights burn out/quit working. Currently it is only the pasenger side of my vehilce but its a common issue and eventually both passenger and driver side DRL's quit working. there is no repair for this, only option for the owner is to replace the entire headlight assembly and that is extremely c…
Read full complaint
Daytime running lights (LED) in headlights burn out/quit working. Currently it is only the pasenger side of my vehilce but its a common issue and eventually both passenger and driver side DRL's quit working. there is no repair for this, only option for the owner is to replace the entire headlight assembly and that is extremely costly.
NHTSA ODI #11760881
Mileage unknown · Aug 28, 2026
Forward Collision AvoidanceService Brakes
Emergency parking brake came on and would not turn off even when I tried to do a reset. We had to have the truck towed.
NHTSA ODI #11760339
Mileage unknown · Aug 27, 2026
EngineFuel/propulsion System
While driving, my 2022 Ford F-150 equipped with the 2.7L EcoBoost experienced abnormal engine operation, a check-engine light, and reduced engine power. The unexpected reduction in available engine power created a safety concern because loss of acceleration or propulsion can be dangerous when merging, crossing traffic, passing, …
Read full complaint
While driving, my 2022 Ford F-150 equipped with the 2.7L EcoBoost experienced abnormal engine operation, a check-engine light, and reduced engine power. The unexpected reduction in available engine power created a safety concern because loss of acceleration or propulsion can be dangerous when merging, crossing traffic, passing, or traveling at highway speeds. The vehicle was inspected and diagnosed by an authorized Ford dealership. The PCM stored DTC P0332, Knock/Combustion Vibration Sensor “B” Circuit Low. The dealer performed Ford Pinpoint Test DG. Testing reportedly found no open circuit, short to ground, short to voltage, or intermittent circuit fault. The dealer determined that the knock-sensor assembly required replacement.The repair involves replacement of Ford knock-sensor assembly FT4Z-12A699-E, which contains both knock sensors. Access to the assembly requires extensive disassembly of engine fuel and cooling-system components. Ford’s service procedure includes removal of both direct-injection fuel rails, draining the cooling system, removal of the coolant pump, and removal of the coolant outlet connector.I am concerned about the possibility of coolant leakage or contamination affecting the knock-sensor assembly because of its location in relation to cooling-system components. I do not currently know whether coolant contamination caused this particular failure. I request that NHTSA investigate whether coolant leakage or contamination in this area contributes to premature knock-sensor failures on 2.7L EcoBoost engines. I have also identified another 2022 Ford F-150 with the 2.7L EcoBoost that was diagnosed by a Ford dealership with a similar knock-sensor circuit-low fault, P0327 also quoted replacement of the same FT4Z-12A699-E assembly. I request investigation knock-sensor failures on 2.7L EcoBoost F-150s, including Ford warranty/field data and whether coolant leakage or contamination contributes to failures capable of causing unexpected reduced engine powe
NHTSA ODI #11760176
Mileage unknown · Aug 27, 2026
Service Brakes
I was driving and went to press the brakes and the pedal went to the floor. The truck would not stop right away and then the rear tires locked up. Light came on the dash ABS, service traction control and brake system failure, this was a similar issue with the 2021 and 2025 model having issues with the EBB/ECU that was on recall.…
Read full complaint
I was driving and went to press the brakes and the pedal went to the floor. The truck would not stop right away and then the rear tires locked up. Light came on the dash ABS, service traction control and brake system failure, this was a similar issue with the 2021 and 2025 model having issues with the EBB/ECU that was on recall.
NHTSA ODI #11760069
Official recalls
23Jul 28, 2026
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Additional source detail variants (2)
Back Over Prevention:display Function
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Back Over Prevention:software
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Additional source detail variants (2)
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Electrical System: Integrated Trailer Brake Control
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.
Consequence & remedy
Consequence: A detached wind deflector can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.
Aug 8, 2025
Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles that were repaired incorrectly under recalls 22V686 and 23V802. The parking lights may flicker when the headlights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Flickering parking lights can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will replace the light emitting diode control module and update the software, free of charge. Owner notification letters were mailed August 20, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C38.
Aug 8, 2025
Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles that were repaired incorrectly under recall 22V686. The parking lights may flicker when the headlights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Flickering parking lights can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will replace the light emitting diode control module and update the software, free of charge. Owner notification letters were mailed September 12, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C37.
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Consequence & remedy
Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
Feb 28, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality can extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Sep 13, 2024
Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles. The parking lights may flicker when the headlights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Flickering parking lights can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will replace the LED Driver module, free of charge. Owner notification letters were mailed on March 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C30. These vehicles were previously recalled for this same issue under 22V-686 and will need to have the new remedy performed.
Aug 23, 2024
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
Dec 22, 2023
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with the Trailer Tow Max Duty package and a 9.75-inch heavy duty axle with a 3/4 float axle design. The rear axle hub bolt may fatigue and break, which can result in damage to the axle hub splines.
Consequence & remedy
Consequence: Damaged axle hub splines can result in a vehicle rollaway when the vehicle is in park without the parking brake applied or cause a loss of drive power. Both of these conditions can increase the risk of a crash.
Remedy: Dealers will replace the left and right rear axle shaft assemblies, free of charge. Owner notification letters were mailed on May 9, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S65.
Nov 28, 2023
Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles. The parking lights may flicker when the headlights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Flickering parking lights can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will update the LED driver module software, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C36. Vehicles with high series headlamps previously recalled under recall number 22V-686 that received an incomplete remedy, or have not yet been repaired, will need to have the new remedy completed.
Jul 21, 2023
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with a single exhaust system. Contact with the rear axle housing may damage the wiring harness, causing the electric parking brake to activate unexpectedly.
Consequence & remedy
Consequence: Unexpected activation of the electric parking brake while driving increases the risk of a crash.
Remedy: Dealers will install a protective tie strap, tape wrap, and replace the harness as necessary, free of charge. Owner notification letters were mailed February 12, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S35.
Feb 10, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."
Consequence & remedy
Consequence: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.
Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.
Nov 15, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.
Remedy: Dealers will replace the front windshield wiper motor, free of charge. Owner notification letters were mailed June 30, 2023. Remedy parts are expected in the 3rd Quarter of 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S71. This recall expands previous recall number 22V-142.
Sep 14, 2022
Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles. The right-side instrument panel cover may have been manufactured incorrectly, which can cause the air bag to not deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: During air bag deployment, the air bag cover my break and project fragments into the vehicle, or the air bag may deploy improperly, increasing the risk of occupant injury.
Remedy: Dealers will replace the right-side instrument panel cover, free of charge. Owner notification letters were mailed October 26, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C23.
Sep 14, 2022
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco Sport and 2022 F-150 vehicles. The parking lights may flicker when the headlights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Flickering parking lights can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will replace the LED Driver module, free of charge. Owner notification letters were mailed March 29, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C22.
Sep 8, 2022
Ford Motor Company (Ford) is recalling certain 2022 F-150 Raptor Series vehicles equipped with 37-inch tires. The lug nuts on the wheels may have been incorrectly tightened.
Consequence & remedy
Consequence: Incorrectly tightened wheel lug nuts can loosen and result in wheel separation from the vehicle, increasing the risk of a crash.
Remedy: Dealers will tighten or replace the wheel lug nuts, as necessary, free of charge. Owner notification letters were mailed September 26, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S59.
Aug 12, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios increases the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft, as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed September 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S53.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios increases the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft, as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed September 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S53.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios increases the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft, as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed September 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S53.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles. The power-adjustable telescoping steering column connector wiring may be too short. Wiring that is too short can become damaged or separate if the adjustable steering column is extended all the way.
Consequence & remedy
Consequence: Damaged or separated wiring may result in the steering column not moving as intended in certain crash conditions, increasing the risk of injury in a crash.
Remedy: Dealers will inspect the steering column wiring harness and repair the wiring, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk, were mailed on May 9, 2022. Owner notification letters were mailed July 28, 2022. Remedy parts are expected to be available by the end of July, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S24.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality could result in extended stopping distance, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S17.
Dec 16, 2021
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed February 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S56.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed February 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S56.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed February 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S56.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24019 · Low-pressure Fuel Pump Failure
Opened Jul 29, 2024 · Closed Sep 19, 2025
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
On July 29, 2024, the Office of Defects Investigation (ODI) opened PE24019 to investigate complaints of low-pressure fuel pump failures in MY 2021 Ford Bronco vehicles. Some consumers reported that the failure occurred without warning while driving, resulting in a complete loss of motive power with no ability to restart the engine. Ford determined that several other vehicle models contain low-pressure fuel pumps substantially similar to the 2021 Ford Bronco, including the 2022-2023 Ford Bronco, 2018-2023 Ford F-150, 2022-2023 Ford Expedition, 2019-2023 Lincoln Navigator, 2020-2023 Ford F-250-F-550, 2024 Ford Super Duty Chassis Cab, 2024-2025 Ford Ranger, 2020-2023 Ford Explorer, 2020-2023 Lincoln Aviator, and 2021-2025 Ford Mustang. ODI's investigation found that the affected vehicles may lose fuel pressure and flow from the fuel delivery module (consisting of a low-pressure fuel pump, jet pump, reservoir, and other parts) due to a low-pressure pump failure. This can cause the engine to stall while driving. The root cause is reduced internal clearance in the fuel pump, increasing friction and sensitivity to vapor lock. Fuel blockage from contamination inside the jet pump also contributed to the failure. Ford stated that the contamination source was unknown. On July 7, 2025, Ford filed recall 25V-455 for certain 2021-2023 Ford F-550 SD/F-450 SD/F-350 SD/F-250 SD, 2021-2022 Lincoln Navigator, 2021-2022 Ford Mustang, 2021-2022 Ford F-150, 2021-2023 Ford Explorer, 2022 Ford Expedition, and 2021-2023 Ford Bronco vehicles produced between July 1, 2021, and July 30, 2022. The recall also included certain 2021-2023 Lincoln Aviator produced between July 1, 2021, and December 21, 2022. Ford explained in its recall filingthat the production dates used for the recall were based on changes in the manufacturing process. Specifically, Ford determined that in June 2021, the supplier modified the jet pump manufacturing process, producing fuel pump chambers with a lower-than-specified internal clearance. In July 2022, the supplier implemented corrective actions to the manufacturing process by adding two additional vacuum pumps to reduce contamination during the production of the jet pump. ODI has identified approximately 1,000 reports involving vehicles covered in this investigation but excluded from recall 25V-455. However, even with such reports, these vehicles experienced comparatively lower failure rates than the vehicles that are subject to Recall 25V-455. Ford has explained that these vehicles were excluded from the recall population because they did not experience the manufacturing changes that prompted the recall. Specifically, according to Ford, vehicles built before July 1, 2021 (the recall production start date), were not affected by the supplier’s change to the jet pump manufacturing process. Even after closing this investigation, ODI will continue to monitor complaints for vehicles excluded from recall 25V-455 to consider whether they exhibit the same risks as the vehicles encompassed by the recall. The recall remedy is currently under development. In view of Ford’s recall action, ODI is closing this Preliminary Evaluation, but will continue to monitor the issue as a remedy is developed and implemented. ODI will take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA23002 · Loss Of Motive Power
Opened Sep 29, 2023 · Closed Oct 31, 2024
Status: closed (inferred from source dates) · Engine
On July 22, 2022, the Office of Defects Investigation (ODI) granted a Defect Petition (DP22001) and opened a Preliminary Evaluation (PE22007) to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco vehicles equipped with 2.7L EcoBoost engines. Complainants were reporting sudden engine failure while driving resulting in a loss of motive power, often without the ability to restart. During PE22007, the cause of engine failure and loss of motive power in the subject vehicles was determined to be intake valve fracture, and the full scope of vehicles affected by the subject defect was identified as all MY 2021-2022 Ford and Lincoln models equipped with either the 2.7L or 3.0L EcoBoost engines, referred to as the “Nano” engine family. If an intake valve fractures in the subject engines, it may drop into the cylinder and contact the piston, often resulting in catastrophic engine damage. On September 29, 2023, PE22007 was upgraded to an Engineering Analysis (EA23002) to further investigate the subject defect across the full scope of affected vehicles. During EA23002, ODI visited Ford facilities to review technical information related to intake valve fracture in “Nano” engines, coordinated with NHTSA’s Vehicle Research and Testing Center (VRTC), and analyzed updated field data relating the subject defect. Forensic analysis of fractured intake valves demonstrated that the defective components exhibited “grinding burn” or out of specification hardness in the area of the keeper grooves. The presence of grinding burn is evidence that during the groove grinding phase of production, the temperature of the valve became sufficiently high to alter the microstructure of the material and is indicative that the valve supplier’s manufacturing processes were not within control specifications. Grinding burn results in a hard, brittle microstructure and high residual stresses toward the surface of the valve. Through normal engine loading, a valve with grinding burn will likely fracture at the area of highest vulnerability, which is the third keeper groove. In its response to the EA23002 Information Request (IR) letter, Ford provided evidence of 396 customer complaints (including field reports), 825 warranty claims, and 936 engine exchanges. When considering both ODI and manufacturer failure report data, there have been reports representing 1066 unique vehicles within the subject vehicle population. Analysis of the failure report data demonstrates that vehicles equipped with potentially defective intake valves were built within a production “spike period” of May 2021 – October 2021. The beginning of the spike period corresponds to a ramp up in production at the valve supplier manufacturing facility, and the end of the spike period aligns with the implementation of several mid-production process improvements and the decision to change the metal alloy used to produce intake valves from “Silchrome Lite” to “Silchrome 1”. Ford began investigating the subject defect in July 2021, determined the root cause, and took corrective measures for the new production vehicles. Analysis of the failure report data demonstrates that these corrective actions were successful in eliminating the risk of intake valve fracture for subject vehicles produced after October 2021. However, Ford did not take any field action to address vehicles produced during the spike period, and in the several months following the implementation of the production changes, a significant number of field failures continued to occur. It is Ford’s assessment that not all valves produced during the spike period are defective, and that failures associated with the subject defect occur at low time in service. Analysis of the failure report data demonstrates that the vast majority of failures have occurred before 20,000 miles with over half of all reported failures occurring before 5,000 miles. The rate of reported failures related to the subject defect has steadily decreased since November 2021. ODI coordinated with NHTSA’s National Center for Statistics and Analysis (NCSA) to conduct statistical analysis and predict the number of future failures associated with the subject defect. The results of this analysis, and the trends identified through the failure report data are generally consistent with Ford’s assessment that defective intake valves will likely fail at a low time in service and indicate that the majority of subject vehicles equipped with defective valves have already experienced a failure. On August 23, 2024, Ford submitted recall 24V635 for subject vehicles equipped with “Nano” engines and built within the production spike period identified above (total population 90,736 vehicles). The remedy includes an inspection at a Ford/Lincoln dealership where the lifetime engine cycles of the vehicle will be determined. If a vehicle does not meet a threshold for lifetime engine cycles, the dealership will conduct a high RPM engine cycle accumulation procedure, which aims to identify if the vehicle is equipped with defective intake valves. Any vehicle that fails the accumulation procedure will receive an engine replacement under the recall. In addition to recall 24V635, Ford has stated that it will launch customer satisfaction campaign 24N12, which will provide extended warranty coverage to the subject vehicles through the earlier of 10 years or 150,000 miles. In view of the recall action being taken by Ford, ODI is closing this Engineering Analysis. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration